2024 Volvo XC40

Brake system failed. I was NOT in one pedal mode. I have up to date software. After break system failed I was unable to put vehicle in park. Parking break could not be applied. Could not turn car off or lock doors. I was driving on interstate when it occurred. I got multiple warnings on display. I was lucky to pull over and not crash.

The contact owned a 2024 Volvo XC40. The contact stated that his wife was entering a parking lot at approximately 10 MPH when she heard the vehicle engine abnormally revving and the vehicle independently accelerated. The vehicle drove through the parking lot and crashed into a tree. The contact stated that the driver's and passenger front air bags deployed, and the front collision avoidance had not engaged. The contact stated that the vehicle crashed into the tree almost at the center of the front bumper and grill. The hood had been crushed, the grill cracked, and the bumper had been torn off. The contact stated that the police arrived on scene but did not write a report since no other vehicles were involved. The contact stated that his wife had scrapes and bruises on both arms and scrapes on her nose and forehead. The wife was not attended to by EMT, but later went to the ER for neck and back pain. The vehicle was towed to an impound lot and later declared a total loss by the contact's insurance provider. The contact had contacted the manufacturer, who sent a technician to download information from the vehicle computers. The contact stated that a summary was released by the manufacturer that indicated that the crash was a driver error. The failure mileage was approximately 8,000.

On two separate occasions, brakes failed completely in snow. Vehicle did not appear to be hydroplaning, and anti-lock function did not kick-in despite the pedal being floored. Pumping had no effect either. Safety sensors around the car should have detected motion even if the wheels were locked-up and should initiate anti-lock procedures as well. Distance traveled (at low speed due to snow and heavy traffic) was well over 100 feet. Emergency stopping feature finally engaged anti-lock brakes about 1/2 second before impact. To avoid a second crash (someone two vehicles ahead caused a pileup) a year later, driver had the wherewithal (and space) to leave the roadway when brakes failed to even slow the vehicle.

I pulled over right side of street to park behind a parked vehicle to a visit house across the street. Was too far out from curb so I backed up about 12-15 feet or so. Put car in drive and slowly started to drive toward curb when car suddenly accelerated very hard. I turned steering to left to avoid hitting the car in front, straightened car out but could not stop it until it stopped about 20-30 feet down the road. Brake was not stopping my car. The acceleration was something like being on a ramp to get on highway and pressing pedal down to get to highway speed. It was a very hard acceleration. Very frightening. I got an appointment tomorrow for volvo service to look at this. Drove the car after this happened and today without any incident. I bought the car new in Mar 2024 and have NEVER experience this.

am writing to formally report a serious issue involving the sale of a Certified Pre-Owned Volvo by a franchised Volvo dealership in Pennsylvania that I believe violates consumer protection standards and certified vehicle regulations. On [XXX], I purchased a 2024 Volvo XC40 from Volvo Cars Fort Washington, represented and sold to me as a Certified Pre-Owned (CPO) vehicle. However, I have since discovered that this vehicle had an active safety recall as of May 1, 2025, prior to the sale. The recall was related to a malfunction in the safety camera system, which could potentially lead to severe accidents and endanger the driver and passengers. Despite this open recall, the vehicle was still certified and sold to me without any disclosure of the safety issue. I only learned about the recall after experiencing a problem with the camera system and independently seeking service. This violates the core standards of manufacturer-backed CPO programs, which clearly state that no certified vehicle may be sold with an unresolved safety recall. I believe this sale represents a misrepresentation of the vehicle’s condition, a failure of duty to disclose, and a potential violation of consumer protection laws in the state of Pennsylvania. I am requesting that this matter be investigated and that appropriate action be taken against the dealership for selling a vehicle as “certified” when it did not meet the required safety and certification standards. Details: •Dealer Name: Volvo Cars Fort Washington •Vehicle: 2024 Volvo XC40 •VIN: [XXX] •Purchase Date: [XXX] •Recall Issue Date: May 1, 2025 •Nature of Recall: Safety camera malfunction that could lead to accidents •Consumer: [XXX] •Address: [XXX] •Email: [XXX] •Phone: [XXX] I am happy to provide additional documentation, including sales contracts, service records, and communications with the dealer, upon request INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Brake failure. I was slowing to stop at traffic light when “brake failure” warning came on. I then stepped on the brake and it was not working. I turned on a side street just bf the traffic light and coasted to a stop amd turned car off. Airbag not operative light came on and seatbelts were tightening then loosening. I could have hit cars stopped at the light.

I am a new leasee of a Volvo XC40 Recharge (leased September 13, 2024). When starting my car from a decline on my driveway, or in a parking spot on a decline, after putting the car in reverse, the car immediately surges forward 20 inches before I have to hit the brakes again to make it stop from hitting a car in front of me. The same behavior occurs if I am parked on an incline and put the car in drive - it immediately surges backwards and I have to hit the brakes to make the car stop. This issue puts my and other cars parked in front or behind me at risk of being hit when trying to leave a parking spot. This issue was confirmed by the dealer (see attachment) and replicated on another XC40 Recharge that the dealer tested it on. The service rep stated that "As far as Volvo is concerned at this time the vehicle is working as designed and this is a normal characteristic of the vehicle." I am not sure why they would say this as a car should not surge forward when it reverse or backward when in drive. No other car in the history of my driving cars has ever done this.

My wife pulled into a neighbor's driveway and put the car in Park. The car stopped. She reached over to the passenger's seat to pick up an item and the car lurched forward, crashing into the closed garage door before she could stop it. There were no warning lights alerting her that this would happen. She later told me, though, there had been previous instances of the car "bucking" after she had put it into park. The incident clearly posed a safety risk to my wife and others. Had someone been standing in front of the car when this happened, they could have been seriously injured or killed. Had the car not stopped after hitting the garage door, my wife, too, could have been seriously injured or killed. Had this happened in an area such as a parking lot, others also might have been injured. Volvo advised me not to file a police report at this time. The vehicle was inspected at Wallace Volvo in Stuart, Florida, and would be available for additional inspection. Volvo claims to have found liquid on internal parts. The larger, and more important question, though, is how the vehicle’s design could have allowed that to happen. Facts clearly point to a design flaw. The vehicle design clearly allows liquid to reach the parts in question and create the problem we experienced. If Volvo had designed the vehicle with a “tight” interior – a design that would have protected internal parts and not left them vulnerable – no amount of liquid in any amount from any source under any circumstance would have ended up in the vehicle’s internal parts. In my claim to Volvo, I asked that they make repairs to assure that this never happens again. They conceded that they did perform "repairs" to the vehicle but called it a "one-time good will gesture." I also asked Volvo to pay for the body damage to my vehicle and the damage ($2,364) caused to my neighbor's garage door by the malfunctioning vehicle. Volvo has refused to compensate me for the damage caused by their malfunctioning vehicle.