IllustrationTHE HOOD BRACKET CUTS THROUGH THE HOOD ON THE PASSENGER SIDE OF THE TRUCK. THIS CAUSES THE HOOD TO ONLY BE SECURED WITH ONE BRACKET WHEN OPENING THE HOOD FOR DAILY INSPECTIONS. THE HOOD IS ONLY PARTIALLY SECURED WHEN OPERATING ON ROADS AND HIGHWAYS. *TR
2007 Volvo Vnl
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Vnl years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 8 of 15 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Air. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports2 fire reports1 injury reports
What owners actually said
15 reportsI'D LIKE TO REQUEST FROM THIS DEPARTMENT TO OPEN AN INVESTIGATION ON A RUSTY FRAME PROBLEM ON 2005, 2006, 2007 AND 2008 COMMERCIAL VOLVO VNL TRUCKS. THESE TRUCKS HAVE HIGH TENDENCY TO HAVE FRAME RUST AND EVEN PERFORATION PUTTING MOTORISTS AT RISK IN THE USA HIGHWAYS.
I HAVE ~15 YEARS EXPERIENCE DRIVING MOST MAKE/MODELS OF CLASS 8 TRUCKS IN ALASKA AND LOWER 48 STATES. I HAVE NEVER OPERATED ANY TRUCK WITH LOW BEAM HEADLIGHTS SO BAD THAT I HAD TO RISK BLINDING ON-COMING TRAFFIC WITH MY HIGH BEAMS IN ORDER TO OPERATE AT ALL AFTER SUNSET - UNTIL THIS ONE. THE PROJECTOR STYLE LENS SHEDS LITTLE MO…
Read full complaint
I HAVE ~15 YEARS EXPERIENCE DRIVING MOST MAKE/MODELS OF CLASS 8 TRUCKS IN ALASKA AND LOWER 48 STATES. I HAVE NEVER OPERATED ANY TRUCK WITH LOW BEAM HEADLIGHTS SO BAD THAT I HAD TO RISK BLINDING ON-COMING TRAFFIC WITH MY HIGH BEAMS IN ORDER TO OPERATE AT ALL AFTER SUNSET - UNTIL THIS ONE. THE PROJECTOR STYLE LENS SHEDS LITTLE MORE LIGHT ON THE PAVEMENT AHEAD THAN I EXPECT FROM A CLEARANCE LAMP SHOP MECHANICS TELL ME THAT THIS IS NORMAL FOR ALL VOLVO TRUCKS USING THE "VN" STYLE AERO-COMPOSITE DESIGN. ON THE OTHER HAND, THE HIGH BEAM, FOG AND DRIVING LAMPS ARE WONDERFUL. THIS REALLY IS STUNNINGLY DANGEROUS AND NEEDS AN INVESTIGATION. I'M MYSTIFIED THAT NHTSA HASN'T ACTED ALREADY. COULD IT BE AS SIMPLE AS WORN OUT BULBS? ...INCORRECT BULBS? INVISIBLY DEGRADED PROJECTOR LENSES? ...DEGRADED VOLTAGE TO THE BULBS? WHATEVER IS WRONG, NOBODY SEEMS TO KNOW HOW TO FIX IT. AND EVERY NIGHT I OPERATE, I WORRY THAT I MIGHT BE BLAMED FOR AN INCIDENT BECAUSE MY LOW BEAMS KEEP ME BLIND OR BECAUSE I BLINDED ON-COMING TRAFFIC WITH MY HIGH BEAMS. HOW 'BOUT IT NHTSA? THIS IS YOUR OPPORTUNITY TO FIX SOMETHING BEFORE PEOPLE GET HURT. PLEASE SEE ALSO: HTTP://WWW.THETRUCKERSREPORT.COM/TRUCKINGINDUSTRYFORUM/VOLVO-FORUM/168835-STARTED-VOLVO-HEADLIGHT-COMPLAINT-WITH-NHTSA.HTML. *TR
TL* THE CONTACT OWNS A 2007 VOLVO VNL TRUCK. THE CONTACT WAS DRIVING 20 MPH WHEN HE LOST CONTROL OF STEERING AND CRASHED INTO A POLE. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AT THE DRAG LINK. THE DRAG LINK SEPARATED FROM THE FIRE WALL. THE DRAG LINK AND THE TIE ROD WAS REPLAC…
Read full complaint
TL* THE CONTACT OWNS A 2007 VOLVO VNL TRUCK. THE CONTACT WAS DRIVING 20 MPH WHEN HE LOST CONTROL OF STEERING AND CRASHED INTO A POLE. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AT THE DRAG LINK. THE DRAG LINK SEPARATED FROM THE FIRE WALL. THE DRAG LINK AND THE TIE ROD WAS REPLACED. A POLICE REPORT WAS FILED (OKLAHOMA STATE POLICE REPORT NUMBER: AM02905-11). THE FAILURE AND THE CURRENT MILEAGE WAS 507,648.
TL* THE CONTACT OWNS A 2007 VOLVO VNL64T TRUCK. THE CONTACT STATED THE HEADLIGHT COVERS WERE DETERIORATING AND REDUCING VISIBILITY FOR THE DRIVER. IN ADDITION, THE FAILURE WOULD CAUSE THE HEADLIGHTS TO BECOME EXTREMELY FOGGY AND HAZY. THERE WERE NO RECALLS FOR THE VEHICLE AND THE DEALER ADVISED ANY REPAIRS WOULD BE AT THE CONTAC…
Read full complaint
TL* THE CONTACT OWNS A 2007 VOLVO VNL64T TRUCK. THE CONTACT STATED THE HEADLIGHT COVERS WERE DETERIORATING AND REDUCING VISIBILITY FOR THE DRIVER. IN ADDITION, THE FAILURE WOULD CAUSE THE HEADLIGHTS TO BECOME EXTREMELY FOGGY AND HAZY. THERE WERE NO RECALLS FOR THE VEHICLE AND THE DEALER ADVISED ANY REPAIRS WOULD BE AT THE CONTACTS EXPENSE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 122,000 AND THE CURRENT MILEAGE WAS 174,928.
TL-THE CONTACT OWNS A 2007 VOLVO VNL64T TRUCK. WHILE INSPECTING THE VEHICLE HE NOTICE THE HEADLIGHTS COVERS WAS DETERIORATING AND THE PLASTIC WAS FLOGGED. THE COVERS DETERIORATING REDUCES VISIBILITY FOR THE DRIVERS. THE VEHICLE HAS NOT BEEN REPAIRED. HE HAS CONTACT THE DEALER AND WAS TOLD THERE WERE NO RECALL. THE COST PER THE D…
Read full complaint
TL-THE CONTACT OWNS A 2007 VOLVO VNL64T TRUCK. WHILE INSPECTING THE VEHICLE HE NOTICE THE HEADLIGHTS COVERS WAS DETERIORATING AND THE PLASTIC WAS FLOGGED. THE COVERS DETERIORATING REDUCES VISIBILITY FOR THE DRIVERS. THE VEHICLE HAS NOT BEEN REPAIRED. HE HAS CONTACT THE DEALER AND WAS TOLD THERE WERE NO RECALL. THE COST PER THE DEALER WOULD BE OVER $600. THE FAILURE MILEAGE WAS 120,000 AND THE CURRENT MILEAGE WAS 186,221. VWB
THE SLEEPER WINDOW ON OUR 2007 VOLVO VNL TRUCK FELL OUT ONTO A BRAND NEW POLICE CAR IN OLAHOMA CITY, OKLAHOMA, JUST WEST OF THE CITY. DRIVER STATES THAT THE WINDOW IS ATTACHED BY GLUE ONLY, NO SCREWS OR RIVITS. UPON FURHTER INVESTIGATION BY OUR FLEET, DRIVERS HAVE BEEN INSTRUCTED NOT TO OPEN SLEEPER WINOWS. THIS WAS TO AVOID A…
Read full complaint
THE SLEEPER WINDOW ON OUR 2007 VOLVO VNL TRUCK FELL OUT ONTO A BRAND NEW POLICE CAR IN OLAHOMA CITY, OKLAHOMA, JUST WEST OF THE CITY. DRIVER STATES THAT THE WINDOW IS ATTACHED BY GLUE ONLY, NO SCREWS OR RIVITS. UPON FURHTER INVESTIGATION BY OUR FLEET, DRIVERS HAVE BEEN INSTRUCTED NOT TO OPEN SLEEPER WINOWS. THIS WAS TO AVOID ANY FURTHER PORBLEMS SUCH AS THIS INCIDENT
BUNK WINDOWN HAS FALLEN OUT ON SEVERAL OCCATIONS. DRIVER SAYS "HE DID SET UP A CASE" WITH VOLVO AND THEY WOULD NOT DO ANYTHING ABOUT IT. NOT COVERED UNDER ANY WARRANTY DRIVER SAYS HE FIXED PROBLEM WITH A GENERAL MOTORS VALVE COVER WASHER AND A SHEET METAL SCREW BUT IS NOT ABLE TO OPEN THIS WINDOW ANY LONGER.
TL*THE CONTACT OWNS A 2007 VOLVO 780VNL SEMI HEAVY DUTY TRUCK. THE ENGINES ELECTRICAL SYSTEM SHUT ON AND OFF WHEN THE VEHICLE WAS IN TRAFFIC. THE CONTACT WAS ABLE TO RESTART THE VEHICLE; HOWEVER, NONE OF THE ELECTRICAL COMPONENTS WOULD FUNCTION. THE VEHICLE WAS TAKEN TO THE DEALER TWICE. THE MASS AIR FLOW SENSOR AND THE WIRES T…
Read full complaint
TL*THE CONTACT OWNS A 2007 VOLVO 780VNL SEMI HEAVY DUTY TRUCK. THE ENGINES ELECTRICAL SYSTEM SHUT ON AND OFF WHEN THE VEHICLE WAS IN TRAFFIC. THE CONTACT WAS ABLE TO RESTART THE VEHICLE; HOWEVER, NONE OF THE ELECTRICAL COMPONENTS WOULD FUNCTION. THE VEHICLE WAS TAKEN TO THE DEALER TWICE. THE MASS AIR FLOW SENSOR AND THE WIRES THAT SHORTEN THE FRAME OF THE TRUCK WHICH THE ABS SENDING UNIT COMMUNICATES WITH EACH BRAKE SYSTEM WERE REPLACED. THE MANUFACTURER WAS CALLED AND ADVISED THE CONTACT TO CALL THEM BACK IN A COUPLE OF DAYS. THE FAILURE MILEAGE WAS 354,926.
2007 VOLVO VNL RIGHT FRONT TIRE BLEW OUT CAUSING DAMAGE TO THE RIGHT SIDE FUEL TANK. *KB OHIO TRAFFIC CRASH REPORT # 10-0764-90. *JB
Official recalls
913V268000 · Power Train:clutch Assembly
Jun 26, 2013
Volvo Trucks North America (Volvo) is recalling certain model year 2007-2014 VAH, VHD, VNL, VNM, and VT models. The affected vehicles were built without a redundant clutch disengagement switch. Without a redundant switch, a loss of signal from the brake air pressure switch can prevent the clutch from automatically disengaging when the brake is applied.
Consequence & remedy
Consequence: Without a signal to disengage the clutch when the brakes are applied, the distance required to stop the truck may lengthen, increasing the risk of a crash.
Remedy: Volvo Trucks will notify owners and dealers will inspect and repair the vehicles if necessary. The recall began on August 26, 2013. Volvo's recall number is RVXX1303. Owners may contact Volvo at 1-336-393-2000.
09V173000 · Visibility:windshield Wiper/washer:motor
May 21, 2009
VOLVO TRUCKS IS RECALLING 127,764 MY 2001-2008 VHD, VNL, VNM, AND MY 2005-2008 VT TRUCKS. A SEAL MAY FAIL ALLOWING WATER AND CONTAMINANTS TO SEEP INTO THE WINDSHIELD WIPER MOTOR.
Consequence & remedy
Consequence: IF THIS HAPPENS A SHORT CIRCUIT MAY OCCUR, WHICH OVER TIME COULD POSSIBLY LEAD TO A VEHICLE FIRE.
Remedy: VOLVO WILL REPLACE THE WIPER MOTOR FREE OF CHARGE. SINCE THIS RECALL INVOLVES A LARGE NUMBER OF VEHICLES, VOLVO WILL RELEASE THE RECALL IN STAGES AS PARTS ARE RECEIVED. PRIORITY WILL BE GIVEN TO THE VEHICLES LOCATED IN THE REGIONS/STATES THAT HAVE A CORROSIVE ENVIRONMENT. THE RECALL BEGAN ON SEPTEMBER 30, 2009. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
09V030000 · Service Brakes, Air
Jan 27, 2009
VOLVO TRUCKS IS RECALLING 366 MY 2006-2009 VNL TRUCKS EQUIPPED WITH SUPER SINGLE TIRES, BENDIX BRAKE CAM TUBES, AND VOLVO AIR SUSPENSION. THE VIBRATION FREQUENCY FROM THE SUSPENSION WITH SUPER SINGLE TIRES MAY RESULT IN A FATIGUE CRACK OF THE MOUNTING BRACKETS FOR THE BRAKE CAM TUBE.
Consequence & remedy
Consequence: IF LEFT UNTREATED, THE CRACK CAN PROPAGATE AND CAUSE FAILURE OF THE BRAKE CAM TUBE SUPPORT BRACKET(S), WHICH CAN RESULT IN LOSS OF BRAKES AT THE CORRESPONDING WHEEL END INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL ADD A SUPPORT BRACKET TO THE BRAKE CAM TUBE. THE RECALL BEGAN ON JUNE 30, 2009. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
07V573000 · Electrical System:wiring:fuses And Circuit Breakers
Dec 14, 2007
ON CERTAIN HEAVY DUTY TRUCKS, THE CIRCUIT PROTECTION (I.E. AUTOMATIC CIRCUIT BREAKERS) USED TO PROTECT THE VEHICLE LIGHTING SYSTEM MAY NOT PROVIDE ADEQUATE PROTECTION.
Consequence & remedy
Consequence: IF A SHORT CIRCUIT OCCURS AND IS LEFT UNTREATED, COMPONENTS AND WIRING MAY BE SUBJECT TO OVERHEATING WHICH COULD POSSIBLY RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL REPLACE THE CIRCUIT BREAKERS WITH FUSES. THE RECALL BEGAN ON FEBRUARY 25, 2008. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
07V496000 · Trailer Hitches:fifth Wheel Assembly
Oct 23, 2007
ON CERTAIN TRUCKS EQUIPPED WITH A SAF HOLLAND SIMPLEX FIFTH WHEEL, THE LEVER ARM PIVOT BOLT MAY HAVE BEEN OVER TIGHTENED. AN OVER TIGHTENED PIVOT BOLT CAN DISTORT THE PIVOT BOLT SPACER SLEEVE, WHICH MAY PREVENT THE FIFTH WHEEL LATCH JAW FROM CLOSING AND LATCHING SECURELY AROUND THE TRAILER KING PIN.
Consequence & remedy
Consequence: THERE IS A POSSIBILITY THAT THE PIVOT BOLT CAN BECOME LOOSE WITHOUT THE DRIVER'S KNOWLEDGE. WHEN THIS OCCURS, THE DRIVER COULD DRIVE AWAY AND THE TRAILER COULD BECOME DISENGAGED, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE PIVOT BOLT AND SLEEVE WITH A HEX HEAD SHOULDER BOLT AND WASHER FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 28, 2008. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
07V345000 · Fuel System, Diesel
Aug 7, 2007
ON CERTAIN TRUCKS, AN UNPROTECTED LEAD IN THE THERMOSWITCH OF THE HEATER MAY MAKE CONTACT WITH ANOTHER POST POSSIBLY CREATING A SHORT CIRCUIT, WHICH CAN RESULT IN CONTINUOUS OPERATION OF THE HEATING ELEMENT.
Consequence & remedy
Consequence: IF THE CONDITION EXISTS AND THE KEY IS LEFT ON WITHOUT FUEL IN THE FILTER, THE HEATING ELEMENT MAY HEAT TO A POINT WHERE A FLAME BECOMES PRESENT AT THE TIP OF THE ELEMENT WHICH COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSPECT THE THERMOSWITCH AND WILL REPLACE IT IF NECESSARY. THE RECALL BEGAN ON SEPTEMBER 10, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
07V323000 · Steering
Jul 24, 2007
ON CERTAIN TRUCKS, THE NUT USED TO RETAIN THE STEERING SHAFT MAY OR MAY NOT BE A LOCK NUT THAT HAS THE LOCKING FEATURE. A LOCK NUT IS REQUIRED TO PROVIDE ADDITIONAL RESISTANCE TO ENSURE THAT THE NUT DOES NOT COME LOOSE.
Consequence & remedy
Consequence: IF THE NUT WERE TO COME LOOSE, THE STEERING SHAFT COULD POTENTIALLY SEPARATE RESULTING IN LOSS OF STEERING CONTROL WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE STEERING SHAFT PINCH BOLTS AND LOCKNUTS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 24, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
07V108000 · Power Train:axle Assembly
Mar 16, 2007
ON CERTAIN TRUCKS, THE AXLE HOUSINGS MAY HAVE BEEN MANUFACTURED WITH STEEL THAT WAS OUT OF SPECIFICATION WHICH COULD RESULT IN A FATIGUE FAILURE OVER TIME.
Consequence & remedy
Consequence: IF A FATIGUE FAILURE OCCURS AND IS LEFT UNATTENDED, THE AXLE MAY LOCK UP OR THE END OF THE AXLE COULD COME OFF, WHICH MAY RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL REPAIR AND INSPECT THE AXLES AND REPLACE THEM FREE OF CHARGE. THE RECALL BEGAN ON APRIL 9, 2007. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
06V385000 · Power Train:driveline
Oct 11, 2006
ON CERTAIN TRUCKS EQUIPPED WITH ARVINMERITOR RPL20 HIGH ANGLE INTERAXLE DRIVESHAFTS, AN IMPROPER SEATED OR MISSING SNAP RING CAN RESULT IN THE BEARING CUP TO SEPARATE FROM THE SLIP YOKE SUB-ASSEMBLY. THE UNIVERSAL JOINT CROSS COULD THEN CONTACT THE SLIP YOKE CASTING AND EVENTUALLY CAUSE THE EAR WORK TO FRACTURE.
Consequence & remedy
Consequence: THIS COULD RESULT IN ADDITIONAL DAMAGE TO THE DRIVELINE, THE VEHICLE TO WHICH IT IS ATTACHED AND AY ADDITIONAL NEARBY OBJECTS.
Remedy: DEALERS WILL INSPECT THE DRIVESHAFTS AND REPLACE THEM AS NEEDED. THE RECALL BEGAN ON OCTOBER 23, 2006. OWNERS MAY CONTACT VOLVO TRUCKS AT 1-800-528-6586.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE13002 · Stop Lamp Switch Signal
Opened Feb 7, 2013 · Closed Jul 3, 2013
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:manual Transmission; Service Brakes, Air:controls:foot Control/valve
The Office of Defects Investigation (ODI) received Early Warning Reporting (EWR) data from the manufacturer that indicated some number of subject vehicles equipped with the subject automated manual transmission had allegedly experienced a condition where the clutch failed to automatically disengage the transmission from the engine as intended. This may result in extended stopping distances and/or unintended forward motion of a vehicle previously at rest.To date, ODI is aware of 134 subject vehicles with one or more complaints or field reports related to this condition.Also, ODI is aware of 164 subject vehicles with one or more warranty claims related to this condition.By letter dated June 25, 2013, Volvo Trucks North America (Volvo) notified ODI that it has initiated a safety recall (NHTSA Recall No. 13V268 and Volvo Recall No. RVXX1303) to address a safety defect in approximately 23,003 model year (MY) 2007 through 2014 Volvo VAH, VHD, VNL, VNM and VT model trucks. The affected vehicles were manufactured from December 20, 2006 through May 22, 2013 and were originally equipped with the subject automated manual transmissions.According to Volvo, reports of the subject transmission clutch mechanism failing to automatically disengage as intended are associated with the removal of a brake pedal micro switch that provided a redundant signal to the transmission control module indicating the brakes had been applied.Previously, Volvo had removed this brake pedal micro switch from new vehicle production and from certain vehicles already in-service via two field service campaigns (SP 432-024 and SP 432-026) because it decided the switch was unnecessary and/or a maintenance issue.In the absence of this redundant brake pedal micro switch, the clutch mechanism may fail to disengage the transmission from the engine at low vehicle speed should the stop lamp switch fail to send and/or the transmission control module fail to receive the primary signal.At the time of this closing, Volvo is evaluating available remedies and will provide NHTSA with details when the recall remedy procedure has been finalized.Volvo will notify affected owners by mail by August 25, 2013.Please see NHTSA Recall No. 13V268 for details.Accordingly, this investigation is closed.
Additional source detail variants (3)
Power Train:automatic Transmission
The Office of Defects Investigation (ODI) received Early Warning Reporting (EWR) data from the manufacturer that indicated some number of subject vehicles equipped with the subject automated manual transmission had allegedly experienced a condition where the clutch failed to automatically disengage the transmission from the engine as intended. This may result in extended stopping distances and/or unintended forward motion of a vehicle previously at rest.To date, ODI is aware of 134 subject vehicles with one or more complaints or field reports related to this condition.Also, ODI is aware of 164 subject vehicles with one or more warranty claims related to this condition.By letter dated June 25, 2013, Volvo Trucks North America (Volvo) notified ODI that it has initiated a safety recall (NHTSA Recall No. 13V268 and Volvo Recall No. RVXX1303) to address a safety defect in approximately 23,003 model year (MY) 2007 through 2014 Volvo VAH, VHD, VNL, VNM and VT model trucks. The affected vehicles were manufactured from December 20, 2006 through May 22, 2013 and were originally equipped with the subject automated manual transmissions.According to Volvo, reports of the subject transmission clutch mechanism failing to automatically disengage as intended are associated with the removal of a brake pedal micro switch that provided a redundant signal to the transmission control module indicating the brakes had been applied.Previously, Volvo had removed this brake pedal micro switch from new vehicle production and from certain vehicles already in-service via two field service campaigns (SP 432-024 and SP 432-026) because it decided the switch was unnecessary and/or a maintenance issue.In the absence of this redundant brake pedal micro switch, the clutch mechanism may fail to disengage the transmission from the engine at low vehicle speed should the stop lamp switch fail to send and/or the transmission control module fail to receive the primary signal.At the time of this closing, Volvo is evaluating available remedies and will provide NHTSA with details when the recall remedy procedure has been finalized.Volvo will notify affected owners by mail by August 25, 2013.Please see NHTSA Recall No. 13V268 for details.Accordingly, this investigation is closed.
Power Train:manual Transmission
The Office of Defects Investigation (ODI) received Early Warning Reporting (EWR) data from the manufacturer that indicated some number of subject vehicles equipped with the subject automated manual transmission had allegedly experienced a condition where the clutch failed to automatically disengage the transmission from the engine as intended. This may result in extended stopping distances and/or unintended forward motion of a vehicle previously at rest.To date, ODI is aware of 134 subject vehicles with one or more complaints or field reports related to this condition.Also, ODI is aware of 164 subject vehicles with one or more warranty claims related to this condition.By letter dated June 25, 2013, Volvo Trucks North America (Volvo) notified ODI that it has initiated a safety recall (NHTSA Recall No. 13V268 and Volvo Recall No. RVXX1303) to address a safety defect in approximately 23,003 model year (MY) 2007 through 2014 Volvo VAH, VHD, VNL, VNM and VT model trucks. The affected vehicles were manufactured from December 20, 2006 through May 22, 2013 and were originally equipped with the subject automated manual transmissions.According to Volvo, reports of the subject transmission clutch mechanism failing to automatically disengage as intended are associated with the removal of a brake pedal micro switch that provided a redundant signal to the transmission control module indicating the brakes had been applied.Previously, Volvo had removed this brake pedal micro switch from new vehicle production and from certain vehicles already in-service via two field service campaigns (SP 432-024 and SP 432-026) because it decided the switch was unnecessary and/or a maintenance issue.In the absence of this redundant brake pedal micro switch, the clutch mechanism may fail to disengage the transmission from the engine at low vehicle speed should the stop lamp switch fail to send and/or the transmission control module fail to receive the primary signal.At the time of this closing, Volvo is evaluating available remedies and will provide NHTSA with details when the recall remedy procedure has been finalized.Volvo will notify affected owners by mail by August 25, 2013.Please see NHTSA Recall No. 13V268 for details.Accordingly, this investigation is closed.
Service Brakes, Air:controls:foot Control/valve
The Office of Defects Investigation (ODI) received Early Warning Reporting (EWR) data from the manufacturer that indicated some number of subject vehicles equipped with the subject automated manual transmission had allegedly experienced a condition where the clutch failed to automatically disengage the transmission from the engine as intended. This may result in extended stopping distances and/or unintended forward motion of a vehicle previously at rest.To date, ODI is aware of 134 subject vehicles with one or more complaints or field reports related to this condition.Also, ODI is aware of 164 subject vehicles with one or more warranty claims related to this condition.By letter dated June 25, 2013, Volvo Trucks North America (Volvo) notified ODI that it has initiated a safety recall (NHTSA Recall No. 13V268 and Volvo Recall No. RVXX1303) to address a safety defect in approximately 23,003 model year (MY) 2007 through 2014 Volvo VAH, VHD, VNL, VNM and VT model trucks. The affected vehicles were manufactured from December 20, 2006 through May 22, 2013 and were originally equipped with the subject automated manual transmissions.According to Volvo, reports of the subject transmission clutch mechanism failing to automatically disengage as intended are associated with the removal of a brake pedal micro switch that provided a redundant signal to the transmission control module indicating the brakes had been applied.Previously, Volvo had removed this brake pedal micro switch from new vehicle production and from certain vehicles already in-service via two field service campaigns (SP 432-024 and SP 432-026) because it decided the switch was unnecessary and/or a maintenance issue.In the absence of this redundant brake pedal micro switch, the clutch mechanism may fail to disengage the transmission from the engine at low vehicle speed should the stop lamp switch fail to send and/or the transmission control module fail to receive the primary signal.At the time of this closing, Volvo is evaluating available remedies and will provide NHTSA with details when the recall remedy procedure has been finalized.Volvo will notify affected owners by mail by August 25, 2013.Please see NHTSA Recall No. 13V268 for details.Accordingly, this investigation is closed.
RQ11001 · Volvo Sleeper Glass de-bonding
Opened May 23, 2011 · Closed Jan 20, 2012
Status: closed (inferred from source dates) · Visibility:glass, Side/rear
ODI opened Recall Query RQ11-001 after a review of EWR Field Reports identified lower bunk window separations on the subject vehicles.Volvo had issued three recalls for sleeper window separations since 2003.Additionally, Volvo had issued two bulletins for sleeper window issues during the same time period.The frequency of related actions led ODI to open this formal investigation.An Information Request (IR) letter was sent to Volvo on 23 June 2011.Volvo responded on 17 August 2011 and then provided updated warranty information on 9 January 2012.Volvo provided production change data and warranty information which was correlated to vehicle build month and failure date.ODI analyzed the data to determine if additional production time frames should have been included in previous recalls.ODI also requested information from its network of fleet owners.The response from this network reaffirmed the accuracy of the updated warranty information.Based on the information and data received, ODI has concluded that all production periods have been appropriately addressed by Volvo's previous recalls and no additional recall action is required at this time.
PE07046 · Saf Holland Fifth Wheel Assembly
Opened Sep 14, 2007 · Closed Nov 9, 2007
Status: closed (inferred from source dates) · Trailer Hitches:fifth Wheel Assembly
ON OCTOBER 18, 2007 VOLVO TRUCKS NORTH AMERICA FILED DEFECT REPORT 07V-496 WHICH OUTLINES A SAFETY RECALL PROGRAM TO NOTIFY THE AFFECTED OWNERS AND CORRECT THE AFFECTED VEHICLES.