WHILE DRIVING MY 2000 VOLVO S80 ABOUT 20-25MPH ALL THE SUDDEN LOST POWER TO ALL MY GAUGES, DASHBOARD LIGHTS, POWER WINDOWS, & POWER LOCKS. THE RADIO WAS THE ONLY DEVICE THAT WAS WORKING. THE FOLLOWING MESSAGE WAS DISPLAYED SRS-AIRBAG SERVICE URGENT. I HAVE NOTICED A DIFFERENCE ON MY BRAKE PEDAL THAT IT DOES NOT RESPOND AS WELL A…
Read full complaint
WHILE DRIVING MY 2000 VOLVO S80 ABOUT 20-25MPH ALL THE SUDDEN LOST POWER TO ALL MY GAUGES, DASHBOARD LIGHTS, POWER WINDOWS, & POWER LOCKS. THE RADIO WAS THE ONLY DEVICE THAT WAS WORKING. THE FOLLOWING MESSAGE WAS DISPLAYED SRS-AIRBAG SERVICE URGENT. I HAVE NOTICED A DIFFERENCE ON MY BRAKE PEDAL THAT IT DOES NOT RESPOND AS WELL AS IT USE TOO THERE IS A SHORT DELAY WHEN STEPPED ON. BEFORE THIS INCIDENT I HAD NOTICED A CLICKING NOISE ON THE DRIVER SIDE WHEN A CAME TO A STOP LIKE A RELAY CHATTERING & ALSO THE AC WOULD COME ON WHEN THE CAR IS TURNED OFF. AT TIMES THE FOLLOWING MESSAGE WOULD APPEAR FREQUENTLY ALARM NEEDS SERVICING. I DON'T KNOW WHAT IS CAUSING THIS MALFUNCTIONS BUT IF ITS A MANUFACTURING PROBLEM VOLVO SHOULD BE LIABLE ON CORRECTING THE PROBLEM & PROVIDE US WITH A SAFE VEHICLE. *TR
NHTSA ODI #10482246
119,500 miles · Jan 6, 2008
Air BagsExterior LightingFuel System, Gasoline
1) ENGINE IDLES ROUGH, PROBLEM BECAME SO BAD THAT CAR STALLS AT LOW SPEEDS, LOST POWER STEERING & "ENGINE DIES" AT LOW SPEEDS (UNSAFE!). LOCAL MECH REFERRED TO ETM WARRANTY PROGRAM TO RE-PROGRAM FAULTY ETM MODULE. TOOK CAR TO DLR, RE-PROGRAMMED ETM CAR DIED AGAIN! TURNS OUT BAD BATTERY AS WELL: SEVERAL HUN…
Read full complaint
1) ENGINE IDLES ROUGH, PROBLEM BECAME SO BAD THAT CAR STALLS AT LOW SPEEDS, LOST POWER STEERING & "ENGINE DIES" AT LOW SPEEDS (UNSAFE!). LOCAL MECH REFERRED TO ETM WARRANTY PROGRAM TO RE-PROGRAM FAULTY ETM MODULE. TOOK CAR TO DLR, RE-PROGRAMMED ETM CAR DIED AGAIN! TURNS OUT BAD BATTERY AS WELL: SEVERAL HUNDRED $$$ TO REPLACE BATTERY. CAR DOES NOT ACCELERATE SMOOTHLY, LARGE "SHUDDERS" PRESENT WHEN MERGING ONTO HWY, DURING TRANSMISSION/GEAR SHIFT. NOT GOOD! 2) AIRBAG "SRS-URGENT SERVICE" WARNING INDICATOR LIGHT IS ON. GOOD LOCAL MECH. STATES THIS IS A $1000 REPAIR. 3) "CHECK BRAKE LIGHT" WARNING INDICATOR LIGHT TURNS ON WHEN DEPRESSING ON BRAKE PEDAL: GOOD LOCAL MECH. STATES THAT THIS IS "NORMAL" REQUIRES EXACT MATCHING ELECTRICAL RESISTANCE OF ALL BRAKE LAMPS TO ENSURE THAT "CHECK BRAKE LIGHT" WARNING DOES NOT OCCUR (IN ACTUALITY THE BRAKE LIGHTS WORK FINE, THE BUILT-IN-TEST IS FAULTY). 4) "CHECK ENGINE LIGHT" COMES ON 2-3 TIMES IN LAST 3 MONTHS. MAJOR SERVICE WAS REQUIRED. ONE FAULT WAS ISOLATED TO FUEL TANK GAS CAP: IF NOT SECURED PROPERLY "ECM-4308 (LEAK DIAGNOSTIC) LARGE LEAK" OCCURS...REMEDIED BY TWISTING FUEL CAP 3 FULL ROTATIONS, AFTER RE-FUELING GAS TANK. GOOD LOCAL MECH. DIAGNOSED THE LOOSE GAS CAP PROBLEM, WARNED ME ABOUT IT, AND DIDN'T CHARGE ME (NICE!). 5) BODY PAINT IS VERY SUSCEPTIBLE TO CHIPPING & SCRATCHES. PAINT OR EXTERIOR PANELS ARE VERY SOFT AND EASILY DAMAGED. ANOTHER SHAME, THIS CAR LOOKS GREAT BUT DOES NOT HOLD UP VERY WELL UNDER TYPICAL PARKING LOT CONDITIONS (I.E. SOMEONE PARKED NEXT TO YOU OPENS THEIR CAR DOOR INTO THE SIDE OF YOUR CAR RESULTING IN A LARGE SCRATCH). SOLUTION: PURCHASE A FANCY CAR COVER AND PROTECT THE BODY PAINT, IF YOU CAN! 6) PARKING BRAKE "SEEMS LOOSE", UPON PARKING CAR AND ENGAGING PARKING BRAKE THE VEHICLE ROLLS ALMOST 30 CM BWDS OR FWD DEPENDING ON LEVEL OR INCLINED SURFACE. *TR
NHTSA ODI #10213987
82,000 miles · Oct 8, 2006
Electrical SystemExterior Lighting
MY 2000 VOLVO S80 BEGAN GIVING ME ERROR MESSAGES OF SEVERAL KINDS, ONE OF WHICH TELLS ME "DIPPED BEAM BULB FAILURE." WHEN THAT HAPPENS, THE LOW BEAM HEADLIGHTS DO NOT WORK (THEY COME ON WHEN I START THE CAR AS RUNNING LIGHTS). AFTER BUYING NEW BULBS TO PUT IN, I FOUND THAT THE OLD BULBS WERE NOT BURNED OUT AND THAT THE PROBLE…
Read full complaint
MY 2000 VOLVO S80 BEGAN GIVING ME ERROR MESSAGES OF SEVERAL KINDS, ONE OF WHICH TELLS ME "DIPPED BEAM BULB FAILURE." WHEN THAT HAPPENS, THE LOW BEAM HEADLIGHTS DO NOT WORK (THEY COME ON WHEN I START THE CAR AS RUNNING LIGHTS). AFTER BUYING NEW BULBS TO PUT IN, I FOUND THAT THE OLD BULBS WERE NOT BURNED OUT AND THAT THE PROBLEM OCCURRED AT RANDOM. THE BIG PROBLEM WAS DRIVING HOME WITH THE BRIGHT LIGHTS ONLY - WHICH THOUGH SEEMED DIFFERENTLY, ARE NOT TOO AWFULLY BRIGHT - ONLY A FEW PEOPLE FLASHED ME. I THEN HAD OTHER CODES COMING UP AND HAD TO REPLACE THE "ABS CONTROLLER" TO THE TUNE OF $1000; AND, GUESS WHAT? THE DIPPED BEAM BULB FAILURE MESSAGE STILL OCCURS OFF AND ON (SPENDING THE $1000 DID CURE THE OTHER, MULTIPLE MESSAGES)*JB
NHTSA ODI #10170237
71,000 miles · Jun 28, 2006
Exterior Lighting
DT*: THE CONTACT STATED THE HEADLIGHTS, BRAKE LIGHTS, TURN SIGNAL LIGHTS AND REVERSE LIGHTS HAVE FAILED ON 30 SEPERATE OCCASSIONS. THE BULB LIGHT FAILURE INDICATOR HAS WORKED IN EACH CASE. THE DEALER AGREED THERE WAS A PROBLEM, BUT HAD NO SOLUTION.
NHTSA ODI #10160956
Mileage unknown · Jul 18, 2001
Exterior LightingStructureSuspension
THERE IS AN OVERALL PROBLEM WITH THE S80 CARS. I HAVE BEEN TO THE DEALER ON MANY OCCASIONS FOR OTHER REPAIRS SUCH AS THE ROOF TOP COVER, BRAKE LIGHTS...BECAUSE OF THE BALL JOINTS AND THE ON AND OFF HUMING NOISE, I AM UNCOMFORTABLE DRIVING THE CAR BEYOND THE AREA. THE DEALER AND THE MANUFACTURER WERE CONTACTED. WE ONLY REQUESTED …
Read full complaint
THERE IS AN OVERALL PROBLEM WITH THE S80 CARS. I HAVE BEEN TO THE DEALER ON MANY OCCASIONS FOR OTHER REPAIRS SUCH AS THE ROOF TOP COVER, BRAKE LIGHTS...BECAUSE OF THE BALL JOINTS AND THE ON AND OFF HUMING NOISE, I AM UNCOMFORTABLE DRIVING THE CAR BEYOND THE AREA. THE DEALER AND THE MANUFACTURER WERE CONTACTED. WE ONLY REQUESTED THE OTPIONS OF EITHER CANCELLING THE LEASE OR ANOTHER CAR SINCE MINE IS A LEMON...I WAS NOT SUCCESSFUL WHICH MADE ME WONDER IF THIS IS A SERIOUS ISSUE AND OTHERS ARE COMING FORWARD. I FELT THE NEED TO HIGHLIGHT THIS TO THE NTSB TO FOLLOW-UP WITH THE MANUFACTURER AND GET DATA ACCROSS THE COUNTRY.*AK
NHTSA ODI #748653
Mileage unknown · May 20, 2001
Exterior Lighting
RIGHT TURN SIGNAL FAILURE. FOUND R/F SIGNAL LIGHT BULB BLOWN,MELTED HOUSING OF CORNER LAMP. THERE WAS A BURNING SMELL. CAR WAS REPAIRED AT VOLVO REPAIR SHOP UNDER WARRANTY. *AK
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence & remedy
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, UNDER CERTAIN OPERATING CONDITIONS, SOME ELECTRIC COOLING FANS MAY OVERHEAT POTENTIALLY CAUSING HEAT DAMAGE AND, IN RARE INSTANCES, A FIRE IN THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: A FIRE IN THE ENGINE COMPARTMENT COULD OCCUR.
Remedy: DEALERS WILL REPLACE THE COOLING FAN. THE RECALL BEGAN ON NOVEMBER 29, 2004. CUSTOMERS SHOULD CONTACT VOLVO CARS AT 1-800-458-1552.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. OVER TIME, THE BALL JOINT BETWEEN THE FRONT WHEEL KING PIN AND THE SUSPENSION LINK ARM, CAN EXPERIENCE INCREASED LOOSENESS.
Consequence & remedy
Consequence: THIS CONDITION COULD AFFECT THE BALL JOINT'S DURABILITY AND PERFORMANCE.
Remedy: DEALERS WILL REPLACE BOTH FRONT BALL JOINTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
2000 Volvo S80 Problems, Complaints & Recalls | Skip That Year
Illustration