IllustrationWHILE DRIVING 40 MPH THE ETS (ELECTRONIC THROTTLE SYSTEM) LIGHT ILLUMINATED ON THE CONSUMER'S 2000 VOLVO V70XC. THE VEHICLE STARTED LOSING POWER THEN CAME TO A STOP. *NM THE MANUFACTURER WAS CONTACTED BUT DIDN'T SEEM TO BE CONCERNED AND REFUSED TO COVER THE COST TO REPAIR THE VEHICLE. *NM
2000 Volvo S70
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all S70 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
30–25K
1625–50K
5350–75K
2775–100K
21100–150K
7150K+
127 reports with mileage · 37 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Vehicle Speed Control. Review the 70 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports1 fire reports7 injury reports
What owners actually said
164 reports(SAFETY ISSUE) WHILE DRIVING ON THE HIGHWAY, THE PLASTIC SUN ROOF AIR DEFLECTOR SHATTERED AND PIECES OF THE AIR DEFLECTOR ENDED UP ON THE HIGHWAY POSSIBLY HITTING OTHER VEHICLES. THERE ARE NO SIGNS OF THE AIR DEFLECTOR BEING HIT BY ANY TYPE OF OBJECT. IT JUST APPEARED TO CRACK IN THE CENTER AND THE CENTER SECTION CAME OFF. BO…
Read full complaint
(SAFETY ISSUE) WHILE DRIVING ON THE HIGHWAY, THE PLASTIC SUN ROOF AIR DEFLECTOR SHATTERED AND PIECES OF THE AIR DEFLECTOR ENDED UP ON THE HIGHWAY POSSIBLY HITTING OTHER VEHICLES. THERE ARE NO SIGNS OF THE AIR DEFLECTOR BEING HIT BY ANY TYPE OF OBJECT. IT JUST APPEARED TO CRACK IN THE CENTER AND THE CENTER SECTION CAME OFF. BOTH ENDS OF THE DEFLECTOR WERE STILL ATTACHED TO THE VEHICLE. I DID REPORT THIS INCIDENT TO VOLVO, BUT THEY DID NOT SEEM CONCERNED ABOUT IT AND WOULD NOT LET ME KNOW IF THIS WAS A RECURRING INCIDENT. *NM
THROTTLE BODY WAS DEFECTIVE. VEHICLE WILL NOT ACCELERATE. DEALER STATED THROTTLE NEEDED TO BE CLEANED.*AK THE FAULTY THROTTLE MODULE CAUSED THE VEHICLE TO STALL AND SOMETIMES MADE IT IMPOSSIBLE TO MAINTAIN A CONSTANT SPEED. *NM
AUTOMATIC TRANSMISSION DEVELOPED A PROBLEM: SLIPPING AND SHUDDERING DURING ACCELERATION BETWEEN 16-20 MPH. THE VOLVO DEALER SAID TRANSMISSION WAS DAMAGED AND COULD NOT BE REPAIRED: THEY REPLACED IT WITH A REBUILT VOLVO TRANS. WARRANTY WAS 4 YR, 50,000 MI: TRANS FAILED AT 3 YR, 9 MO, 56839 MI -THE DEALER REFUSED TO HONOR WARR…
Read full complaint
AUTOMATIC TRANSMISSION DEVELOPED A PROBLEM: SLIPPING AND SHUDDERING DURING ACCELERATION BETWEEN 16-20 MPH. THE VOLVO DEALER SAID TRANSMISSION WAS DAMAGED AND COULD NOT BE REPAIRED: THEY REPLACED IT WITH A REBUILT VOLVO TRANS. WARRANTY WAS 4 YR, 50,000 MI: TRANS FAILED AT 3 YR, 9 MO, 56839 MI -THE DEALER REFUSED TO HONOR WARRANTY OR TO TRY TO REPAIR EXISTING TRANS: INSISTED UPON REPLACEMENT OF TRANS AT COST OF $3,889.92. *JB THE CONSUMER FELT THAT VOLVO INTENTIONALLY PLACED DEFECTIVE AUTOMATIC TRANSMISSIONS IN THEIR VEHICLES TO FAIL PREMATURELY. *SC *JB
DRIVING ON INTERSTATE HIGHWAY, CAR BEGAN TO HESITATE AND STALL ELECTRONIC THROTTLE CONTROL WAS DEFECTIVE, CAR BECAME INOPERABLE DEALER REPLACED THROTTLE BODY AND ASSOCIATED PARTS. *AK
MY ETS LIGHT KEPT COMING ON. I HAD TO STOP MY CAR IN HIGH SPEED TRAFFIC 10-12 TIMES AND RESTART IT. A WEB SEARCH REVEALS THAT THIS IS A FREQUENT PROBLEM WITH VOLVO S-70. THE CAR SUDDENLY LOSES POWER AND WILL SHUT OFF IF YOU CONTINUE TO DRIVE.*AK
I HAVE A 200 VOLVO S70. A COUPLE OF DAYS AGO, MY SON WAS DRIVING IT AND, SUDDENLY, THE ETS INDICATORLIGHT CAME ON, THE CAR STARTED SHAKING, AND LOST POWER (MY SON SAID IT COULDN'T GO FASTER THAN ABOUT 10 MPH). MY OWNER'S MANUAL INFORMS ME THAT THIS LIGHT INDICATES A FAULT IN THE ETC (ELECTRONIC THROTTLE CONTROL SYSTEM). IN RE…
Read full complaint
I HAVE A 200 VOLVO S70. A COUPLE OF DAYS AGO, MY SON WAS DRIVING IT AND, SUDDENLY, THE ETS INDICATORLIGHT CAME ON, THE CAR STARTED SHAKING, AND LOST POWER (MY SON SAID IT COULDN'T GO FASTER THAN ABOUT 10 MPH). MY OWNER'S MANUAL INFORMS ME THAT THIS LIGHT INDICATES A FAULT IN THE ETC (ELECTRONIC THROTTLE CONTROL SYSTEM). IN RESEARCHING THIS PROBLEM, I HAVE DISCOVERED THAT IT IS FAIRLY WIDESPREAD. THIS IS POTENTIALLY VERY DANGEROUS. IN FACT, ONE PERSON GAVE A HARROWING ACCOUNT (ON THE INTERNET) OF ALMOST BEING HIT BY ONCOMING TRAFFIC WHILE MAKING A LEFT TURN BECAUSE THIS PROBLEM CAUSED HIS CAR'S SPEED TO DIMINISH TO A CRAWL EVEN AS HE FLOORED THE ACCELERATOR IN A SITUATION WHERE OTHER DRIVERS RIGHTLY EXPECTED HIM TO BE MOVING MUCH MORE QUICKLY. APPARENTLY, THE USUAL REPAIR FOR THIS PROBLEM IS REPLACEMENT OF THE ECM(ELECTRONIC CONTROL MODULE), A JOB WHICH COSTS ABOUT A THOUSAND DOLLARS. CONSIDERING THE SIGNIFICANT EXPENSE OF THIS JOB, MANY VOLVO DRIVERS MIGHT BE UNDERSTANDABLY RELUCTANT TO PART WITH THAT MUCH MONEY; THAT COULD BE DANGEROUS. I HAVE SPOKEN TO SEVERAL PEOPLE AT VOLVO DEALERSHIPS AND WILL SPEAK TO SOMEONE IN THE SERVICE DEPARTMENT OF MY LOCAL VOLVO DEALER TOMORROW. I SHOULD ADD THAT, AFTER LETTING THE CAR SIT WITH THE IGNITION OFF FOR ABOUT A HALF HOUR, IT STARTED RIGHT UP AND HAS BEEN PERFORMING ABSOLUTELY NORMALLY SO FAR. SOME SAY THE PROBLEM WILL PROBABLY HAPPEN AGAIN, AND ONE VOLVO TECHNICIAN SAID THAT MAYBE IT WAS JUST A "HICCUP" THAT WON'T EVER RETURN. I DON'T WANT TO SPEND A THOUSAND DOLLARS IF THE LATTER POSSIBILITY IS CORRECT; ON THE OTHER HAND, I DON'T FEEL SECURE ABOUT TAKING MY DAILY COMMUTE OVER A HIGH-TRAFFIC BRIDGE OR CONTEMPLATING A LONG VACATION TRIP IN THIS CAR. I BOUGHT A VOLVO BECAUSE OF ITS REPUTATION FOR SAFETY. IRONICALLY, NOW I FEEL ANYTHING BUT SAFE.*AK
ETS LIGHT CAME ON AND CAR THROTTLE SYSTEM WAS AFFECTED. CAR LOST POWER TWICE ON THE HIGHWAY WHEN TRAVELLING AT APPROX 60 MPH. HAD TO PULL OVER TO AVOID POTENTIAL ACCIDENT. REPEATEDLY EXPERIENCED PROBLEMS WHEN IDLING AT TRAFFIC LIGHT. THROTTLE BODY WAS REPLACED AT DEALER FOR OVER $900.00 AND VEHICLE WAS 7,000 MILES OUT OF WARRA…
Read full complaint
ETS LIGHT CAME ON AND CAR THROTTLE SYSTEM WAS AFFECTED. CAR LOST POWER TWICE ON THE HIGHWAY WHEN TRAVELLING AT APPROX 60 MPH. HAD TO PULL OVER TO AVOID POTENTIAL ACCIDENT. REPEATEDLY EXPERIENCED PROBLEMS WHEN IDLING AT TRAFFIC LIGHT. THROTTLE BODY WAS REPLACED AT DEALER FOR OVER $900.00 AND VEHICLE WAS 7,000 MILES OUT OF WARRANTY. COMPLAINED TO VOLVO CUSTOMER SERVICE. NO HELP WAS GIVEN. LOSING A CUSTOMER!!!*AK
DURING NORMAL CRUISING AROUND 55-60 MPH, THE ETS LIGHT WILL COME ON AS THE VEHICLE BEGINS TO STUTTER AND THE ENGINE MODULATES. IT HAS BECOME WORSE OVER THE LAST WEEK AND NOW THE ENGINE "BUCKS" WHEN THE LIGHT IS ON! THIS IS UNPLEASANT AT 55 MPH! EVERY TIME THE ETS LIGHT COMES ON THE CRUISE CONTROL DISENGAGES AND IS NOT ABLE TO…
Read full complaint
DURING NORMAL CRUISING AROUND 55-60 MPH, THE ETS LIGHT WILL COME ON AS THE VEHICLE BEGINS TO STUTTER AND THE ENGINE MODULATES. IT HAS BECOME WORSE OVER THE LAST WEEK AND NOW THE ENGINE "BUCKS" WHEN THE LIGHT IS ON! THIS IS UNPLEASANT AT 55 MPH! EVERY TIME THE ETS LIGHT COMES ON THE CRUISE CONTROL DISENGAGES AND IS NOT ABLE TO BE RESET UNTIL THE LIGHT GOES OFF MANY IGNITION CYCLES (DAYS) LATER. SOME RESEARCH WAS DONE OVER THE WEB AND IT IS AMAZING TO SEE PEOPLE DESCRIBE THE EXACT SAME OR SIMILAR MANIFESTATION HAPPEN ON THEIR S70S. I HAVE AN APPOINTMENT TOMORROW AT THE DEALER IN ANN ARBOR AND EXPECT A > $900 BILL! COME ON VOLVO, HOW CAN YOU NOT HAVE SO MANY COMPLIANTS AND NOT RECALL?*AK
THE ETS (ELECTRONIC THROTTLE SYSTEM) LIGHT COME ON INTERMITTENLY FOR ABOUT A MONTH, THEN ON APRIL 20, 2004 WHILE I WAS DRIVING ON THE HIGHWAY, THE LIGHT STAYS ON THE CAR WAS SLUGGISH IN ACCELERATING. I HAD TO GET OFF THE HIGHWAY TO TAKE LOCAL STREETS. *AK
Official recalls
306V441000 · Vehicle Speed Control
Nov 15, 2006
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence & remedy
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
04V504000 · Exterior Lighting:headlights:switch
Oct 21, 2004
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, OVER AN EXTENDED PERIOD OF TIME, THE HEADLIGHT SWITCH MAY CEASE TO FUNCTION.
Consequence & remedy
Consequence: THE HEAD LIGHTS MAY NOT OPERATE PROPERLY WHICH COULD RESULT IN INTERMITTENT OR NO HEADLIGHT FUNCTION. THIS COULD IMPAIR A DRIVER'S VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: ON VEHICLES WITH AN ORIGINAL OEM SWITCH, DEALERS WILL REPLACE THE HEADLIGHT SWITCH. ALL OTHER VEHICLES WILL BE INSPECTED TO DETERMINE IF THE SWITCH HAS EEN DAMAGED AND REPLACE ONLY IF NECESSARY. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
00V405000 · Exterior Lighting:turn Signal
Dec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THERE COULD BE INADEQUATE CONTACT BETWEEN THE BULB AND SOCKET WHICH COULD CAUSE THE FRONT TURN SIGNAL NOT TO FUNCTION AS DESIGNED.
Consequence & remedy
Consequence: THIS WOULD FAIL TO WARN AN APPROACHING DRIVER THAT THE VEHICLE IS TURNING AND COULD LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT TURN SIGNAL BULB AND SOCKET.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
RQ04004 · Headlight Failure
Opened Jun 8, 2004 · Closed Nov 5, 2004
Status: closed (inferred from source dates) · Exterior Lighting:headlights; Exterior Lighting:headlights:switch
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Additional source detail variants (2)
Exterior Lighting:headlights:switch
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Exterior Lighting:headlights
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.