NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
70 reportsClear category filter61,800 miles · Jul 22, 2005
Vehicle Speed Control
VEHICLE EXHIBITS "HESITATION AND STUTTERING" DURING BOTH ACCELERATION AND MAINTAINING STEADY SPEED. ETS WARNING LIGHT HAS APPEARED AND THEN RESET TWICE. TUNE-UP AND FUEL CHANGES WERE TESTED WITH NO CHANGE IN ISSUE. ETS WARNING LIGHT AND ON-BOARD DIAGNOSTICS INDICATED ELECTRONIC THROTTLE MODULE FAILURE AND REQUIRED REPLACEMENT. I…
Read full complaint
VEHICLE EXHIBITS "HESITATION AND STUTTERING" DURING BOTH ACCELERATION AND MAINTAINING STEADY SPEED. ETS WARNING LIGHT HAS APPEARED AND THEN RESET TWICE. TUNE-UP AND FUEL CHANGES WERE TESTED WITH NO CHANGE IN ISSUE. ETS WARNING LIGHT AND ON-BOARD DIAGNOSTICS INDICATED ELECTRONIC THROTTLE MODULE FAILURE AND REQUIRED REPLACEMENT. I HAVE THE OLD PART AND THE DIAGNOSTIC PRINTOUTS. AFTER RESEARCHING THIS ISSUE, IT APPEARS THAT THIS IS A COMMON AND PREMATURE FAILURE ITEM ON VOLVO CARS FROM 1999 THRU 2001 MODEL YEARS. SINCE THIS IS A CRITICAL SFAETY COMPONENT THAT CAN FAIL WITHOUT NOTICE (AT THE WORST POSSIBLE TIME), IT SHOULD BE AS RELIABLE AS OTHER CRITICAL COMPONEENTS SUCH AS THE ABS OR SRS/AIRBAG SYSTEMS. THIS DOES NOT APPEAR TO BE THE CASE.
NHTSA ODI #10129684
68,880 miles · Apr 18, 2005
Vehicle Speed Control
ELECTRONIC THROTTLE SYSTEM IN MY 2000, VOLVO S70 WENT OUT, AND THE CAR SURGED AND LIMPED HOME. NO ADVERSE CONSEQUENCES OCCURRED THIS TIME, BUT THE POTENTIAL FOR DISASTER BY BEING STRANDED ON A BUSY HIGHWAY OR ELECTRONIC THROTTLE SYSTEM MALFUNCTIONING AS YOU PULL OUT INTO TRAFFIC RAISED MANY SAFETY CONCERNS. THIS SEEMED FROM…
Read full complaint
ELECTRONIC THROTTLE SYSTEM IN MY 2000, VOLVO S70 WENT OUT, AND THE CAR SURGED AND LIMPED HOME. NO ADVERSE CONSEQUENCES OCCURRED THIS TIME, BUT THE POTENTIAL FOR DISASTER BY BEING STRANDED ON A BUSY HIGHWAY OR ELECTRONIC THROTTLE SYSTEM MALFUNCTIONING AS YOU PULL OUT INTO TRAFFIC RAISED MANY SAFETY CONCERNS. THIS SEEMED FROM MY RESEARCH TO BE A COMMON PROBLEM, AND THE ONLY OPTION WAS TO CARRY A CELL PHONE AND MAKE SURE YOUR INSURANCE COVERED TOWING. TO MAKE THINGS WORSE THE REPAIRS COST NEARLY $1000, AND COULD HAPPEN AGAIN DUE TO THE SAME FAULTY PART BEING INSTALLED A SECOND TIME. VOLVO SHOULD OWN UP TO THIS AND RECALL ALL THE VEHICLES WITH THIS FAULTY PART.*AK
NHTSA ODI #10118038
42,000 miles · Feb 16, 2005
Vehicle Speed Control
WHILE DRIVING 40 MPH THE ETS (ELECTRONIC THROTTLE SYSTEM) LIGHT ILLUMINATED ON THE CONSUMER'S 2000 VOLVO V70XC. THE VEHICLE STARTED LOSING POWER THEN CAME TO A STOP. *NM THE MANUFACTURER WAS CONTACTED BUT DIDN'T SEEM TO BE CONCERNED AND REFUSED TO COVER THE COST TO REPAIR THE VEHICLE. *NM
NHTSA ODI #10113803
60,000 miles · Sep 28, 2004
Vehicle Speed Control
THROTTLE BODY WAS DEFECTIVE. VEHICLE WILL NOT ACCELERATE. DEALER STATED THROTTLE NEEDED TO BE CLEANED.*AK THE FAULTY THROTTLE MODULE CAUSED THE VEHICLE TO STALL AND SOMETIMES MADE IT IMPOSSIBLE TO MAINTAIN A CONSTANT SPEED. *NM
NHTSA ODI #10091614
56,810 miles · Jun 6, 2004
Electrical SystemVehicle Speed Control
I HAVE A 200 VOLVO S70. A COUPLE OF DAYS AGO, MY SON WAS DRIVING IT AND, SUDDENLY, THE ETS INDICATORLIGHT CAME ON, THE CAR STARTED SHAKING, AND LOST POWER (MY SON SAID IT COULDN'T GO FASTER THAN ABOUT 10 MPH). MY OWNER'S MANUAL INFORMS ME THAT THIS LIGHT INDICATES A FAULT IN THE ETC (ELECTRONIC THROTTLE CONTROL SYSTEM). IN RE…
Read full complaint
I HAVE A 200 VOLVO S70. A COUPLE OF DAYS AGO, MY SON WAS DRIVING IT AND, SUDDENLY, THE ETS INDICATORLIGHT CAME ON, THE CAR STARTED SHAKING, AND LOST POWER (MY SON SAID IT COULDN'T GO FASTER THAN ABOUT 10 MPH). MY OWNER'S MANUAL INFORMS ME THAT THIS LIGHT INDICATES A FAULT IN THE ETC (ELECTRONIC THROTTLE CONTROL SYSTEM). IN RESEARCHING THIS PROBLEM, I HAVE DISCOVERED THAT IT IS FAIRLY WIDESPREAD. THIS IS POTENTIALLY VERY DANGEROUS. IN FACT, ONE PERSON GAVE A HARROWING ACCOUNT (ON THE INTERNET) OF ALMOST BEING HIT BY ONCOMING TRAFFIC WHILE MAKING A LEFT TURN BECAUSE THIS PROBLEM CAUSED HIS CAR'S SPEED TO DIMINISH TO A CRAWL EVEN AS HE FLOORED THE ACCELERATOR IN A SITUATION WHERE OTHER DRIVERS RIGHTLY EXPECTED HIM TO BE MOVING MUCH MORE QUICKLY. APPARENTLY, THE USUAL REPAIR FOR THIS PROBLEM IS REPLACEMENT OF THE ECM(ELECTRONIC CONTROL MODULE), A JOB WHICH COSTS ABOUT A THOUSAND DOLLARS. CONSIDERING THE SIGNIFICANT EXPENSE OF THIS JOB, MANY VOLVO DRIVERS MIGHT BE UNDERSTANDABLY RELUCTANT TO PART WITH THAT MUCH MONEY; THAT COULD BE DANGEROUS. I HAVE SPOKEN TO SEVERAL PEOPLE AT VOLVO DEALERSHIPS AND WILL SPEAK TO SOMEONE IN THE SERVICE DEPARTMENT OF MY LOCAL VOLVO DEALER TOMORROW. I SHOULD ADD THAT, AFTER LETTING THE CAR SIT WITH THE IGNITION OFF FOR ABOUT A HALF HOUR, IT STARTED RIGHT UP AND HAS BEEN PERFORMING ABSOLUTELY NORMALLY SO FAR. SOME SAY THE PROBLEM WILL PROBABLY HAPPEN AGAIN, AND ONE VOLVO TECHNICIAN SAID THAT MAYBE IT WAS JUST A "HICCUP" THAT WON'T EVER RETURN. I DON'T WANT TO SPEND A THOUSAND DOLLARS IF THE LATTER POSSIBILITY IS CORRECT; ON THE OTHER HAND, I DON'T FEEL SECURE ABOUT TAKING MY DAILY COMMUTE OVER A HIGH-TRAFFIC BRIDGE OR CONTEMPLATING A LONG VACATION TRIP IN THIS CAR. I BOUGHT A VOLVO BECAUSE OF ITS REPUTATION FOR SAFETY. IRONICALLY, NOW I FEEL ANYTHING BUT SAFE.*AK
NHTSA ODI #10074895
57,000 miles · Jun 4, 2004
Vehicle Speed Control
ETS LIGHT CAME ON AND CAR THROTTLE SYSTEM WAS AFFECTED. CAR LOST POWER TWICE ON THE HIGHWAY WHEN TRAVELLING AT APPROX 60 MPH. HAD TO PULL OVER TO AVOID POTENTIAL ACCIDENT. REPEATEDLY EXPERIENCED PROBLEMS WHEN IDLING AT TRAFFIC LIGHT. THROTTLE BODY WAS REPLACED AT DEALER FOR OVER $900.00 AND VEHICLE WAS 7,000 MILES OUT OF WARRA…
Read full complaint
ETS LIGHT CAME ON AND CAR THROTTLE SYSTEM WAS AFFECTED. CAR LOST POWER TWICE ON THE HIGHWAY WHEN TRAVELLING AT APPROX 60 MPH. HAD TO PULL OVER TO AVOID POTENTIAL ACCIDENT. REPEATEDLY EXPERIENCED PROBLEMS WHEN IDLING AT TRAFFIC LIGHT. THROTTLE BODY WAS REPLACED AT DEALER FOR OVER $900.00 AND VEHICLE WAS 7,000 MILES OUT OF WARRANTY. COMPLAINED TO VOLVO CUSTOMER SERVICE. NO HELP WAS GIVEN. LOSING A CUSTOMER!!!*AK
NHTSA ODI #10074765
52,000 miles · Sep 1, 2003
Vehicle Speed Control
SPEED CONTROL. HAVE HAD A VARIETY OF SPEED/ENGINE CONTROL PROBLEMS. ENGINE WOULD DIE. ENGINE WOULD CAUSE "BUCKING". ENGINE WOULD NOT ACCELERATE. THROTTLE BODY AND AIR MASS METER REPLACED. THROTTLE BODY COVERED BY WARRANTY BUT I HAD TO PAY FOR AIR MASS METER REPLACEMENT. CURRENT PROBLEM TRAVELING @ 55 TO 60 MPH PRESS ON ACC…
Read full complaint
SPEED CONTROL. HAVE HAD A VARIETY OF SPEED/ENGINE CONTROL PROBLEMS. ENGINE WOULD DIE. ENGINE WOULD CAUSE "BUCKING". ENGINE WOULD NOT ACCELERATE. THROTTLE BODY AND AIR MASS METER REPLACED. THROTTLE BODY COVERED BY WARRANTY BUT I HAD TO PAY FOR AIR MASS METER REPLACEMENT. CURRENT PROBLEM TRAVELING @ 55 TO 60 MPH PRESS ON ACCELERATOR AND CAR WILL NOT ACCELERATE BUT WILL SLOW DOWN WITH RPMS HESITATING AT 5000 AND 4500 WITHOUT ACCELERATING. CAR SLOWS DOWN,LOSES POWER. THIS OCCURS USUALLY UNDER A HILL CLIMBING SITUATION BUT HAS OCCURRED ON FLAT TERRAIN. IN HILL CLIMBING ONCE MORE GRADUAL SLOPE REACHED, CAR ACCELERATES.*AK UPDATED 01/03/06. *JB
NHTSA ODI #10036988
Mileage unknown · Apr 16, 2001
Engine And Engine CoolingVehicle Speed Control
CONSUMER WAS TRAVELING 60MPH IN A 65MPH ZONE. PASSING ANOTHER VEHICLE GOING 60MPH HE FLOORED THROTTLE AND ETS LIGHT CAME UP ON DASHBOARD. VEHICLE WENT DOWN TO 2,000 RPM'S. CONSUMER PULLED OVER, AND READ MANUAL, STARTING VEHICLE BACK UP AND IT HAPPENED AGAIN. DEALER DIDN'T KNOW WHAT TO DO. THEY HAD TO INSPECT IT FOR PROBL…
Read full complaint
CONSUMER WAS TRAVELING 60MPH IN A 65MPH ZONE. PASSING ANOTHER VEHICLE GOING 60MPH HE FLOORED THROTTLE AND ETS LIGHT CAME UP ON DASHBOARD. VEHICLE WENT DOWN TO 2,000 RPM'S. CONSUMER PULLED OVER, AND READ MANUAL, STARTING VEHICLE BACK UP AND IT HAPPENED AGAIN. DEALER DIDN'T KNOW WHAT TO DO. THEY HAD TO INSPECT IT FOR PROBLEM. *AK THE TUBE GOING FROM BEHIND THE GRILL TO THE AIR CLEANER INLET WAS COLLAPSING CAUSING LACK OF AIR FLOW TO THE ENGINE. THE TUBE WAS REMOVED AND THE PROBLEM WAS SOLVED. *YH
NHTSA ODI #885996
Mileage unknown · Aug 5, 2000
Vehicle Speed Control
AS HAPPENED IN JULY AND REPORTED, ETS LIGHT CAME ON AND ENGINE SPEED THROTTLED AND SPUTTERED. PER MANUAL INSTRUCTIONS TURNED CAR ON AND OFF. ON 3RD ATTEMPT, ETS LIGHT WENT OFF AFTER STARTING. PROCEEDED TO DRIVE ONE MILE WITHOUT INCIDENT. AS SLOWED FOR LIGHT, ETS CAME ON AGAIN AND ENGINE CUT BACK. REPEATED PROCEDURE 4 TIME…
Read full complaint
AS HAPPENED IN JULY AND REPORTED, ETS LIGHT CAME ON AND ENGINE SPEED THROTTLED AND SPUTTERED. PER MANUAL INSTRUCTIONS TURNED CAR ON AND OFF. ON 3RD ATTEMPT, ETS LIGHT WENT OFF AFTER STARTING. PROCEEDED TO DRIVE ONE MILE WITHOUT INCIDENT. AS SLOWED FOR LIGHT, ETS CAME ON AGAIN AND ENGINE CUT BACK. REPEATED PROCEDURE 4 TIMES AND ROUGH STARTED EACH TIME. THEN CHECK ENGINE LIGHT CAME ON AND CAR DIED. TRIED STARTING AGAIN AND NO IGNITION. WAITED 5 MINUTES AND STARTED AGAIN. ENGINE KICKED IN, NO ETS ON, BUT CHECK ENGINE LIGHT CAME ON AND STAYED ON. CAR DRIVEABLE, NO ACCELERATION PROBLEMS. MADE U-TURN AND RETURNED HOME. TURNED VECHICLE OFF AND ON AGAIN 3 TIMES. CHECK ENGINE LIGHT STAYED ON. WAITED SEVEN HOURS BEFORE TRYING AGAIN. ON FIRST ATTEMPT, CAR STARTED PROPERLY AND NO DASH LIGHTS CAME ON. CONTACTED MCDONALD VOLVO (CLOSET TO HOME). TOLD OKAY TO DRIVE. DON'T BELIEVE IT. WILL TAKE IN TO DEALER ON MONDAY, 8/7 AND LEAVE FOR REPAIR. *AK
NHTSA ODI #726763
Mileage unknown · Jul 15, 2000
Vehicle Speed Control
ELECTRONIC THROTTLE SYSTEM (ETS) DASH LIGHT ILLUMINATED. ENGINE SPEED ELECTRONICALLY AUTOMATICALLY CUT BACK FROM 30 MPH AND HELD TO APPROX 10 MPH. I COULD NOT ACCERLATE. ACCELERATION RESTRAINED LIKE THERE WAS A GOVERNOR ON THE ENGINE. FOLLOWED OWNERS MANUAL INSTRUCTION. 4 TIMES CAR TURNED OFF AND ON AND LIGHT STAYED ON. LE…
Read full complaint
ELECTRONIC THROTTLE SYSTEM (ETS) DASH LIGHT ILLUMINATED. ENGINE SPEED ELECTRONICALLY AUTOMATICALLY CUT BACK FROM 30 MPH AND HELD TO APPROX 10 MPH. I COULD NOT ACCERLATE. ACCELERATION RESTRAINED LIKE THERE WAS A GOVERNOR ON THE ENGINE. FOLLOWED OWNERS MANUAL INSTRUCTION. 4 TIMES CAR TURNED OFF AND ON AND LIGHT STAYED ON. LET CAR SIT ONE HOUR. THROTTLE SYSTEM RETURNED TO NORMAL AFTER WAITING ONE HOUR BEFORE RESTARTING. PROBLEM NOT REOCCURRED FOR 2 DAYS NOW. CONTACTED DEALER--NO CLUE AS TOO PROBLEM. RELATED TO CURRENT TSB REGARDING THROTTLE SYSTEM. *AK
NHTSA ODI #725485
NHTSA investigations
3EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
RQ04004 · Headlight Failure
Opened Jun 8, 2004 · Closed Nov 5, 2004
Status: closed (inferred from source dates) · Exterior Lighting:headlights; Exterior Lighting:headlights:switch
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Additional source detail variants (2)
Exterior Lighting:headlights:switch
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Exterior Lighting:headlights
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Illustration