Electrical SystemFuel System, GasolineFuel System, Other
REGARDING VOLVO THROTTLE CONTROL JULY 2001-PURCHASED 1999 S70 WITH 22,600 MILES; CRUISE CONTROL QUIT, WARNING LIGHTS LIT, CAR BEGAN DECELERATING. DEALERSHIP SAID CHECK GAS CAP SECURELY-FITTING. AFTER RESTARTING, CRUISE CONTROL WORKED AND WARNING LIGHTS OFF. 30,000 MILE SERVICE- TOLD AGAIN TO CHECK GAS CAP WHENEVER CRUISE …
Read full complaint
REGARDING VOLVO THROTTLE CONTROL JULY 2001-PURCHASED 1999 S70 WITH 22,600 MILES; CRUISE CONTROL QUIT, WARNING LIGHTS LIT, CAR BEGAN DECELERATING. DEALERSHIP SAID CHECK GAS CAP SECURELY-FITTING. AFTER RESTARTING, CRUISE CONTROL WORKED AND WARNING LIGHTS OFF. 30,000 MILE SERVICE- TOLD AGAIN TO CHECK GAS CAP WHENEVER CRUISE PROBLEM OCCURRED. AUGUST 2002-USING CRUISE CONTROL, ACCELERATION WITHOUT REASON. IMMEDIATELY, CRUISE CONTROL QUIT, CAR DECELERATED, WARNING LIGHTS ON. NORMAL FUNCTION WITH MANUAL ACCELERATION. BY THIS TIME, I HAD "LEARNED" TO RESTART CAR TO GET WARNING LIGHTS TO TURN OFF OR TO GET CRUISE CONTROL TO START WORKING. AT DESTINATION, CAR WOULDN'T RESTART. TOW TRUCK DRIVER JUMP-STARTED BATTERY. ETS WARNING LIGHT STILL ON. WROTE TO DEALERSHIP OCTOBER 28, 2003, REGARDING ETS WARNING LIGHT. AT 37,500 MILE CHECK-UP, I WAS TOLD CAR REQUIRED ONLY NORMAL SERVICING. WHEN I LEFT DEALERSHIP, ETS LIGHT NO LONGER ON. LATER CAR BEGAN IDLING ROUGHLY AND DIDN'T ACCELERATE AS SMOOTHLY. AFTER 37,500 MILE SERVICE, CAR OPERATED MORE AS EXPECTED. WITHIN WEEKS, AGAIN IDLING ROUGHLY AND NOT ACCELERATING PROPERLY AFTER TURNING CORNERS. DEC. 31, 2003 (38,695 MILES), VOLVO TOWED TO DEALERSHIP BECAUSE UNSAFE TO DRIVE. WHEN TURNING, CAR BARELY MOVED FORWARD. ALSO, MOTOR STALLING OUT DURING ACCELERATION AFTER TURNING. NOISE SOUNDED LIKE IT EMANATED FROM POWER STEERING. POWER STEERING RACK REPLACED. AFTER SERVICING, ENGINE'S ACCELERATION BETTER FOR FEW MONTHS. (DID DEALERSHIP CLEANED THROTTLE DURING SERVICE?) REST OF THIS SENT IN SEPARATE DESCRIPTION DUE TO SPACE LIMITATIONS. *JB
NHTSA ODI #10137311
105,000 miles · Sep 11, 2005
Electrical System
1999 VOLVO S70 T5, DURING 2004 CAR STARTED AN IDLE/SURGE PROBLEM. TOOK IT TO DEALER WHO SAID THE MASS AIR FLOW CONTROL REGULATOR NEEDED CLEANING. PAID AROUND $200 AND CAR SEEMED FINE FOR AWHILE. IN JAN 2005 THE PROBLEM RETURNED, BUT WORSE. TOOK IT TO TWO DIFFERENT VOLVO CERTIFIED MECHANICS WHO SAID THERE WERE NO CODES IN COMPUT…
Read full complaint
1999 VOLVO S70 T5, DURING 2004 CAR STARTED AN IDLE/SURGE PROBLEM. TOOK IT TO DEALER WHO SAID THE MASS AIR FLOW CONTROL REGULATOR NEEDED CLEANING. PAID AROUND $200 AND CAR SEEMED FINE FOR AWHILE. IN JAN 2005 THE PROBLEM RETURNED, BUT WORSE. TOOK IT TO TWO DIFFERENT VOLVO CERTIFIED MECHANICS WHO SAID THERE WERE NO CODES IN COMPUTER, THEY COULD SEE THERE WAS A PROBLEM BUT HAD NO CLUE WHAT WAS CAUSING IT, JUST OPINIONS ON A COUPLE OF PART WE COULD TRY REPLACING. IN MARCH 05 THE VEHICLE STALLED WHILE DRIVING IN TRAFFIC, RESTARTED AND SEEMED TO RUN FINE, ASIDE FROM THE SURGING. HOWEVER, SURGING CONTINUED AND STALLING, IN TRAFFIC, OCCURRED AGAIN TWO WEEKS AGO. DOING MY OWN RESEARCH, I'M NOW FINDING THIS IS A KNOWN AND DANGEROUS PROBLEM WITH THIS MODEL VEHICLE. DUE TO FINANCIAL RESTRAINTS AT THIS MOMENT, I CANNOT AFFORD TO REPLACE THE ELECTRONIC THROTTLE CONTROL MODULE AND SO MY CAR MOSTLY SITS, BEING DRIVEN ONLY IF ABSOLUTELY NECESSARY. LUCKILY WE HAVE A SECOND VEHICLE. WE PURCHASED OUR VOLVO, DESPITE THE REPUTATION FOR PRICEY MAINTENANCE, WITH FAITH IN VOLVO'S REPUTATION FOR SAFETY AND RELIABILITY. A REPUTATION BUILT, IN PART, BY RATINGS SUPPLIED BY SEVERAL CONSUMER REPORTING AGENCIES, INCLUDING YOUR OWN. THE MANUFACTURER NEEDS TO TAKE RESPONSIBILITY FOR THIS DEFECTIVE EQUIPMENT, AND CONSUMER ADVOCACY AGENCIES SHOULD SEE TO IT THAT THEY DO. *NM
NHTSA ODI #10136138
50,000 miles · Sep 7, 2005
Electrical System
ROUGH IDLE ETS LIGHT CAME ON CAR DIED REPLACED ETM. *NM
NHTSA ODI #10135538
Mileage unknown · Sep 3, 2005
Electrical System
ELECTRONIC THROTTLE MODULE HAD TO BE REPLACED DUE TO FAILURE. THE WARNING LIGHTS CAME ON AND THE CAR REPEATEDLY JERKED DURING DRIVING. DEALER ASSESSED SITUATION AND HAD NO CHOICE BUT TO REPLACE. *JB
NHTSA ODI #10135236
63,000 miles · Sep 2, 2005
Electrical System
ST: VEHICLE STALLED/DIED/LOST POWER WHILE DRIVING AT 20 MPH. DEALER REPLACED THROTTLE BODY. *AK *JB
NHTSA ODI #10131951
Mileage unknown · Aug 30, 2005
Electrical System
MY CARS ELECTRONIC THROTTLE HAD TO BE REPLACED. THIS WAS DONE UNDER THE WARRANTY PERIOD BUT I'M WRITING TO MAKE YOU AWARE OF THIS FOR THE BENEFIT OF THE PEOPLE WHOSE CARS SYSTEMS LASTED SLIGHTLY LONGER, OUT OF WARRANTY. VOLVO KNEW THEY HAD ISSUES WITH DEFECTIVE THROTTLES AND SHOULD STAND BEHIND THEIR PRODUCT. THESE CARS ARE NOT…
Read full complaint
MY CARS ELECTRONIC THROTTLE HAD TO BE REPLACED. THIS WAS DONE UNDER THE WARRANTY PERIOD BUT I'M WRITING TO MAKE YOU AWARE OF THIS FOR THE BENEFIT OF THE PEOPLE WHOSE CARS SYSTEMS LASTED SLIGHTLY LONGER, OUT OF WARRANTY. VOLVO KNEW THEY HAD ISSUES WITH DEFECTIVE THROTTLES AND SHOULD STAND BEHIND THEIR PRODUCT. THESE CARS ARE NOT CHEAP AND OWNERS SHOULD NOT BE 'BETA' TESTERS FOR NEW SYSTEMS.*JB
NHTSA ODI #10134802
99,500 miles · Aug 26, 2005
Electrical System
ELECTRONIC THROTTLE CONTROL CAUSES CAR TO STALL REPEATEDLY- OFTEN IN SITUATIONS WHERE IT IS UNSAFE TO PULL OVER. *JB
NHTSA ODI #10134321
75,845 miles · Aug 26, 2005
Electrical System
1. I NOTICED THE PROBLEM WHEN I WAS DRIVING ON THE HIGHWAY. THE CAR FELT LIKE IT WAS LOSING POWER OR MISSING LIKE IT WAS GONG TO STOP RUNNING. FORTUNATELY, UNLIKE OTHERS, I WAS NOT STRANDED. 2. MY 75,000 MILE SERVICE WAS DUE SO I TOOK THE CAR IN FOR THAT AND ALSO LET THE VOLVO DEALER KNOW ABOUT THE PROBLEM. 3. THEY RAN DIA…
Read full complaint
1. I NOTICED THE PROBLEM WHEN I WAS DRIVING ON THE HIGHWAY. THE CAR FELT LIKE IT WAS LOSING POWER OR MISSING LIKE IT WAS GONG TO STOP RUNNING. FORTUNATELY, UNLIKE OTHERS, I WAS NOT STRANDED. 2. MY 75,000 MILE SERVICE WAS DUE SO I TOOK THE CAR IN FOR THAT AND ALSO LET THE VOLVO DEALER KNOW ABOUT THE PROBLEM. 3. THEY RAN DIAGNOSTICS AND DETERMINED IT TO BE THE ELECTRONIC THROTTLE MODULE. THEY REPLACED THE PART WITH A NEW REDESIGNED PART. I DO NOT KNOW IF THE OLD PART IS AVAILABLE. P.S. THE DEALERSHIP CALLED VOLVO AND VOLVO AGREED TO PAY FOR THE PART NOT THE LABOR, WHICH SAVED ME ABOUT $500. THAT WAS A GOOD GESTURE. 8JB
NHTSA ODI #10134294
87,000 miles · Aug 23, 2005
Electrical System
ETS LIGHTS COMES ON/OFF. CAR CONTINUES TO BREAK DOWN, LAST TIME ON INTERSTATE. DEALER SAYS DOESN'T KNOW WHAT'S WRONG.
NHTSA ODI #10133850
60,150 miles · Aug 15, 2005
Electrical System
CAR BEGAN RUNNING POORLY, STALLING ON OCCASION AND HESITATING TO ACCELERATE. UPON SERVICING THE CAR, THE DEALER INFORMED ME THAT THE ELECTRONIC THROTTLE BODY WAS BAD AND NEEDED TO BE REPLACED. WHEN I TOOK IT TO THE DEALER FOR REPLACEMENT, THEY CLEANED IT INSTEAD. I SUBSEQUENTLY RETURNED TO HAVE IT REPLACED. THE DEALER DISCOUNTE…
Read full complaint
CAR BEGAN RUNNING POORLY, STALLING ON OCCASION AND HESITATING TO ACCELERATE. UPON SERVICING THE CAR, THE DEALER INFORMED ME THAT THE ELECTRONIC THROTTLE BODY WAS BAD AND NEEDED TO BE REPLACED. WHEN I TOOK IT TO THE DEALER FOR REPLACEMENT, THEY CLEANED IT INSTEAD. I SUBSEQUENTLY RETURNED TO HAVE IT REPLACED. THE DEALER DISCOUNTED THE REPLACEMENT COST BY THE AMOUNT I HAD PAID FOR THE EARLIER CLEANING. *JB
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence & remedy
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, OVER AN EXTENDED PERIOD OF TIME, THE HEADLIGHT SWITCH MAY CEASE TO FUNCTION.
Consequence & remedy
Consequence: THE HEAD LIGHTS MAY NOT OPERATE PROPERLY WHICH COULD RESULT IN INTERMITTENT OR NO HEADLIGHT FUNCTION. THIS COULD IMPAIR A DRIVER'S VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: ON VEHICLES WITH AN ORIGINAL OEM SWITCH, DEALERS WILL REPLACE THE HEADLIGHT SWITCH. ALL OTHER VEHICLES WILL BE INSPECTED TO DETERMINE IF THE SWITCH HAS EEN DAMAGED AND REPLACE ONLY IF NECESSARY. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THERE COULD BE INADEQUATE CONTACT BETWEEN THE BULB AND SOCKET WHICH COULD CAUSE THE FRONT TURN SIGNAL NOT TO FUNCTION AS DESIGNED.
Consequence & remedy
Consequence: THIS WOULD FAIL TO WARN AN APPROACHING DRIVER THAT THE VEHICLE IS TURNING AND COULD LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT TURN SIGNAL BULB AND SOCKET.
VEHICLE DESCRIPTION: ALL-WHEEL-DRIVE SEDANS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILTER BRACKET CONFIGURATION MARGINS ARE INSUFFICIENT.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, FUEL LEAKAGE COULD OCCUR. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A FUEL FILTER PROTECTION BRACKET.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Additional source detail variants (2)
Exterior Lighting:headlights:switch
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Exterior Lighting:headlights
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
PE00031 · Turn Signal
Opened Aug 15, 2000 · Closed Dec 22, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE99040 · Inadvertent Side Air Bag Deployment
Opened Jun 7, 1999 · Closed Oct 27, 1999
Status: closed (inferred from source dates) · Air Bags:side/window
No summary supplied.
1999 Volvo S70 Problems, Complaints & Recalls | Skip That Year
Illustration