NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
48 reportsClear category filter79,842 miles · Jun 19, 2009
Electrical SystemEngine And Engine Cooling
TL*THE CONTACT OWNS A 1999 VOLVO S70. IN 2001, THE SPEEDOMETER FAILED AND DISPLAYED ZERO WHEN THE VEHICLE WAS TRAVELING 10 MPH. EVENTUALLY, THE VEHICLE BEGAN TO SHUT OFF IN TRAFFIC AND WHILE DRIVING BETWEEN 60-65 MPH. THE DEALER REPLACED THE SENSORS SEVERAL TIMES. THE CONTACT TOOK THE VEHICLE TO A REPAIR SHOP AND THE SENSORS…
Read full complaint
TL*THE CONTACT OWNS A 1999 VOLVO S70. IN 2001, THE SPEEDOMETER FAILED AND DISPLAYED ZERO WHEN THE VEHICLE WAS TRAVELING 10 MPH. EVENTUALLY, THE VEHICLE BEGAN TO SHUT OFF IN TRAFFIC AND WHILE DRIVING BETWEEN 60-65 MPH. THE DEALER REPLACED THE SENSORS SEVERAL TIMES. THE CONTACT TOOK THE VEHICLE TO A REPAIR SHOP AND THE SENSORS WERE REPLACED AGAIN. SHE WAS UNSURE ABOUT THE NAME OF THE SENSOR; HOWEVER, THE FAILURES CONTINUED AND THE VEHICLE WAS UNABLE TO BE RESTARTED. RECENTLY, IN JUNE OF 2009, THE VEHICLE SHUT OFF AND WAS TOWED TO THE DEALER. THEY STATED THAT THE ELECTRONIC THROTTLE MODULE FAILED AND THE BATTERY CABLE WAS CORRODED. THE REPAIR COST WAS ESTIMATED AT $1,021. THE FAILURE MILEAGE WAS 79,842 AND CURRENT MILEAGE WAS 189,000.
NHTSA ODI #10274313
124,000 miles · May 1, 2009
Electrical SystemFuel System, Other
WE OWN A 1999 VOLVO S70. WHILE DRIVING THE CAR IT STARTED TO SURGE WHILE AT A STOP WITHOUT AND FOOT ON THE GAS PEDAL AT ALL. WHILE TRYING TO PULL OUT FROM A STOP SIGN THE CAR HAD A MIND OF ITS OWN. IT DID WHAT IT WANTED TOO WITHOUT MY CONTROLLING IT. THE GAS PEDAL WENT UP AND DOWN ALL BY ITSELF. THE CAR THEN STALLED AND WOULD N…
Read full complaint
WE OWN A 1999 VOLVO S70. WHILE DRIVING THE CAR IT STARTED TO SURGE WHILE AT A STOP WITHOUT AND FOOT ON THE GAS PEDAL AT ALL. WHILE TRYING TO PULL OUT FROM A STOP SIGN THE CAR HAD A MIND OF ITS OWN. IT DID WHAT IT WANTED TOO WITHOUT MY CONTROLLING IT. THE GAS PEDAL WENT UP AND DOWN ALL BY ITSELF. THE CAR THEN STALLED AND WOULD NOT START AND RUN. A CHECK ENGINE LIGHT CAME ON AND A ETS LIGHT CAME ON. LUCKY WE WHERE NOT ON A MAJOR HIGHWAY AND WHERE ABLE TO PULL OVER. WE HAD TO GET A TOW TRUCK TO BRING IT HOME. I CALLED A VOLVO DEALER IN OUR AREA. AFTER SOME RESEARCH ON THE INTERNET I FIND OUT THIS WAS A PROBLEM IN ALL 99 TO 2001 VOLVO'S. A RECALL HAD BEEN ISSUED FOR THIS PROBLEM. THE VOLVO DEALER WILL ONLY UPGRADE A SOFTWARE ISSUE. IF THE PART { ETM} FAILS THEY WILL NOT REPLACE IT. WE NEVER HAD A CAR THAT THE GAS PEDAL IS CONTROLLED BY THIS SYSTEM. AFTER GETTING OUT CAR BACK FROM THE DEALER THE SAME DAY IT DID IT AGAIN. WE TOOK THE CAR BACK AND EVEN THOUGH THE CAR MEETS THE RECALL REQUIREMENTS THEY WILL NOT REPLACE IT THE ETM. NOW WE HAVE A CAR THAT IS NOT SAFE TO DRIVE. IF THIS HAD HAPPENED ON A INTERSTATE WE COULD HAVE BEEN REARENDED OR RAN INTO SOMEONE ELSE. PLEASE HELP. *TR
NHTSA ODI #10267445
Mileage unknown · Dec 29, 2008
Electrical SystemExterior Lighting
THERE IS AN ELECTRICAL SHORT IN THE TAIL-LIGHTS AND INTERIOR PANEL. *TR
NHTSA ODI #10253105
70,000 miles · Apr 2, 2007
Electrical System
TL*THE CONTACT OWNS A 1999 VOLVO S-70 GLT. WHILE DRIVING 55 MPH THE VEHICLE BEGAN TO VIBRATE, THE ETS INDICATOR ILLUMINATED, AND THE ENGINE COMPLETELY SHUT OFF. THE CONTACT WAITED APPROXIMATELY FIVE MINUTES BEFORE THE VEHICLE RESTARTED, BUT IT STILL CONTINUED TO VIBRATE. THE CONSUMER STATES THIS EVENT OCCURRED 3-4 TIMES IN AUG…
Read full complaint
TL*THE CONTACT OWNS A 1999 VOLVO S-70 GLT. WHILE DRIVING 55 MPH THE VEHICLE BEGAN TO VIBRATE, THE ETS INDICATOR ILLUMINATED, AND THE ENGINE COMPLETELY SHUT OFF. THE CONTACT WAITED APPROXIMATELY FIVE MINUTES BEFORE THE VEHICLE RESTARTED, BUT IT STILL CONTINUED TO VIBRATE. THE CONSUMER STATES THIS EVENT OCCURRED 3-4 TIMES IN AUGUST 2005. THE VEHICLE WAS TOWED TO A DEALER, WHO STATED THE ETS MODULE SHOULD BE REPLACED. APPROXIMATELY SEVEN YEARS LATER THE VEHICLE HAD THE SAME FAILURE. THE DEALER STATED THAT THE SOFTWARE MODULE NEEDED TO BE UPDATED. THE VEHICLE REMAINS AT THE DEALER. THE CURRENT AND FAILURE MILEAGE WERE 70,000.*AK UPDATE 4/30/07 *TR
NHTSA ODI #10186708
78,814 miles · Jan 25, 2007
Electrical SystemVehicle Speed Control
TL* - THE CONTACT STATED THAT THE VEHICLE HESITATED WHEN ACCELERATING. THE VEHICLE WAS A 1999 VOLVO S70, THE CONTACT TOOK THE VEHICLE TO A MECHANIC ,AND HE INFORMED HER THAT THERE WAS A RECALL ON THE THROTTLE BODY ,AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO A VOLVO DEALER. THE VOLVO DEALER PERFORMED A COMPUTER DOWNLOAD. …
Read full complaint
TL* - THE CONTACT STATED THAT THE VEHICLE HESITATED WHEN ACCELERATING. THE VEHICLE WAS A 1999 VOLVO S70, THE CONTACT TOOK THE VEHICLE TO A MECHANIC ,AND HE INFORMED HER THAT THERE WAS A RECALL ON THE THROTTLE BODY ,AND ADVISED THE CONTACT TO TAKE THE VEHICLE TO A VOLVO DEALER. THE VOLVO DEALER PERFORMED A COMPUTER DOWNLOAD. THE CONTACT STATED SHE CONTINUED TO EXPERIENCE HESITATION WHEN ACCELERATING. OCCASIONALLY. THE CHECK ENGINE LIGHT WOULD TURN ON. THE CONTACT HAD THE VEHICLE TOWED TO THE DEALER BECAUSE SHE DID NOT FEEL SAFE DRIVING THE VEHICLE. THE DEALER ADVISED HER THAT SHE NEEDED NEW SPARK PLUGS AND A NEW 02 SENSOR. THE ENGINE SIZE AND NUMBER OF CYLINDERS WERE UNKNOWN BY THE CONTACT. THE CONTACT BELIEVED THAT THE PROBLEMWAS RELATED TO RECALL # 06V441000. *AK UPDATED 02/16/07. *JB
NHTSA ODI #10180689
58,000 miles · Nov 10, 2005
Electrical System
FAILED ETM, THROTTLE BODY. NO ACCIDENTS OR INJURIES OCCURRED. DEALER SAID THIS WAS A COMMON PROBLEM, THAT THEY DO NOT KNOW WHY IT IS OCCURING. THE PART HAD TO BE REPLACED AT A COST OF $900. PART # 8644347. *JB
NHTSA ODI #10142420
105,442 miles · Oct 17, 2005
Electrical SystemEngine And Engine CoolingVehicle Speed Control
DT: THE CONTACT STATED THAT 1999 VOLVO S70 EXPERIENCED THE SAME PROBLEM WITH STALLING WHILE DRIVING UNDER 40 MPH. THE ENGINE LIGHT WAS COMING ON AND THE CAR WAS UNCONTROLLABLE. THE CAR WOULD SHAKE AND JERK, SPEED AHEAD AND SLOW DOWN. T THE CONTACT TOOK VEHICLE TO THE DEALERSHIP AND THEY REPLACED THE FUEL THROTTLE BODY, PUT I…
Read full complaint
DT: THE CONTACT STATED THAT 1999 VOLVO S70 EXPERIENCED THE SAME PROBLEM WITH STALLING WHILE DRIVING UNDER 40 MPH. THE ENGINE LIGHT WAS COMING ON AND THE CAR WAS UNCONTROLLABLE. THE CAR WOULD SHAKE AND JERK, SPEED AHEAD AND SLOW DOWN. T THE CONTACT TOOK VEHICLE TO THE DEALERSHIP AND THEY REPLACED THE FUEL THROTTLE BODY, PUT IN NEW SPARK PLUGS, AND REPROGRAMMED THE COMPUTER. THE CAR HAS SINCE THEN RAN WELL. THE CONTACT STATED THAT THIS HAPPENED A YEAR AGO. THE REPAIR COST FOR THE CONTACT WAS ALMOST $1,000.00. THE CONTACT HAS BEEN IN TOUCH WITH VOLVO DEALERSHIP, AND THEY TOLD HIM THAT THEY HAVE NOT HEARD ANYTHING ABOUT RECALL. THE VOLVO MANUFACTURER SAID THAT THERE WAS AN INVESTIGATION ON THE CAR, AND TO CALL THE NHTSA. THE CONTACT HAS ALSO FILED A COMPLAINT WITH VOLVO.*AK
NHTSA ODI #10139848
Mileage unknown · Oct 13, 2005
Electrical System
CONSUMER HAS HAD PROBLEM WITH VEHICLE STALLING. THIS IS A PROBLEM WITH THE THROTTLE MODULE. *TS THE CONSUMER WAS TOLD THAT EVENTUALLY THE VEHICLE WOULD SHUT DOWN. *JB
NHTSA ODI #10140991
50,000 miles · Sep 26, 2005
Electrical System
WE HAVE 1999 VOLVO GLT. DURING ROUTINE MAINTENANCE OUR MECHANIC NOTED THAT OUR ELECTRONIC THROTTLE MODULATOR (?) NEEDED TO BE REPLACED. HE SAID THAT HE HAS SEEN THIS PROBLEM ON MANY 1999-2001 VOLVOS. THE CLUE FOR HIM WAS THE IRREGULAR AND HIGH IDLE OF THE CAR. IT COST APPROXIMATELY $1000.00 TO REPAIR. THE CAR ONLY HAS 54K M…
Read full complaint
WE HAVE 1999 VOLVO GLT. DURING ROUTINE MAINTENANCE OUR MECHANIC NOTED THAT OUR ELECTRONIC THROTTLE MODULATOR (?) NEEDED TO BE REPLACED. HE SAID THAT HE HAS SEEN THIS PROBLEM ON MANY 1999-2001 VOLVOS. THE CLUE FOR HIM WAS THE IRREGULAR AND HIGH IDLE OF THE CAR. IT COST APPROXIMATELY $1000.00 TO REPAIR. THE CAR ONLY HAS 54K MILES. *JB
NHTSA ODI #10137584
22,600 miles · Sep 22, 2005
Electrical System
THIS IS THE SECOND SUBMISSION (PART TWO, ACTUALLY) OF COMPLAINT # 10137311, REGARDING VOLVO THROTTLE CONTROL MODULE AND CRUISE CONTROL. I HAD TO DIVIDE THE DESCRIPTION INTO TWO SECTIONS DUE TO SPACE LIMITATIONS. PART TWO OF ODI # 10137311: MAY 2004 (45,000 MILE SERVICE) -CAR IDLING ROUGHLY, NOT ACCELERATING SMOOTHLY, AND CLUN…
Read full complaint
THIS IS THE SECOND SUBMISSION (PART TWO, ACTUALLY) OF COMPLAINT # 10137311, REGARDING VOLVO THROTTLE CONTROL MODULE AND CRUISE CONTROL. I HAD TO DIVIDE THE DESCRIPTION INTO TWO SECTIONS DUE TO SPACE LIMITATIONS. PART TWO OF ODI # 10137311: MAY 2004 (45,000 MILE SERVICE) -CAR IDLING ROUGHLY, NOT ACCELERATING SMOOTHLY, AND CLUNKING SOUND WHEN ACCELERATING. UPPER ENGINE TORQUE MOUNT. CLUNKING NOISE DISAPPEARED. CAR SEEMED TO ACCELERATE MORE NORMALLY AFTER SERVICING. SUMMER 2004- CAR CUTTING OFF WHEN ACCELERATING AFTER TURNING AND WARNING LIGHT(S) ON. CRUISE CONTROL CONTINUES CUTTING OFF, CAUSING DECELERATION; CAR CONTINUES TO IDLE ROUGHLY AND ACCELERATE UN-SMOOTHLY. WHEN IT IS TIME FOR ENGINE TO AUTOMATICALLY BE GIVEN A LITTLE MORE GAS (SUCH AS GOING UP A HILL), THE CRUISE CONTROL SHUTS OFF AND THE "ABS" LIGHT COMES ON. SOMETIMES "CHECK ENGINE" LIGHT COMES ON, EITHER ALONE OR IN ADDITION TO THE ABS WARNING LIGHT. SEPTEMBER 20, 2005--WARRANTY EXPIRED--67,500 MILE SERVICE- AGAIN REPORTED CRUISE CONTROL/WARNING LIGHT PROBLEM TO DEALERSHIP,SUPPOSEDLY NEED NEW CONTROL MODULE, COSTING $1,000. PROBLEM WAS REPORTED REPEATEDLY WHILE CAR UNDER WARRANTY; DON'T REPAIR AT MY EXPENSE BECAUSE PROBLEM DEVELOPED WHILE UNDER WARRANTY. USING CELL PHONE WHILE CONVERSING WITH DEALERSHIP. WOMAN IN SAME STORE OVERHEARD CONVERSATION, TOLD ME OF SIMILAR PROBLEMS WITH SUDDEN DECELERATION, AND GAVE ME YOUR URL. [XXX]. VIN [XXX] (1999 S70) THROTTLE CONTROL NOT YET REPLACED. *JB UPDATED 07/18/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #10137316
Official recalls
4Nov 15, 2006
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence & remedy
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Oct 21, 2004
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, OVER AN EXTENDED PERIOD OF TIME, THE HEADLIGHT SWITCH MAY CEASE TO FUNCTION.
Consequence & remedy
Consequence: THE HEAD LIGHTS MAY NOT OPERATE PROPERLY WHICH COULD RESULT IN INTERMITTENT OR NO HEADLIGHT FUNCTION. THIS COULD IMPAIR A DRIVER'S VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: ON VEHICLES WITH AN ORIGINAL OEM SWITCH, DEALERS WILL REPLACE THE HEADLIGHT SWITCH. ALL OTHER VEHICLES WILL BE INSPECTED TO DETERMINE IF THE SWITCH HAS EEN DAMAGED AND REPLACE ONLY IF NECESSARY. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
Dec 6, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THERE COULD BE INADEQUATE CONTACT BETWEEN THE BULB AND SOCKET WHICH COULD CAUSE THE FRONT TURN SIGNAL NOT TO FUNCTION AS DESIGNED.
Consequence & remedy
Consequence: THIS WOULD FAIL TO WARN AN APPROACHING DRIVER THAT THE VEHICLE IS TURNING AND COULD LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT TURN SIGNAL BULB AND SOCKET.
Feb 25, 1999
VEHICLE DESCRIPTION: ALL-WHEEL-DRIVE SEDANS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." THE FUEL FILTER BRACKET CONFIGURATION MARGINS ARE INSUFFICIENT.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, FUEL LEAKAGE COULD OCCUR. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A FUEL FILTER PROTECTION BRACKET.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
RQ04004 · Headlight Failure
Opened Jun 8, 2004 · Closed Nov 5, 2004
Status: closed (inferred from source dates) · Exterior Lighting:headlights; Exterior Lighting:headlights:switch
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Additional source detail variants (2)
Exterior Lighting:headlights:switch
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Exterior Lighting:headlights
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
PE00031 · Turn Signal
Opened Aug 15, 2000 · Closed Dec 22, 2000
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE99040 · Inadvertent Side Air Bag Deployment
Opened Jun 7, 1999 · Closed Oct 27, 1999
Status: closed (inferred from source dates) · Air Bags:side/window
No summary supplied.
Illustration