IllustrationSee attached document for complaint.
2020 Volvo S60
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all S60 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 11 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Forward Collision Avoidance. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
1 crash reports0 fire reports0 injury reports
Service Brakes complaints
5 reportsThe car has “detected” a crash many times and automatically stopped even on the highway. It jerks and to slam on the brakes and then keeps going. It’s very dangerous and I have a strong theory it’s the model in general and not an isolated situation with my car.
2020 VOLVO S60 T-6 R WENT IN FOR SERVICE AT VOLVO DEALER, 5/12/21, MILEAGE 24,018. TECHNICIAN NOTED REAR BRAKES LESS THAN 2MM & ROTORS GROOVED, NEEDS TO BE REPLACED. I WAS TOLD THIS IS NOT UNDER WARRANTY, IT'S NORMAL WEAR. THIS VEHICLE HAD SERVICE AT THE SAME DEALER ON 12/8/20, MILEAGE 16,952 THE SERVICE REPORT STATED, "BRAKES I…
Read full complaint
2020 VOLVO S60 T-6 R WENT IN FOR SERVICE AT VOLVO DEALER, 5/12/21, MILEAGE 24,018. TECHNICIAN NOTED REAR BRAKES LESS THAN 2MM & ROTORS GROOVED, NEEDS TO BE REPLACED. I WAS TOLD THIS IS NOT UNDER WARRANTY, IT'S NORMAL WEAR. THIS VEHICLE HAD SERVICE AT THE SAME DEALER ON 12/8/20, MILEAGE 16,952 THE SERVICE REPORT STATED, "BRAKES IN THE GREEN 7MM OR MORE". THE VEHICLE IS DRIVEN HIGHWAY MILES MAINLY, REGARDLESS OF THAT FACT, BRAKE PADS DON'T NOT WEAR DOWN 5MM IN 7,000 MILES ON A NEW CAR UNLESS THERE'S AN UNDERLYING PROBLEM, THERE HAS ALREADY BEEN A RECALL ON THE REAR AUTOMATIC PARK BRAKE, SEEMS LIKELY THAT THERE'S ADDITIONAL PROBLEMS WITH THE REAR BRAKES. THE REPLACEMENT COST ME $888.00
MY 2020 S60 T5 R-DESIGN HAD 3 BROKEN SENSORS, A SAFETY RECALL, MALFUNCTIONING BRAKES WHICH CAUSED THE CAR TO VEER, AND MOST RECENTLY A LEAKING A/C HOSE. ALL PROBLEMS FROM THE FACTORY (OUT OF THIN AIR) WITHIN THE FIRST 12 MONTHS OF MY LEASE. AFTER NUMEROUS COMPLAINTS TO VOLVO CAR USA, I WAS OFFERED A GENERIC AND DISMISSIVE ANSWE…
Read full complaint
MY 2020 S60 T5 R-DESIGN HAD 3 BROKEN SENSORS, A SAFETY RECALL, MALFUNCTIONING BRAKES WHICH CAUSED THE CAR TO VEER, AND MOST RECENTLY A LEAKING A/C HOSE. ALL PROBLEMS FROM THE FACTORY (OUT OF THIN AIR) WITHIN THE FIRST 12 MONTHS OF MY LEASE. AFTER NUMEROUS COMPLAINTS TO VOLVO CAR USA, I WAS OFFERED A GENERIC AND DISMISSIVE ANSWER THAT VOLVO 'IS NOT IN THE POSITION' TO OFFER A TRADE ASSIST OR ANY HELP. NO EXPLANATION TO A LOYAL VOLVO CUSTOMER. THEY'RE SIMPLY 'SORRY' THAT I HAD TO TAKE OFF WORK TO SERVICE THEIR CAR AND WAS TOLD TO UBER HOME (NO COURTESY LOANER). AFTER THE MOST RECENT SERVICE VISIT, I DEMANDED VOLVO EITHER REPLACE THE CAR OR TERMINATE THE LEASE, BUT THE AGENT THOUGHT SERVICING THE VEHICLE 5 TIMES (BECAUSE PARTS WERE BREAKING) WAS ABSOLUTELY NORMAL. SHE WAS STUNNED I DO NOT HAVE A POSITIVE ATTITUDE NOW THAT MY CAR WAS FIXED. I DEMANDED CONTACT TO THE REGIONAL MANAGER, BUT MY AGENT (WHO TURNED OUT TO BE SUPERVISOR) REFUSED TO FORWARD ANY INFORMATION. MY CAR WOULD GO THROUGH A REVIEW PROCESS WITH 'SPECIAL PARAMETERS', BUT THE SUPERVISOR OF THE HEADQUARTERS OF VOLVO CARS USA WAS INCAPABLE OF ANSWERING WHAT THE PARAMETERS WERE, WHEN THIS REVIEW WOULD TAKE PLACE, OR WHO IS REVIEWING MY CASE' NOTHING WAS TRANSPARENT, AND FOR ALL I KNOW, THIS REVIEW COULD HAVE BEEN ARBITRARY. AS EXPECTED, 'VOLVO IS NOT IN THE POSITION'' VOLVO SENT AN AUTOMATED CUSTOMER SATISFACTION SURVEY, TO WHICH I PROVIDED FEEDBACK OF MY AWFUL EXPERIENCE. SADLY, THE SAME AGENT HANDLING MY CASE RESPONDED 'THANK YOU' AND THAT WAS IT. I GUESS MY FEEDBACK AND PROBLEMS CAUSED BY VOLVO DO NOT REALLY INTEREST VOLVO? SO BY VOLVO 'PARAMETERS,' A CAR BREAKING 5 TIMES IS NORMAL, THERE IS NO QUALITY CONTROL OF THEIR CARS, AND CUSTOMER SERVICE IS INEXISTENT (3 OR 4 'PROFESSIONALS' IN HEADQUARTERS SERVING NORTH AMERICA IS INEXISTENT).
'THE BRAKE FLUID IS LOW STOP SAFELY' MESSAGE CAME ON AT LESS THAN 87 MILES ON THE ODOMETER WHILE THE ENGINE WAS RUNNING ON MY DRIVEWAY. A VOLVO DEALER STATED THE FOLLOWING: FLUID WAS LOW NO EXTERNAL LEAK FOUND TOPPED OFF BRAKE FLUID TO FULL MARK 'THE BRAKE FLUID IS LOW STOP SAFELY' MESSAGE CAME ON AGAIN AT LESS THAN 191…
Read full complaint
'THE BRAKE FLUID IS LOW STOP SAFELY' MESSAGE CAME ON AT LESS THAN 87 MILES ON THE ODOMETER WHILE THE ENGINE WAS RUNNING ON MY DRIVEWAY. A VOLVO DEALER STATED THE FOLLOWING: FLUID WAS LOW NO EXTERNAL LEAK FOUND TOPPED OFF BRAKE FLUID TO FULL MARK 'THE BRAKE FLUID IS LOW STOP SAFELY' MESSAGE CAME ON AGAIN AT LESS THAN 191 MILES ON THE ODOMETER WHILE I WAS DRIVING ON A LOCAL ROAD AT ABOUT 35 MILES AN HOUR SPEED.
Official recalls
425V179000 · Electrical System:propulsion System:traction Battery; Electrical System:software
Mar 24, 2025
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
Consequence & remedy
Consequence: A short circuit in a high-voltage battery increases the risk of a fire.
Remedy: Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.
Additional source detail variants (2)
Electrical System:propulsion System:traction Battery
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
Consequence: A short circuit in a high-voltage battery increases the risk of a fire.
Remedy: Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.
Electrical System:software
Volvo Car USA, LLC (Volvo Car) is recalling certain 2020-2021 S90, 2020-2022 S60, V60, XC60, XC90, and 2022 V90 plug-in hybrid vehicles. The high-voltage battery may experience a short circuit within the battery module when the battery is fully charged and the vehicle is parked.
Consequence: A short circuit in a high-voltage battery increases the risk of a fire.
Remedy: Owners are advised not to charge their vehicles until the remedy has been completed. Dealers will inspect and replace the high-voltage battery module as necessary. In addition, dealers will update the software to monitor the battery. All repairs will be performed free of charge. Owner notification letters were mailed May 28, 2025. Owners may contact Volvo Car's customer service at 1-800-458-1552. Volvo Car's number for this recall is R10312.
23V780000 · Air Bags:frontal
Nov 21, 2023
Volvo Car USA, LLC. (Volvo Car) is recalling certain 2019-2024 S60 vehicles. The passenger air bag may not be secured properly, which can cause the air bag to deploy improperly.
Consequence & remedy
Consequence: An air bag that does not deploy properly in a crash increases the risk of injury.
Remedy: Dealers will inspect and tighten the bolts securing the passenger air bag, as necessary, free of charge. Owner notification letters were mailed January 5, 2024. Owners may contact Volvo Car customer service at 1-800-458-1552. Volvo Car's number for this recall is R10254.
21V414000 · Electrical System:wiring:fuses And Circuit Breakers; Fuel System, Gasoline:delivery:fuel Pump
Jun 2, 2021
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.
Consequence & remedy
Consequence: Failure of the low-pressure fuel pump can cause a stall, increasing the risk of a crash.
Remedy: Dealers will replace the fuse, free of charge. Owner notification letters were mailed July 2, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10100.
Additional source detail variants (2)
Electrical System:wiring:fuses And Circuit Breakers
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.
Consequence: Failure of the low-pressure fuel pump can cause a stall, increasing the risk of a crash.
Remedy: Dealers will replace the fuse, free of charge. Owner notification letters were mailed July 2, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10100.
Fuel System, Gasoline:delivery:fuel Pump
Volvo Car USA, LLC (Volvo Car) is recalling certain 2019-2020 V90, XC60, S60, V60, V60CC, S90, V90CC, S90L, and XC90 vehicles. The low-pressure fuel pump can blow a fuse and fail.
Consequence: Failure of the low-pressure fuel pump can cause a stall, increasing the risk of a crash.
Remedy: Dealers will replace the fuse, free of charge. Owner notification letters were mailed July 2, 2021. Owners may contact Volvo Car customer service at 1-888-458-1552. Volvo Car's number for this recall is R10100.
20V144000 · Forward Collision Avoidance: Automatic Emergency Braking; Forward Collision Avoidance:software:pedestrian/cyclist/object/obstacle/ Recognition
Mar 12, 2020
Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.
Consequence & remedy
Consequence: If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.
Remedy: Volvo will notify owners, and dealers will update the Active Safety Domain Master (ASDM) software, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29998.
Additional source detail variants (2)
Forward Collision Avoidance: Automatic Emergency Braking
Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.
Consequence: If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.
Remedy: Volvo will notify owners, and dealers will update the Active Safety Domain Master (ASDM) software, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29998.
Forward Collision Avoidance:software:pedestrian/cyclist/object/obstacle/ Recognition
Volvo Cars USA LLC (Volvo Cars) is recalling certain 2019-2020 S60, V60, V60 Cross Country, S90L, V90, V90 Cross Country, XC40, XC60, and XC90 vehicles. Due to a software/hardware incompatibility, the Automatic Emergency Brake (AEB) system may not detect obstacles and engage as intended.
Consequence: If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.
Remedy: Volvo will notify owners, and dealers will update the Active Safety Domain Master (ASDM) software, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R29998.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.