2015 Volvo S60

BOUGHT USED VOLVO ONLY HAD 66,000 MILES ON IT 1ST SHIFTER STUCK IN PARK, THERE APPARENTLY IS A SLOT IN BEHIND SHIFTER IN THE CUBBY TO STICK KEY IN AND MANUALLY UNLOCK SHIFTER, 2ND SERIOUS WABBLE AT 50+ MPH WAS TOLD BY VOLVO IT WAS WASHER SYSTEM NEEDED IN ALL WHEEL DRIVE, THE WAS NOT THE ISSUE NEEDED DRIVERS AXEL. ONLY 1 MONTH AFTER REPLACING FRONT DRIVERS AXEL I ALREADY HEAR THE TELL TAIL CLICKING OF AXEL BEARING GONE BAD ON A NEW 750.00 AXEL, 3RD FOG / RUNNING LIGHT ON BUMPER FLICKERS OVER BUMPS. 4TH HAD THE REPLACE BEARINGS ON STRUTS ALL UNDER 70,000 MILES ON THE CAR NOT IMPRESSED VOLVO

TL* THE CONTACT OWNS A 2015 VOLVO S60. WHILE THE VEHICLE WAS STOPPED AT A TRAFFIC LIGHT, IT STALLED WITHOUT WARNING. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO SUBARU OF MELBOURNE (LOCATED AT 4340 W NEW HAVEN AVE, WEST MELBOURNE, FL 32904, (321) 768-8020) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE STARTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 49,999.

WHILE DRIVING, ALL POWER (ALL POWER) IS LOST, WITHOUT WARNING. DRIVING NORMALLY IN TRAFFIC, THE CAR SIMPLY SHUTS DOWN. ENGINE STOPS, NO LIGHTS (INTERIOR OR EXTERIOR), NO DASHBOARD DATA, SAFETY SYSTEMS DISABLED, NO TURN SIGNALS, NO POWER STEERING, SAFETY FLASHERS DO NOT FUNCTION, ETC. ESSENTIALLY LIKE THE CAR WAS TUNED OFF. TRY TO RESTART - NOTHING. AFTER 'RESTING' FOR 5 MINUTES, STARTS AND RUNS NORMALLY. HAS REOCCURRED 3 TIMES. VISITS TO THE DEALERSHIP HAVE RESULTED IN NEW BATTERY, AND ALTERNATOR. NO DEFINITIVE DIAGNOSIS, JUST 'HOPE' THAT THE PROBLEM HAS BEEN FIXED. BUT NEITHER OF THOSE REPAIRS HAVE FIXED THE PROBLEM, IT REOCCURED AGAIN (3RD TIME). THE CAR IS EXTREMELY DANGEROUS TO DRIVE IN THIS CONDITION, TO ME AND MY FAMILY BUT ALSO TO OTHER DRIVERS ON THE ROAD. IT HAS BEEN TOWED TO THE DEALERSHIP. NO DIAGNOSIS YET.

WHILE DRIVING ON A HIGHWAY AT 65 MPH (THE LEGAL LIMIT) AT APPROXIMATELY 6:55 AM ON 2 JULY 2018, I WAS TWO OR MORE CAR LENGTHS BEHIND THE CAR AHEAD OF ME WHEN THE SUN ROOF CATASTROPHICALLY SHATTERED. NO ROAD DEBRIS WAS OBSERVED AND THE ROAD WAS DRY AND NOT IN A CONSTRUCTION ZONE. WITH THE SUDDEN EXPLODING SOUND, I DIDN'T KNOW WHAT WAS GOING ON BUT WAS ABLE TO MAINTAIN CONTROL OF THE CAR. I WAS DUCKING DOWN REFLEXIVELY AS THE NOISE WAS ABOVE MY HEAD. FORTUNATELY, THE INTERIOR SUN ROOF SHADE WAS CLOSED AND THE SUN ROOF WAS CLOSED. IN MY REARVIEW MIRROR, I SAW THE CAR DIRECTLY BEHIND BRAKING HARD AND THE CARS IN THE NEXT LANE SLOWING DOWN TO AVOID THE DEBRIS I LATER REALIZED WAS THE EJECTED GLASS FROM MY SUN ROOF. THE NOISE CONTINUED AND THEN THE GLASS BEGAN FALLING INTO THE FRONT AREA OF THE CAR THROUGH THE VENTS IN THE SUN SHADE AND I FINALLY REALIZED THE SUN ROOF GLASS HAD SHATTERED. THE CAR IS MAINTAINED IN EXCELLENT CONDITION AND THERE WERE NO SIGNS OF CHIPPING, CRACKS OR OTHER DAMAGE TO THE SUN ROOF PRIOR TO THE INCIDENT. THERE WERE ALSO NO SIGNS ON THE CAR'S HOOD, WINDSHIELD, OR ROOF THAT SHOWS DEBRIS IMPACTED THE CAR AND CAUSED THE FAILURE.

I WAS SOLD THIS CAR BY VOLVO OF NORTH MIAMI ON 4/11/18. I HAD TO TAKE THE CAR FOR SERVICE ON 4/13 DUE TO OTHER REPAIRS THEY DID NOT TAKE CARE OF UNDER WARRANTY TO GUNTHER VOLVO , DELRAY BEACH , FLORIDA. I WAS TOLD I SHOULD HAVE NEVER BEEN ALLOWED TO DRIVE THE CAR OFF THE LOT DUE TO THE CONDITION OF THE TIRES THAT WERE EXTREMELY DANGEROUS AND COULD HAVE CAUSED A SERIOUS ACCIDENT AND AFFECTED OTHERS. I WAS TOLD BY RICKY MENENDEZ WHO SOLD THE CAR THAT ALL THERE CARS ARE INSPECTED THOROUGHLY BEFORE BEING SOLD.

THIS IS AN ADDITIONAL COMPLAINT REGARDING THE SAME VEHICLE BRAKE PROBLEM FILED UNDER NHTSA SAFETY ISSUE ID 10979689. ON 15 DEC THE SAME VOLVO FAILED TO STOP AT A RED LIGHT ON A CITY STREET IN DRY PAVEMENT CONDITIONS. THE ONLY WAY TO STOP THE VEHICLE WHILE TRAVELING AT APPROXIMATELY 35 MPH WAS BY CONTINUING TO HOLD THE BRAKE PEDAL ALL THE WAY DOWN AND THEN SLAMMING THE GEARSHIFT FROM DRIVE INTO PARK. THE VEHICLE WAS SUBSEQUENTLY TOWED BACK TO THE LOCAL DEALER. WHEN THIS VEHICLE WAS AT THE DEALER THEY DRAINED THE BRAKE LINES AND CHANGED THE MASTER BRAKE CYLINDER BASED ON THIS FIX REPORTEDLY WORKING ON ANOTHER S60 WITH THE SAME PROBLEM ACCORDING TO VOLVO TECH SUPPORT. AFTER EIGHT MONTHS THE BRAKES FAILED AGAIN. VOLVO HAS A BRAKING PROBLEM ON THESE VEHICLES AND DOES NOT NO THE CAUSE NOR THE CORRECTIVE ACRION.

WE PURCHASED THIS CAR NEW FROM THE DEALER AND ITS GREAT. HOWEVER, AS I HAND WASH ALL OF OUR CARS, I COULDN'T HELP BUT NOTICE THAT THE RIGHT FRONT WHEEL ALWAYS HAS AN UNUSUAL DISCOLORATION, A MIX OF SOME KIND OF FLUID WITH THE BRAKE DUST. THE OTHER 3 WHEELS EXHIBIT ONLY THE USUAL BRAKE DUST; BUT ON THE RIGHT FRONT THIS MIX OF FLUID AND DUST DOESN'T JUST WASH OFF. ROTATE WHEELS, THE NEW WHEEL ON THE RIGHT FRONT EXHIBITS THE SAME DISCOLORATION. THE DEALER INSISTS IT IS ONLY BRAKE DUST. NOW, 2 YEARS ON, MOST OF WHATEVER FLUID WAS SECRETING TO THE RIGHT FRONT WHEEL SEEMS TO BE GONE BUT, AFTER RETRIEVING THE CAR FROM ITS 20K SERVICE, I COULDN'T HELP BUT NOTICE A RUMBLE COMING FROM THE RIGHT FRONT. SOUNDS LIKE A WHEEL BEARING TO ME (IN MY DAY, I'VE REPLACED EM). THE DEALER SAYS ITS THE TIRES; CONTINUES TO SAY THAT THE DISCOLORATION ON ONLY THE RIGHT FRONT, IS BRAKE DUST. EVEN SAID IT MIGHT BE RUST FROM THE DISC BRAKES. OK, FINE, THEN WHY NONE ON THE FRONT LEFT? OR EITHER OF THE REARS? WHY ONLY THE RIGHT FRONT. I HAVE TAKEN SWABS OF ALL 4 WHEELS AND HAVE THEM IN SEPARATE LABELED ZIP LOCK BAGS IF ANYONE WANTS TO RUN THEM THROUGH A SPECTROMETER. I'VE NEVER REPORTED ANYTHING TO THE NHTSA BEFORE BUT, IN LIGHT OF THEIR INSISTENCE THAT IT IS ONLY BRAKE DUST ... WELL, I'VE REBUILT MY SHARE OF BRAKE SYSTEMS, WORKED ON A RACE TEAM ETC., AND I'M FINDING THIS ALL A BIT INSULTING IF NOT DISMISSIVE. THIS CAR IS PRIMARILY USED AS MY WIFE'S DAILY COMMUTER (30 MILES ROUND TRIP) IN THE SUBURBS WITH AN OCCASIONAL ROAD TRIP ON THE BOOKS. *BF*JB 'PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB

THE INSTRUMENT PANEL GOES COMPLETELY BLANK FOR APPROXIMATELY 5 SECONDS WHILE DRIVING WHICH RENDERS SPEED, SAFETY WARNINGS, ETC. UNAVAILABLE DURING THAT TIME. THERE IS NO PATTERN OF OCCURRENCE. IT HAPPENS WHILE DRIVING AT CITY OR HIGHWAY SPEEDS. IT HAS ALWAYS OCCURRED WHILE THE VEHICLE IS IN A STRAIGHT LINE OF MOTION. THIS STARTS OUT ON AN INFREQUENT BASIS (ONCE OR TWICE A WEEK) UNTIL IT MANIFESTS INTO AN EVENT OF SEVERAL TIMES A DAY. I TOOK THE VEHICLE TO THE DEALER THE FIRST TIME ON 01/13/2017 WITH 12,097 MILES ON THE ODOMETER. IT WAS HOOKED TO THE DIAGNOSTIC COMPUTER, AND WHEN THEY SAW THAT NO CODES WERE STORED, IT WAS "FIXED" WITH A DRIVER INFORMATION MODULE SOFTWARE UPGRADE. WHEN THE PROBLEM STARTED AGAIN, I TOOK THE VEHICLE IN ON 07/20/2017 WITH 16,066 MILES ON IT. ONCE AGAIN, THE CAR WAS CONNECTED TO THE DIAGNOSTIC COMPUTER AND NO CODES WERE FOUND TO BE STORED. THE WIRING WAS CHECKED AND FOUND TO BE OKAY. ANOTHER SOFTWARE UPGRADE WAS USED TO RESOLVE THE ISSUE.