2015 Volvo S60

The contact owns a 2015 Volvo S60. The contact stated while driving at approximately 35 MPH, the steering became extremely difficult to turn and several warning lights were illuminated. The contact stated that the "City Safety" light was illuminated and drove over a manhole cover on the road and the vehicle stopped. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the two EV batteries needed to be replaced because the battery could not be charged and tested out at 9 percent. The contact was advised that the battery failure caused the failure of several vehicle systems. The vehicle was repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 80,000.

Was on the highway driving back from my aunts house and there were no signs anything was wrong with my car. No alerts on the dash besides low pressure tire which I filled up. As I was almost home, an alert randomly came up with “no oil pressure” along with a check engine light flashing and the car started shaking (misfiring). The car flashed a message that said something about reduced engine performance. As my car was shaking fervently, it was slowing down and failed to accelerate, causing cars behind me to almost crash. No oil pressure can also cause fires and put my life at risk. I had much time left to get my oil changed and yet I had oil message lights come on. I believe this is a problem with the piston rings that are defective & there was just recently a class action suit of them. I have had to continually fill up oil, and now I suddenly have an engine that does not work and threatened the safety of myself and others on the road. Volvo diagnosed the issue as being valve broken, piston ring damage, along with other engine components. I now need an entire new engine.

I bought the car as a CPO on 9/25/19 32,860 mi. On 8/19/20 at 50,052 the engine failed. The oscillating dampener rubber separated causing serpentine belt to break, which in turn got caught in timing belt which caused that to break which then caused bent valves and valves to break. The failure was sudden. Had I been on the interstate I’d be severely injured or dead. I was told that I needed a new engine but they could not find one. I was told they would completely re-build my engine. In the end they replaced the cylinder head and starter under warranty. I was never told they didn’t re-build the engine and also used “ good parts” from the old engine. In the following months I had the car in the Volvo shop (Hendricks Volvo Charleston, SC). At 50,277 miles the check engine light showed a problem with the Cam shaft position sensor on 9/3/20. They claim to have driven the car 100 miles and cleared the code w/no repairs. On 3/18/21 w/ 64,485 miles, I took the car into the dealer because it was running and idling rough. They found no codes and they aligned the car. “Couldn’t duplicate”. The right rear door never shut properly and I was repeatedly told it was fine. Re-call on latches. Seat belts on rt rear passenger constantly was stuck. This is where my granddaughter’s car seat was placed. I’ll have to skip some. At 110,024 miles on 11/28/22 the car continued to have bad gas mileage and heavy oil use. I was told that the EGR leak detection pump was faulty and was replaced. At 113,706 miles on 1/19/2023 the cam VVT Solenoid was changed. Cause of poor gas mileage stated. On 3/29/23 at 116,790 miles replaced brakes and had aligned. Service tech noticed oil under the car underside while up on racks. Said it would be fine until next service. On 7/3/23 the engine failed again on the road and was towed to the dealer. Apparently a fuel injector failed causing gas to spray into the engine causing it to lose compression. I’ve never been given a clear answer. Records of services done.

The contact owns a 2015 Volvo S60. The contact stated while driving 20 MPH, the brake pedal was depressed however, the vehicle failed to stop until the brake pedal had gone to the floorboard. There was no warning light illuminated. The vehicle was taken to the dealer, but no failure was found. The contact stated that the failure had occurred several times. The contact stated that the vehicle was test driven by the mechanic however, the cause of the failure was not yet determined. The manufacturer was made aware of the failure and no assistance was offered. The failure mileage was approximately 14,000.

The contact owns a 2015 Volvo S60. The contact stated that the vehicle was previously repaired under an unknown recall for the catalytic converter and the check engine warning light illuminated. The contact was told that the catalytic converter had failed due to an oil leak. The contact was informed that the catalytic converter needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that the vehicle had exceeded the mileage. There was no additional assistance provided. The approximate failure mileage was 165,000. The dealer stated the vehicle is outside of the warranty perimeters by mileage.

The contact owns a 2015 Volvo S60. The contact stated while driving approximately 15 MPH and slowing down for a crosswalk with pedestrians in the crosswalk, the vehicle independently accelerated while depressing the brake pedal. The contact stated that she had not noticed any warning lights being illuminated. The contact stated that the failure was intermittent. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the failure could not be duplicated. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 15,000.

I have a 2015 Volvo S60 T5 that I purchased 08 -2021 from Volvo that is consuming oil. I have had the oil changed (out of pocket) 3 times within 10,000 miles because the low oil light was on and I had purchased a extended warranty and wanted to play it safe. Never once did any Volvo service staff mention that this model car had a issue with oil consumption. After researching this cars history I came across a bulletin on the NHTSA webpage that Volvo has known about the issue on or around 11-02-2020. Webpage ( https://static.nhtsa.gov/odi/tsbs/2020/MC-10184147-9999.pdf) I received a letter from Volvo about Excessive oil consumption dated February 3, 2023 and I contacted their customer service department. I was told that my car original delivery date was Sept 2014 and that the car is now out of warranty and I would have to pay for anything related to the oil consumption issue. I when to my extended warranty that I purchased with the car ($5000 for 4 years). Within the language of the service contract under "EXCLUSIONS" #17 reads "The correction of oil consumption" It seems to me the Volvo purposely withheld this information from Volvo owners and only sent out a letter to most owners after the factory warranty expired. In my case my car was 5 months out of warranty and they were a wear of the issue in 2020 and failed to notify millions of Volvo owners. *All service records are available but contain personal information for this complaint. Thank you for your time in this matter and this letter may be forwarded to the appropriate department for review.