2012 Volvo S60

TL* THE CONTACT OWNS A 2012 VOLVO S60. WHEN THE ENGINE WAS STARTED, THE LOW OIL PRESSURE INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO HAVE AN OIL CHANGE. AFTERWARDS, THE VEHICLE STALLED. THE CONTACT HAD THE VEHICLE PUSHED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 155,000.

THE OIL WAS CHANGED AT 85,000 MILES. AT APPROXIMATELY 90,000 MILES, THE LOW OIL PRESSURE LIGHT FLASHED ON AND IMMEDIATELY DISAPPEARED WHEN MAKING TURNS. THE SENSOR LIGHT DID NOT REMAIN ON THE DASHBOARD. THERE WAS NO EVIDENCE OF OIL LEAKING. AFTER A COUPLE OF DAYS, THE ENGINE BEGAN KNOCKING. THE OIL LEVEL WAS CHECKED AND WAS LOW. OIL WAS ADDED TO THE CAR. THE CAR WAS TAKEN TO THE VOLVO DEALER FOR A DIAGNOSTIC CHECK. THE DEALER REPRESENTATIVE STATED THAT NO WARNING LIGHT INDICATORS SHOWED DURING THE DIAGNOSTIC CHECK. THE ENGINE WAS STARVED OF OIL AND NEEDED TO BE REPLACED. HE MENTIONED THAT FOR THIS MODEL AND YEAR, NEW VEHICLE OWNERS THAT STILL HAD A WARRANTY WERE ASKED TO COME IN AND HAVE PISTON O-RINGS REPLACED BECAUSE OF EXCESSIVE OIL CONSUMPTION. WE WERE NOT MADE AWARE OF THIS ISSUE.

PURCHASED THIS VOLVO A FEW MONTHS AGO HAD IT FOR A WEEK AND IT BROKE DOWN WHILE IDLING IN MY DRIVEWAY IT WAS TOWED TO VOLVO OF ROANOKE, VA. THEY TOLD ME THE IDLER PULLEY SEIZED UP CAUSING THE VEHICLE TO JUMP TIME. THEY REPLACED THE DIVE BELT AND PUT THE VEHICLE BACK IN TIME AND TOLD ME THE VEHICLE WAS GOOD TO GO. (THEY CHARGED ME $1,000) I DOVE IT FOR A COUPLE OF DAYS AND THEN IT BROKE DOWN AGAIN ON THE INTERSTATE AND WAS TOWED BACK TO THE SAME DEALER. I WAS INFORMED THIS TIME THAT THE MOTOR NEEDED TO BE REPLACED AND GAVE ME NO EXPLANATION AS TO WHY. (THEY SAID THEY WOULD PUT A USED ENGINE IN WITH 130K MILES FOR $10,000) I HAD THE VEHICLE TOWED TO AN INDEPENDENTLY OWNED VOLVO REPAIR SHOP TO HAVE THEM CHECK IT OVER. THEY ALSO AGREE THAT THE ENGINE NEEDS TO BE REPLACED AND SAID THAT THE VALVES ARE BENT.

TL* THE CONTACT OWNS A 2012 VOLVO S60. WHILE DRIVING 30 MPH, THE VEHICLE LOST POWER AND THE ENGINE SEIZED. THE CONTACT STATED THAT THE VEHICLE EXHIBITED THE SAME SYMPTOMS AS LISTED IN NHTSA CAMPAIGN NUMBER: 13V592000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE VEHICLE AND STATED THAT THE ENGINE SEIZED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 115,000.

IN AUGUST OF THIS PAST YEAR MY ENGINE SHUT DOWN AS MY WIFE AND I MADE A TURN. THE MECHANIC THAT I HAD IT TOWED TO SAID THE ENGINE WAS THREE QUARTS LOW AND WAS GETTING NO COMPRESSION AND YET NO CHECK OIL INDICATOR LIGHT TURNED ON. I SPENT $6,000 ON A USED ENGINE. THURSDAY OF LAST WEEK THE SAME THING HAPPENED EXCEPT I WAS DRIVING STRAIGHT. I AGAIN HAD IT TOWED TO MY MECHANIC AND IT WAS CONFIRMED THAT THE ENGINE IS NOT GETTING ANY COMPRESSION. I THEN CALLED VOLVO WHO INFORMED ME THAT THERE WAS NOTHING THEY COULD DO FOR ME SINCE I HADN'T TAKEN THE VEHICLE IN TO A DEALER. I EXPLAINED THAT I LIVE OVER AN HOUR AWAY FROM THE CLOSEST DEALERSHIP AND ITS NOT FEASIBLE FOR ME TO TAKE MY CAR IN. I'M AFRAID TO SPEND ANY MORE MONEY ON A USED ENGINE ONLY TO HAVE IT SEIZE UP ON ME WITH NO WARNING. THIS IS THE SECOND ENGINE IN LESS THAN SIX MONTHS. I LOOKED ON THE INTERNET AND SAW THAT VOLVO HAD ISSUED A RECALL FOR CERTAIN 2012 S60 IN REGARDS TO THIS ISSUE. I AM NOT THE ORIGINAL OWNER OF THIS VEHICLE, SO I AM NOT SURE IF THIS VEHICLE WAS PART OF THAT RECALL OR NOT. I HAVE WAITED MY WHOLE LIFE TO OWN A VOLVO. HOWEVER, I CAN NOT IN GOOD CONSCIOUS SPEND ANY ADDITIONAL MONEY ON A DEFECTIVE VEHICLE.

LIKE MANY OF THE COMPLAINS LISTED FOR THIS MAKE AND MODEL, MY 2012 VOLVO S60 IS CONSUMING OIL BETWEEN OIL CHANGES WITH NO WARNING LIGHT OF LOW OIL PRESSURE SHOWING UP. THERE IS NO SMOKE OR PUDDLES INDICATING BURNING OIL OR AN OIL LEAK. WE TRY TO KEEP A CLOSE EYE ON THE OIL BECAUSE THE DEALER SAID SINCE IT'S A TURBO IT NEEDS EXTRA OIL BETWEEN CHANGES. ABOUT A YEAR AGO THE OIL TRAP WAS CHANGED BECAUSE IT WAS LEAKING. RECENTLY, THE CAR STARTED RUNNING ROUGH, LIKE IT NEEDED SPARK PLUGS,(THOUGH IT WAS NOT TIME) THEN THE CHECK ENGINE LIGHT CAME ON. WE FOUND OUT THE 5TH CYLINDER STOPPED FIRING AND I HAVE A WARPED HEAD NOW BECAUSE OF THE ENGINE GETTING TOO HOT. THE WEEK BEFORE, I COULD SMELL THE CAR WAS BURNING RICH, NOW I REALIZE IT WAS BECAUSE OF THE 5TH CYLINDER AND VERY LIKELY THE 'GUNK' FROM THE STOPPED UP OIL TRAP. EVERYTHING LEADS BACK TO THE OIL ISSUE.

IN OCTOBER 2018. WHILE DRIVING MY 2012 VOLVO ( 88,000 MILES)THE CAR STARTED TO HESITATE IN TRAFFIC THEN IT STOP. I HAD JUST EXIT THE EXPRESS HIGHWAY ON TO A CITY STREET. THERE WAS NO SENSOR LIGHTS OR ENGINE CHECK LIGHT THAT CAME ON AT ALL. TRIED TO CRANK THE CAR BACK UP. THE CAR WOULD NOT START. SUDDENLY THE OIL LIGHT AND THE AIR BAG LIGHT CAME ON. A SEARS TECHNICAL CAME OUT TO JUMP START THE CAR THINKING IT WAS MY BATTERY TO TAKE CAR TO THERE SHOP. HE CHECK THE OIL BECAUSE THE LIGHT WAS ON. THE OIL WAS FINE NOT LOW. I HAD JUST HAD A OIL CHANGE SEPT 2018. THE CAR STILL WOULD NOT START. I HAD TO GET A TOW TO A SHOP FOR FOREIGN CARS. MY DIAGNOSIS ENGINE LOCKED UP. THE INJECTORS 5 AND 6 WAS WIDE OPEN (HYDRO LOCKING ) FUEL HAD BEEN LEAKING EVERYWHERE EVEN IN MY OIL. THE PRICE WAS $1400.00 TO REPAIR.

ON DECEMBER 24, 2015, OUR 2012 VOLVO S60 FWD T5 ENGINE BROKE DOWN ON A CITY STREET. THE BELT WAS REPLACED AT THE VOLVO DEALERSHIP WITH A STANDARD "VOLVO-BELT." MILEAGE ON THE CAR AT THE TIME WAS 43843. FAST FORWARD TO AUGUST 21, 2018, THE CAR BREAKS DOWN AGAIN ON CITY STREET. CURRENT MILEAGE IS 73114. THE BELT AGAIN BREAKS. HOWEVER, THIS TIME DEBRIS GOT INTO TIMING BELT GEARS. THIS CAUSED THE ENGINE TO JUMP TIME AND NOW VALVES ARE BENT. VOLVO DEALERSHIP QUOTED $~6000.00 TO REPAIR. IS THERE AN UNDERLYING ENGINE/BELT PROBLEM THAT NEEDS TO BE INVESTIGATED.

CONSUMING OIL BETWEEN OIL CHANGES AND NO WARNING LIGHT OF LOW OIL PRESSURE SHOWS UP. JUST LUCKY TO HAVE CHECKED THE DIP-STICK DURING MY ROUTINE CHECKUP AND FOUND OIL COMPLETELY DEPLETED. ADDED 5 QUARTS OF SYNTHETIC OIL AGAIN CHECKING IN THREE WEEKS I HAD TO ADD ANOTHER 2 QUARTS. THIS IS NOT GOOD AT ALL. THE MANUFACTURER NEEDS TO BE NOTIFIED OF THIS PROBLEM WHICH IS VERY RAMPANT AND MANY PEOPLE HAVE HAD THEIR VEHICLES ENGINE SEIZE. A RECALL TO FIX THE PROBLEM IS NEEDED ASAP. THE VEHICLE HAS ONLY 62K

I TOOK MY CAR IN FOR A ROUTINE OIL CHANGE AND DISCOVERED WITHIN 45 MILES OF DRIVING THE CAR THAT THERE WAS NO OIL IN THE VEHICLE. THE OIL PRESSURE LIGHT NEVER CAME ON NOR DID THE CHECK ENGINE LIGHT COME ON. IT WASN'T UNTIL AFTER I ADDED 4QUARTZ OF OIL AND THE ENGINE QUIETED DOWN THAT THE OIL PRESSURE LIGHT CAME ON FOLLOWED BY A CHECK ENGINE LIGHT AND A NOTIFICATION SAYING TO TURN OFF THE ENGINE IMMEDIATELY. THIS HAPPENED AS I WAS DRIVING MY CAR TO PEP BOYS TO SEE A MANAGER ABOUT THEM NOT PUTTING OIL IN THE CAR. I HAVE BEEN FIGHTING WITH PEP BOYS ON THE ISSUE FOR OVER A MONTH AND THE MECHANIC I HIRED HAS JUST POINTED OUT THAT THERE WAS A RECALL FOR THE ISSUE I AM HAVING WITH MY CAR. APPARENTLY VOLVO HAS HAD AN ISSUE WITH THE TIRE PRESSURE LIGHT NEVER COMING ON WHICH IS EXACTLY WHAT I TOLD PEP BOYS THAT THERE WAS ABSOLUTELY NO INDICATION THAT THERE WAS NO OIL IN THE CAR UNTIL A KNOCKING SOUND HAD STARTED.