Electronic Stability Control (esc)EngineFuel/propulsion System
IN OCTOBER 2018. WHILE DRIVING MY 2012 VOLVO ( 88,000 MILES)THE CAR STARTED TO HESITATE IN TRAFFIC THEN IT STOP. I HAD JUST EXIT THE EXPRESS HIGHWAY ON TO A CITY STREET. THERE WAS NO SENSOR LIGHTS OR ENGINE CHECK LIGHT THAT CAME ON AT ALL. TRIED TO CRANK THE CAR BACK UP. THE CAR WOULD NOT START. SUDDENLY THE OIL LIGHT AND THE AI…
Read full complaint
IN OCTOBER 2018. WHILE DRIVING MY 2012 VOLVO ( 88,000 MILES)THE CAR STARTED TO HESITATE IN TRAFFIC THEN IT STOP. I HAD JUST EXIT THE EXPRESS HIGHWAY ON TO A CITY STREET. THERE WAS NO SENSOR LIGHTS OR ENGINE CHECK LIGHT THAT CAME ON AT ALL. TRIED TO CRANK THE CAR BACK UP. THE CAR WOULD NOT START. SUDDENLY THE OIL LIGHT AND THE AIR BAG LIGHT CAME ON. A SEARS TECHNICAL CAME OUT TO JUMP START THE CAR THINKING IT WAS MY BATTERY TO TAKE CAR TO THERE SHOP. HE CHECK THE OIL BECAUSE THE LIGHT WAS ON. THE OIL WAS FINE NOT LOW. I HAD JUST HAD A OIL CHANGE SEPT 2018. THE CAR STILL WOULD NOT START. I HAD TO GET A TOW TO A SHOP FOR FOREIGN CARS. MY DIAGNOSIS ENGINE LOCKED UP. THE INJECTORS 5 AND 6 WAS WIDE OPEN (HYDRO LOCKING ) FUEL HAD BEEN LEAKING EVERYWHERE EVEN IN MY OIL. THE PRICE WAS $1400.00 TO REPAIR.
NHTSA ODI #11143317
7,000 miles · Jun 21, 2012
Electronic Stability Control (esc)Service BrakesVehicle Speed Control
THIS IS THE SECOND OCCASION ON WHICH THIS DEFECT HAS APPEARED, THE PRIOR INCIDENT HAPPENING IN APPROXIMATELY MARCH 2012, AT A MILEAGE OF APPROXIMATELY 5000 MILES. I HAVE OWNED THE CAR FOR JUST UNDER SIX MONTHS. I LIVE IN A SOUTHEASTERN US STATE AND TRAVELLED TO MY SECOND HOME IN FLORIDA. THE CAR HAS BEEN PARKED IN FLORIDA FEW…
Read full complaint
THIS IS THE SECOND OCCASION ON WHICH THIS DEFECT HAS APPEARED, THE PRIOR INCIDENT HAPPENING IN APPROXIMATELY MARCH 2012, AT A MILEAGE OF APPROXIMATELY 5000 MILES. I HAVE OWNED THE CAR FOR JUST UNDER SIX MONTHS. I LIVE IN A SOUTHEASTERN US STATE AND TRAVELLED TO MY SECOND HOME IN FLORIDA. THE CAR HAS BEEN PARKED IN FLORIDA FEWER THAN 20 TOTAL DAYS. ON BOTH OF THE LAST TWO OCCASIONS DURING WHICH THE VEHICLE WAS PARKED IN FLORIDA, AN ANIMAL WAS APPARENTLY ABLE TO CLIMB DEEP INTO THE UNDERBODY OF THE CAR AND CHEW ON WIRES CONTROLLING THE DYNAMIC TRACTION STABILITY CONTROL SYSTEM, THE ANTILOCK BRAKING SYSTEM, THE CRUISE CONTROL SYSTEM, AND THE VOLVO CITY SAFETY CRASH AVOIDANCE SYSTEM. ON BOTH OCCASIONS, THE INTERNAL CAR ALERT SYSTEM DETECTED THE PROBLEM, ALERTED ME, AND VOLVO AGREED TO COVER THE COST OF THE REPAIRS, THOUGH TODAY, ON THE SECOND OCCASION, VOLVO INDICATED THEY WILL NOT COVER THIS FORM OF DAMAGE IN THE FUTURE. I PROPOSED TO BOTH MY VOLVO DEALERSHIP AND TO THE NATIONAL VOLVO CUSTOMER CARE CENTER THAT AN APPROPRIATE FORM OF SHIELDING SHOULD BE ADDED TO COVER THE WIRES CONTROLLING THESE SYSTEMS TO PREVENT AN ANIMAL'S ACCESS TO THEM. TO THE BEST OF MY KNOWLEDGE, THIS SUGGESTION WAS IGNORED, AS NO SPECIAL SHIELDING WAS DESCRIBED/OFFERED, DESPITE THE CRITICAL NATURE OF THESE SYSTEMS. THIS PROBLEM HAS NEVER OCCURRED WITH EITHER OF THE OTHER TWO VEHICLES WHICH I REGULARLY TAKE TO THE SAME LOCATION, THUS, I BELIEVE THIS IS A DESIGN FLAW IN WHICH EITHER THE MATERIALS USED IN THESE WIRING SYSTEMS ARE PARTICULARLY ATTRACTIVE TO WHATEVER ANIMAL CHEWED THE WIRES (E.G. SOY-BASED WIRE COATING POLYMERS PERHAPS), OR MORE LIKELY, THE WIRES ARE NOT SUFFICIENTLY SHIELDED/JACKETED TO PREVENT SUCH DAMAGE. IN EACH CASE, SINCE THERE WAS NOT A NEARBY VOLVO DEALERSHIP, I DROVE MY VEHICLE BACK TO THE DEALERSHIP FROM WHICH I PURCHASED IT WITHOUT FUNCTIONAL SAFETY SYSTEMS.
Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not secure the occupant in the event of a crash.
Consequence & remedy
Consequence: An unsecured occupant has an increased risk of injury in the event of a crash.
Remedy: Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R10029.
Volvo Car of USA LLC (Volvo) is recalling certain 2011-2017 S60, S60I, V60, S60CC and V60CC vehicles. A component within the door latches may break, making the doors difficult to latch and/or leading the driver or a passenger to believe a door is securely closed when, in fact, it is not.
Consequence & remedy
Consequence: A door that is not securely latched could open while the vehicle is in motion, increasing the risk of injury to a vehicle occupant.
Remedy: Volvo will notify owners, and dealers will replace all four door latches, free of charge. The recall began April 9, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R89978.
Volvo Cars of North America, LLC (Volvo) is recalling certain model year 2011-2012 S60 vehicles manufactured June 22, 2010, through May 14, 2012, and equipped with 5-cylinder B5254T5 (VIN code 62) engines. In the affected vehicles, the vehicle may not alert the driver of a low oil pressure situation.
Consequence & remedy
Consequence: Without being warned of a low oil pressure situation, the driver may continue to drive the vehicle until it stalls, which increases the risk of a crash.
Remedy: Volvo will notify owners, and dealers will update the vehicle's software so that the driver is alerted should there be a low oil pressure situation, free of charge. The recall began on January 10, 2014. Owners may contact Volvo at 1-800-458-1552. Volvo's number for this campaign is R29436.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60 AND XC60 PASSENGER VEHICLES. AN INCORRECT MIXTURE OF UNDERBODY COATING AND OVER-APPLICATION CAN RESULT IN RIGID, ICICLE-LIKE AREAS HANGING FROM VEHICLES UNDERCARRIAGE.
Consequence & remedy
Consequence: IF THIS CONDITION EXISTS, THE UNDERBODY COATING MAY PENETRATE THE FUELS LINES AND CAUSE FUEL LEAKAGE, INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL INSPECT THE VEHICLE UNDERCARRIAGE, AND IF EXCESSIVE UNDERBODY COATING IS FOUND IN THE FUEL LINE AREA, IT WILL BE REMOVED. IF THE INSPECTION REVEALS THAT THE FUEL LINES ARE DAMAGED, THEY WILL BE REPLACED. THE SAFETY RECALL BEGAN ON APRIL 25, 2012. OWNERS MAY CONTACT VOLVO CUSTOMER CARE CENTER AT 1-800-458-1552.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60, XC60, S80 AND XC70 VEHICLES MANUFACTURED FROM MAY 16, 2011, THROUGH OCTOBER 6, 2011. IN THESE VEHICLES, THE WIRE HARNESS UNDER THE FRONT SEATS MAY HAVE NOT BEEN ATTACHED PROPERLY TO THE SEAT FRAME. AS A RESULT, WHEN THE SEATS ARE MOVED TO ADJUST THE SEATING POSITION, THE WIRE HARNESS MAY GET PULLED, CAUSING IT TO DISCONNECT.
Consequence & remedy
Consequence: IN THE EVENT OF CRASH, THE FRONT AND/OR SIDE IMPACT AIR BAGS MAY DEPLOY IMPROPERLY OR NOT AT ALL, INCREASING THE RISK OF INJURY. ALSO, THE LAP BELT PRETENSIONER MAY NOT DEPLOY.
Remedy: VOLVO WILL NOTIFY OWNERS, AND DEALERS WILL INSPECT AND, IF NECESSARY, SECURE THE SEAT WIRE HARNESS. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 12, 2012. OWNERS MAY CONTACT VOLVO CARS AT 1-800-458-1552.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2006-2012 C70 VEHICLES MANUFACTURED FROM NOVEMBER 15, 2005, THROUGH JULY 31, 2011, AND MODEL YEAR 2011-2012 S60 VEHICLES MANUFACTURED FROM JULY 14, 2010, THROUGH APRIL 16, 2011, THAT WERE EQUIPPED WITH OPTIONAL ACCESSORY SPARE TIRE KIT. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES DO NOT CONTAIN THE CORRECT INFORMATION FOR VEHICLES EQUIPPED WITH THE OPTIONAL ACCESSORY SPARE TIRE AND WHEEL KIT.
Consequence & remedy
Consequence: A MISPRINTED LABEL COULD LEAD TO IMPROPER TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Remedy: VOLVO WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE VEHICLE AND INSTALL THE LABEL AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 23, 2012. OWNERS MAY CONTACT VOLVO AT 1-201-768-7300.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60 PASSENGER CARS MANUFACTURED FROM JANUARY 18, 2011, THROUGH JANUARY 28, 2011. THE MALE PART OF THE FUEL LINE QUICK CONNECTOR END SHAPE WAS PRODUCED WITH DIMENSIONS OUT OF SPECIFICATION, LEADING TO EXCESSIVE ASSEMBLY FORCE ON THE FEMALE CONNECTOR ASSEMBLY AND THE POSSIBILITY THAT THE LOCKING FUNCTION MAY NOT BE ENGAGED.
Consequence & remedy
Consequence: IF A VEHICLE EXHIBITS THIS CONDITION, THE FUEL LINE QUICK CONNECTOR MAY DETACH AND THE ENGINE MAY STALL, INCREASING THE RISK OF A CRASH. THE CUSTOMER MAY ALSO NOTICE A FUEL SMELL AND LEAKAGE. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: VOLVO DEALERS WILL REPLACE THE FUEL LINES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 24, 2011. OWNERS MAY CONTACT VOLVO AT 1-201-768-7300.
VOLVO IS RECALLING CERTAIN MODEL YEAR 2012 S60 PASSENGER CARS MANUFACTURED FROM NOVEMBER 18, 2010, THROUGH MAY 5, 2011. THE SOFTWARE FOR THE FUEL PUMP UNITS MAY NOT BE COMPATIBLE WITH ALL FUEL PUMPS AND COMPONENTS RESULTING IN INSUFFICIENT FUEL TRANSFER IN THE PUMP UNIT.
Consequence & remedy
Consequence: UNDER CERTAIN DRIVING CONDITIONS, THERE MAY BE ENGINE HESITATION AND POSSIBLE ENGINE STALL EVEN THOUGH THE FUEL GAUGE INDICATES UP TO 1/4 OF THE FUEL IS LEFT IN THE TANK. THIS CONDITION INCREASES THE RISK OF A VEHICLE CRASH.
Remedy: VOLVO WILL NOTIFY OWNERS AND DEALERS WILL UPGRADE THE ENGINE CONTROL MODULE SOFTWARE, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 1, 2011. OWNERS MAY CONTACT VOLVO AT 1-201-768-7300.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2012 Volvo S60 Problems, Complaints & Recalls | Skip That Year
Illustration