2001 Volvo S60

INTERMITTENT FAILURE OF ELECTRONIC THROTTLE IN 2001 VOLVO S60. FORTUNATELY OCCURRED IN PARKING LOT WITH VEHICLE AT REST. VEHICLE SUDDENLY STOPPED RESPONDING TO THROTTLE. TURNED OFF VEHICLE AND DID VISUAL AND TACTILE SURVEY OF THROTTLE PEDAL AREA. RESTARTED VEHICLE AND PROBLEM DISAPPEARED. COULD HAVE BEEN VERY SERIOUS SITUATION HAD VEHICLE BEEN AT SPEED. *TR

I WAS PLANNING TO GO INTO WORK A BIT LATER THAN USUAL SO I LOADED UP MY TWO YOUNGEST BOYS INTO THE CAR FOR MY WIFE, AFTER SHE PULLED OUT I NOTICED NUMEROUS WET SPOTS ON MY CARPORT, THERE IS ENOUGH TREE POLLEN ON THE CARPORT THAT IT HOLDS THE FUEL EVIDENTLY FOR AN EXTENDED PERIOD OF TIME. UPON SEEING THE SPOTS ON THE CARPORT I RAN MY FINGER THROUGH THE AREA AND BEFORE I HAD MY HAND WITHIN A FOOT OF MY NOSE I COULD CLEARLY IDENTIFY THE SMELL. I NORMALLY LEAVE FOR WORK HOURS BEFORE MY WIFE AND KIDS DEPART FOR SCHOOL AND I NORMALLY ARRIVE HOURS AFTER THEY ARE HOME, IT HAS TAKEN ME A WHILE TO NOTICE THE PROBLEM AND DISCOVER THE SOURCE. OUR CARPORT IS OPEN ON THREE SIDES, IN THE LAST TWO WEEKS WE HAVE NOTICED A VERY STRONG GASOLINE SMELL, I THOUGHT IT WAS FROM A GAS CAN I KEPT NEARBY. AFTER REMOVAL OF THE GAS CAN WE CONTINUED TO SMELL THE GASOLINE, IT IS SO STRONG THAT EVEN IN AN OPEN AREA IT WILL ACTUALLY MAKE YOU NAUSEOUS WITHIN MINUTES. I QUESTIONED MY WIFE ABOUT HER GAS MILEAGE AND ANY OUT OF THE ORDINARY PERFORMANCE IN THE CARE LATELY, SHE STATED THAT THE GAS MILEAGE HAS DECREASED SEVERELY IN THE PAST COUPLE OF MONTHS AND THE CAR RUNS VERY ROUGH AS FAR AS IDLING AND ACCELERATION. I USED A FLOOR JACK TO RAISE THE LEFT SIDE OF THE CAR AND DISCOVERED THAT THE GAS TANK HAS A LEAK ON THE TOP OF IT OR THE OUTLET FUEL LINE ABOVE THE TANK HAS A LEAK. NORMALLY THE CAR CAN BE DRIVEN BY MY WIFE FOR HER DAY TO DAY PURPOSES FOR TWO WEEKS ON A FULL TANK NOW IT WILL NOT MAKE ONE FULL WEEK. THERE HAS BEEN NO INCIDENT WHERE ANYONE WAS SERIOUSLY HURT BUT I BELIEVE THAT THE AMOUNT OF FUEL LEAKING COULD BE A FATAL DEFECT AT SOME POINT IF NOT DISCOVERED AND REPAIRED PROPERLY. I DID SOME INVESTIGATING ON THE INTERNET AND DISCOVERED THE FILING AND RECALL IN ARIZONA AND NEVADA ID # 07V152000. I HAVE TO WONDER WHO DECIDED THAT THESE TWO STATES WERE THE ONLY ONE'S HOT ENOUGH TO HAVE THIS PROBLEM? I HAVE TAKEN NUMEROUS PICTURES AND WOULD BE HAPPY TO SUPPLY THEM IF NECESSARY. THANK YOU *TR

2001 VOLVO S60 T5 AFTER ABOUT 30 MILES OF HIGHWAY DRIVING, I CAME TO A STOP DUE TO TRAFFIC. WHEN TRAFFIC STARTED MOVING, I NOTICED JERKING AND HARD SHIFTING. THE TRANSMISSION SERVICE LIGHT CAME ON AND THE CAR WENT INTO LIMP MODE. I EVENTUALLY HAD TO HAVE THE CAR TOWED TO THE DEALERSHIP WHERE I WAS TOLD THAT IT NEEDED A NEW TRANSMISSION FOR 4000.00. THE 2001 S60 TRANSMISSION ISSUE IS VERY COMMON AND SHOULD BE REPLACED FREE OF CHARGE BY VOLVO. *TR

FUEL ODOR WHEN EXITING VEHICLE AFTER PARKING. FUEL RESIDUE OBSERVED ON THE SIDE OF THE GAS TANK WHEN LOOKING UNDER THE VEHICLE. DEALER NOT SURE IF COVERED BY EXTENDED WARRANTY.*TR UPDATE 1/9/09: WEB USER COMMENTS: ISSUE RESOLVED, VEHICLE REPAIRED UNDER EXTENDED WARRANTY. HOWEVER, TO BE SURE I WAS COVERED BEFORE VISITING THE DEALER, I HAD TO REMOVE THE SEAT BOTTOM AND THE PUMP COVER AND VERIFY THE FUEL LEAK WAS AT THE TOP OF THE FUEL PUMP. THEN THE SERVICE MANAGER AGREED I WOULD BE COVERED. ---- THIS MAIL WAS SENT USING THE CONTACT FORM FROM HTTP://WWW-ODI.NHTSA.DOT.GOV WEB

IN VOLVO 2001 S60 T5. THE CAR SOMETIMES STOP ACCELERATING FOR SECONDS, AND THEN SUDDENLY IT CLICKS WITH A JOLT AFTER ABOUT A SECOND AND THE CAR LURCHES FORWARD. THE PROBLEM SEEMS TO BE HAPPENING WITH A LOT OF PEOPLE DUE TO A PROBLEM WITH THE VALVE BODY AS THE DEALER AND ANOTHER MECHANIC SUGGESTED (TRANSMISSION PART). THIS REQUIRE REPLACEMENT OF TRANS. VALVE BODY, SEALING KIT AND TCM UPGRADE. THEN TRANS OIL FLUSH. A TOTAL COST OF $2488 QUOTED FROM GALPIN VOLVO VAN NUYS CALIFORNIA. BELOW IS A PAGE SHOWING DIFFERENT CUSTOMERS ARE HAVING THE SAME PROBLEM. HTTP://WWW.MATTHEWSVOLVOSITE.COM/FORUMS/VIEWTOPIC.PHP?P=20617. *TR

I DRIVE A 2001 VOLVO S60. I PURCHASED IT NEW IN 2002. IT HAS A TOTAL OF 35,000 MILES. I DRIVE THE CAR SHORT DISTANCES AND IN TOWN ONLY. IT STARTED GIVING ME PROBLEMS A COUPLE OF WEEKS AGO WITH JERKING FORWARD. THE "TRANSMISSION REQUIRED" "CHECK ENGINE" MESSAGES CAME ON TODAY. I IMMEDIATELY BROUGHT IT TO A VOLVO DEALER WHO COULD NOT EXPLAIN TO ME WHAT THE PROBLEM IS UNTIL AFTER THEY PERFORM A DIAGNOSTIC TEST AT A COST $122.00. I FELT THAT I HAD NO OTHER RECOURSE BUT TO LEAVE IT WITH THEM. I DON'T FEEL THAT MY CAR SHOULD EXPERIENCE TRANSMISSION PROBLEMS SINCE THE CAR IS ONLY 7 YEARS OLD AND IS NOT DRIVEN FOR LONG DISTANCES. THANK YOU FOR YOUR CONSIDERATION. *TR

WHILE STOPPING AT A TRAFFIC LIGHT, I NOTICED ALL THE WARNING LIGHTS ON THE LOWER RIGHT SIDE OF THE INSTRUMENT PANEL CAME ON AND IMMEDIATELY WENT OFF, NO OTHER INDICATIONS. WHILE WAITING AT THE LIGHT, EVERYTHING APPEARED NORMAL. WHEN THE LIGHT CHANGED TO GREEN, I PUSHED ON THE GAS PEDAL TO PULL AWAY AND NOTHING HAPPENED. THE CAR WOULD NOT ACCELERATE AT ALL. NO LIGHTS WERE ON. I PUSHED TO GAS PEDAL TO THE FLOOR AND BACK UP AND THEN HALF WAY DOWN, ABSOLUTELY NOTHING WORKED. IT WOULD NOT GO ANY FASTER THAN IDLE. NO INCREASE IN RPM'S AT ALL, NO MATTER WHAT POSITION THE GAS PEDAL WAS IN. I'M IN THE FAST LANE AT RUSH HOUR AND COULD ONLY GO ABOUT 4 MILES PER HOUR. I MANAGED TO WORK MY WAY OVER THE SIDE OF THE ROAD AND PULL INTO A PARKING LOT. I STOPPED AND PUT THE CAR INTO PARK. I HEARD A "CLICK" AS IF A RELAY WAS RESET. I THEN PUT THE CAR INTO REVERSE AND IT SEEMED TO WORK. I PUT IT IN DRIVE AGAIN AND EVERYTHING APPEARED TO WORK OKAY AFTER THAT. I TOOK IT TO TURNER VOLVO, HERE IN SACRAMENTO, CA AND THEY SAID THEY COULDN'T DUPLICATE THE PROBLEM AND THERE WEREN'T ANY CODES IN THE COMPUTER SO THERE WAS NOTHING THEY COULD DO. THIS WAS AN "EXTREMELY" DANGEROUS SITUATION AND COULD HAVE CAUSED A VERY SERIOUS ACCIDENT, MADE WORSE BY THE FACT THAT MY 5 YEAR OLD NIECE WAS WITH ME AT THE TIME THIS HAPPENED. WE COULD HAVE BEEN KILLED AND TURNER VOLVO SAYS THERE'S NOTHING THEY CAN DO. WELL TURNER, THANKS FOR NOTHING AND FOR TAKING OUR LIVES SO LIGHTLY. MAYBE SOMEDAY A MEMBER OF YOUR FAMILY WILL BE INVOLVED IN AN ACCIDENT CAUSED BY THIS PROBLEM AND THEN WE'LL SEE WHAT YOU THINK. THIS IS AN ONGOING PROBLEM WITH VOLVO'S AND NEEDS TO BE TAKING CARE OF BY THE MANUFACTURER NOT THE PEOPLE WHO TRUSTED YOU ENOUGH TO BUY YOUR CARS. *TR

THE CAR WOULD SUDDENLY CEASE TO ACCELERATE NOT GOING OVER TWENTY MILES PER HOUR. THE CAR WAS TAKEN TO THE VOLVO DEALERSHIP WHERE THE EMT WAS CLEANED. UNDER AN EXTENDED WARRANTY. 10 DAYS LATER THE CAR WITHOUT WARNING WENT INTO THE 'LIMP HOME MODE AGAIN" THE CAR WAS RETURNED TO VOLVO THIS TIME I WAS TOLD THE ENGINE CONTROL MODULE WAS FAULTY AND NEEDED REPLACEMENT AND THE ETM WAS NOT THE PROBLEM THIS PART WAS OUT OF WARRANTY AND WOULD COST OVER $2,000 TO REPLACE OR I COULD TRADE IN THE CAR. I FEEL THAT THIS TOO SHOULD BE TAKEN CARE OF SINE THE ECM DIRECTS THE ACTIVITY OF THE ETM AND WAS NOT INITIALLY IDENTIFIED AS THE PROBLEM IF THIS DOES NOT CORRECT THE PROBLEM SOMEONE COULD BE SERIOUSLY INJURED WHEN TRYING TO MERGE ONTO THE FREEWAY OR CROSSING INTERSECTIONS. *TR

I BOUGHT MY 2001 VOLVO S60 N/A BRAND NEW AT THE END OF 2001. SINCE UP TO ABOUT SEPTEMBER OF 2007, I HAD NO PROBLEMS WITH THE VEHICLE EXCEPT ROUTINE SERVICE. THEN I NOTICED LOUD "CLANGING" AND "METALLIC THUMPING" WHENEVER I WENT OVER ROUGH ROADS AT ANY SPEED. TURNS OUT THAT MY CONTROL ARM BUSHINGS (BE THEY EVER POORLY MADE) CRACKED INTO PIECES. TOOK MY VEHICLE TO MY INDEPENDENT VOLVO SHOP TO REPAIR THE BUSHINGS. THE TECHNICIAN, AFTER THE REPAIRS WERE DONE, NOTIFIED ME THAT THERE WAS A FUEL LEAK COMING FROM THE REAR FUEL TANK AREA. FUNNY THAT IT WAS THAT EXACT WEEK THAT I STARTED TO NOTICE THE GASOLINE SMELL, BE SO EVER FAINT. AS OF TODAY, SEPTEMBER 22, 2008, THE SMELL HAS BECOME VERY STRONG WHERE AS EVEN WITH THE WINDOWS OPEN WHILE DRIVING, I LITERALLY HAVE TO STICK MY NOSE AGAINST THE OPEN WINDOW TO BREATHE IN WHAT SHOULD BE FRESH AIR. *TR