REPLACEMENT OF CV JOINTS- OCTOBER 2018 MY VEHICLE WAS DIAGNOSED WITH LEAKAGE FROM THE CV JOINTS WHICH SPLATTERED ALL UNDERNEATH MY VEHICLE. MY VEHICLE ONLY HAD 69,000 MILES. THE TECHNICIAN STATED THAT THEY SHOULD NOT HAVE BEEN A PROBLEMS WITH SO FEW MILES. HE STATED THAT MY VEHICLE'S STEERING WOULD HAVE BEEN COMPROMISED IF THEY…
Read full complaint
REPLACEMENT OF CV JOINTS- OCTOBER 2018 MY VEHICLE WAS DIAGNOSED WITH LEAKAGE FROM THE CV JOINTS WHICH SPLATTERED ALL UNDERNEATH MY VEHICLE. MY VEHICLE ONLY HAD 69,000 MILES. THE TECHNICIAN STATED THAT THEY SHOULD NOT HAVE BEEN A PROBLEMS WITH SO FEW MILES. HE STATED THAT MY VEHICLE'S STEERING WOULD HAVE BEEN COMPROMISED IF THEY HAD FAILED AND CAUSE DAMAGE TO MY ENGINE. I TRAVEL 1 HOUR ONE DAILY TO WORK. IT COULD HAVE CAUSED A POTENTIAL ACCIDENT IF IT HADN'T BEEN DIAGNOSED IN TIME. IT HAS BEEN SINCE THEN REPAIRED.
NHTSA ODI #11156048
80,000 miles · May 8, 2017
Fuel/propulsion SystemPower TrainUnknown Or Other
IMPROPER DRAINING ROUTE WHICH IN RESULT CAUSES MOLD AND DAMAGE TO FLOOR MATS AND SEAT CUSHIONS IN RAINY WEATHER. TRANSMISSION FLUID HAS HIGHER ACIDITY LEVELS. COOLANT REGULARLY FALLS BELOW MINIMUM LEVEL REQUIRED.
NHTSA ODI #10984381
65,000 miles · Nov 6, 2015
Power Train
TL* THE CONTACT OWNS A 2009 VOLVO S40. WHILE DRIVING APPROXIMATELY 25 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE INDEPENDENTLY DECELERATED AND STALLED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FUEL LINE WAS FRACTURED. THE TRANSMISSION FUEL LIN…
Read full complaint
TL* THE CONTACT OWNS A 2009 VOLVO S40. WHILE DRIVING APPROXIMATELY 25 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE INDEPENDENTLY DECELERATED AND STALLED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FUEL LINE WAS FRACTURED. THE TRANSMISSION FUEL LINE AND THE TRANSMISSION FLUID WERE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.
VOLVO IS RECALLING CERTAIN PASSENGER VEHICLES EQUIPPED WITH POWER FRONT PASSENGER SEATS. THE FRONT SEAT RAIL'S DETECTION SYSTEM WAS MANUFACTURED INCORRECTLY AND MAY PERMIT THE PASSENGER TO FORWARD THE SEAT BEYOND THE INTENDED MAXIMUM.
Consequence & remedy
Consequence: POSITIONING OF THE SEAT BEYOND THE INTENDED MAXIMUM CAN CAUSE INCREASED RISK OF INJURY TO THE PASSENGER IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL INSPECT THE FRONT POWER SEAT STOPS FOR BOTH FRONT SEATS FOR THE PRESENCE OF AN "END STOP" AND REPAIR THE VEHICLES AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 23, 2010. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552 OR AT CUSTOMERCARE@VOLVOFORLIFE.COM.
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
VOLVO IS RECALLING MY 2008-2009 VEHICLES. A SECTION OF THE POWER STEERING RETURN LINE HOSE WAS NOT PROPERLY VULCANIZED (CURED) AND DOES NOT MEET SPECIFICATIONS. IF THE POWER STEERING RETURN HOSE FAILS, A SUDDEN RUPTURE OF THE HOSE CAN OCCUR.
Consequence & remedy
Consequence: THIS CAN RESULT IN A RAPID DRAINAGE OF THE POWER STEERING FLUID IN THE SYSTEM AND A COMPLETE LOSS OF POWER ASSISTANCE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT AND REPLACE THE STEERING RETURN LINE HOSE ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 13, 2008. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2009 Volvo S40 Problems, Complaints & Recalls | Skip That Year
Illustration