IllustrationTHE COOLING SYSTEM AND DEFROST SHUT DOWN AFTER DRIVING FOR A WHILE. TURNS OUT THE CLUTCH WENT BAD ON THE COMPRESSOR. AFTER RESEARCHING FURTHER ONLINE, THERE ARE MANY COMPLAINTS ABOUT THIS FAILURE. UNFORTUNATELY, THIS IS A VERY EXPENSIVE REPAIR THAT I CANNOT AFFORD. *TR
2007 Volvo S40
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2007 Volvo S40 do not stand out strongly from the model-year median of 26.
About this comparison →How this year compares
Owner complaints by model year
Compare all S40 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
70–25K
125–50K
750–75K
375–100K
4100–150K
0150K+
22 reports with mileage · 3 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 5 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports1 fire reports4 injury reports
Engine And Engine Cooling complaints
3 reportsI OWN A '07 VOLVO S40 WITH 78,000 MILES. IT BEGAN MAKING A LOUD WHISTLING NOISE COMING FROM THE OIL DIPSTICK. AFTER RESEARCHING ONLINE I FOUND THAT IT WAS A KNOWN PROBLEM BY VOLVO AND THE DEFECTIVE PART IS COVERED UNDER AN EXTENDED WARRANTY, HOWEVER THIS DEFECTIVE PART CAUSES EXCESSIVE DAMAGE TO THE ENGINE THAT IS NOT COVERED BY…
Read full complaint
I OWN A '07 VOLVO S40 WITH 78,000 MILES. IT BEGAN MAKING A LOUD WHISTLING NOISE COMING FROM THE OIL DIPSTICK. AFTER RESEARCHING ONLINE I FOUND THAT IT WAS A KNOWN PROBLEM BY VOLVO AND THE DEFECTIVE PART IS COVERED UNDER AN EXTENDED WARRANTY, HOWEVER THIS DEFECTIVE PART CAUSES EXCESSIVE DAMAGE TO THE ENGINE THAT IS NOT COVERED BY VOLVO. IT IS NOW UP TO THE CONSUMER TO PAY FOR THE ENGINE DAMAGE OR IT WILL CAUSE THE TIMING BELT TO SNAP AND THE ENGINE TO EXPLODE. AN UNSUSPECTING CONSUMER CAN BE FATALLY INJURED BY THIS PROBLEM AND SOMETHING MUST BE DONE ABOUT IT! *KB
TL*THE CONTACT OWNS A 2007 VOLVO S40. THE CONTACT HAS RECENTLY RENTED THREE ZIP-CARS WITHIN THE PAST FEW MONTHS AND HAS DETECTED AN UNUSUAL SCENT COMING FROM THE VENTS. THE PANTS HE HAD HANGING INSIDE THE VEHICLE HAD A FAINT SMELL TO THEM ONCE HE ARRIVED HOME. HE BELIEVES THERE COULD BE ASBESTOS INSIDE THE VEHICLES. THE DEAL…
Read full complaint
TL*THE CONTACT OWNS A 2007 VOLVO S40. THE CONTACT HAS RECENTLY RENTED THREE ZIP-CARS WITHIN THE PAST FEW MONTHS AND HAS DETECTED AN UNUSUAL SCENT COMING FROM THE VENTS. THE PANTS HE HAD HANGING INSIDE THE VEHICLE HAD A FAINT SMELL TO THEM ONCE HE ARRIVED HOME. HE BELIEVES THERE COULD BE ASBESTOS INSIDE THE VEHICLES. THE DEALER AND MANUFACTURER HAVE NOT BEEN NOTIFIED. THE VIN AND ENGINE SIZE WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 40.
Official recalls
210V566000 · Equipment:electrical:navigational System(global Positioning System)
Nov 8, 2010
VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence & remedy
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE INSERTED ON TOP OF THE BATTERY NEXT TO THE PCB. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 18, 2010. OWNERS MAY CONTACT GARMIN AT 866-957-1981 OR VISIT GARMIN'S WEBSITE AT WWW.GARMIN.COM/NUVIBATTERYPCBRECALL.
08V101000 · Service Brakes, Hydraulic:foundation Components:master Cylinder
Mar 5, 2008
VOLVO IS RECALLING 1,114 MY 2007 C30, C70, S40, AND V50 PASSENGER VEHICLES. A SOFT ANODIZED LAYER IN THE MASTER CYLINDER MAY TRIGGER EARLY WEAR ON A RUBBER SEAL THAT CAN RESULT IN INTERNAL LEAKAGE OF BRAKE FLUID. IF AFFECTED, THE DRIVER MAY EXPERIENCE REDUCED BRAKE PERFORMANCE WHEN APPLYING AND MAINTAINING FORCE OF THE BRAKE PEDAL.
Consequence & remedy
Consequence: THE CAPACITY TO BRAKE WILL GRADUALLY DETERIORATE FORCING THE DRIVER TO USE A HIGHER THAN EXPECTED FORCE ON THE BRAKE PEDAL WHEN COMPARED TO AN INTACT BRAKE SYSTEM. THE DETERIORATION CAN EVENTUALLY RESULT IN COMPLETE LOSS OF THE BRAKE SYSTEM FUNCTIONALITY INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE MASTER CYLINDER. THE BRAKE MASTER CYLINDER AND BRAKE FLUID RESERVOIR WILL BE REPLACED AND CERTAIN BRAKE LINES CLEANED FREE OF CHARGE. THE RECALL BEGAN ON MARCH 11, 2008. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.