2025 Volvo EX90

While driving the car on a state road (45 mph) the car suddenly notified me of an "electrical fault", a light that looks like a turtle came on, and the vehicle lost power and couldn't go any faster than 5 mph. Another vehicle almost rear-ended me around a blind curve because I was moving significantly slower than normal traffic. I pulled into a parking lot, shutdown and restarted the car and everything seemed fine. It happened again a few minutes later so we started to head back home. But the real issue happened a minute or so after the second fault - the fault cleared itself and all of a sudden the vehicle's speed shot up to over 60 mph with very little throttle response or control from me. I slowed the car down using the brakes and continued home. The fault happened again, and cleared itself again in the same manner but this time while I was turning causing me to almost hit a curb while trying to turn. The car is dangerous. These should be taken off the road permanently.

I was parked in a parking lot and when I released my foot from the break, the car accelerated on its own and crashed into the car in front of me. The automatic emergency braking did not deploy. It was most recently a safety risk and put others in the parking lot, particularly the driver in front me, in danger. I have reported this issue to Volvo and they instructed me to get the body of the car repaired and then the dealer will inspect it. I filed an insurance claim with my insurance company and the car is going to be repaired. There were no warning lamps or messages prior to the failure.

DESCRIPTION OF DEFECT: I am reporting a recurring incident of unintended acceleration in my Volvo EX90. On multiple occasions, immediately upon shifting the vehicle into Drive — before I touched the accelerator pedal — the vehicle accelerated forward on its own without any input from me. This has happened more than once and is not an isolated event. The acceleration occurs at the moment of gear engagement, before I have made any contact with the accelerator pedal. I took the vehicle to my Volvo dealership on 2/12/26. The dealer was unable to reproduce the issue or identify a cause. This defect poses a serious and immediate safety risk, particularly in parking lots, driveways, and congested traffic, where unexpected acceleration could result in a collision, property damage, or injury to pedestrians or other drivers. I am requesting that NHTSA open a formal investigation into this issue.

Ongoing Software Issues From shortly after delivery through now, the vehicle experiences frequent and recurring warning messages and system failures, including but not limited to: Suspension system warnings Driver assistance and self-driving feature failures One-pedal driving malfunctions Parking camera and sensor errors Other system warnings that appear to be software-related While the vehicle was often still technically drivable, these issues regularly caused the car to operate at reduced functionality, with key safety and convenience features disabled. Although software updates have reduced the frequency of these issues, they still occur intermittently and often require a vehicle reset or time to resolve. Because of these persistent and unpredictable warnings, my family and I have avoided taking this vehicle on long trips out of concern that the car may become unsafe or inoperable while traveling. The vehicle was brought in for service in December 2024 in an attempt to address these software-related issues; however, the service did not resolve the problem at that time. Hardware Failure #1 – GHCA In January 2025, the vehicle experienced a failure of the GHCA component, rendering the all-electric vehicle unable to charge. This occurred shortly after purchase. Service appointment booked: January 27, 2025 Vehicle in shop: aprox 30 days The vehicle was out of service for approximately one full month. During this time, I shared my experience on Reddit due to the severity of the issue and the vehicle’s newness. That post received over 350,000 views, and numerous Volvo EX90 owners reported experiencing the same GHCA failure—many stating they had required multiple replacements of the same component. This strongly suggests a widespread defect rather than an isolated incident. Hardware Failure #2 – GHCA (Repeat Failure) On February 3, 2026, the GHCA failed again, and the vehicle was returned to the dealership for service with no ETA on a fix.

The vehicle supports a feature to reset the display computer by holding the play/pause button for approximately 45 seconds. When executed the center console display as well as the speedometer display over the steering wheel reset and go blank for up to 1 minute. The safety issue is that this function can be performed while the vehicle is in motion. This leaves the speedometer inoperable until the reset completes. This poses an extreme safety hazard as the driver has no way to assess current speed. I'm able to reproduce this on the latest OTA software update 1.3.18.

I experienced a serious safety issue with my 2025 Volvo EX90 around 1:15 PM on October 7, 2025. It was drizzling at the time. I had stopped in front of an ATM to deposit and withdraw money. After finishing, when I released the brake pedal to leave, the vehicle suddenly accelerated forward on its own, much faster than normal creeping speed. I had to keep pressing the brake pedal to control the car. I used intermittent braking to steer it around and managed to park it safely. After shifting into Park (P), I restarted the vehicle’s system, but the issue did not go away. Only after I parked, locked the car, and came back later did it return to normal. I shared my experience on Reddit to see if other owners had similar incidents, and several reported the same issue. I am very concerned that this could happen again, as it poses a serious safety risk if it occurs in traffic or near pedestrians.

The vehicle gear selector had reverse (R) selected and pressing the accelerator pedal caused the vehicle to drive forwards. This appears to have been a result of enabling the "one pedal drive" function from the infotainment display while the gear selector was already in reverse. The mismatch of selected / indicated direction vs the resulting direction is a safety issue

I was on the 101 freeway on January 20, 2025. I was driving on the far left lane, driving 72-65 miles an hour. The 2025 Volvo EX90 suddenly wouldn't accelerate more than 36 mph. A turtle error came on the screen. "Driving Performance Reduced Drive with Caution Book a Service" message displayed. Due to the car suddenly slowing down, we almost were read ended by a truck. I have kids in the car. This car had multiple faults. I had the car serviced on 01/20/25 and received it back from the dealer on 01/28/25. After, receiving the car two days later, now the SOS fault System light turned on, and now the Air Bag Fault Light is on. I do have a video of the incident on the freeway when the car started slowing down and the error messages.