2025 Volvo EX90

Multiple times I have gotten a "Park assistance fault - book a service" message while driving and the parking sensors stop working. The issue temporarily resolves itself only to reoccurring several days later. Took to service and they replaced the car computer and said they could to replicate the issue after replacing the computer. Now a week later and the issue has re-occurred twice again.

My Volvo EX90 has recurring software reliability problems affecting safety-related detection systems and hands-free operation features. These failures involve inconsistent or incorrect detection of vehicles and pedestrians and unpredictable loss of hands-free phone functionality. These issues create increased distraction and reduce confidence in driver-assistance safety features.

When leaving a downtown parking garage, I noted the following alert on the driver's screen: "Steering fault - Drive with caution. Book a service." The driver's screen also showed that there was a driver support system fault and that the lane keeping aid was not available. The center stack stated the following: "1 serious issue detected. Steering fault Drive with caution. Book a service." At the time that the fault came up, the car had been driven out of its parking spot (by turning left) approximately 50 feet. I had then stopped the car to talk to a friend. When I got back into the car, I noted the fault message on the driver's screen when I went to back the car up so that I could leave the parking garage. During my trip from downtown to the dealership, I did not note anything unusual other than the fact that the fault messages were displayed. The messages were displayed when I arrived at the dealership and stayed displayed until I exited the car. When I got back in the car to turn it on, the error messages had disappeared.

While driving, my car suddenly displayed the "Driver Support System Fault" icon (Picture 1). At that time, the only issue was the fault icon. I still had full navigation, lane departure warning and 360 camera functionality when I backed into my parking spot. The car was locked with my key card. I returned to 15 to 20 minutes later. The Driver Support System Fault Icon was lit in addition to the lane departure unavailability icon (Picture 2). The following functions and/or features did not work: - Lane Departure - 360 Camera - Front Camera - Tracking Lines for the Rear Camera - Park Sensor audible alerts (Forward or Backup) - Ambient Temperature (Reads "0 degrees Celsius") - Odometer in the central stack (Reads "-- km") - HVAC Functionality - Heated Seats - Heated Steering Wheel - Bluetooth - Wi-Fi - Google Assistant - Navigation, including map being frozen in one position - Glovebox access - Connectivity with Internet or Volvo App - Volume control for the radio did not function. - 4-way hazard button greyed out and non-functional on center stack Attempted reset/reboot of the Infotainment System did not resolve the issue and the car was taken to the local Volvo dealer. Summary of Pictures attached: Pic 3 - Quick Controls - Shows glove box, 4-way hazard icon and other control icons greyed out Pic 4 - Status - States "Everything is OK", but tire pressure button is not available and Total distance reads "--km". Additionally, as shown in Picture 3, the 4-way hazard icon is greyed out. Pic 5 - Similar shot as Picture 2 - Shows Driver Support System Fault and no Lane Departure Pic 6 - Car is in reverse. Shows rear back up camera without guidance lines. Does not show 360 camera. Pic 7 - HVAC Climate is off and cannot turn on. All controls were greyed out. I pressed "Manual" and "Auto" with no change. Pic 8 - Heated seats and heated steering wheel would not turn on even when I pressed the buttons.

The screen behind the steering wheel, which provides the car's speed, driver assist, warning lights, turn signals, and other driving information suddenly went blank. I was grateful that I was close to home and no longer on the interstate highway I had just exited. I drove home, reset the car, and the screen was back on. I was lucky. I could have been at the beginning on my drive, over a hundred miles from home and unable to easily exit the highway. The car is being towed today back to the dealer, again. This happened without warning. I was driving and the whole screen just went black.

Vehicle: 2024 Volvo EX90 VIN: [XXX] While driving on the highway, the entire digital instrument cluster and infotainment screen went completely black without warning. I could not see my speed, gear indicator, or use turn signals. This created an immediate and dangerous safety hazard, especially at high speed. The issue has occurred more than once, and despite taking the vehicle to the dealership, it has not been permanently resolved. I have filed a California Lemon Law claim with Volvo, and while Volvo acknowledged the defect and promised a buyback on March 18, 2025, they have failed to follow through or provide a resolution for over two weeks. I am submitting this complaint because the vehicle presents an active safety risk to myself and others, and I am concerned that this defect could result in a serious accident or injury if not addressed immediately. I also have video evidence of the blackout event. I am requesting that NHTSA open an investigation into this issue and hold the manufacturer accountable for failing to address a known safety defect in a timely manner. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

At 164 miles on the odometer, I had the following issues: a. Received a message that the active high beam was not available and that it would be necessary to run the wipers to clean the front camera. I ran the wipers with washer fluid to clear the camera as instructed, but it did not clear the error message during the drive cycle; b. Car has Driver Support System Fault; and c. Car has Lane Keeping Aid Fault later in drive cycle which turned off the lane keeping aid function. Car was taken to dealership on 12/23/2024 and returned to me on 1/2/2025.