Engine And Engine CoolingPower TrainVehicle Speed Control
DT*: THE CONTACT STATED IN FEBRUARY 2005 THE ENGINE SURGED WHILE IDLING AT STOP SIGNS. THE DEALERSHIP REPLACED THE ELECTRIC THROTTLE MODULE. IN 2002 AND ON JULY 25, 2005 THE VEHICLE VEERED TO THE RIGHT. UPON INSPECTION THE INDEPENDENT REPAIR SHOP DETERMINED THE ENGINE MOUNTS NEEDED TO BE REPLACED. ALSO, ON JANUARY 20, 2005 …
Read full complaint
DT*: THE CONTACT STATED IN FEBRUARY 2005 THE ENGINE SURGED WHILE IDLING AT STOP SIGNS. THE DEALERSHIP REPLACED THE ELECTRIC THROTTLE MODULE. IN 2002 AND ON JULY 25, 2005 THE VEHICLE VEERED TO THE RIGHT. UPON INSPECTION THE INDEPENDENT REPAIR SHOP DETERMINED THE ENGINE MOUNTS NEEDED TO BE REPLACED. ALSO, ON JANUARY 20, 2005 THERE WAS A NOISE COMING FROM THE DRIVE SHAFT. UPON INSPECTION THE INDEPENDENT REPAIR SHOP REPLACED THE DRIVE SHAFT BECAUSE IT HAD WEAKENED. ALL THE PROBLEMS OCCURRED AT VARIOUS SPEEDS.
NHTSA ODI #10150128
115,100 miles · Dec 8, 2005
Engine And Engine Cooling
ETM FAILED IN CAR FOR THE SECOND TIME AT 115,000 MILES ON VEHICLE, PREVIOUSLY REPLACED SEPTEMBER 2003 AT 64,000 MILES. DRIVING FROM OHIO TO PA FOR THANKSGIVING ETS LIGHT AND CHECK ENGINE LIGHT ILLUMINATED. AFTER THANKSGIVING DINNER WENT TO GO HOME AND MY VOLVO C70 QUIT ACCELERATING WHILE ENTERING A 4 LANE HIGHWAY FROM AN ENTRY…
Read full complaint
ETM FAILED IN CAR FOR THE SECOND TIME AT 115,000 MILES ON VEHICLE, PREVIOUSLY REPLACED SEPTEMBER 2003 AT 64,000 MILES. DRIVING FROM OHIO TO PA FOR THANKSGIVING ETS LIGHT AND CHECK ENGINE LIGHT ILLUMINATED. AFTER THANKSGIVING DINNER WENT TO GO HOME AND MY VOLVO C70 QUIT ACCELERATING WHILE ENTERING A 4 LANE HIGHWAY FROM AN ENTRY RAMP. FORTUNATELY, TRAFFIC WAS LIGHT AND TRAFFIC WAS EASILY ABLE TO PASS TO THE LEFT UNTIL I COASTED OFF TO THE BERM OF THE ROAD. THE CAR WAS IDLING BUT DID NOT HAVE POWER TO GO UP SMALL GRADE. SHUT CAR OFF AND RESTARTED, THROTTLE RESPONSE RESUMED AND WAS ABLE TO RETURN HOME. DEALER REPLACED ETM MODULE UNDER RECENTLY ANNOUNCED EXTENDED WARRANTY PROGRAM ON 12/2/2005. I DO NOT HAVE OLD PART. *JB
NHTSA ODI #10144759
Mileage unknown · Aug 14, 2005
Engine And Engine Cooling
I HAVE A 1999 VOLVO C70 AND I AM EXPERIENCING MY CAR TRYING TO PUSH ITSELF AND THE RPM IDLING VERY FAST AND THE CAR FEELS LIKE ITS GOING TO SHUT OFF. I SUBMITTED A COMPLAINT ALREADY ABOUT MY SONS S60 AND MY S80, WHICH ARE HAVE THE SAME TROUBLES AS MY S80. THE THROTTLE CONTROL MODULE I THINK IS DEFECTIVE AND SHOULD BE RECALLED. …
Read full complaint
I HAVE A 1999 VOLVO C70 AND I AM EXPERIENCING MY CAR TRYING TO PUSH ITSELF AND THE RPM IDLING VERY FAST AND THE CAR FEELS LIKE ITS GOING TO SHUT OFF. I SUBMITTED A COMPLAINT ALREADY ABOUT MY SONS S60 AND MY S80, WHICH ARE HAVE THE SAME TROUBLES AS MY S80. THE THROTTLE CONTROL MODULE I THINK IS DEFECTIVE AND SHOULD BE RECALLED. LUCKILY MY CAR HASN'T TURN OFF ON ME YET, BUT ONE TIME GETTING OUT OF MY GARAGE THE CAR STALLED. PLEASE GET THIS PROBLEM FIXED OR RECALLED. THANKS. *NM
NHTSA ODI #10132775
Mileage unknown · Jan 23, 2003
Engine And Engine Cooling
CONSUMER STATES THAT THE ETS LIGHT COMES ON AND THEN THE ENGINE LIGHT COMES ON, SOON AFTERWARD THE VEHICLE BEGINS TO HESITATE. THE MECHANIC CAN NOT FIND THE PROBLEM. CONSUMER STATES SHE HAS HAD THE VEHICLE IN THE SHOP, GET IT OUT AND THEN WHEN SHE GET IN THE VEHICLE TO START IT UP, THE VEHICLE'S ENGINE LIGHT COMES ON AND THE V…
Read full complaint
CONSUMER STATES THAT THE ETS LIGHT COMES ON AND THEN THE ENGINE LIGHT COMES ON, SOON AFTERWARD THE VEHICLE BEGINS TO HESITATE. THE MECHANIC CAN NOT FIND THE PROBLEM. CONSUMER STATES SHE HAS HAD THE VEHICLE IN THE SHOP, GET IT OUT AND THEN WHEN SHE GET IN THE VEHICLE TO START IT UP, THE VEHICLE'S ENGINE LIGHT COMES ON AND THE VEHICLE BEGIN TO HESITATE. SHE SAYS NOW THERE IS A RINGING SOUND THAT COMES ON ABOUT EVERY 8 SECONDS. TS
NHTSA ODI #10004534
Mileage unknown · Jun 29, 2000
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
ENGINE CHECK LIGHT CAME ON AND WE WERE TOLD THAT NOTHING WAS WRONG AND IT WAS RESET. THE SECOND TIME THE CHECK ENGINE LIGHT CAME ON, THE CO2 SENSOR WAS REPLACED. THE THIRD TIME WAS THE SAME DAY IT WAS REPAIRED FOR THE 2ND TIME AND THE CHECK ENGINE LIGHT CAME ON 20 MILES LATER. THE OXYGEN SENSOR WAS REPLACED AGAIN. IN ADDITIO…
Read full complaint
ENGINE CHECK LIGHT CAME ON AND WE WERE TOLD THAT NOTHING WAS WRONG AND IT WAS RESET. THE SECOND TIME THE CHECK ENGINE LIGHT CAME ON, THE CO2 SENSOR WAS REPLACED. THE THIRD TIME WAS THE SAME DAY IT WAS REPAIRED FOR THE 2ND TIME AND THE CHECK ENGINE LIGHT CAME ON 20 MILES LATER. THE OXYGEN SENSOR WAS REPLACED AGAIN. IN ADDITION, THE IGNITION & FUEL INJECTION FAULT TRACING WAS FOUND FAULTY. THEY ALSO FOUND THAT THE MASS AIR FLOW METER WAS FAULTY & HAD TO BE REPLACED, WE'VE HAD PROBLEMS WITH THE AIR CONDITIONER WHICH HAS A CONSTANT TICKING SOUND THAT THEY CLAIM IS NORMAL FOR THIS MODEL. THE CONVERTIBLE TOP HAD TO ADJUSTED AND THE DASHBOARD ALSO HAS HAD TO BE REMOUNTED 3 TIMES. THIS CAR HAS BEEN TIED UP AT THE DEALER FOR 40 DAYS BECAUSE OF THE CHECK ENGINE LIGHT THAT KEEPS COMING ON AND WE'VE BEEN TOLD NOT TO WORRY ABOUT THIS. *AK
ON CERTAIN PASSENGER VEHICLES, A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING, AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.
Consequence & remedy
Consequence: THIS RESULTED IN A HIGH NUMBER OF VEHICLES GOING INTO THE LIMP HOME MODE WITHOUT NEED.
Remedy: DEALERS WILL INSTALL THE CURRENT SOFTWARE UPGRADE ONTO THE INVOLVED VEHICLES. THE RECALL BEGAN ON DECEMBER 29, 2006. OWNERS MAY CONTACT VOLVO AT 1-800-458-1552.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, OVER AN EXTENDED PERIOD OF TIME, THE HEADLIGHT SWITCH MAY CEASE TO FUNCTION.
Consequence & remedy
Consequence: THE HEAD LIGHTS MAY NOT OPERATE PROPERLY WHICH COULD RESULT IN INTERMITTENT OR NO HEADLIGHT FUNCTION. THIS COULD IMPAIR A DRIVER'S VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: ON VEHICLES WITH AN ORIGINAL OEM SWITCH, DEALERS WILL REPLACE THE HEADLIGHT SWITCH. ALL OTHER VEHICLES WILL BE INSPECTED TO DETERMINE IF THE SWITCH HAS EEN DAMAGED AND REPLACE ONLY IF NECESSARY. THE RECALL BEGAN ON JANUARY 24, 2005. OWNERS SHOULD CONTACT VOLVO AT 1-800-458-1552.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THERE COULD BE INADEQUATE CONTACT BETWEEN THE BULB AND SOCKET WHICH COULD CAUSE THE FRONT TURN SIGNAL NOT TO FUNCTION AS DESIGNED.
Consequence & remedy
Consequence: THIS WOULD FAIL TO WARN AN APPROACHING DRIVER THAT THE VEHICLE IS TURNING AND COULD LEAD TO A CRASH.
Remedy: DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT TURN SIGNAL BULB AND SOCKET.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA05021 · Throttle Control Malfunction
Opened Dec 6, 2005 · Closed Dec 12, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
ON NOVEMBER 14, 2006 VOLVO SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING ETM FAILURES IN MODEL YEAR (MY) 1999 THROUGH 2001 VOLVO MODELS (NOT INCLUDING THE S40 AND V40), MY 2002 S60 AND V70 WITH NATURALLY ASPIRATED ENGINES AND MY 2002 V70S.ACCORDING TO VOLVO, ?A COMBINATION OF THROTTLE POSITIONING SENSOR IRREGULARITIES, A DIRTY THROTTLE HOUSING AND/OR INEFFICIENT SOFTWARE CALIBRATION MAY CAUSE A WARNING LAMP TO LIGHT AND THE SUBSEQUENT ONSET OF LIMP HOME MODES.VOLVO FURTHER STATED THAT,THIS RESULTED IN A HIGH NUMBER OF THESE VEHICLES GOING INTO LIMP HOME MODE WITHOUT NEED.?VOLVO INDICATED THAT THIS WAS THE MOST SEVERE CONSEQUENCE OF AN ETM FAULT IN THE SUBJECT VEHICLES.THE RECALL REMEDY IS A SOFTWARE UPGRADE INTRODUCED BY VOLVO ON MARCH 16, 2006 IN A CUSTOMER SATISFACTION PROGRAM.AT THE TIME OF THE NOTIFICATION 161,202 VEHICLES OF THE POPULATION OF 331,301 HAD ALREADY HAD THE SOFTWARE UPLOADED AND WERE THEREFORE NOT INCLUDED IN THE POPULATION COUNT OF THE RECALL. ODI?S ANALYSIS OF COMPLAINTS TO ODI AND VOLVO, VOLVO FIELD REPORTS AND WARRANTY DATA FOUND THAT ETM FAILURE COULD RESULT IN (1) ENGINE STALL; (2) MECHANICAL LIMP MODE; (3) LUNGING FORWARD DURING LOW-SPEED DRIVING MANEUVERS; AND (4) FALTERING DURING HIGH SPEED MERGES OR WHEN CROSSING TRAFFIC.ODI IDENTIFIED 12 CRASHES RELATED TO ETM FAILURE, WITH 6 CAUSED BY LUNGING INCIDENTS, 3 CAUSED BY STALLING INCIDENTS, 2 CAUSED BY MECHANICAL LIMP MODE AND 1 FROM THE FALTERING CONDITION.ODI'S ANALYSIS OF COMPLAINT DATA AND INFORMATION OBTAINED FROM CONSUMER INTERVIEWS IDENTIFIED 1,289 INCIDENTS WITH SAFETY RELATED CONSEQUENCES (389.1 PER 100,000 VEHICLES), INCLUDING 479 INVOLVING ENGINE STALL (144.6 PER 100,000 VEHICLES) AND 729 INVOLVING MECHANICAL LIMP MODE (220.0 PER 100,000 VEHICLES).ODI'S ANALYSIS OF WARRANTY CLAIM NARRATIVE TEXT SHOWS AT LEAST 14,965 WARRANTY CLAIMS WITH CODES INDICATING AN ETM FAULT RESULTING IN VEHICLE OPERATION IN MECHANICAL LIMP MODE (4.5% OF THE SUBJECT VEHICLES). VOLVO?S RECALL ADDRESSES ODI?S SAFETY CONCERNS WITH ETM FAILURES.ODI WILL CONTINUE TO MONITOR THE SUBJECT VEHICLES TO DETERMINE IF ADDITIONAL ACTION IS REQUIRED.THIS ENGINEERING ANALYSIS IS CLOSED.
PE05041 · Throttle Control Malfunction
Opened Jul 26, 2005 · Closed Dec 7, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control
PE05-041 WAS OPENED ON JULY, 26, 2005, BASED ON 136 CONSUMER COMPLAINTS TO ODI ALLEGING THROTTLE CONTROL MALFUNCTIONS IN THE SUBJECT VEHICLES.ODI HAS NOW RECEIVED 591 COMPLAINTS OF ETM FAILURES WHICH ALLEGE SYMPTOMS WITH POTENTIAL SAFETY RELATED CONSEQUENCES.THESE INCLUDE ALLEGATIONS OF ENGINE STALL, VEHICLE SURGING FORWARD WITHOUT ACCELERATOR INPUT, VEHICLE HESITATION UPON ACCELERATION AND SUDDEN AND UNEXPECTED TRANSITION INTO REDUCED PERFORMANCE OPERATION (LIMP MODE).VOLVO SUBMITTED OVER 2,900 COMPLAINTS CONCERNING THE ETM IN THE SUBJECT VEHICLES DURING PE05-041.ODI'S PRELIMINARY ANALYSIS OF A SAMPLE THE VOLVO COMPLAINTS IDENTIFIED APPROXIMATELY 55 PERCENT WITH ONE OR MORE OF THE SYMPTOMS DESCRIBED ABOVE.ODI IS CONTINUING ITS ASSESSMENT OF THE INFORMATION CONTAINED IN THE VOLVO COMPLAINTS. IN NOVEMBER 2005, TO RESOLVE AN INVESTIGATION BY THE CALIFORNIA AIR RESOURCES BOARD, VOLVO ANNOUNCED THAT IT WOULD EXTEND THE WARRANTY COVERAGE TO 10 YEARS / 200,000 MILES FOR THE ETM IN APPROXIMATELY 356,000 MODEL YEAR 1999 THROUGH 2002 PASSENGER CARS SOLD IN THE UNITED STATES AND CANADA.UNDER VOLVO'S POLICY, VEHICLES THAT EXPERIENCE ETM FAILURES WILL RECEIVE A VARIETY OF REPAIRS INCLUDING ETM CLEANING, REPROGRAMMING THE ENGINE CONTROL MODULE AND/OR REPLACEMENT OF THE ETM. THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-021) TO CONTINUE TO ASSESS THE SAFETY CONSEQUENCES OF ETM FAILURES IN THE SUBJECT VEHICLES.
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Additional source detail variants (2)
Exterior Lighting:headlights:switch
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
Exterior Lighting:headlights
ON AUGUST 23, 1999, VOLVO NOTIFIED NHTSA THAT IT WOULD CONDUCT A SAFETY RECALL (99V235) ON CERTAIN 1997 MODEL YEAR (MY) 850 VEHICLES AND CERTAIN 1998 S/V/C 70 SERIES VEHICLES FOR FAILURE OF THE HEADLIGHT SWITCH.THE DEFECT REPORT STATED IN PART: OPERATION OF THE HEADLIGHT SWITCH, OVER AN EXTENDED PERIOD OF TIME, CAN RESULT IN INCONSISTENT OPERATION OF THE SWITCH.VOLVO'S REMEDY FOR THIS RECALL WAS TO REPLACE THE HEADLIGHT SWITCH.THIS RECALL QUERY INVESTIGATION WAS OPENED ON JUNE 8, 2004, BASED ON 13 REPORTS OF HEADLIGHT FAILURE ON 1998 AND 1999 S/V/C 70 SERIES VEHICLES THAT WERE NOT INCLUDED IN THE EARLIER RECALL.BY LETTER OF OCTOBER 18, 2004, VOLVO HAS NOTIFIED THE AGENCY THAT IT WILL NOW CONDUCT A SAFETY RECALL OF AN ADDITIONAL 97,000 MY 1998 THROUGH 2000 S70/V70/V70XC AND C70 VEHICLES BUILT FROM JUNE 5, 1997 THROUGH JANUARY 11, 2000. VOLVO DEALERS WILL REPLACE THE ORIGINAL EQUIPMENT MASTER LIGHT SWITCH WITH ONE OF AN IMPROVED DESIGN. SEE SAFETY RECALL 04V504 FOR DETAILS.
1999 Volvo C70 Problems, Complaints & Recalls | Skip That Year
Illustration