2021 Volkswagen Tiguan

Here is a quick description of the issue from our Volkswagon of Huntington service report. We have had this ongoing issue for a few months now. the check engine light will come on. We get it checked, we replace a sensor, and all is good for a day or week. Then we do it again, replacing a different sensor. Now the dealer is saying the oil separator is leaking and requires repairs starting at $8,400 and going up from there as they uncover more. We have always maintained the car properly. From research this appears to be a very known issue with this model car and should be reported and covered by VW. SCANNED VEHICLE AND FOUND FAULTS PRESENT FOR SECONDARY AIR. OBSERVED OIL SEPARATOR LEAKING CUASING UPPER TIMING COVER GASKETS TO BLOW OUT ALLOWING OIL TO ESCAPE. FOUND SECONDARY AIR PORTS IN CYLINDER HEAD CLOGGED TRIGGERING CHECK ENGINE LIGHT. ADVISED TO REPLACE OIL SEPARATOR,CAM SHAFT MAGNETS AND CYLINDER HEAD TO START. APPROX $ 8480.00 PLUS TAX

After oil changes (always maintained at dealerships) it would require a quart of oil with in 2 days. Random starts will blow smoke out the rear. random sluggish behavior. Dealership confirmed PCV valve is causing a buildup in engine pressure which caused a premature oil pan gasket leak. Without full teardown cannot know full extent of damages caused. (which spills out of the bottom and towards tires.....) dealership and fellow Tiguan owners have all reported the same issue! with a repair cost of $1,000-8,000+. same with alot of other years as well.. The date below that i will list is for when the problem was fully confirmed (89k miles) but has always been an issue told its fine ... really noticed it after (68k miles) when i purchased the vehicle. With how many people are dealing with this it is hard to understand how we dont see an open recall for them..... also dealer said pvc valves are on back order and have been. why should one replace with oem if they won't acknowledge its a faulty part?

Check Engine Light came on and got estimate from Pete Moore VW Dealer in Pensacola, Florida and was told the car needed extensive engine repair which included a new cylinder head part. So we waited to come get the car repaired on 3/5/2026 once we had saved up the money for it. We found out the cylinder head is on a Nationwide back order with NO estimated time to get it fixed properly. The technician who gave us the estimate back in September 2025 failed to mention that the cylinder head has been on a Nationwide back order during that time. I am not the only person dealing with this issue in the USA but feel VW has not provided a fix or estimate time to repair these cars properly causing a safety hazard. This time to wait for a part is unacceptable and feel our cars fall under the Lemon Law.

I am experiencing severe oil consumption and leakage with my 2021 Volkswagen Tiguan. The low oil level light began coming on weekly, and I have had to add oil nearly every week to keep the engine from running dry. Recently, I noticed oil leaking underneath the vehicle and immediately parked it. After parking, the vehicle began leaking oil excessively. The problem appears related to PCV system failure, which has caused multiple oil seals to rupture. After researching online, I found many other Tiguan owners reporting the same issues — including PCV valve failure, cracked oil pans, damaged valve seals, and crankshaft seal failures. My vehicle is no longer under the manufacturer’s warranty, and the dealership has not provided a fix. This defect presents a major safety concern because the engine can suddenly lose oil pressure or seize while driving, leading to sudden loss of power or control, which could cause an accident and potential injury. It appears Volkswagen has been aware of similar issues in other model years, but has not issued a recall or permanent repair for this problem. There is currently a class action lawsuit for the exact same issue for 2022 - 2023 Volkswagen Tiguan but doesn't currently include the 2021 Tiguan that I have. I am requesting that NHTSA investigate these widespread PCV and oil consumption failures in 2021 Volkswagen Tiguan vehicles.

The 2021 Tiguan, R-Line that I own now requires a new engine after roughly 70,000. The engine is no longer under warranty, According to the VW Dealership, this is what is wrong with the engine - Based on our observations and diagnostic review, we have determined that damage to the rotating assembly was caused by the presence of one or more metal objects entering the engine. This type of foreign-object intrusion can lead to significant internal impact, which is consistent with the damage we found during our assessment. Also, if you do a search on Reddit and other public forums, there are a lot of 2021 VW Tiguan's with similar issues.

I’ve had my Volkswagen Tiguen since 2021 fresh off the lot. I have been the only owner of the car at about 30,000 miles my head gasket blew, causing the engine to go into default after weeks in the dealer. They replaced the head gasket and stitched it up, the head gasket blew again at this point I was still under warranty so they agreed to replace the engine. It drove fine after the engine was replaced this year 2025. I started to have a whole host of problems. It began to jerk and hesitate at acceleration. My engine light came on with continuous jerking upon acceleration for weeks until I started to lose power in my engine. I couldn’t go over 50 60 mph. I would always pull the car over power it off and power it back on just to see if it would change and it didn’t do much I had a local mechanic add oil to each tire also drain the engine, which had shards of metal in it. And basically stitch the car back together until we can figure out the bigger issues. It’s only been a day since the oil was added to each tire. I had a very violent jerk of the engine, which made it feel and sound like I blew a tire I got out to look at the tire and it was just fine. It was the backfire of the engine going into the exhaust that caused such the violent jerk. Happy that no one was on the road. If somebody was behind me it would’ve easily been an accident. Most of these dealerships know exactly what’s going on and have been avoiding the big conversation of what to do next they rather just replace and Band-Aid these things into the consumer just gives up. I have two small children and this is the only means of transportation. I’m fearful that I’ll be stuck with a car note for a car. I can’t drive.

Check engine light came on with excessive oil leaking from engine. Dealer inspected and diagnosed the PCV/Oil separator had failed, multiple valve stem seals had failed, and valve stem guides were worn causing excessive crankcase pressure. Dealer recommended cylinder head replacement. Vehicle has been at the dealer a month with the cylinder head on backorder and no timeline for resolution. Dealer indicated thousands of cylinder heads in the queue, with tens of units being distributed per month.

2021 Volkswagen Tiguan, Approximately 40,000 miles
Date of failure: Oct 12th, 2025
Component(s): Engine, Powertrain, Vehicle Speed Control, Throttle body Description of the problem:
My 2021 Volkswagen Tiguan experienced a complete engine failure despite having multiple prior service visits for engine-related issues while it was still under warranty. During the warranty period, I brought the vehicle to Grand Junction Volkswagen (Grand Junction, CO) several times for problems including: * Excessive oil consumption * “Check coolant” warning light turning on * EPC (Engine Power Control) mode activating and loss of power The dealership performed an oil consumption test and told me the results were “normal,” but they did not address the coolant light or EPC issues, stating these conditions were within normal limits. The same problems continued after each visit. At approximately 40,000 miles, the engine failed completely while driving, leaving the vehicle inoperable and creating a significant safety risk. The vehicle had to be towed. Volkswagen is now denying liability, claiming the vehicle is out of warranty, even though the same engine problems were documented repeatedly while it was still under warranty. I have opened a case with Volkswagen of America Customer Care (Case #07085098), but there has been no resolution so far. Safety concern:
This issue poses a serious safety hazard. The vehicle can lose power suddenly and stall while in motion, which could lead to a crash or leave occupants stranded in unsafe conditions.

Subject: Complaint Regarding 2021 Volkswagen Tiguan – Premature Engine Failure at 46,000 Miles To Whom It May Concern, I am filing a complaint regarding my 2021 Volkswagen Tiguan (VIN: [XXX] ) which suffered a catastrophic engine failure at only 46,000 miles. •I purchased the vehicle used in August 2023 through CarMax Auto Finance. •At the time of failure, the car had fewer than 50,000 miles and had been properly maintained. •Despite the extremely low mileage, Volkswagen has refused to cover the repair under warranty because the vehicle is slightly past the 4-year time limit. I believe this is unfair and unreasonable. A major component such as the engine should not fail this early, and a vehicle sold under these conditions is not fit for its ordinary purpose. Because of this premature failure, I was left with no functional car but still obligated to pay the outstanding loan balance. This has caused severe financial hardship and forced me to dispose of the vehicle below value. Requested Action: 1.That Volkswagen cover or reimburse the cost of the engine replacement, OR 2.Provide financial relief toward the remaining auto loan balance. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I purchased about 4 months ago with about 139,000 miles on it. The vehicle now has 142,000 miles and is experiencing excessive oil consumption—approximately 0.9 quarts per 600 miles. VW seems to be pushing this off and as I try to use my extended warranty I purchased when I got the car, AUL has asked for an engine tear down. VW knows about this issue, as it is internally a known issue for this model, yet they are unwilling to help. At time of purchase, this issue was not disclosed to me, as such had it been, I would not have chosen this car.