IllustrationPOWER TO THE AIRBAG HAS FAILED, MAKING THE VEHICLE UNSAFE TO OPERATE. AIRBAG WARNING LIGHT HAS BEEN ACTIVATED. SEE VW DEALERS STATEMENT OF FACT WITH REMARKS.
2014 Volkswagen Tiguan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2014 Volkswagen Tiguan do not stand out strongly from the model-year median of 124.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tiguan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
90–25K
1425–50K
1250–75K
575–100K
4100–150K
3150K+
47 reports with mileage · 37 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports0 fire reports0 injury reports
What owners actually said
84 reportsTL* THE CONTACT OWNS A 2014 VOLKSWAGEN TIGUAN. THE CONTACT STATED AFTER RETURNING TO THE VEHICLE, THE CONTACT BECAME AWARE OF SEVERAL ITEMS OF BELONGINGS ON THE GROUND AROUND THE VEHICLE. THE CONTACT ATTEMPTED TO LOCK THE VEHICLE USING THE KEYFOB HOWEVER, THE PASSENGER'S SIDE REAR DOOR REMAINED UNLOCKED. THE CONTACT USED THE INT…
Read full complaint
TL* THE CONTACT OWNS A 2014 VOLKSWAGEN TIGUAN. THE CONTACT STATED AFTER RETURNING TO THE VEHICLE, THE CONTACT BECAME AWARE OF SEVERAL ITEMS OF BELONGINGS ON THE GROUND AROUND THE VEHICLE. THE CONTACT ATTEMPTED TO LOCK THE VEHICLE USING THE KEYFOB HOWEVER, THE PASSENGER'S SIDE REAR DOOR REMAINED UNLOCKED. THE CONTACT USED THE INTERNAL DOOR LOCK FUNCTION TO LOCK THE DOORS. THE CONTACT STATED THAT THERE WAS NO WARNING LIGHTS OR MESSAGES TO THE DOOR BEING AJAR. THE VEHICLE WAS TAKEN TO DICK HANNAH VOLKSWAGEN OF PORTLAND LOCATED AT (12345 E BURNSIDE ST, PORTLAND, OR 97233) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE DOOR LOCKING MECHANISM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.
A CLICKING SOUNDS STARTED COMING FROM THE STEERING WHEEL WHILE TURNING, AT ONE POINT THE AIR BAG LIGHT TURNED ON, AND FROM THAT POINT FORWARD, THE CONTROLS ON THE STEERING WHEEL NO LONGER WORK, INCLUDING THE HORN. THE CLICKING SOUNDS FROM THE STEERING WHEEL IS STILL PRESENT WHILE TURNING. I CALLED A PLACE THAT SPECIALIZES IN VW…
Read full complaint
A CLICKING SOUNDS STARTED COMING FROM THE STEERING WHEEL WHILE TURNING, AT ONE POINT THE AIR BAG LIGHT TURNED ON, AND FROM THAT POINT FORWARD, THE CONTROLS ON THE STEERING WHEEL NO LONGER WORK, INCLUDING THE HORN. THE CLICKING SOUNDS FROM THE STEERING WHEEL IS STILL PRESENT WHILE TURNING. I CALLED A PLACE THAT SPECIALIZES IN VW AND THEY SUGGESTED I CALL VW DEALER INSTEAD BECAUSE IT WAS A SAFETY ISSUE AND HIGHLY LIKELY A RECALL. I CALLED VW AND THEY STATED IT WAS NOT A RECALL BUT PART OF AN "EXTENDED WARRANTY", WHICH MY CAR DOES NOT QUALIFY FOR DUE TO THE MILES ON THE CAR. AFTER SOME RESEARCH, IT SEEMS THIS IS A VERY COMMON ISSUE WITH VW, AND THEY ARE ASKING FOR $160 TO SIMPLY DIAGNOSE THE PROBLEM, EVEN THOUGH IT IS CLEAR TO THEM WHAT THE ISSUE IS, AND NOT NEW TO THEM. IT IS NOT DUE TO THE AGE OR MILEAGE ON THE CAR, BUT A SAFETY MISS FROM THEIR END.
WHILE TURNING MY 2014 TIGUAN I NOTICED A CLICKING NOISE. ABOUT A DAY LATER MY AIRBAG ELECTRICAL ALERT APPEARED ON THE DASH AND ALL MY ELECTRICAL ON MY STEERING WHEEL BUTTONS STOPPED WORKING AS WELL AS MY HORN. I CHECKED ALL MY FUSES AND THEN SAW THAT IT MIGHT BE THE CLOCK SPRING DUE TO COMPLAINTS EXACTLY LIKE MINE. I SAW THAT TH…
Read full complaint
WHILE TURNING MY 2014 TIGUAN I NOTICED A CLICKING NOISE. ABOUT A DAY LATER MY AIRBAG ELECTRICAL ALERT APPEARED ON THE DASH AND ALL MY ELECTRICAL ON MY STEERING WHEEL BUTTONS STOPPED WORKING AS WELL AS MY HORN. I CHECKED ALL MY FUSES AND THEN SAW THAT IT MIGHT BE THE CLOCK SPRING DUE TO COMPLAINTS EXACTLY LIKE MINE. I SAW THAT THERE WAS A RECALL BUT MY CARS VIN NUMBER WAS NOT INCLUDED IN THE RECALL. THIS IS UNACCEPTABLE AND MANY OTHER 2014 TIGUAN VOLKSWAGEN ARE HAVING TO COVER THESE COST THEMSELVES DUE TO NOT BEING INCLUDED IN THE RECALL. VOLKSWAGEN NEEDS TO HAVE ITS RECALL EXPANDED BECAUSE THIS IS COMPLETELY UNACCEPTABLE TO MAKE CONSUMERS PAY OUT OF POCKET OVER A MANUFACTURED MALFUNCTION. I FEEL VERY UNSAFE DRIVING MY CAR NOW KNOWING MY AIRBAGS OR HORN WILL NOT WORK. PLEASE INVESTIGATE THIS SITUATION FURTHER AND NOT ALLOW VOLKSWAGEN TO GET AWAY WITH THIS.
THE EMERGENCY BRAKE WAS ACCIDENTALLY ENGAGED WHILE DRIVING ON THE HIGHWAY AT 65 MPH IN TRAFFIC, BRINGING THE CAR TO A FULL STOP. THE EMERGENCY BRAKE BUTTON IS LOCATED NEXT THE TO CUP HOLDER IN THE CENTER CONSOLE BETWEEN THE FRONT SEATS. THE DRIVER PUT A COFFEE MUG WITH AN OPEN HANDLE IN THE CUP HOLDER WHILE DRIVING. THE MUG…
Read full complaint
THE EMERGENCY BRAKE WAS ACCIDENTALLY ENGAGED WHILE DRIVING ON THE HIGHWAY AT 65 MPH IN TRAFFIC, BRINGING THE CAR TO A FULL STOP. THE EMERGENCY BRAKE BUTTON IS LOCATED NEXT THE TO CUP HOLDER IN THE CENTER CONSOLE BETWEEN THE FRONT SEATS. THE DRIVER PUT A COFFEE MUG WITH AN OPEN HANDLE IN THE CUP HOLDER WHILE DRIVING. THE MUG HANDLE PRESSED ON THE BUTTON WHEN IT WAS PLACED IN THE CUP HOLDER (WHILE TRAVELING AT 65 MPH) AND THE EMERGENCY BRAKE ENGAGED BRINGING THE VEHICLE TO A FULL STOP IN THE CENTER LANE OF INTERSTATE 91. THE ONLY REASON WE SURVIVED IS THAT THE PERSON BEHIND US WAS DRIVING A VOLVO AND WAS FOLLOWING AT SAFE DISTANCE. IF A TRACTOR TRAILER HAD BEEN BEHIND US WE WOULD BE DEAD.
SOMETHING WAS WRONG WITH THE TURBO I WAS DRIVING AND CAR JUST SHUT OFF I TOOK IT IN THEY SAID IT WAS THE TURBO NOT EVEN 2 YEARS GO BY AND I STARTED TO DRIVE AND CAR WAS JERKY AND IDLING FUNNY TOOK IT TO ADVANCED AUTO FOR A DIAGNOSTIC AND THEY SAID IT WAS THE TURBO. IM TAKING IT BACK TO THE DEALER TOMORRW WITH 3 MORE YEARS OF PA…
Read full complaint
SOMETHING WAS WRONG WITH THE TURBO I WAS DRIVING AND CAR JUST SHUT OFF I TOOK IT IN THEY SAID IT WAS THE TURBO NOT EVEN 2 YEARS GO BY AND I STARTED TO DRIVE AND CAR WAS JERKY AND IDLING FUNNY TOOK IT TO ADVANCED AUTO FOR A DIAGNOSTIC AND THEY SAID IT WAS THE TURBO. IM TAKING IT BACK TO THE DEALER TOMORRW WITH 3 MORE YEARS OF PAYMENTS LEFT
TL* THE CONTACT OWNS A 2014 VOLKSWAGEN TIGUAN. WHILE DRIVING APPROXIMATELY 65 MPH, THE MOON ROOF SUDDENLY EXPLODED AND GLASS FELL INTO THE VEHICLE. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO EMICH VOLKSWAGEN (1260 S. COLORADO BLVD, DENVER, CO) AND THE MOON ROOF WAS REPLACED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE…
Read full complaint
TL* THE CONTACT OWNS A 2014 VOLKSWAGEN TIGUAN. WHILE DRIVING APPROXIMATELY 65 MPH, THE MOON ROOF SUDDENLY EXPLODED AND GLASS FELL INTO THE VEHICLE. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO EMICH VOLKSWAGEN (1260 S. COLORADO BLVD, DENVER, CO) AND THE MOON ROOF WAS REPLACED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000. THE VIN WAS UNKNOWN.
ON DECEMBER 7TH, 2018 I WAS DRIVING ABOUT 65 MPH WHEN I HEARD AN EXPLOSION LOAD ENOUGH TO MAKE MY EARS RING. I LOOKED UP AND DISCOVERED THAT THE SUNROOF HAD EXPLODED AND FINE PARTICLES OF GLASS WERE RAINING DOWN ON ME THROUGH THE SUNROOF SUNSHADE. NOTHING HIT THE SUNROOF TO CAUSE THIS AS THERE WAS NO OTHER TRAFFIC, OVERPAS…
Read full complaint
ON DECEMBER 7TH, 2018 I WAS DRIVING ABOUT 65 MPH WHEN I HEARD AN EXPLOSION LOAD ENOUGH TO MAKE MY EARS RING. I LOOKED UP AND DISCOVERED THAT THE SUNROOF HAD EXPLODED AND FINE PARTICLES OF GLASS WERE RAINING DOWN ON ME THROUGH THE SUNROOF SUNSHADE. NOTHING HIT THE SUNROOF TO CAUSE THIS AS THERE WAS NO OTHER TRAFFIC, OVERPASSES OR CONSTRUCTION ON THE ROAD AT THE TIME. THE ATTACHED PHOTOS SHOW THAT THE SUNROOF EXPLODED OUT. THE VEHICLE WAS GOING STRAIGHT DOWN THE ROAD AT ABOUT 65 MPH. WE ARE PUTTING THE REPAIR THROUGH OUR INSURANCE WITH A $500 DEDUCTABLE AND AS YET WE DO NOT KNOW THE FINAL COST OF REPAIR AS IT IS STILL BEING WORKED ON. DAMAGE BEING REPAIRED IS THE SUNROOF GLASS, SUNSHADE AND THE ROOF HAD TO BE REPAINTED BECAUSE IT WAS SCRATCHED BY BROKEN GLASS.
AIR BAG RECALL - AIR BAG LIGHT CAME ON AND STEERING WHEEL CONTROLS DO NOT WORK INCLUDING HORN. TOOK CAR IN AND DEALER SHOWED THERE IS A RECALL FOR THIS SPECIFIC ISSUE/MODEL BUT NOT FOR MY SPECIFIC VIN
TAKATA RECALL. I WAS DRIVING MY CAR WHEN I HEARD SOME CLICKING NOISE COMING FROM THE STEERING WHEEL. SUDDENLY, THE AIRBAG LIGHT APPEARED ON MY DASHBOARD. THE HORN AND THE STEERING WHEEL CONTROLS, SUCH AS, VOLUME, STOPPED WORKING. I CALLED VOLKSWAGEN AND THEY SAID MY CAR WASN'T INCLUDED ON THE CLOCK SPRING RECALL EVEN THOUGH MY C…
Read full complaint
TAKATA RECALL. I WAS DRIVING MY CAR WHEN I HEARD SOME CLICKING NOISE COMING FROM THE STEERING WHEEL. SUDDENLY, THE AIRBAG LIGHT APPEARED ON MY DASHBOARD. THE HORN AND THE STEERING WHEEL CONTROLS, SUCH AS, VOLUME, STOPPED WORKING. I CALLED VOLKSWAGEN AND THEY SAID MY CAR WASN'T INCLUDED ON THE CLOCK SPRING RECALL EVEN THOUGH MY CAR DETAILS(YEAR, MODEL, PROBLEM) FIT. I HAVE HAD VOLKSWAGEN FOR EVER 9 YEARS AND I AM SO FRUSTRATED. MY CAR SHOULD HAVE BEEN INCLUDED ON THE RECALL. NO DOUBT.
Official recalls
318V329000 · Unknown Or Other
May 16, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2016 Eos, 2012 Passat, 2012-2016 CC, 2015-2016 e-Golf, 2011-2015 Touareg, 2012-2015 and 2017 Tiguan, and 2011-2016 Golf and 2011-2013 GTI vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
Consequence & remedy
Consequence: If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Remedy: Volkswagen will notify owners, and dealers will repair the vehicles to make them fully compliant or Volkswagen will repurchase them if necessary, free of charge. The recall began November 29, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298.
15V483000 · Air Bags:frontal
Aug 4, 2015
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2010-2014 Volkswagen CC, and Passat, 2010-2013 Eos, 2011-2014 Golf, GTI, Jetta, and Tiguan, and 2012-2014 Jetta Sportwagen vehicles. In the affected vehicles, debris may contaminate the air bag clock spring, a spiral wound, flat cable that keeps the air bag powered while the steering wheel is being turned. This contamination may tear the cable and result in a loss of electrical connection to the driver's frontal air bag.
Consequence & remedy
Consequence: A loss of electrical connection to the driver's frontal air bag will prevent the air bag from deploying in the event of a vehicle crash, increasing the risk of injury.
Remedy: Volkswagen will notify owners, and dealers will install a protective cover over the steering wheel clock spring if the air bag light is off. If the airbag light is on and the steering wheel clock spring requires replacement, dealers will install a new steering wheel clock spring. These repairs will be performed free of charge. The recall began on January 15, 2016. Owners may contact Volkswagen customer service at 1-800-822-8987.
14V441000 · Fuel System, Gasoline
Jul 21, 2014
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2014 Tiguan vehicles manufactured July 2007 to June 2014. When using winterized fuel, in certain conditions bubbles may form in the fuel system which could result in the vehicle stalling.
Consequence & remedy
Consequence: A vehicle stall increases the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will update the vehicle's software to increase the fuel pump pressure, free of charge. The recall is expected to begin August 19, 2014. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 24AV/2W.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA18003 · Air Bag Clockspring Failure
Opened Apr 18, 2018 · No close date supplied
Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Additional source detail variants (3)
Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Air Bags:frontal
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Air Bags
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
RQ17009 · Air Bag Clockspring Failure
Opened Nov 13, 2017 · Closed May 4, 2018
Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626
Additional source detail variants (2)
Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626
Air Bags:frontal
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626
PE15010 · Air Bag Clockspring Failure
Opened Mar 24, 2015 · Closed Sep 28, 2015
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Electrical System
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.
Additional source detail variants (3)
Air Bags:frontal
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.
Air Bags
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.
Electrical System
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.