IllustrationTIMING CHAIN TENSIONER FAILURE, CAUSING CATASTROPHIC ENGINE FAILURE AT 77,000 MILES. A NEWER MODEL OF TIMING BELT TENSIONER HAS BEEN USED SINCE DECEMBER 2011. EST. $5000 REPAIR BILL.
2010 Volkswagen Tiguan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2010 Volkswagen Tiguan do not stand out strongly from the model-year median of 124.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tiguan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
140–25K
1725–50K
1650–75K
2575–100K
20100–150K
1150K+
93 reports with mileage · 17 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 31 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports4 fire reports5 injury reports
What owners actually said
110 reportsTL* THE CONTACT OWNS A 2010 VOLKSWAGEN TIGUAN. WHILE DRIVING 30 MPH, THE VEHICLE STALLED. PRIOR TO THE VEHICLE STALLING, THERE WAS AN ABNORMAL VIBRATION WHILE DRIVING. THE CONTACT STATED THAT THE FAILURE OCCURRED WHILE DRIVING TO THE DEALER (MOLLE VOLKSWAGEN, 808 W 103RD ST, KANSAS CITY, MO 64114, (816) 941-9500) FOR DIAGNOSTIC …
Read full complaint
TL* THE CONTACT OWNS A 2010 VOLKSWAGEN TIGUAN. WHILE DRIVING 30 MPH, THE VEHICLE STALLED. PRIOR TO THE VEHICLE STALLING, THERE WAS AN ABNORMAL VIBRATION WHILE DRIVING. THE CONTACT STATED THAT THE FAILURE OCCURRED WHILE DRIVING TO THE DEALER (MOLLE VOLKSWAGEN, 808 W 103RD ST, KANSAS CITY, MO 64114, (816) 941-9500) FOR DIAGNOSTIC TESTING. THE CONTACT WAS INFORMED THAT THE TIMING BELT FRACTURED, WHICH CAUSED THE ENGINE AND TURBO CHARGER TO BE DESTROYED. THE CONTACT WAS INFORMED THAT THE ENGINE WAS IRREPARABLY DAMAGED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.
ANOTHER EXAMPLE OF THE WELL KNOWN, WELL DOCUMENTED, AND PRONE TO FAILURE TIMING CHAIN TENSIONER
I PURCHASED MY 2010 VW TIGUAN A YEAR AGO. AT 10K MILES AS REQUESTED I DID THE OIL CHANGE. A MONTH LATER OR SO OIL STARTED TO LEAK. ONE DAY I DROVE MY CAR TO A STORE AND LEFT THE ENGINE RUNNING BECAUSE I WAS ONLY THERE FOR A FEW MINS. CAME BACK AND MY ENGINE DIED. MY MECHANIC DIAGNOSED IT AND STATED IT WAS THE TIMING BELT THAT WE…
Read full complaint
I PURCHASED MY 2010 VW TIGUAN A YEAR AGO. AT 10K MILES AS REQUESTED I DID THE OIL CHANGE. A MONTH LATER OR SO OIL STARTED TO LEAK. ONE DAY I DROVE MY CAR TO A STORE AND LEFT THE ENGINE RUNNING BECAUSE I WAS ONLY THERE FOR A FEW MINS. CAME BACK AND MY ENGINE DIED. MY MECHANIC DIAGNOSED IT AND STATED IT WAS THE TIMING BELT THAT WENT. A LOT OF OF PEOPLE HAS BEEN COMPLAINING ABOUT OIL LEAK IN GENERAL WITH THIS VEHICLE. WISH I KNEW SOONER I WOULD HAVE NEVER BOUGHT THIS CAR.
TIMING BELT TENSIONER FAILURE WITHOUT NOTICE HAPPENED WHILE DRIVING FROM PARKING LOT CHAIN SKIPPED BECAUSE OF CHAIN TENSIONER FAILED CAUSING CHAIN TO SKIP A TOOTH MAKING THE TIMING ISSUES. TOWED TO MECHANIC
OUR TIGUAN STARTED SHAKING AND MAKING A HORRIBLE NOISE WHEN OUR 20 YEAR OLD DAUGHTER ATTEMPTED TO START DRIVING. SHE NOTICED THE CHECK ENGINE LIGHT ON AND THE CAR SUDDENLY STOPPED IN THE MIDDLE OF A CITY ROAD- PRESENTING A DANGER TO HER AS SHE COULD NOT MOVE THE CAR AND WAS NOT IN A SAFE NEIGHBORHOOD. SHE HAD TO WAIT FOR A TOW…
Read full complaint
OUR TIGUAN STARTED SHAKING AND MAKING A HORRIBLE NOISE WHEN OUR 20 YEAR OLD DAUGHTER ATTEMPTED TO START DRIVING. SHE NOTICED THE CHECK ENGINE LIGHT ON AND THE CAR SUDDENLY STOPPED IN THE MIDDLE OF A CITY ROAD- PRESENTING A DANGER TO HER AS SHE COULD NOT MOVE THE CAR AND WAS NOT IN A SAFE NEIGHBORHOOD. SHE HAD TO WAIT FOR A TOW TRUCK. AT THE REPAIR SHOP, IT WAS DETERMINED THAT THE TIMING CHAIN AND TENSIONER WERE BAD SO THEY WERE REPLACED. AFTER THIS REPAIR THE CAR STILL WOULD NOT RUN SO IT WAS TOWED TO A VOLKSWAGEN DEALERSHIP. THEY TORE DOWN THE ENGINE AND DETERMINED THAT IT NEEDED TO BE REPLACED. THE COST AT THE FIRST REPAIR SHOP WAS NEARLY $1600 AND THE COST TO REPLACE THE ENGINE IS NEARLY $9000.
CAR HAD 90,000 MILES AND STARTED HAVING TICKING ENGINE NOISES. VW DEALERSHIP SERVICE TECHNICIANS DIAGNOSED THE ISSUE AS A TURBO WASTE GATE NOISE ("NOTHING TO WORRY ABOUT AT THIS TIME"). TWO DAYS LATER THE ENGINE STARTS TO ACT LIKE IT'S MISFIRING ALMOST BUCKING THEN WITHIN MINUTES THE ENGINE GOES(WON'T START, TRYING TO START ENGI…
Read full complaint
CAR HAD 90,000 MILES AND STARTED HAVING TICKING ENGINE NOISES. VW DEALERSHIP SERVICE TECHNICIANS DIAGNOSED THE ISSUE AS A TURBO WASTE GATE NOISE ("NOTHING TO WORRY ABOUT AT THIS TIME"). TWO DAYS LATER THE ENGINE STARTS TO ACT LIKE IT'S MISFIRING ALMOST BUCKING THEN WITHIN MINUTES THE ENGINE GOES(WON'T START, TRYING TO START ENGINE JUST 'SPINS'). TOWED BACK TO SERVICE. INTERNAL INSPECTION FROM THEIR TECHNICIANS CONFIRMED BENT PARTS, ETC - $8,000 TO REPLACE ENGINE. MY RESEARCH INDICATES THE PROBLEM WAS WITH THE 2.0T TSI TIMING CHAIN TENSIONER FAILURE AS LISTED IN NHTSA SERVICE BULLETIN #TB-15-12-01 NHTSA ITEM NUMBER 10045560. CERTAINLY THE RESULTS INDICATE THAT WAS THE ACTUAL PROBLEM. ACCORDING TO THE TSB IT SEEMS LIKE THIS IS A KNOWN ISSUE ACROSS MANY VW MODELS/YEARS. WHY OWNERS ARE NOT NOTIFIED OF THIS POTENTIAL ISSUE AND GIVEN A CHANCE TO TAKE ACTION TO FIX IT BEFORE SOMETHING CATASTROPHIC HAPPENS IS DISHEARTENING.
TIMING CHAIN FAILED CAUSING COMPLETE ENGINE FAILURE. ENGINE STARTED LOSING POWER WHEN DRIVING HOME. TIGUAN WOULD NOT RESTART ONCE PARKED AND TURNED OFF.
THE TIMING CHAIN SKIPPED OR BROKE WHICH CAUSED A FAILURE. IT COULD NOT BE DETERMINED IF THE TIMING CHAIN WAS THE FIRST TO FAIL OR IF SOMETHING ELSE (TENSIONER FAILURE) CAUSED THE TIMING CHAIN TO BREAK AS A RESULT. THIS RESULTED IN THE VEHICLE BEING TOWED TO THE DEALER SINCE IT WAS NOT SAFE TO DRIVE. I WAS LUCKY THIS OCCURRED WHE…
Read full complaint
THE TIMING CHAIN SKIPPED OR BROKE WHICH CAUSED A FAILURE. IT COULD NOT BE DETERMINED IF THE TIMING CHAIN WAS THE FIRST TO FAIL OR IF SOMETHING ELSE (TENSIONER FAILURE) CAUSED THE TIMING CHAIN TO BREAK AS A RESULT. THIS RESULTED IN THE VEHICLE BEING TOWED TO THE DEALER SINCE IT WAS NOT SAFE TO DRIVE. I WAS LUCKY THIS OCCURRED WHEN THE VEHICLE WAS IDLING IN A TURN LANE. WHILE IDLING, THE VEHICLE STARTED SHAKING RATHER VIOLENTLY FORE/AFT. I IMMEDIATELY PULLED OF THE ROAD AND TURNED OFF THE VEHICLE.
FROM MECHANIC AT VW ROSEVILLE. CHAIN TENSIONER FAILED CAUSING SLACK IN TIMING CHAINS, WHICH CAUSED CHAINS TO JUMP TIME AND CAUSED UPPER CYLINDER HEAD DAMAGE. CAR HAS 87,702 MILES
Official recalls
214V441000 · Fuel System, Gasoline
Jul 21, 2014
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2014 Tiguan vehicles manufactured July 2007 to June 2014. When using winterized fuel, in certain conditions bubbles may form in the fuel system which could result in the vehicle stalling.
Consequence & remedy
Consequence: A vehicle stall increases the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will update the vehicle's software to increase the fuel pump pressure, free of charge. The recall is expected to begin August 19, 2014. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 24AV/2W.
13V569000 · Electrical System:wiring:fuses And Circuit Breakers; Exterior Lighting
Nov 22, 2013
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2011 Tiguan vehicles manufactured July 2007 through June 2011. Due to a problem with the fuse for the exterior lights, the holder for the fuse that controls the vehicle's exterior lights circuit may melt.
Consequence & remedy
Consequence: If the holder melts, there may be a partial loss of exterior lighting. Reduced vehicle illumination diminishes the vehicle's visibility, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the fuse, free of charge. Owners may contact Volkswagen at 1-800-893-5298. Volkswagen's recall number is 97Z9/2V.
Additional source detail variants (2)
Exterior Lighting
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2011 Tiguan vehicles manufactured July 2007 through June 2011. Due to a problem with the fuse for the exterior lights, the holder for the fuse that controls the vehicle's exterior lights circuit may melt.
Consequence: If the holder melts, there may be a partial loss of exterior lighting. Reduced vehicle illumination diminishes the vehicle's visibility, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the fuse, free of charge. Owners may contact Volkswagen at 1-800-893-5298. Volkswagen's recall number is 97Z9/2V.
Electrical System:wiring:fuses And Circuit Breakers
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2011 Tiguan vehicles manufactured July 2007 through June 2011. Due to a problem with the fuse for the exterior lights, the holder for the fuse that controls the vehicle's exterior lights circuit may melt.
Consequence: If the holder melts, there may be a partial loss of exterior lighting. Reduced vehicle illumination diminishes the vehicle's visibility, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the fuse, free of charge. Owners may contact Volkswagen at 1-800-893-5298. Volkswagen's recall number is 97Z9/2V.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA18003 · Air Bag Clockspring Failure
Opened Apr 18, 2018 · No close date supplied
Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Additional source detail variants (3)
Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Air Bags:frontal
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Air Bags
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
PE13036 · Partial Loss Of Exterior Lights
Opened Nov 4, 2013 · Closed Feb 28, 2014
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:fuses And Circuit Breakers; Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:back Up Lights:switch; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit; Exterior Lighting:headlights; Exterior Lighting:headlights:concealment Devices; Exterior Lighting:headlights:high/low Beam Dimmer Switch; Exterior Lighting:headlights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit; Exterior Lighting:turn Signal:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Additional source detail variants (21)
Electrical System
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Electrical System:wiring:fuses And Circuit Breakers
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:back Up Lights:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:back Up Lights
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:brake Lights:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:brake Lights
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:fog Lights:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:fog Lights
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:hazard Flashing Warning Lights:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:hazard Flashing Warning Lights:unit
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:hazard Flashing Warning Lights
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:headlights:concealment Devices
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:headlights:high/low Beam Dimmer Switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:headlights:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:headlights
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:tail Lights:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:tail Lights
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:turn Signal:flasher Unit
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:turn Signal:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:turn Signal
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.