IllustrationTHE F16 FUSE IN THE ENGINE BAY FUSE BOX IS COMPLETELY MELTED RESULTING IN FAILURE OF REVERSE LIGHTS, HEADLIGHTS, AND OTHER SAFETY EQUIPMENT. *TT
2009 Volkswagen Tiguan
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2009 Volkswagen Tiguan do not stand out strongly from the model-year median of 124.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Tiguan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
3225–50K
3050–75K
3975–100K
24100–150K
4150K+
149 reports with mileage · 18 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine. Review the 80 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports6 fire reports3 injury reports
What owners actually said
167 reportsMY WIFE'S VEHICLE WAS PARKED YES SHE SPILLED WATER ON THAT AREA, THANK GOD IT WAS PARKED. FROM WHAT I HAVE READ ABOUT THESE PARTICULAR E BRAKES THEY SEEM A VERY BAD DESIGN. I KNEW WHEN WE PURCHASED THE CAR IN 2009 JUST KNOWING AUTOS THIS WAS A TERRIBLE DESIGN AND FEATURE ESPECIALLY THE PLACEMENT. I READ ENOUGH ONLINE AFTER TODA…
Read full complaint
MY WIFE'S VEHICLE WAS PARKED YES SHE SPILLED WATER ON THAT AREA, THANK GOD IT WAS PARKED. FROM WHAT I HAVE READ ABOUT THESE PARTICULAR E BRAKES THEY SEEM A VERY BAD DESIGN. I KNEW WHEN WE PURCHASED THE CAR IN 2009 JUST KNOWING AUTOS THIS WAS A TERRIBLE DESIGN AND FEATURE ESPECIALLY THE PLACEMENT. I READ ENOUGH ONLINE AFTER TODAY THIS HAS TO BE A RECALL I HAVE HAD PREVIOUS RECALLS ON BOTH MY VW SEAT BELTS, MISC. SENSORS BOTH A COUPLE OF TIMES EACH YES VW TOOK CARE OF IT BUT THIS SITUATION IS FAR TOO DANGEROUS. *TR
TAKING OFF AFTER GETTING FUEL CAR START TO IDLE ROUGH WHEN SLOWING DOWN. DROVE DIRECTLY TO DEALERSHIP LESS THAN A MILE WHERE THE CAR BARELY MADE IT INTO THE SERVICE AREA AND CHECK ENGINE LIGHT CAME ON. TIMING CHAIN BROKE AND BLEW ENGINE. VEHICLE HAS BEEN PERFECTLY MAINTAINED BY DEALER. IT APPEARS TO BE A RECURRING PROBLEM BASED…
Read full complaint
TAKING OFF AFTER GETTING FUEL CAR START TO IDLE ROUGH WHEN SLOWING DOWN. DROVE DIRECTLY TO DEALERSHIP LESS THAN A MILE WHERE THE CAR BARELY MADE IT INTO THE SERVICE AREA AND CHECK ENGINE LIGHT CAME ON. TIMING CHAIN BROKE AND BLEW ENGINE. VEHICLE HAS BEEN PERFECTLY MAINTAINED BY DEALER. IT APPEARS TO BE A RECURRING PROBLEM BASED ON INTERNET RESEARCH. FORTUNATELY, I WAS NOT DRIVING ON THE INTERSTATE AS NORMAL AT THAT TIME OF DAY. *TR
A MAJOR SHORT OCCURRED IN THE FUSE BOX, WHICH CREATED ENOUGH HEAT TO CAUSE MELTING DAMAGE - REQUIRING REPLACEMENT AT GREAT COST TO ME. IT ALSO CAUSED MANY OF THE VEHICLE'S LIGHTING SYSTEMS TO BE INOPERATIVE. IN DISCUSSING THE ISSUE WITH OTHER OWNERS, IT IS CLEAR THAT THIS IS A COMMON, RECURRING ISSUE -- COMMON ENOUGH THAT VOLKSW…
Read full complaint
A MAJOR SHORT OCCURRED IN THE FUSE BOX, WHICH CREATED ENOUGH HEAT TO CAUSE MELTING DAMAGE - REQUIRING REPLACEMENT AT GREAT COST TO ME. IT ALSO CAUSED MANY OF THE VEHICLE'S LIGHTING SYSTEMS TO BE INOPERATIVE. IN DISCUSSING THE ISSUE WITH OTHER OWNERS, IT IS CLEAR THAT THIS IS A COMMON, RECURRING ISSUE -- COMMON ENOUGH THAT VOLKSWAGEN SERVICE DEPARTMENTS HAVE STOCKED UP ON REPLACEMENT FUSE BOXES SO THEY ARE WELL-STOCKED TO REPLACE THEM WHEN THEY COME IN. VOLKSWAGEN OF AMERICA, HOWEVER, REFUSES TO ACKNOWLEDGE OR CORRECT THE ISSUE. *TR UPDATED 9/19/13 *CN MOST OF THE LIGHTS ON THE PASSENGER SIDE WENT OUT, EXCEPT FOR THE FRONT DRIVING LIGHT. THE CONSUMER RECEIVED A WARNING ON THE DASH, THAT THE FOG LIGHT, HEADLIGHT, BRAKE LIGHT, TAIL LIGHT AND TURN SIGNALS WERE ALL DEAD.
A 30 AMP FUSE MELTED INSIDE THE FUSE BOX, CAUSING MY RIGHT SIDE HIGH AND LOW BEAM, FOG LIGHT, AND TURN SIGNAL, ALONG WITH THE RIGHT HALF OF ALL MY TAIL AND BRAKE LIGHTS TO STOP WORKING. *TR UPDATED 09/17/13*LJ THE CONSUMER STATED THE FUSE BOX WAS NOT REPAIRED. THE FUSE WAS REPLACED AND WAS BEING CAREFULLY MONITORED TO ENSURE…
Read full complaint
A 30 AMP FUSE MELTED INSIDE THE FUSE BOX, CAUSING MY RIGHT SIDE HIGH AND LOW BEAM, FOG LIGHT, AND TURN SIGNAL, ALONG WITH THE RIGHT HALF OF ALL MY TAIL AND BRAKE LIGHTS TO STOP WORKING. *TR UPDATED 09/17/13*LJ THE CONSUMER STATED THE FUSE BOX WAS NOT REPAIRED. THE FUSE WAS REPLACED AND WAS BEING CAREFULLY MONITORED TO ENSURE IT WAS NOT MELTING. *JS
I WAS TAKING MY VEHICLE IN FOR IT'S 40K SERVICE AND THE SERVICE TECH'S NOTICED SEVERAL TROUBLE CODES. ONE OF THESE CODES WAS AN OPEN-CIRCUIT FRONT HEADLIGHT WARNING. WHEN THEY CHECKED THE HEADLIGHT (WHICH I HAD RECENTLY REPLACED) OTHER LIGHTS STARTED SHORTING OUT. TURNS OUT THE MAIN FUSE FOR ALL LIGHTS HAD SHORTED AND THAT TH…
Read full complaint
I WAS TAKING MY VEHICLE IN FOR IT'S 40K SERVICE AND THE SERVICE TECH'S NOTICED SEVERAL TROUBLE CODES. ONE OF THESE CODES WAS AN OPEN-CIRCUIT FRONT HEADLIGHT WARNING. WHEN THEY CHECKED THE HEADLIGHT (WHICH I HAD RECENTLY REPLACED) OTHER LIGHTS STARTED SHORTING OUT. TURNS OUT THE MAIN FUSE FOR ALL LIGHTS HAD SHORTED AND THAT THE FUSE BOX ITSELF HAD STARTED TO MELT. THIS SHORTING AND MELTING WOULD HAVE CAUSED ALL THE LIGHTS ON THE CAR TO FAIL OR INCORRECTLY FUNCTION INCLUDING BRAKE LIGHTS. LUCKILY I DID NOT FIND THIS OUT WHEN SOMEONE RAN INTO ME, BUT INSTEAD LUCKILY DURING A SERVICE CHECK. RESEARCHING ON THE WEB SHOWS THAT THIS APPEARS NOT TO BE UNCOMMON. HERE ARE SOME EXAMPLE THREADS: HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?5927373-FUSE-BOX-LEFT-LOW-BEAM-HEADLIGHT HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?5618907-BLOWN-FUSE-CAUSING-RANDOM-EXT-LIGHTS-OUT-2009-TIGUAN HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?5891263-2009-TIGUAN-REPLACED-ENGINE-FUSE-BOX-NO-ESP-OR-WINDSHIELD-WIPERS HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?5940918-MELTING-FUSE-BOX-STRIKES-AGAIN!-%28THE-40K-CLUB..%29. *TR *UPDATED 09-18-13 *BF
OVER THE LAST THREE MONTHS: FIRST-CHECK ENGINE AND EPC LIGHTS ON AND ENGINE PERFORMANCE LOW. SECOND-FUEL RAIL/SYSTEM PRESSURE TOO LOW. THIRD-BATTERY LIGHT CAME ON AND VEHICLE DID NOT HAVE NORMAL POWER (BATTERY BRAND NEW OCT12). FOURTH-HEADLIGHTS WENT OUT MULTIPLE TIME OVER A TWO WEEK PERIOD (BULBS BRAND NEW APR13). CAR IS WITH …
Read full complaint
OVER THE LAST THREE MONTHS: FIRST-CHECK ENGINE AND EPC LIGHTS ON AND ENGINE PERFORMANCE LOW. SECOND-FUEL RAIL/SYSTEM PRESSURE TOO LOW. THIRD-BATTERY LIGHT CAME ON AND VEHICLE DID NOT HAVE NORMAL POWER (BATTERY BRAND NEW OCT12). FOURTH-HEADLIGHTS WENT OUT MULTIPLE TIME OVER A TWO WEEK PERIOD (BULBS BRAND NEW APR13). CAR IS WITH VW NOW FOR MELTED FUSE AND MELTED FUSE BOX. *TR UPDATED 09/17/13*LJ THE CONSUMER STATED THERE WERE MULTIPLE ELECTRICAL SYSTEM DTCS. THE FUSE BURNT AT THE CONNECTION AND BOTH RELAYS DUE TO AN OVERHEATED CONDITION. *JS
FIRST, THIS EXACT SAME SCENARIO ALSO HAPPENED IN OCTOBER 2010. THE FIRST INCIDENT OCCURRED WHEN I WAS DRIVING THE VEHICLE, AND NOW THIS TIME, WHEN MY HUSBAND WAS DRIVING THE VEHICLE. BOTH OF US, EACH HAVE 30+ YEARS OF DRIVING EXPERIENCE AND NEITHER OF US HAVE EVER BEEN INVOLVED IN A CRASH OR EXPERIENCED THIS TYPE OF LOSS OF CO…
Read full complaint
FIRST, THIS EXACT SAME SCENARIO ALSO HAPPENED IN OCTOBER 2010. THE FIRST INCIDENT OCCURRED WHEN I WAS DRIVING THE VEHICLE, AND NOW THIS TIME, WHEN MY HUSBAND WAS DRIVING THE VEHICLE. BOTH OF US, EACH HAVE 30+ YEARS OF DRIVING EXPERIENCE AND NEITHER OF US HAVE EVER BEEN INVOLVED IN A CRASH OR EXPERIENCED THIS TYPE OF LOSS OF CONTROL IN A VEHICLE, EVER. BOTH INCIDENTS OCCURRED WHILE TURNING A CORNER AT APPROXIMATELY 5 TO 15 MPH IN APPROXIMATELY 1- 3 INCHES OF NEW SNOW. THE CAR SLID WITH TOTAL LOSS OF STEERING AND BRAKES, SMASHING INTO THE CURB, BREAKING THE AXLE, CONTROL ARM, STEERING KNUCKLE, ETC... THERE WAS NO CONTROL WHATSOVER. THIS WAS NOT ICE. THIS HAS NEVER EVER HAPPENED BEFORE WITH ANY OTHER VEHICLE WE HAVE EVER DRIVEN. THE CAR DID NOT CORRECT ITSELF EVEN WHEN THE STEERING WHEEL WAS RELEASED. WE BELIEVE THERE IS A DEFICIENCY IN THE ESP MONITORING SYSTEM. THE ESP SYSTEM TOTALLY FAILED WHILE TURNING. THE ESP SENSORS DID NOT DETECT THE SITUATION AND DID NOT REACT AT ALL INDEPENDENT OF THE DRIVER. THE ESP SYSTEM DID NOT USE THE VEHICLE'S BRAKING SYSTEM TO "STEER" THE VEHICLE BACK ON TRACK. THE ESP DID NOT INITIATE ANY BRAKING INTERVENTION AT ALL. IT WAS LIKE ALL SYSTEMS JUST TOTALLY MALFUNCTIONED. HORRIBLE. SOMEONE IS GOING TO BE SERIOUSLY HURT. I AM THANKFUL ANOTHER VEHICLE OR PERSON WAS IN THE AREA. *TR
VEHICLE COMPLETELY STOPPED WHILE I WAS DRIVING ON THE FREEWAY. I WAS IN THE FAR LEFT LANE, AND THE ENGINE FAILED AND I WAS NOT ABLE TO MOVE TO THE RIGHT SHOULDER. I PUT MY HAZARDS ON AND CALLED FOR ASSISTANCE. WHILE ON THE PHONE IT WAS CLEAR THAT I WAS NOT IN A SAFE POSITION, SO MYSELF AND MY PASSENGER EXITED THE VEHICLE WHEN…
Read full complaint
VEHICLE COMPLETELY STOPPED WHILE I WAS DRIVING ON THE FREEWAY. I WAS IN THE FAR LEFT LANE, AND THE ENGINE FAILED AND I WAS NOT ABLE TO MOVE TO THE RIGHT SHOULDER. I PUT MY HAZARDS ON AND CALLED FOR ASSISTANCE. WHILE ON THE PHONE IT WAS CLEAR THAT I WAS NOT IN A SAFE POSITION, SO MYSELF AND MY PASSENGER EXITED THE VEHICLE WHEN THERE WAS A BREAK IN TRAFFIC. WE WERE ABLE TO GET ACROSS TO THE RIGHT SIDE OF THE ROAD, BEHIND A GUARDRAIL. WHILE ON THE PHONE WITH 911 SOMEONE SLAMMED INTO THE BACK OF MY CAR, CAUSING EXTENSIVE DAMAGE TO BOTH VEHICLES. LUCKILY NO ONE WAS INJURED, AND NO OTHER CARS WERE AFFECTED. BOTH VEHICLES WERE INOPERABLE AND HAD TO BE TOWED FROM THE SCENE. I WAS TOLD BY THE VOLKSWAGEN DEALERSHIP THAT AN ENGINE COIL BROKE OFF, AND BACKFED INTO THE HARNESS, CAUSING THE ENGINE TO FAIL. IN ADDITION, I HAD JUST BEEN TO THE DEALER FOR AN OIL CHANGE THAT MORNING, AND HAD DRIVEN 8 MILES WHEN THE INCIDENT HAPPENED. THE DEALER SAYS THERE IS NO RELATIONSHIP, AND THAT ENGINE PARTS FAILED. I AM CONCERNED THAT THERE IS A DEFECT WITH THIS PART, AS I HAVE VERY LOW MILEAGE ON THE VEHICLE. THIS INCIDENT PUT ME IN AN EXTREMELY UNSAFE SITUATION, AND I WANT TO REPORT THIS IN ORDER TO FIND OUT IF THIS IS A DEFECTIVE PIECE, SO THAT THIS DOES NOT HAPPEN TO ANYONE ELSE. *TR
APPARENTLY, THE TOP PORTION OF MY FUSE BOX MELTED WHEN THE TEMPERATURES IN CHICAGO REACHED 100 DEGREES. THE EFFECTED AREA CONTROLS THE LIGHTING ON THE RIGHT SIDE OF THE CAR, AND MAY ALSO IMPACT THE POWER STEERING AND TRACTION CONTROL. ALTHOUGH THE CAR IS JUST OUT OF WARRANTY, THIS IS A DANGEROUS SITUATION IF THE FUSE BOX IS NO…
Read full complaint
APPARENTLY, THE TOP PORTION OF MY FUSE BOX MELTED WHEN THE TEMPERATURES IN CHICAGO REACHED 100 DEGREES. THE EFFECTED AREA CONTROLS THE LIGHTING ON THE RIGHT SIDE OF THE CAR, AND MAY ALSO IMPACT THE POWER STEERING AND TRACTION CONTROL. ALTHOUGH THE CAR IS JUST OUT OF WARRANTY, THIS IS A DANGEROUS SITUATION IF THE FUSE BOX IS NOT DESIGNED TO WITHSTAND NORMAL HOT TEMPERATURES GIVEN THAT THE ENTIRE CAR IS IMPACTED BY THE FUSE BOX, LOSS OF ELECTRONIC CONTROLS IN A CAR WITH COMPUTER TECHNOLOGY THAT CONTROLS ALL OF THE FUNCTIONS OF THE CAR IS A DANGEROUS SITUATION. THANKS. *TR...UPDATED 09-18-13 *BF
Official recalls
314V441000 · Fuel System, Gasoline
Jul 21, 2014
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2014 Tiguan vehicles manufactured July 2007 to June 2014. When using winterized fuel, in certain conditions bubbles may form in the fuel system which could result in the vehicle stalling.
Consequence & remedy
Consequence: A vehicle stall increases the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will update the vehicle's software to increase the fuel pump pressure, free of charge. The recall is expected to begin August 19, 2014. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 24AV/2W.
13V569000 · Electrical System:wiring:fuses And Circuit Breakers; Exterior Lighting
Nov 22, 2013
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2011 Tiguan vehicles manufactured July 2007 through June 2011. Due to a problem with the fuse for the exterior lights, the holder for the fuse that controls the vehicle's exterior lights circuit may melt.
Consequence & remedy
Consequence: If the holder melts, there may be a partial loss of exterior lighting. Reduced vehicle illumination diminishes the vehicle's visibility, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the fuse, free of charge. Owners may contact Volkswagen at 1-800-893-5298. Volkswagen's recall number is 97Z9/2V.
Additional source detail variants (2)
Exterior Lighting
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2011 Tiguan vehicles manufactured July 2007 through June 2011. Due to a problem with the fuse for the exterior lights, the holder for the fuse that controls the vehicle's exterior lights circuit may melt.
Consequence: If the holder melts, there may be a partial loss of exterior lighting. Reduced vehicle illumination diminishes the vehicle's visibility, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the fuse, free of charge. Owners may contact Volkswagen at 1-800-893-5298. Volkswagen's recall number is 97Z9/2V.
Electrical System:wiring:fuses And Circuit Breakers
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2011 Tiguan vehicles manufactured July 2007 through June 2011. Due to a problem with the fuse for the exterior lights, the holder for the fuse that controls the vehicle's exterior lights circuit may melt.
Consequence: If the holder melts, there may be a partial loss of exterior lighting. Reduced vehicle illumination diminishes the vehicle's visibility, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the fuse, free of charge. Owners may contact Volkswagen at 1-800-893-5298. Volkswagen's recall number is 97Z9/2V.
08V235000 · Engine And Engine Cooling
May 28, 2008
VOLKSWAGEN IS RECALLING 4,079 MY 2008 PASSAT AND 2,500 MY 2009 TIGUAN PASSENGER VEHICLES EQUIPPED WITH 2.0T FSI ULEV II ENGINES. THESE VEHICLES HAVE AN ENGINE CONTROL MODULE (ECM) CONTAINING SOFTWARE THAT MAY NOT PROPERLY CONTROL ENGINE IDLE WITH THE AIR CONDITIONING TURNED ON. IN RARE CASES, THE ECM MAY UNEXPECTEDLY INCREASE ENGINE RPM.
Consequence & remedy
Consequence: AN ENGINE SURGE CAUSED BY AN UNEXPECTED INCREASE IN ENGINE RPM MAY SURPRISE THE VEHICLE OPERATOR AND CAN RESULT IN A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT AND UPDATE THE ECM SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON MAY 30, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-893-5298.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE13036 · Partial Loss Of Exterior Lights
Opened Nov 4, 2013 · Closed Feb 28, 2014
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:fuses And Circuit Breakers; Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:back Up Lights:switch; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit; Exterior Lighting:headlights; Exterior Lighting:headlights:concealment Devices; Exterior Lighting:headlights:high/low Beam Dimmer Switch; Exterior Lighting:headlights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit; Exterior Lighting:turn Signal:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Additional source detail variants (21)
Electrical System
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Electrical System:wiring:fuses And Circuit Breakers
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:back Up Lights:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:back Up Lights
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:brake Lights:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:brake Lights
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:fog Lights:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:fog Lights
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:hazard Flashing Warning Lights:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:hazard Flashing Warning Lights:unit
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:hazard Flashing Warning Lights
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:headlights:concealment Devices
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:headlights:high/low Beam Dimmer Switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:headlights:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:headlights
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:tail Lights:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:tail Lights
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:turn Signal:flasher Unit
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:turn Signal:switch
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting:turn Signal
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.
Exterior Lighting
Volkswagen Group of America (VW) is conducting a safety recall of approximately 62,155 model year (MY) 2009-2011 Volkswagen Tiguan vehicles to address a partial loss of the exterior lighting (see NHTSA recall 13V-569 for more information).These vehicles' exterior lighting system is protected by two separate fuses contained in a fuse box located in the engine compartment.According to VW, high thermal cycling and soft-coated fuse coating material used at the F16 (also referred to as SB16) location causes movement between the fuse blade and socket, resulting in abrasions on the fuse coating material.This increases resistance and results in overheating of the fuse and disruption of electrical current flow to roughly half of the vehicle's exterior lighting circuits. Examples include loss of one of each of the following: low beam headlight, high beam headlight, brake light, and turn signal light involving the front and rear of the vehicle.VW has stated that the subject F16 fuse in the Tiguan model was used in several other Volkswagen models.According to VW, the temperature of the vehicle's engine and the fuse box varies by vehicle model.ODI found that the complaint and warranty rates for the MY 2009-2010 Tiguan are more than four times greater than that of MY 2009-2010 Volkswagen Jetta sedans.ODI is aware of VW's plan to take a service action of some, but not all, of the other vehicle models.The action will cover MY 2009-2010 Jetta sedan and MY 2009 GTI vehicles.ODI will monitor complaints to NHTSA on all other Volkswagen models equipped with the same subject fuse and take further action if warranted.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10362206, 10471503, 10490408, 10501271, 10504495, 10508638, 10512642, 10520573, 10521147, 10522909, 10523748, 10526032, 10534679, 10538004, 10538410, 10543629, 10544805, 10545540, 10547334, 10547530, 10547775, 10549584, 10550140, 10550903, 10551486, 10551503, 10551538, 10551776, 10551816, 10551848, 10551853, 10552153, 10552322, 10552740, 10552811, 10552866, 10553122, 10553299, 10554352, 10554441, 10554443, 10554730, 10554890, 10555047, 10555080, 10555527, 10555540, 10555988, 10556475, 10558014, 10559441, 10559447, 10561642, 10562693.