2024 Volkswagen Taos

I am filing this complaint because Volkswagen is refusing to honor its factory powertrain warranty to cover a catastrophic internal engine failure on a vehicle with only 22,531 miles. The vehicle is well within its manufacturer's powertrain warranty limits. I have provided Volkswagen with two official receipts proving routine oil changes, GEICO insurance records proving the accident caused no front-end or engine damage, and an official email from Volkswagen stating there were no pre-existing issues with the vehicle. Furthermore, the engine issues align closely with known fuel system and engine defects currently being litigated in the class-action lawsuit Hardy v. Volkswagen. The vehicle suffered an acute mechanical/electronic failure the engine revved past 4,000 RPM, but the vehicle experienced severe sputtering, shaking, and minimal forward propulsion. The EPC (Electronic Power Control) warning light illuminated on the dashboard. Volkswagen dealership at middletown even states via email as attached can not determine the exact cause of the failure.

The vehicle suffered a recurring mechanical failure of the fuel injectors and a flooded EVAP charcoal canister, causing the engine to run lean (Fault P2177) and lose power. This defect creates an unreasonable safety risk as it can cause the engine to stall or lose motive power unexpectedly at highway speeds. Furthermore, the fuel system defect led to a flooded EVAP system, which poses a potential fire hazard and fuel vapor accumulation. Volkswagen Technical Assistance confirmed the mechanical failure of all four injectors . The defect was initially misdiagnosed as 'fuel contamination,' which delayed the critical safety repair for over 25 days and resulted in a total electrical system failure (battery death) while the vehicle was inoperable.

Brake System Failures (Multiple Occurrences): The vehicle has experienced repeated brake-related failures requiring multiple repairs. Brakes are a critical safety system, and repeated failures pose a serious risk to occupant and public safety. Despite repairs, the brake issues have reoccurred. 2.Fuel System Failures (Two Occurrences): The fuel system has failed on multiple occasions, requiring repeated service visits. Fuel system defects affect drivability, reliability, and safety, including the risk of stalling or fuel-related hazards. 3.Head Gasket Failure and Repeated Repairs: The vehicle required a head gasket repair along with a timing belt replacement, followed by additional head gasket-related repairs days later. A head gasket failure on a nearly new vehicle is a catastrophic engine defect and significantly diminishes the vehicle’s reliability, longevity, and resale value.

I have had issue with the propulsion system. Sometime the vehicle "jumps" when just touching the gas petal, other times it takes a long time to get up to speed. I typically see slower power generation when going around corners, power seems to drop. Additionally every once in awhile I'll be driving and the emergency alert system comes on unexpectedly and unnecessarily, which in itself causes panic. The lane departure on this vehicle ping pongs you back and forth, it doesn't perform well at all and needs to be addressed. Aloy of software updates are needed. The fuel gauge (miles til empty) and the speedometer appear to read incorrectly. VW knows about this problem as I informed them on my 30,000 mile check up, but they don't have a fix for it yet. All these things can be safety hazards and again needs to be addressed.

Malfunction: Acceleration failure from a full stop. on [XXX], with approx 300 miles on the vehicle, I needed to pull onto the two lanes going my direction on right. On my left was a wide curve blinded by large full trees on [XXX] in Delaware with traffic running 55-65ish. It was a doable look-twice then hustle situation. Waited for traffic to clear, nothing in sight, pulled out fuller throttle but it crawled...immediately I went full throttle with no effect as it continued to steadily crawl for several long seconds until turbo activated. This was way outside of normal-clearly I had been placed in a dangerous situation but thankfully no traffic approached before full speed was obtained. There have been no warning lamps or messages. As for possible symptoms prior to the incident, I had complained to the dealer, day after purchase about the amount of lagging and lunging I was beginning to take notice of, as well as when accelerating from lower gears, it wanted to pull back - like a tap on the brakes. Two workers test drove, expressed experiencing this and determined issue was attributed to being in 'ECO mode' and recommended/showed how to change to regular 'driving mode', which helped but not significantly. Just as easily the children could have been riding with me in the car seats as they often do. This incident was disturbing and I take it seriously. On [XXX], this repeated itself to a lesser yet unacceptable degree taking a right from a standstill on [XXX] in Danville PA. These I reported to the dealership on 7/19 and reported 2nd incident on 7/29 at first scheduled service visit. The incidents have not reproduced themselves so not confirmed by the dealer...no fault codes were identified in ECM, no further diagnostics were performed. My printer doesn't scan-please send me the address so I can mail you a copy of the first service visit 7/30 to be attached to this report. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2024 S AWD VW Taos has a serious lag when I need to speed up fast. The car does not go at all if I try to accelerate quickly and has almost caused many accidents. I have needed to quickly get out of the way of other drivers who were not paying attention and tried to accelerate quickly only to have my car not go anywhere. I am afraid to let my children drive this vehicle or even ride with me due to the fact that i cant count on it to work when i need to drive defensively.