2022 Volkswagen Taos

Went into Volkswagen dealership as my low coolant light came on. I called early June, they couldn't get me in until June 17th, when I was then told my warranty was barely a week expired. My head gasket needs replaced and Volkswagen is refusing to cover this, knowing full well this has been an issue on thousands of these vehicles.

About a month ago I saw paint flaking off from about the front windscreen where the sunroof meets the body about quarter sized. The paint appeared not to hold to the body of the vehicle even though the primer was applied. A month later it's about the size of 2 credit cards and definitely the primer on the vehicle is not holding the paint and is a manufacturer defect. I reported this to the dealer but they said it's out of warrenty. Other owners with this vehicle reported the same flaking from the same area on online forums and on the news. I would like the manufacturer to fix this before rusting happens on the body of the car and more serious issues occur. It is definitely a defect with the primer or paint, I never got hit by any object while driving nor saw any paint damage prior to this when I purchased the car.

Light came on for leak detection pump failure upon starting car. Drove to dealer directly immediately upon looking up indicator light. Felt as if care was misfiring Deal found fuel pump in need of recall repair. Dealer also found coolant leak and recommended engine teardown. Diagnostic found block deck warp over permissible range 0.05m. Requiring full engine replacement. No previous indication of issue, leaking, or over heating. No cause of warp known or can be given. 60K miles on car.

Car was purchased in August 2021. In August 2022 it was taken in for service at Onion Creek VW in Austin for multiple occurrences of alerts for low coolant level. The dealership topped off the coolant reservoir and said there are no visible leaks and refused to further diagnose. Then in June 2025 with 22,000+ miles the same occurred again. Took it to Vanguard VW in Austin and they diagnosed a bad head gasket.

I own a 2022 Volkswagen Taos with about 45,000 miles. I have had to replace the rear brake pads and rotors THREE TIMES already within this mileage, which is extremely unusual. During the third replacement, a local independent shop discovered that the rear brake caliper was leaking brake fluid, so the caliper also had to be replaced along with the pads and rotors once again. The service shop disposed of the old parts but I have service records. A leaking rear brake caliper can reduce braking performance and increase the risk of brake failure, putting my safety and the safety of others at risk. This issue was confirmed by the independent shop during the third replacement. The first two replacements were done at an authorized dealer, but the caliper defect was not detected then. There were no warning lights or messages. The only sign was the unusually frequent need to replace the rear brakes three times in a short period, which may have been caused by an early defect in the caliper. I strongly request that NHTSA investigate this issue and consider whether a recall is needed due to the repeated rear brake failure in this vehicle.

Rear brake pads and rotors failed prematurely at 17,000 miles and again at 34,981 miles. Both times the brakes wore down to metal-on-metal with no dashboard warning light. The front brakes remain nearly new, suggesting an issue with brake balance or failure of the front braking system. First repair was performed under warranty, but second failure occurred outside VW's 24k rear brake warranty limit. Check engine light also returned within 24 hours of software update. This poses a major safety risk due to sudden brake failure and lack of warning.

When taking the vehicle in for service at Safford Brown Volkswagen to replace a faulty EVAP module, we were notified that the cylinder head gasket was leaking and would need to be replaced. This leaking coolant and crack in the head gasket can lead to early engine failure. This seems to be a consistent issue due to a faulty part specific to this vehicle year and make. Volkswagen has released a TSB on the issue but is not offering any recalls or free service to fix the faulty part they produced. The TSB was released on 17th of August 2023.

This is my second report as I have 2 VW Taos 2022 model vehicles. This vehicle also needed rear brake pads replaced after only 11233 miles. This is a low mileage vehicle and was outside of the extended warranty VW had offered and hence did not cover the repair. These faulty brake pads also damaged the rotors and they needed replacement too. This is a safety and a quality issue. VW needs to recall these faulty brake pads and cover previous repair costs. I did call VW customer care on 6/2/2025, they documented my concern but said they would not cover any repair costs beyond their original extended warranty but did document my situation with early brake pad wear on 2 VW Taos 2022 model vehicles.

Excessive break pad wear. Vehicle is 3 years old with only 18847 miles. Rear break pads have now been replaced twice (@11000 and @18847 miles). VW did have an extended warranty but that did not apply owing to the low mileage and lack of need to visit dealership for repair. Excessive break wear is a quality and safety concern. Problems with Taos break wear according to dealer is a known issue. They also stated that VW just released (May 2025) new brake pads to finally correct the issue. VW should recall the defective Taos 2022 brake pads.