2022 Volkswagen Taos

On July 30, 2026, while driving my 2022 Volkswagen Taos out of my apartment parking lot, the EPC and check engine lights illuminated. The vehicle shook, lagged, stalled, and could not accelerate normally. I parked and turned it off. An authorized Volkswagen dealer diagnosed a faulty spark plug. On August 12, the same failure recurred. The EPC and check engine lights illuminated, the vehicle shook, and it again lost acceleration. The dealer attributed the misfire to poor fuel caused by Arizona monsoon and dust-storm conditions and added a fuel additive. However, the only major dust storm around these dates occurred on August 19, after the first two incidents. No fuel-test results were provided to support this explanation. On August 20, the failure occurred a third time while I was driving on a major road. The vehicle shook and experienced a severe loss of propulsion and acceleration. The check engine light remained on after the engine was turned off. I had to restart the vehicle three times before I could move it into a parking lot. I was less than one mile from entering a highway, and the sudden loss of acceleration in traffic created a serious collision risk. The vehicle was towed to the dealer. On August 21, the dealer again attributed the misfire to poor fuel. It added fuel-system cleaner, filled the tank with 91-octane fuel, and test-drove the vehicle, but the misfire remained. The technician then reported that three spark plugs were fouled and required replacement. The same dangerous loss-of-power condition occurred three times within 22 days despite two prior repair attempts. The cause of the repeated misfires and fouled plugs remains unidentified. The vehicle is at the Volkswagen dealership and is available for inspection. There was no crash, fire, or injury.

On 7/9/2026, my 2022 VW Taos was brought to the dealer for being severely underpowered, check engine lights on, and a strong raw fuel smell inside the vehicle. On 7/10/2026, the dealer stated the vehicle was ready, claiming they replaced a turbo charge pipe O-ring. The service advisor verbally stated the vehicle had been successfully test-driven for 5 miles on streets and the highway. However, official paperwork only stated "cleared faults verified no leaks in system, vehicle is now operating as designed." Immediately upon driving home on the highway, as the vehicle reached 70–75 mph under load, a loud whistling noise and a sudden, dangerous loss of propulsion occurred simultaneously. The vehicle was returned to the dealer on 7/10/2026. On 7/13/2026, the vehicle was picked up after a second repair where the dealer admitted the plastic charge pipe (05E-145-673-Q) was actually fractured and had completely blown off the turbocharger during my highway drive, generating fault code P227900 (Intake Air System Leak). Upon reviewing the paperwork from both visits, I discovered the odometer had only increased by exactly 1 mile during the first service visit. The dealer completely failed to road-test the vehicle under actual highway boost loads before certifying it as safe, which directly caused a catastrophic structural engine failure and an emergency safety hazard at 75 mph.

The systems failing are electrical, engine, and fuel/propulsion systems. VW TAOS 2022 purchased Sept. 2023. Two weeks after purchasing the vehicle, I'm driving down the street and the vehicle began to lose power and start slowing down. It eventually cut off. About a week later, I experienced the same issue. I called the dealer and they had me to bring my car in. I was told that they couldn't find the problem, but that the car was misfiring. They "repaired" and returned it to me. As I drove on local streets and the interstate, I have problems with acceleration. The car does not pick up speed like it should and lags behind and then suddenly jerks forward (even after battery rest times during a stop). It rides a bit rough. Occasionally, my dashboard blacks out while I'm driving. My auto-start doesn't always work, even after the fob batteries have been changed. My gas seems to disappear and I find myself gassing up more often than I should be. I would contact the dealership, they'd coordinate service around my scheduled service dates and claim that they could never find or duplicate the problems that I'm having. The problems continue. My engine light came on while I was driving and stayed on. I was told to bring in my car. The dealership kept it from July-Sept 2025, replacing parts and then returned it to me. Two days later the engine light came back on and I had to return to the dealer again for service. After leaving a parking lot (Jun 2026), two blocks down the street the TAOS began to lose power, the engine light is flashing and the EPC code (engine control malfunction) light lit up. I called VW and they dispatched a tow. My TAOS was towed to Checkered Flag VW. My safety (and others) is at risk because the power loss just happens without warning. If a driver is not paying attention, they could run into the back of me or hit me on the side during a lane change due to the slow movement.

The vehicle has intermittent hesitation/delayed acceleration from a stop and during low-speed stop-and-go driving. At times, engine RPM increases before the vehicle responds or accelerates normally. This creates a safety concern when entering traffic, turning, merging, or accelerating from a stopped position because the vehicle does not always respond predictably to throttle input. The concern was reported to a Volkswagen dealer in writing during a prior repair process and was later formally documented on a repair order as hesitation on acceleration. The vehicle has prior Volkswagen repair history involving a coolant warning/low coolant concern, head gasket repair, and later camshaft seal/belt cover repair. After the most recent repair, the delayed acceleration/hesitation concern remained unresolved. The vehicle is currently under review with Volkswagen Customer Care, but the safety-related drivability concern has not yet been fully resolved. Supporting documents include the 2025 written report of jerking from a stop, the 2026 repair order documenting hesitation on acceleration, and post-repair emails showing the issue remained unresolved. After I notified the dealer in writing that the hesitation/delayed acceleration concern remained after the most recent repair, I did not receive a documented response or resolution, and the concern remains unresolved with Volkswagen Customer Care.

Vehicle: 2022 Volkswagen Taos Mileage at Incident: 61,170 On April 21, 2026, while driving shortly after leaving my home, the EPC (Electronic Power Control) warning light suddenly illuminated and the engine warning light began flashing rapidly. The vehicle immediately began jerking, hesitating, and losing power. It started slowing down unexpectedly while in motion. This created a serious safety hazard. I was forced to reduce speed and maneuver to the side of the road to avoid being rear-ended. The sudden loss of power in traffic placed me and other drivers at risk of a collision. After turning the vehicle off and restarting it, both warning lights disappeared. Notably, on April 3, 2026 (60,428 miles), I had an oil change performed. On April 6, the engine light came on and remained illuminated until April 18, then turned off without repair. Three days later, the EPC failure occurred. The dealership was unable to reproduce the issue but charged $190 for diagnostics and stated the problem was a cracked N80 valve line (small leak), quoting approximately $700 for repair. I am aware of reports involving similar issues affecting thousands of vehicles of this model year. Sudden loss of engine power while driving is a clear safety concern, especially when warning lights appear and disappear intermittently. The vehicle remains available for inspection.

Vin # [XXX] Evap system hose-canister parts regulator valve. Check engine light stays on and this started in June 2025. Gorman McCracken Volkswagen Longview Texas diagnosed. February 1,2025 Low engine coolant light continues to come on. We have had to add coolant for the last two weeks. About 3 gallons used. The back up camera and navigation screen goes black often and has to be reset. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Since the purchase of my 2022 VW Taos in 2022, there has been a repeated issue of the check engine light coming on at random times. Each time it has happened the code indicates a problem with the fuel evap system. The issue has been fixed multiple times by replacing parts. There has been no fix for the issue and it still persists. Problems with the fuel evap system puts the drivers and passengers at risk. Being unable to determine an issue with the car and the safety of operating a motor vehicle due to continued negligence by the manufacturer is the opposite of a safe motor vehicle. Additionally, since buying the vehicle there have been repeated issues with the communications module. The module had to be replaced just days after purchasing it. Now, it is not working once again and if there was an emergency, the technology presented when purchasing the car, SOS, information, crash detection, location, etc, is not available to help me. VW presents these as safety features then does nothing to fix their equipment issues that ultimately render these options and functions useless.