2022 Volkswagen Taos

- The head gasket failed twice in less than one year on my 2022 Volkswagen Taos. The vehicle also experienced a fuel pump failure, rear brake pad wear down to metal-on-metal, and the underbody panel detached while driving due to being improperly secured after a dealership repair. Yes, the components may be available for inspection upon request through the dealership. - The second head gasket failure resulted in coolant loss, which can lead to engine overheating and potential failure while driving. The underbody panel detached while I was on the freeway, posing a serious safety hazard to me and other drivers. The brake system issues, including vibration and scraping noises, raise concern about brake reliability and stopping ability. - Yes, all issues were confirmed and addressed by authorized Volkswagen dealerships: DeMontrond Volkswagen (Conroe, TX) and Momentum Volkswagen (Houston, TX). - The vehicle has been inspected and repaired multiple times by Volkswagen-certified service technicians. No inspections by police or insurance have taken place. - No warning lamps appeared before the head gasket failures. The brake issues were first noticed as vibrations in the brake pedal after a service visit, followed by scraping noises, which were later diagnosed as metal-to-metal contact. The underbody panel incident occurred suddenly after leaving the dealership.

Car dies/stalls while in drive when adaptive is engaged. Entertainment / navigation system has quit working despite multiple times I’ve reset. Acceleration is dangerous at times and accelerates too quickly. Also seems to be sluggish due to fuel injector issues requiring me to press gas pedal harder to maintain speed. Windows don’t always respond to button and seem to stall. Check engine light keeps coming on despite being cleared . I only have 28,000 miles.

The contact owns a 2022 Volkswagen Taos. The contact stated that while driving approximately 25 MPH, the check engine and ECM warning lights illuminated, and the vehicle decelerated and would only operate in LIMP Mode. During the failure, the vehicle was shaking and vibrating abnormally, and it was difficult for the driver to control the steering. The vehicle was driven directly to the local dealer, who diagnosed the vehicle with a cylinder #3 misfire. The cause of the misfire was not determined. The manufacturer was not yet contacted. The failure mileage was 38,000.

The contact owns a 2022 Volkswagen Taos. The contact stated that the vehicle failed to exceed above 10 MPH, with the check engine and the EPC warning lights illuminated. The vehicle was taken to a certified mechanic who diagnosed the vehicle and determined that the engine had seized and needed to be replaced. The mechanic linked the failure to failure to NHTSA Campaign Numbers: 23V214000 (Fuel System, Gasoline), 21V651000 (Fuel System, Gasoline), and Technical Service Bulletin 1523/01. The mechanic referred the contact to the dealer. The dealer was contacted and confirmed that the VIN was not included in the recalls. The vehicle was not repaired. The manufacturer was informed of the failure. The manufacturer confirmed that the VIN was not covered under recall and that the vehicle had exceeded the mileage for coverage. The failure mileage was 67,168.

Purchased 2022 VW Taos SEL new from dealer. Vehicle began using coolent triggering the coolent warning light. Engine light activated and dealer states coolent is leaking from the rear of the head gasket and is affecting the air flow system. Safety risk of engine over heating causing damage or failure. Research shows this is a common problem and a faulty head gasket was used in production. Vehicle is no longer in warranty and no recalls have been issued.