2022 Volkswagen Taos

Head gasket failure is a known issue for this model. Some owners report failure at 12k miles in for quite some time. I am now faced with this known issue VW has had time to remedy. If it is a known failure why not take care of it especially if it spans across 3 models 2022 - 2024. I should not have to absorb this type of repair 4 years 57k miles in on my vehicle. Of course, everything pops up right as warranties expire. I was refused even dealer “good faith” for being 7,000 miles over the threshold VW powertrain warranty of 4 years 50k miles. Now to find $4638.83 for parts plus whatever labor will be.

The vehicle has intermittent hesitation/delayed acceleration from a stop and during low-speed stop-and-go driving. At times, engine RPM increases before the vehicle responds or accelerates normally. This creates a safety concern when entering traffic, turning, merging, or accelerating from a stopped position because the vehicle does not always respond predictably to throttle input. The concern was reported to a Volkswagen dealer in writing during a prior repair process and was later formally documented on a repair order as hesitation on acceleration. The vehicle has prior Volkswagen repair history involving a coolant warning/low coolant concern, head gasket repair, and later camshaft seal/belt cover repair. After the most recent repair, the delayed acceleration/hesitation concern remained unresolved. The vehicle is currently under review with Volkswagen Customer Care, but the safety-related drivability concern has not yet been fully resolved. Supporting documents include the 2025 written report of jerking from a stop, the 2026 repair order documenting hesitation on acceleration, and post-repair emails showing the issue remained unresolved. After I notified the dealer in writing that the hesitation/delayed acceleration concern remained after the most recent repair, I did not receive a documented response or resolution, and the concern remains unresolved with Volkswagen Customer Care.

This vehicle has ongoing drivability issues that have not been resolved despite multiple repair attempts involving engine-related components and repairs. The issue began in November 2024 while the vehicle was under warranty with coolant and engine warnings. At that time, I reported coolant loss, warning messages, hesitation during acceleration, and abnormal vehicle vibration. I was initially told no issue existed. Shortly after warranty expiration, the vehicle required a major head gasket repair in 2025 after continuing to exhibit the same coolant-related issues. In 2026, the vehicle required an additional engine-related repair involving a camshaft seal in the same area of the engine that had previously been dismantled and rebuilt. Despite these repairs, the same drivability symptoms remain. The vehicle intermittently hesitates during acceleration, particularly from a stop or during merging conditions, where engine RPM increases significantly before the vehicle responds. The vehicle also exhibits significant steering wheel and seat vibration at highway speeds and during extended driving. These conditions create a potential safety concern because the vehicle does not consistently respond as expected during acceleration and becomes unstable and uncomfortable to operate at highway speeds. The hesitation creates concern when entering traffic, crossing intersections, or attempting to accelerate in situations requiring predictable vehicle response. The issue has been repeatedly presented to the dealership and repair attempts have been performed, including major engine work, but the condition remains unresolved. The repairs were treated as separate isolated issues rather than a continuation of the original condition first reported under warranty. The vehicle has been out of service for approximately 43 days across these repairs. No loaner vehicle was provided during those periods. The vehicle remains in its current condition with unresolved issues.

The contact owns a 2022 Volkswagen Taos. The contact stated that while driving 35 MPH, the low coolant warning light illuminated. An independent mechanic was contacted. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the head gasket needed to be replaced. The vehicle was not repaired. The contact stated that the failure had reoccurred approximately ten times. The contact related the failure to Technical Service Bulletin: (15-23-01) Head Gasket Leakage; however, the VIN was not included in the bulletin. The manufacturer was not notified of the failure. The failure mileage was 72,500.

Vin # [XXX] Evap system hose-canister parts regulator valve. Check engine light stays on and this started in June 2025. Gorman McCracken Volkswagen Longview Texas diagnosed. February 1,2025 Low engine coolant light continues to come on. We have had to add coolant for the last two weeks. About 3 gallons used. The back up camera and navigation screen goes black often and has to be reset. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I purchased a 2022 Volkswagen Taos from TOM‘s VW, Union, New Jersey on Sep 23, 2023. At the time of purchase, the vehicle had approximately 19000 miles. Unfortunately, I experienced the engine light illuminating after starting the car at the end of October 2024. I brought this issue to Tom's VW's attention in Nov, 2024 - 1) I made an appointment with Tom's VW, and the first time I went to the dealership was on Nov 2, 2024. Since then, we have come to Tom's VW dealership to fix the same issue at least 6 times, the latest one was on May 15, 2025. 2) The car has been kept in the dealership's shop since it was drop off at the dealership on May 15, 2025. It's still kept in the dealership's shop now. 3) Several times we were told the problem was resolved and we could pick up the car, but the problem would usually reappear the next day. We immediately called Tom's VW to inform them and ask if it was safe to drive the car before it was delivered to Tom's VW again, since the problem involved the engine. However, we were told there was no safety issue. This concerns the engine, and the problem remains unresolved after a year, with no explanation for the cause of the engine light illuminating. We've been repeatedly told there's no safety issue and we can continue driving. Given this situation, I strongly suspect a serious engine-related quality problem with the car, and that the dealer's advice—that we can continue driving—poses a safety hazard.

I am reporting a repeated safety-related defect involving exhaust intrusion into the cabin of my 2022 Volkswagen Taos. The vehicle experienced loss of power, coolant loss, and engine warning indicators, and was serviced twice by Volkswagen Southtowne in Sandy, Utah. First Incident – Vehicle Returned as “Safe to Drive” During the first repair visit, the dealer diagnosed issues involving the manifold/exhaust area, head gasket, coolant system, and catalytic converter. After keeping the vehicle for an extended period, the dealership informed me the vehicle was “safe to drive,” although the repair was not fully completed. I relied on this representation. After the vehicle was returned to me, I began experiencing significant physical symptoms only while driving the vehicle, including nausea, dizziness, and vomiting. These symptoms occurred repeatedly during operation and would subside after leaving the vehicle. At the time, I did not understand that these symptoms were caused by exhaust entering the cabin. Second Incident – Defect Confirmed and Additional Repairs Performed Weeks later, the symptoms persisted and I returned the vehicle to the same dealership. At this second visit, the dealer reported coolant leakage and additional gasket failures. They removed the cylinder head, replaced gaskets, and performed additional exhaust-related repairs. I was provided a loaner vehicle during this extended repair. After this second repair, the symptoms while driving stopped. Safety Concern Based on the timing of symptoms, the repair records, and the resolution following the second repair, I believe that exhaust gases were entering the cabin of the vehicle during normal operation for an extended period. This created a significant safety hazard. I was repeatedly assured the vehicle was “safe to drive” when it was not. I unknowingly operated the vehicle while being exposed to exhaust fumes for several months. The condition caused physical illness, impaired my ability.