2008 Volkswagen R32

MY 2008 VOLKSWAGEN R32 EXHIBITS INTERMITTENT FUEL DELIVERY ISSUES. AT TIMES, USUALLY FOLLOWING A REFUELING, THE CAR SEEMS TO "HICCUP" AND BRIEFLY LOSE POWER, AS IF THE FUEL SUPPLY WAS CUT OFF MOMENTARILY. THIS CAUSES A SEVERE JERKING IN THE CAR, AND CAN HAPPEN AT LOW SPEEDS AFTER ROUNDING A CORNER OR AT CONSTANT FREEWAY SPEEDS. OTHER SYMPTOMS INCLUDE STUMBLING AND STALLING WHILE AT IDLE IN TRAFFIC; WITH DIFFICULTY IN RESTARTING AS IF THE VEHICLE IS STARVED FOR FUEL. THE VEHICLE HAS ALSO FAILED TO START UPON FIRST USE OF THE DAY, CRANKING OVER BUT NOT SEEMING TO RECEIVE FUEL, EVEN THOUGH THE TANK MAY BE FULL. OTHER ISSUES INCLUDE DIFFICULTY WITH REFUELING WHEN TANK IS NEAR EMPTY. OFTEN, THE GAS STATION FUEL DISPENSERS WILL SHUT OFF 10 OR MORE TIMES WHEN BEGINNING TO FILL UP THE TANK, AS IF AIR WERE BLOCKING THE FILLER NECK AND CAUSING THE AUTOMATIC PUMP SHUTOFF TO KICK IN. IT CAN TAKE MANY TRIES BEFORE ONE IS FINALLY ABLE TO COMPLETELY FUEL THE VEHICLE, WHICH ONLY HOLDS 14.5 GALLONS. ON TWO OCCASIONS, THE AUTOMATIC FUEL CUTOFF IN THE GAS STATION DISPENSER DID NOT DETECT A FULL TANK AND THE FUEL ACTUALLY OVERFLOWED OUT OF FILLER NECK AND ONTO THE GROUND UNTIL I MANUALLY SHUT OF THE FUEL DISPENSERS. IT SEEMS THE EVAPORATIVE PURGE CANISTER OR LINES ARE EASILY BLOCKED IN THIS DESIGN, AND I QUESTION WHETHER THERE ARE OTHER VAPOR LOCK OR VACUUM ISSUES WITH THE FUEL SYSTEM DESIGN THAT ARE INVOLVED. I AM TAKING MY VEHICLE TO THE DEALER FOR SERVICE ON 11/26 FOR AN ATTEMPT AT DIAGNOSIS. MANY OTHER OWNERS OF THIS VEHICLE IN THE ONLINE FORUM "VWVORTEX.COM" HAVE ALSO REPORTED SIMILAR PROBLEMS WITH THIS VEHICLE, AND ARE HAVING LITTLE SUCCESS IN REPAIR THROUGH VWOA. I CONSIDER THIS TO BE A POTENTIALLY DANGEROUS SITUATION. *TR

THE CAR WAS EXPERIENCING "HICCUPS" WHILE ACCELERATING AND WOULD EVENTUALLY SMELL AND SEE GAS ESCAPING OUT FROM UNDERNEATH THE PASSENGER SIDE REAR TIRE. WAS TAKEN TO THE DEALER SHIP 3 TIMES BEFORE FOR THIS AND NOW I AM TOLD IT IS A FAULTY GAS TANK THAT WAS PRODUCED. I HAVE BEEN CURRENTLY WAITING ABOUT A MONTH TO HAVE THE TANK REPAIRED. ALL I HAVE BEEN TOLD ON THIS SUBJECT IS "WE WILL CONTACT YOU AT THE END OF THE BUSINESS DAY TOMORROW". ITS ALWAYS TOMORROW. THE DEALER HAS OFFERED ME A COUPLE OF THINGS TO KEEP MY MINE AS EASY WHILE I WAIT BUT I HONESTLY THINK THAT WAITING A MONTH FOR A BRAND NEW CAR TO GET FIXED IS RIDICULOUS. *TR

CAR STARTED TO BOG-OUT OF POWER ON TUESDAY OCTOBER 7TH IN THE AFTERNOON. FUEL STARTED TO LEAK FROM THE RIGHT REAR WHEEL AREA ON WEDNESDAY OCTOBER 8TH IN THE AFTERNOON. THIS HAPPENS TO BE A COMMON ISSUE WITH THIS MAKE/MODEL/TRIM OF THE PRODCUCT LINE. A PROMINENT AUTOMOBILE FORUM WEBSITE (VWVORTEX.COM) HAS ALLOCATED A ROOM FOR THIS SPECIFIC MODEL/TRIM. THE FOLLOWING IS A LINK TO THE TOPIC DEDICATED TO THIS COMMON ISSUE: HTTP://FORUMS.VWVORTEX.COM/ZEROTHREAD?ID=3759501&PAGE=15 I AM SCARED TO DRIVE THIS CAR AGAIN. *TR

FUEL SYSTEM ON CAR BROKE WHILE DRIVING 75MPH ON THE FREEWAY CAUSING THE CAR TO JERK AND DROP IN SPEED IN THE MIDDLE OF TRAFFIC. FUEL SMELL OUT OF A/C VENTS. VW HAS ACKNOWLEDGED THE PROBLEM AND HAS SAID THEY'VE HAD THIS ON MANY CARS OF THE SAME MODEL. VW IS REPLACING THE ENTIRE FUEL SYSTEM RESULTING THE CAR TO BE IN THE SERVICE SHOP FOR 30 PLUS DAYS. *TR

FIRST MINOR INCIDENTS: MY WIFE AND I HAVE BEEN EXPERIENCING INTERMITTENT HICCUPS IN POWER FOR A FEW WEEKS. NO CELS OR INDICATION OF ANYTHING WRONG OTHERWISE. FIRST SERIOUS INCIDENT: AT HIGHWAY SPEED (70MPH) 30 MINUTES INTO A COMMUTE, THE CAR LOSES POWER AND THROWS THE DRIVER FORWARD IN THE SEAT. WAS ABLE TO FINISH THE REMAINDER OF COMMUTE BARELY LIMPING ALONG WITH ERRATIC THROTTLE RESPONSE, STALLING, AND STUTTERING. UPON ARRIVAL, NOTICE SMELL OF FUEL AND SEE FUEL PUDDLE BEHIND RIGHT REAR WHEEL. VW ROADSIDE ASSISTANCE WOULD NOT RESPOND DUE TO REPORT OF FUEL LEAK. TOLD TO CALL FIRE DEPT -- FIRE DEPT RESPONDED. AAA TOWED TO DEALER. AFTER 19 DAYS AT THE DEALER, THE CAR'S ENTIRE FUEL TANK WAS REPLACED. A DEFECT IN THE EVAPORATIVE EMISSIONS SYSTEM WAS REPORTED AS THE CAUSE. WE WERE ASSURED THE VEHICLE WAS SAFE AND THE NEW SYSTEM WAS REDESIGNED. SECOND MAJOR INCIDENT: REPEAT OF FIRST MAJOR INCIDENT ABOVE ONLY DAYS LATER. CAR CURRENTLY IN SHOP. EVIDENCE OF WIDESPREAD ISSUE BEING DISCUSSED AT VWVORTEX.COM AMONG NUMEROUS REPORTS OF SAME ISSUE BUT NO RESOLUTION OR OFFICIAL ACKNOWLEDGMENT OF THIS ISSUE FROM VWOFA AS OF YET. THIS IS EXTREMELY UNSAFE CONDITION FOR A CAR THAT IS BRAND NEW. *TR

USUALLY DURING HOT WEATHER CONDITIONS, THE FAILURE IS PRESENT. THE FAILURE - CAR HESITATES UNDER ACCELERATION ALMOST AS IF THE FUEL IS BEING CUTOFF. OTHER TIMES IT STALLS DURING IDLE AT STOP LIGHT. OTHER TIMES THE CAR WILL TAKE TWO OR THREE TRIES TO RESTART. WHEN PARKED AFTER A DRIVE THE VEHICLE LEAKS FUEL BEHIND THE PASSENGER SIDE REAR WHEEL. OCCURS RANDOMLY AND THE DEALER CANNOT REPRODUCE THE ISSUE. PARTS REPLACED - PURGE VALVE TO FIX THE FUEL LEAK AND HESITATION. THE CAR DOES NOT LEAK FUEL ANYMORE, HOWEVER THE HESITATION ISSUE IS STILL PRESENT. *TR

THE ENGINE POWER OF MY 2008 VW R32 CONTINUED TO CUT OUT PERIODICALLY FOR A FEW WEEKS, THE CEL NEVER ONCE CAME ON. THIS PROBLEM PERSISTED REGARDLESS OF THE WEATHER OR VEHICLE SPEED. ONE DAY WHILE MY WIFE WAS DRIVING, SHE WAS STOPPED AT A TRAFFIC SIGNAL AND THE CAR DIED, SHE RESTARTED IT AND NOTICED A FUEL ODOR. SINCE SHE WAS NEAR MY WORK (APPROX THREE MILES) SHE RESTARTED THE CAR ONCE SHE GOT THERE AND TURNED OFF THE CAR, FUEL STARTED LEAKING BEHIND THE RIGHT REAR WHEEL. *TR

MY BRAND-NEW 08 VW MAKES SEVERE HICCUPS ON MODERATE ACCELERATION WHEN THE OUTSIDE TEMPERATURE IS ABOVE ABOUT 95 F. (SUDDEN LOSS OF POWER AND COME BACK UP IN SHORT PERIOD OF TIME.)HAVE STARTING PROBLEM AFTER THE SYMPTOM, SOMETIMES SMELL OF GAS FROM OUTSIDE REAR. THE PROBLEM DOES NOT LEAVE ANY ERROR CODES ON COMPUTER, THEREFORE DEALERS CANNOT FIX OR REPLICATE PROBLEM. (USUALLY TAKES ABOUT 30 MIN CONSTANT DRIVE IN THE HOT WEATHER TO HAVE THE SYMPTOM.) HAD NUMEROUS VISIT TO A VW DEALER BUT NO FIX. ALWAYS END UP WITH MY CLAIM COMMENTS; "CUSTOMER STATES..." AND DEALER STATES, "CAN NOT REPLICATE THE PROBLEM". I KEEP HAVING THE SAME PROBLEM SINCE LAST YEAR, ONLY WHEN OUTSIDE IS REALLY HOT (FOR CALIFORNIA), ABOVE 95F. TOTAL OF 6-7 DAYS I'VE HAD THE SAME PROBLEM SINCE LAST YEAR. *TR