2016 Volkswagen Passat

The clock spring has failed in my car unexpectedly and rapidly, exposing me as a teenage driver in college to complete unsafely while driving my car, as the airbags and brake assist that my parents wanted in my car to keep me safe do not function. There have been recalls on volkswagens for the clock spring before, and there should be one now. The car is 7 years old and has a little less than 73,000 miles on it - the clock spring should not be failing.

Within 55,000 miles I needed to replace both of my front wheel bearings, for an approximate cost of $1,000. I have done some research and talked to many people and found out that wheel bearings should not go bad on a car with 60K miles. It would be understandable if one went bad due to a defect but both going bad has me quite confused and angry at the cost of these repairs. I wrote VW about this problem and was told that since the vehicle was no longer under warranty there was nothing they could do. That would be an acceptable answer if wheel bearing failure was to be expected as a normal wear and tear item at 60K miles. But the fact that this is quite early for them to fail, I feel that VW might have issues with the wheel bearings and that others have experienced the same thing with the Passat. I thought I would reach out in case others have reached out as well in order to get VW to address this problem. Thank you.

I started my vehicle and the airbag light was on. Also the adaptive cruise control warning light was on and none of my steering wheel controls work. Not even the horn works. This is a huge safety issue that Volkswagen is aware of based on a past recall. There are no open recalls for my vehicle for this problem but there should be! I cannot even drive my car now because It’s not safe with no working horn or airbag! I researched online what the problem could be and several Volkswagen owners have the EXACT SAME issue. Apparently it’s the clock spring? I am not aware of Volkswagen offering to fix this major issue for their customers.

On October 3rd, 2021 the minder to change oil service came on and a wrench in the display. As the mechanic had set the incorrect timing interval between services, I went into the menu to attempt to reset the service minder but never got that far as the airbag light came on and all buttons on the steering wheel stopped responding. My husband in the passenger seat instructed me to restart the car and this did not reset any warnings but also showed the ACC: Error, in the display alternating with the Airbag: Error. The dealership wants $ 165 just to plug in the diagnostic reader and won't apply it to a repair and says this car has no open recalls which I am aware of. However, there was an airbag recall including the 2015 year build Passat, but the dealership wants payment to diagnose. When the car is stirred to make a 90 degree left hand turn I can hear a coil in the steering wheel cracking at times. Frequently, the airbag light for the passenger scale stays on but may go out if someone goes to sit in the passenger seat. All seat belts are unlocked at the top, and the receivers for the buckles look fine and nothing is stuck in them. I have not yet lifted the seats to inspect the harnesses but I doubt I will be able to fix anything as I cannot reset the codes anyhow. Not being able to change the information on the instrument panel from useless Error Messages is distracting. Tell VW to read an airbag fault light for free! This is a safety concern for every passenger and should not be taken advantage of to make a service department money. How can I find out if this model was added to the air bag recalls or is in the process of being added? Honda has a lifetime warranty service for free on all safety restraints. I am surprised that VW does not make safety their highest priority. I'm not certain the Forward Collision Warning is affected but the lanes blink Orange showing me the ACC is not responsive and it's close enough in function to mention just in case it may not work.

The automatic emergency braking has applied three times while driving this vehicle. Once on a freeway onramp curve in traffic with following car, twice driving on different paved city streets. All three times were daylight and no other vehicle or obstruction in front of my car. This to me is asking for a trailing vehicle to rear end collide, or maybe even worse yet what would happen if this were to happen on rain slick or snow covered road? I did take it to an authorized VW dealer after the second brake application and of course they could not replicate the brake issue. I did not have it checked the first time since I falsely assumed I had done something I had not thought about. Now, after the third time, I am sure that it is the car and not something I have done. I have not been back to VW shop yet after this third time. My wife is scared to drive the car now and I am concerned about myself. I do not think the VW dealer went any further than a test drive and maybe a computer check after the second braking I encountered. There have been no warning lights or messages on my car dash before or after all three times. The dash light warning to "BRAKE!" did light up as the brakes were applying on their own. As a small aside comment, I was a professional highway truck driver with over a million miles driving and achieved a 28 year safe driving record. That has let me make this statement with a lot of "boots on the ground" certainty.

I started my car and it showed up with “airbag error” I then turned off my car and started it again and something along the lines of “front lane assist error” showed up, there was also a clicking noise from my steering wheel anytime I would turn the wheel, the car also was “breakchecking” me (aggressively breaking when barely any pressure applied) when I was trying to drive home and the digital speedometer is no longer showing up on my dash board. I was only able to get a picture of the “airbag error” message

After several attempts to identify the cause of my vehicle's excessive oil consumption, white smoke out of tail pipe and illumination of my low oil and EPC lights, the VW dealership has diagnosed my vehicle with a failed air oil seperator/PCV stuck in the open position. During the times the EPC light illuminated, I had a loss of engine power which potentially could have led to engine shut off and caused an accident. I often drive on the highway with construction with my children so sudden engine shut off is a safety risk. On 12/18/20, I took my vehicle to the VW dealership for excessive oil consumption, low oil and EPC lights and white smoke out of tailpipe. The technician diagnosed and repaired a blown upper timing gasket. The problems persisted and I dropped off the vehicle at the dealership on 01/19/21. Dealership advised computer update was needed and was performed. Problems persisted and vehicle was dropped off on 01/30/21 and 03/15/21 for oil consumption tests and advised results were in 'acceptable' range for VW. After researching work history on my vehicle, I remembered I took it in while under warranty (under 36k miles) for fuel smell in cabin when using the heater. VW technicians checked fuel lines, injectors and fuel tank but found nothing wrong. After researching this topic on various VW blogs, I found the fuel smell in cabin was caused by failed PCV system in numerous cases. I believe my air oil seperator/PCV was faulty and began to fail while my vehicle was still under warranty. Further internet research revealed websites and blogs with numerous mentions of failed VW/ Audi PCV systems. I believe my vehicle may have been affected by a faulty part installed and has been overlooked by VW.