2016 Volkswagen Passat

For about 4 months I had a smell that my son and I could not locate. Upon further investigation it was discovered that the fuel pump which is located under the back seat had hair line cracks that caused the fuel to spit out and damage the seal around it thereby damaging the underside of the back seat to infiltrate the the foam with the gasoline. We tried to see if there were any recalls but found none. I think that my back seat has only been used about 3 time since I purchased it new. I wanted to draw to your attention that this could have been a safety issue and possible fire issue if someone were to smoke and lite a cigarette. My son has hopefully repaired the cracks this past week and hopefully it will hold. I am [XXX] and cannot afford a new fuel pump. Just wanted you to be aware that there could possibly be a safety problem with fuel pumps for this model. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

EPC light came on within a week of buying car from dealer,took it to have it looked at and plugs and coil packs were shot,got that fixed and drove home and EPC came back on and was running bad,shaking and everything,made me lose speed drastically in heavy traffic and almost caused accident,now car has been sitting in driveway for the last few months because I’m afraid to drive it and I can’t really get rid of it because I owe way to much on it!

The contact owns a 2016 Volkswagen Passat. The contact stated that while parked, the horn, cruise control, and the radio became inoperable. The message “air bag not available”, check clockspring, and check oil messages were displayed. The vehicle had not been diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 91,986.

Began smelling fuel. Made an appointment for a week out. They found that the fuel pump cover under the seat had been pushing on the top of the fuel pump. This means that the pressure of the seat has been pushing on the top of the fuel pump. The fuel pump was cracked and a stream of fuel was spraying on the bottom side of the plastic fuel pump cover. fuel could be smelled in the car and outside. it would drip on the ground after about 2 minutes of running. This seems like a poor design that has potential for bigger issues because of the fuel hazard.

VW repaired clock spring (a recall) after airbag warning, steering wheel controls stopped working. VW returned the vehicle to me, the customer, with the clock spring supposedly repaired yet steering wheel buttons, including cruise control and others, remained broken and unusable. VW wanted several hundred dollars to fix this, despite the issue obviously being directly related to the clock spring as all buttons were in working order prior to the clock spring issue. (dates below May not be entirely accurate as this happened several years ago and still has not been repaired, however I was unaware I could file a report here)

I am the original owner of a 2016 Volkswagen Passat. My front windshield has been delaminating around the edges. It began as only a small pop, but nothing loud to investigate. But today the separation of the epoxy from the windshield is visually evident. The popping sound happens daily. I have taken good care of my Volkswagen Passat with only a little over 39000 miles. My concern is will my window fly off its base one day while I am driving? Obviously this was not a concern while my vehicle was under warranty. But today I am concerned. I recently took my car to Rudolph Volkswagen for service. They recommended brakes and plugs replacement but did not look into the windshield issue.