IllustrationHEATER NOT BLOWING HOT AIR. THIS SEEMS TO BE A MAJOR PROBLEM AND VW EVEN RECOGNIZES THE ISSUE. THIS SHOULD BE A RECALL WARRANTY ITEM. HERE IS A LINK PROVIDED TO WHAT I HAVE FOUND. HTTPS://F01.JUSTANSWER.COM/KYLESKRAUTCAR/1C235176-E1B5-4388-847A-18433040B6B5_V801601.PDF
2014 Volkswagen Passat
Owner reports · Recalls · Investigations
More warning signs than most Passat years
Owner complaints for the 2014 Volkswagen Passat are substantially higher than the model-year median of 110.
About this comparison →How this year compares
Owner complaints by model year
Compare all Passat years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
740–25K
5625–50K
6150–75K
3675–100K
29100–150K
3150K+
259 reports with mileage · 335 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 354 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 77 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 74 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
19 crash reports3 fire reports11 injury reports
Unknown Or Other complaints
59 reportsTAKATA RECALL THERE WAS A RECKLESS DRIVER WHO WAS NOT OBEYING THE TRAFFIC RULES. I WAS ON THE HIGHWAY (NJ TURNPIKE 78 AROUND BAYONNE). AND THEN THIS GUY WAS ON THE RIGHT ENTERING TO THE HIGHWAY, BUT HE SWITCHED TO THE LEFT LANE WITHOUT WAITING FOR THE SOLID LINE TO BECOME DOTTED LINE. AND THEN RIGHT AWAY, HE CUT IN FRONT OF ME,…
Read full complaint
TAKATA RECALL THERE WAS A RECKLESS DRIVER WHO WAS NOT OBEYING THE TRAFFIC RULES. I WAS ON THE HIGHWAY (NJ TURNPIKE 78 AROUND BAYONNE). AND THEN THIS GUY WAS ON THE RIGHT ENTERING TO THE HIGHWAY, BUT HE SWITCHED TO THE LEFT LANE WITHOUT WAITING FOR THE SOLID LINE TO BECOME DOTTED LINE. AND THEN RIGHT AWAY, HE CUT IN FRONT OF ME, TO AGAIN SWITCH TO THE MOST LEFT LANE. I WAS ALMOST GOING TO HIT HIM BECAUSE OF THIS RECKLESS MOVE. HE DIDN'T SIGNAL AND WAIT FOR ME (OR SOMEONE ELSE) TO GIVE HIM THE WAY. HE JUST CUT IN FRONT ME. I HORNED HIM AND THEN HE SHOWED ME HIS MIDDLE FINGER. IT WAS ABOUT TO BE AN ACCIDENT IF I HADN'T HIT THE BRAKES RIGHT AWAY. HE ENTERED THE HIGHWAY WITHOUT OBEYING THE RULES AND CUT THE ROAD FROM ALL THE WAY FROM RIGHT TO THE LEFT LANE. AND HE IS RUDE AND OFFENSIVE. HE HAS A BLACK LINCOLN, WITH NY PLATE. PLATE NUMBER IS T657065C. THIS HAPPENED IN THE MORNING AROUND 8:46. IT IS A RUSH OUR, HE INCREASES THE RISK OF ACCIDENTS AND PUTS PEOPLE IN DANGER. I HOPE HE WILL BE PUNISHED FOR THIS.
TOOK MY CAR IN BECAUSE I HAD NO HORN, NO AIR BAGS, AND THE STEERING WHEEL SOUNDED 'FUNNY'. I HAD A LITTLE OVER 39,000 WHEN THIS ALL HAPPENED. I WAS TOLD IT WAS THE CLOCK SPRING. APPARENTLY THERE WAS A RECALL FOR THIS FOR THE 2014 PASSATS, BUT MY VIN NUMBER WAS NOT INCLUDED. THEY CAN'T TELL ME WHY. CLEARLY, MY CAR WAS INCLUD…
Read full complaint
TOOK MY CAR IN BECAUSE I HAD NO HORN, NO AIR BAGS, AND THE STEERING WHEEL SOUNDED 'FUNNY'. I HAD A LITTLE OVER 39,000 WHEN THIS ALL HAPPENED. I WAS TOLD IT WAS THE CLOCK SPRING. APPARENTLY THERE WAS A RECALL FOR THIS FOR THE 2014 PASSATS, BUT MY VIN NUMBER WAS NOT INCLUDED. THEY CAN'T TELL ME WHY. CLEARLY, MY CAR WAS INCLUDED IN THE DEFECTIVE VEHICLES!! IT IS A VERY EXPENSIVE PART TO REPLACE.
I OWN A 2014 VW PASSAT. ALL OF THE FUNCTIONS ON MY THE STEERING WHEEL WHEN DEAD AND THE AIRBAG LIGHT CAME ON. THE VEHICLE WAS STATIONARY WHEN THE ISSUE WAS FIRST DISCOVERED. I HAD JUST STARTED THE CAR. AFTER BRINGING THE CAR TO A DEALERSHIP TO HAVE IT DIAGNOSED, IT WAS DIAGNOSED AS A FAULTY CLOCK SPRING. THE REPLACEMENT COST I…
Read full complaint
I OWN A 2014 VW PASSAT. ALL OF THE FUNCTIONS ON MY THE STEERING WHEEL WHEN DEAD AND THE AIRBAG LIGHT CAME ON. THE VEHICLE WAS STATIONARY WHEN THE ISSUE WAS FIRST DISCOVERED. I HAD JUST STARTED THE CAR. AFTER BRINGING THE CAR TO A DEALERSHIP TO HAVE IT DIAGNOSED, IT WAS DIAGNOSED AS A FAULTY CLOCK SPRING. THE REPLACEMENT COST IS $637 AND THE CLOSEST DEALER IS 45 MILES AWAY. THIS IS A SAFETY HAZARD AS THE AIR BAG, HORN AND OTHER STEERING WHEEL FEATURES DO NOT WORK. AFTER RESEARCHING I'VE COME TO REALIZE THERE ARE THOUSANDS OF VEHICLES EFFECTED BY THIS AND NO RECALL.
TAKATA RECALL I HAVE BEEN RECEIVING RECALL NOTICES FOR MY 2014 VOLKSWAGEN PASSAT FOR THE PAST YEAR YEAR. I MADE AN APPOINTMENT WITH MY VOLKSWAGEN DEALER IN MARCH OF 2018, BROUGHT THE CAR IN SO THEY COULD FIX THE RECALL. AFTER TAKING THE DAY OFF, AND WAITING FOR THE CAR, I WAS TOLD THAT THE DEALERSHIP DID NOT HAVE THE CORREC…
Read full complaint
TAKATA RECALL I HAVE BEEN RECEIVING RECALL NOTICES FOR MY 2014 VOLKSWAGEN PASSAT FOR THE PAST YEAR YEAR. I MADE AN APPOINTMENT WITH MY VOLKSWAGEN DEALER IN MARCH OF 2018, BROUGHT THE CAR IN SO THEY COULD FIX THE RECALL. AFTER TAKING THE DAY OFF, AND WAITING FOR THE CAR, I WAS TOLD THAT THE DEALERSHIP DID NOT HAVE THE CORRECT PART TO FIX IT, AND THEY COULD NOT COMPLETE THE REPAIR. I WAS TOLD I WOULD BE CONTACTED AS SOON AS THEY RECEIVED THE PART. LAST MONTH, I CONTACTED THE DEALERSHIP TO INQUIRE ABOUT THE RECALL AND WAS TOLD THEY STILL DID NOT HAVE THE PART. I CONTACTED VOLKSWAGEN, THEY PUT ME IN TOUCH WITH ANOTHER DEALER, I CONTACTED THAT DEALER. THEY ALSO DID NOT HAVE THE PART. AGAIN I WAS TOLD, WE WILL CONTACT YOU WHEN WE HAVE THE PART. THAT WAS OVER A MONTH AGO. YESTERDAY, I RECEIVED ANOTHER RECALL NOTICE. HOW DO GET MY RECALL FIXED IF THE DEALERSHIPS DO NOT HAVE THE PARTS? DO I HAVE TO WAIT UNTIL THE CAR IMPLODES? PLEASE HELP!
ON MAY 31, 2018, I BOUGHT A VOLKSWAGEN PASSAT E.S. 2014 AT INWOOD MOTORS, INC. DOS ID # 447825, LOCATED AT 153 SHERIDAN BLVD, INWOOD NY 11096. THE VEHICLE WAS FINANCED THRU THE LENDER NEW CITY FUNDING, LOCATED AT 146 S LIBERTY DR. # 11B, STONY POINT, NY 10980 FOR THE AMOUNT OF $8,000.00 DOLLARS. AFTER DRIVING THE VEHICLE OVER 40…
Read full complaint
ON MAY 31, 2018, I BOUGHT A VOLKSWAGEN PASSAT E.S. 2014 AT INWOOD MOTORS, INC. DOS ID # 447825, LOCATED AT 153 SHERIDAN BLVD, INWOOD NY 11096. THE VEHICLE WAS FINANCED THRU THE LENDER NEW CITY FUNDING, LOCATED AT 146 S LIBERTY DR. # 11B, STONY POINT, NY 10980 FOR THE AMOUNT OF $8,000.00 DOLLARS. AFTER DRIVING THE VEHICLE OVER 40 MILES PER HOURS, IT WARNED ME OF SOME MECHANICAL PROBLEM THRU THE VEHICLE DASHBOARD (YELLOW LIGHT ECP), FRONT BRAKE BAND WORN, ABNORMAL SOUND IN FRONT OF VEHICLE WHEN TURNING TO RIGHT AND TO LEFT. I IMMEDIATELY INFORMED THE PERSON IN CHARGE OF THE DEALERSHIP ABOUT THIS ISSUES NAMED KASI, HE TOLD ME NOT TO WORRY ABOUT, THAT I HAD 1 MONTH GUARANTEE THAT HE WOULD TAKE CARE ABOUT IT. I HAVE LEFT THE VEHICLE SEVERAL TIMES AT THE DEALERSHIP TO MAKE THE REPAIRS, BUT HE NEVER DID IT. THE DEALERSHIP WORK IN CONJUNCTION WITH THE MECHANIC SHOP TIKAL'S AUTO REPAIR, LOCATED AT 153C SHERIDAN BLVD, INWOOD NY 11096, (516) 371-9582. THE FIRST TIME I LEFT THE VEHICLE WAS ON JUNE 13, 2018, AND TWO DAYS LATER, HE NOTIFIED ME ABOUT THE THROTTLE BODY HAD PROBLEM, AND IT WAS NECESSARY TO ORDER A NEW ONE TO REPLACE IT. HE TOLD ME TO BRING THE CAR WITH ME, HE WOULD CALL ME WHEN HE HAD THE PART IN HIS POSSESSION. AFTER THAT, THE VEHICLE CONTINUED WITH THE SAME PROBLEM, NEVER REPAIR THE BRAKES, NOR THE SOUND THAT I INFORMED HIM ABOUT BEFORE. HE TOLD ME TO LEAVE THE VEHICLE AGAIN, AFTER THREE DAYS LATER, HE SAID IT WAS THE SOLENOID, AND IT WAS NECESSARY TO ORDER A NEW ONE TO REPLACE IT THE OLD ONE. HE TOLD ME TO BRING THE CAR WITH ME, HE WOULD CALL ME ONCE HIS HAD THE PART IN HIS POSSESSION. HE CALLED ME ON JULY 23, 2018, TO BRING THE VEHICLE BACK TO THE DEALERSHIP FOR REPAIR, BUT UNTIL NOW, THE CAR HASN'T BEEN REPAIR IT. IT'S BEEN A MONTH AND TWO WEEKS THAT I NOTIFIED THE DEALERSHIP ABOUT THE PROBLEM, AND THE VEHICLE HAS NOT BEEN REPAIRED IN IT'S ENTIRELY.
1.FAULTY CLOCK SPRING RESULTING IN NO WORKING HORN OR AIRBAG 2. CALL STALLS AND WON'T START INTERMITTENTLY. DEALER CAN'T FIND ISSUES BUT I THINK IT'S RELATED TO THE FAULTY FUEL PUMP RECALL
I WAS DRIVING AT APPROXIMATELY 30 MPH AND UPON MAKING A NORMAL 80 DEGREE RIGHT TURN, I HEARD AN AUDIBLE POP IN THE STEERING COLUMN. AFTER THAT, MY AIRBAG ERROR LIGHT CAME ON AND I LOST FUNCTION IN MY HORN AND ALL STEERING WHEEL FACE CONTROLS (VEHICLE INFORMATION NAVIGATION FOR THE DASHBOARD, VOLUME AND RADIO CONTROLS, BLUETOOTH …
Read full complaint
I WAS DRIVING AT APPROXIMATELY 30 MPH AND UPON MAKING A NORMAL 80 DEGREE RIGHT TURN, I HEARD AN AUDIBLE POP IN THE STEERING COLUMN. AFTER THAT, MY AIRBAG ERROR LIGHT CAME ON AND I LOST FUNCTION IN MY HORN AND ALL STEERING WHEEL FACE CONTROLS (VEHICLE INFORMATION NAVIGATION FOR THE DASHBOARD, VOLUME AND RADIO CONTROLS, BLUETOOTH CONNECTIVITY, ETC.). AFTER TAKING IT TO THE DEALERSHIP FOR REPAIR AND BEING TOLD IT WAS THE CLOCK SPRING, I BEGAN DOING A LITTLE RESEARCH ON CLOCK SPRING ISSUES IN VOLKSWAGEN PASSATS MANUFACTURED BETWEEN 2010 AND 2014 AND THAT THERE WAS EVEN A RECALL ISSUED (ALTHOUGH I NEVER RECEIVED ANY INFORMATION ON A RECALL FROM THE MANUFACTURER OR THE DEALER). I HAVE BEEN TOLD BY MY DEALER THAT THE REPAIR WILL BE COVERED UNDER MY EXTENDED WARRANTY WHICH I STILL HAVE A DEDUCTIBLE FOR. IF THIS IS A DEFECTIVE PART THEN IT SHOULD BE VOLKSWAGEN'S RESPONSIBILITY, NOT THE OWNER.
CAR KEEPS RANDOMLY SHUTTING OFF. LOSES POWER WHILE IDLING AND DIFFICULT TO START. WILL LOSE POWER AND CUT OFF ALSO WHILE DRIVING. CHECK ENGINE LIGHT WILL NOT STAY ON OR COME ON.
CLOCK SPRING ISSUES . VW STATED TO ME THAT MY CAR WAS NOT UNDER RECALL FOR THE CLOCK SPRING .THEY FIXED IT IN JUNE 2016 . IT BROKE AGAIN JUNE 2017 AND WAS REPLACED. IT BROKE AGAIN IN JAN 2018 AND WAS REPLACED 7 WEEKS LATER BROKE AGAIN. IT IS IN NEED OF BEING REPLACED NOW WHICH WILL BE THE 5TH CLOCK SPRING TO BE PUT IN TH C…
Read full complaint
CLOCK SPRING ISSUES . VW STATED TO ME THAT MY CAR WAS NOT UNDER RECALL FOR THE CLOCK SPRING .THEY FIXED IT IN JUNE 2016 . IT BROKE AGAIN JUNE 2017 AND WAS REPLACED. IT BROKE AGAIN IN JAN 2018 AND WAS REPLACED 7 WEEKS LATER BROKE AGAIN. IT IS IN NEED OF BEING REPLACED NOW WHICH WILL BE THE 5TH CLOCK SPRING TO BE PUT IN TH CAR. THE AIRBAG LIGHT IS ON HORN DOES NOT WORK NOR ANYTHING ON THE STEERING WHEEL DUE TO THE BROKEN CLOCK SPRING . I AM THE ORIGINAL OWNER AND THE CAR IS PAID FOR BUT I CANT USE IT SAFELY AND CAN'T SELL IT WITH THESE ISSUES THAT VW WILL NOT FIX. VW CORPORATE OFFICES INVESTIGATED DETERMINED THAT IT INFACT WAS BROKEN AND SAID THEY WOULD PAY FOR MY LAST PART? BUT THAT IS OUT OF THE WARRANTY. THE FIRST REPAIR WAS AT 44,000 MILES . THE ISSUE IS THAT VW NEVER ADDRESSED WHY THEY KEEP BREAKING AND REPLACING THEM DOES NOT CORRECT THE PROBLEM
Official recalls
1024V834000 · Air Bags:frontal:driver Side:inflator Module
Oct 30, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Beetle, Beetle Convertible, 2012-2014 Passat, 2017 Passat Wagon, and 2006-2007 Passat Sedan vehicles. The driver's side frontal air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Dealers will replace the driver's side front air bag module, free of charge. Owner notification letters were mailed December 4, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 69EG, 69GQ, and 69E6.
19V862000 · Air Bags:frontal:driver Side:inflator Module
Dec 4, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2015 Passat, 2011-2014 Golf A6, and 2011-2013 Audi A3 diesel vehicles, thought to have been previously repaired under one of the Takata air bag recalls. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's side air bag inflators, free of charge. The recall began December 20, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 69R6, 69Q8, 69Q9, and 69Y5.
19V389000 · Exterior Lighting:headlights
May 22, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2020 Volkswagen Passat and 2018-2019 Atlas vehicles. The blocking cap disabling the adjustment of the headlight's horizontal aim may not have been installed. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Without the blocking cap, the headlight aim can be adjusted out of specification, reducing visibility and increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect and, as necessary, block the headlight horizontal adjustment, free of charge. The recall began July 16, 2019. Owners may contact Volkswagen customer service at 1-800-253-2834. Volkswagen's number for this recall is 94L9.
18V148000 · Air Bags:frontal:driver Side:inflator Module
Mar 6, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2009-2014 Volkswagen CC, 2010-2014 Golf, 2010-2014 Eos, 2007-2010 Passat Sedan and Wagon, and 2012-2014 Passat vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternative inflator, free of charge. The recall began March 16, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69Q9. Note: This recall partially supersedes recall 16V-078.
17V309000 · Engine And Engine Cooling:engine:diesel; Power Train:driveline:driveshaft
May 11, 2017
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2014 Passat vehicles, equipped with diesel engines and Direct-Shift Transmissions (DSG). The vehicle's underbody heat shield may not be long enough to protect the right half-shaft grease boot from heat, potentially resulting in a grease leak.
Consequence & remedy
Consequence: If the leaking grease contacts a heated surface, such as the exhaust system and/or the diesel particulate filter (DPF), it could increase the risk of fire.
Remedy: Volkswagen will notify owners, and dealers will replace the driveshaft heat shield, free of charge. The recall began on July 7, 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 23W5.
Additional source detail variants (2)
Power Train:driveline:driveshaft
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2014 Passat vehicles, equipped with diesel engines and Direct-Shift Transmissions (DSG). The vehicle's underbody heat shield may not be long enough to protect the right half-shaft grease boot from heat, potentially resulting in a grease leak.
Consequence: If the leaking grease contacts a heated surface, such as the exhaust system and/or the diesel particulate filter (DPF), it could increase the risk of fire.
Remedy: Volkswagen will notify owners, and dealers will replace the driveshaft heat shield, free of charge. The recall began on July 7, 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 23W5.
Engine And Engine Cooling:engine:diesel
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2014 Passat vehicles, equipped with diesel engines and Direct-Shift Transmissions (DSG). The vehicle's underbody heat shield may not be long enough to protect the right half-shaft grease boot from heat, potentially resulting in a grease leak.
Consequence: If the leaking grease contacts a heated surface, such as the exhaust system and/or the diesel particulate filter (DPF), it could increase the risk of fire.
Remedy: Volkswagen will notify owners, and dealers will replace the driveshaft heat shield, free of charge. The recall began on July 7, 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 23W5.
16V171000 · Electrical System:wiring
Mar 24, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2012-2014 Passat vehicles equipped with TDI engines. Due to improperly assembled wire seals in a connector for an underbody sensor, water may enter and corrode the electrical connectors of the sensor, causing an electrical short.
Consequence & remedy
Consequence: An electrical short can cause the electrical connectors of the sensor to overheat, increasing the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will inspect the connector, replacing it as necessary, free of charge. The recall began in September. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 23T3.
16V078000 · Air Bags:frontal:driver Side:inflator Module
Feb 10, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2010-2014 Golf, 2007-2010 Passat sedans and wagon, 2012-2014 Passat sedan and Eos, 2009-2014 CC, 2009-2012 Audi Q5, 2010-2012 S5 Cabriolet and 2010-2012 Audi A5 Cabriolet vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflators, free of charge. Volkswagen issued an interim notification to owners on April 12, 2016, and will send a second notification when parts are available. Volkswagen will notify owners again once parts are available. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298. Audi owners may contact Audi customer service at 1-800-253-2834.
15V483000 · Air Bags:frontal
Aug 4, 2015
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2010-2014 Volkswagen CC, and Passat, 2010-2013 Eos, 2011-2014 Golf, GTI, Jetta, and Tiguan, and 2012-2014 Jetta Sportwagen vehicles. In the affected vehicles, debris may contaminate the air bag clock spring, a spiral wound, flat cable that keeps the air bag powered while the steering wheel is being turned. This contamination may tear the cable and result in a loss of electrical connection to the driver's frontal air bag.
Consequence & remedy
Consequence: A loss of electrical connection to the driver's frontal air bag will prevent the air bag from deploying in the event of a vehicle crash, increasing the risk of injury.
Remedy: Volkswagen will notify owners, and dealers will install a protective cover over the steering wheel clock spring if the air bag light is off. If the airbag light is on and the steering wheel clock spring requires replacement, dealers will install a new steering wheel clock spring. These repairs will be performed free of charge. The recall began on January 15, 2016. Owners may contact Volkswagen customer service at 1-800-822-8987.
15V028000 · Fuel System, Gasoline:fuel Injection System:fuel Rail
Jan 23, 2015
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2014-2015 Jetta vehicles manufactured March 28, 2014, to November 24, 2014, 2014-2015 Passat vehicles manufactured April 7, 2014, to November 18, 2014, 2015 Golf and GTI vehicles manufactured July 1, 2014, to November 20, 2014, and 2014-2015 Beetle and Beetle Convertible vehicles manufactured March 31, 2014, to November 27, 2014. A sealing cap at the fuel rail may fail, allowing fuel to leak into the engine compartment.
Consequence & remedy
Consequence: A fuel leak, in the presence of an ignition source, can result in a vehicle fire.
Remedy: Volkswagen will notify owners, and dealers will replace the fuel rails with new parts, free of charge. The recall began February 6, 2015. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 24BL. Note: This recall expands and supersedes recall 14V-809 (Volkswagen recall number 24Bi) and only affects vehicles not previously repaired under that campaign.
14V182000 · Power Train:automatic Transmission:cooling Unit And Lines
Apr 15, 2014
Volkswagen of America, Inc. (Volkswagen) is recalling certain model year 2014 Jetta, Beetle, Beetle Convertible, and Passat vehicles equipped with a 1.8T engine and torque converter automatic transmission. In the affected vehicles, the O-ring seals between the oil cooler and the transmission may leak fluid.
Consequence & remedy
Consequence: The leaking transmission fluid could contact a hot surface and result in a vehicle fire.
Remedy: Volkswagen will notify owners, and dealers will replace the O-ring seals in the transmission oil cooler, free of charge. The recall is expected to begin on April 16, 2014. Owners may contact Volkswagen at 1-800-822-8987. Volkswagen's number for this recall is 38B9/9V.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA18003 · Air Bag Clockspring Failure
Opened Apr 18, 2018 · No close date supplied
Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Additional source detail variants (3)
Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Air Bags:frontal
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Air Bags
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
RQ17009 · Air Bag Clockspring Failure
Opened Nov 13, 2017 · Closed May 4, 2018
Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626
Additional source detail variants (2)
Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626
Air Bags:frontal
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626
PE15010 · Air Bag Clockspring Failure
Opened Mar 24, 2015 · Closed Sep 28, 2015
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Electrical System
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.
Additional source detail variants (3)
Air Bags:frontal
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.
Air Bags
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.
Electrical System
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.