IllustrationAFTER YOU GUYS INSTALLED THE NEW EMISSION PROGRAM MY CAR NOW HAS PROBLEMS WITH THE ELECTRICAL SYSTEM AND THE SENSOR FOR THE OIL LIGHT. IT HAS BEEN DOING THIS SINCE APRIL 8 AND BEFORE THAT WE NEVER HAD THIS PROBLEM.
2013 Volkswagen Passat
Owner reports · Recalls · Investigations
More warning signs than most Passat years
Owner complaints for the 2013 Volkswagen Passat are substantially higher than the model-year median of 110.
About this comparison →How this year compares
Owner complaints by model year
Compare all Passat years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
960–25K
9625–50K
9150–75K
6375–100K
50100–150K
8150K+
404 reports with mileage · 344 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 382 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 93 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
29 crash reports4 fire reports19 injury reports
Engine complaints
104 reportsWHILE DRIVING ON THE BELTWAY AT 60 MILES AN HOUR, THE CAR SUDDENLY LOST ALL ELECTRICAL POWER AND THE ENGINE SHUT DOWN. I WAS NOT ABLE TO STEER OR BRAKE OR ACCELERATE. I COASTED TO THE SIDE OF THE HIGHWAY, PUT THE CAR IN PARK AND RESTARTED IT AND DROVE IT HOME WITHOUT INCIDENT. DEALER COULD NOT FIND AN ERROR CODE. TWICE SINCE T…
Read full complaint
WHILE DRIVING ON THE BELTWAY AT 60 MILES AN HOUR, THE CAR SUDDENLY LOST ALL ELECTRICAL POWER AND THE ENGINE SHUT DOWN. I WAS NOT ABLE TO STEER OR BRAKE OR ACCELERATE. I COASTED TO THE SIDE OF THE HIGHWAY, PUT THE CAR IN PARK AND RESTARTED IT AND DROVE IT HOME WITHOUT INCIDENT. DEALER COULD NOT FIND AN ERROR CODE. TWICE SINCE THEN, THE ELECTRICAL AND SYSTEM HAVE SHUT DOWN WITHOUT WARNING WHILE THE CAR WAS RUNNING WHILE IDLING AT A TRAFFIC LIGHT.
TL* THE CONTACT OWNS A 2013 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE ENGINE WAS FAULTY AND THE VEHICLE COULD SHUT OFF AT ANY MOMENT. ALSO, THE CHECK ENGINE INDICATOR WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO SHEARER VOLKSWAGEN (2287 BERLIN STATE HWY, BARRE, VT 05641) WHERE IT WAS DIAGNOSED AND REPAIRED. THE DIAGNOSIS INFOR…
Read full complaint
TL* THE CONTACT OWNS A 2013 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE ENGINE WAS FAULTY AND THE VEHICLE COULD SHUT OFF AT ANY MOMENT. ALSO, THE CHECK ENGINE INDICATOR WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO SHEARER VOLKSWAGEN (2287 BERLIN STATE HWY, BARRE, VT 05641) WHERE IT WAS DIAGNOSED AND REPAIRED. THE DIAGNOSIS INFORMATION WAS NOT PROVIDED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND NO ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 103,000.
MY CAR IS A 2013 PASSAT PURCHASED BY ME IN 2014, I HAVE ALWAYS TAKEN MY CAR TO BE SERVICED WITH ALL REQUIRED SERVICE MAINTENANCES SINCE PURCHASE DATE (SERVICES DONE ALL AT VOLKSWAGEN DEALERSHIPS). THE NEXT SERVICE WAS NOT DUE. I HAVE THIS ALL DOCUMENTED BY THE DEALERSHIPS. MY CAR HAS APPROX. 94,000 MILES ON IT. THE CHECK ENG…
Read full complaint
MY CAR IS A 2013 PASSAT PURCHASED BY ME IN 2014, I HAVE ALWAYS TAKEN MY CAR TO BE SERVICED WITH ALL REQUIRED SERVICE MAINTENANCES SINCE PURCHASE DATE (SERVICES DONE ALL AT VOLKSWAGEN DEALERSHIPS). THE NEXT SERVICE WAS NOT DUE. I HAVE THIS ALL DOCUMENTED BY THE DEALERSHIPS. MY CAR HAS APPROX. 94,000 MILES ON IT. THE CHECK ENGINE LIGHT STARTED TO COME ON INTERMITTENTLY. TODAY VOLKSWAGEN DEALER (FOLLOWING DIAGNOSTIC TESTING) TOLD ME THE HEAD GASKET NEEDS TO BE REPLACED BUT THAT THIS IS A RISKY REPAIR AS THE PRIMARY PROBLEM IS THE ENGINE. THE VOLKSWAGEN DEALERSHIP IS TELLING ME THE ENGINE NEEDS TO BE REPLACED. THE VOLKSWAGEN DEALER IS TELLING ME TODAY THAT THIS IS NOT A USUAL PROBLEM WITH THIS VEHICLE. I CALLED VOLKSWAGEN TO ASK FOR FINANCIAL ASSISTANCE OR BUY BACK PLAN FOR THIS AND WAS TOLD THERE IS NOTHING THAT CAN BE DONE.
VOLKSWAGEN OF AMERICA ENGINEERED LESS-THAN-SAFE HEADLAMPS ON MY 2013 VW PASSAT 3.6 SEL. MY HEADLAMPS ARE SUBSTANDARD, AND DO NOT SHINE BRIGHT A NIGHT AS THE XENON HEADLAMPS ON THE COMPETITORS OF VOLKSWAGEN. FOR A $40,000 VEHICLE, IT'S AN EXPECTATION TO HAVE XENON HEADLAMPS, WHICH ARE MUCH SAFER THAN THE EXISTING HEADLAMPS ON T…
Read full complaint
VOLKSWAGEN OF AMERICA ENGINEERED LESS-THAN-SAFE HEADLAMPS ON MY 2013 VW PASSAT 3.6 SEL. MY HEADLAMPS ARE SUBSTANDARD, AND DO NOT SHINE BRIGHT A NIGHT AS THE XENON HEADLAMPS ON THE COMPETITORS OF VOLKSWAGEN. FOR A $40,000 VEHICLE, IT'S AN EXPECTATION TO HAVE XENON HEADLAMPS, WHICH ARE MUCH SAFER THAN THE EXISTING HEADLAMPS ON THE VW PASSAT. VOLKSWAGEN HAS BEEN INSTALLING 280 HP V6 ENGINES IN ITS PASSAT SINCE THE 2006 MODEL WHILE THEIR COMPETITORS HAVE BEEN INSTALLING 330HP AND UP IN THEIR V6 MODELS. THE VW PASSAT SHOULD HAVE AT LEAST 350HP/380 TORQUE WITH ALL WHEEL DRIVE, WITH A LONGITUDINAL ENGINE. IT'S QUITE OBVIOUS THAT THE EXECUTIVES AT VOLKSWAGEN OF AMERICA, AND VOLKSWAGEN AG ARE INTERESTED IN SACRIFICING QUALITY AND SAFETY TO SAVE A DOLLAR.
MY 2013 VW PASSAT 3.6 SEL MAJOR ISSUES WITH THE TRANSMISSION, BURNING EXCESSIVE ENGINE OIL, AND SUBSTANDARD SUSPENSION. THE TRANSMISSION SLIPS IN 3RD GEAR, AND STRUGGLES TO SEARCH FOR A GEAR. VW ENGINEERED MY PASSAT FOR CASTROL OIL 5W40 SYNTHETIC OIL, 6-7 QUARTS EVERY OIL CHANGE (EVERY 10,000 MILES). I HAVE TO ADD 3 QUARTS OF…
Read full complaint
MY 2013 VW PASSAT 3.6 SEL MAJOR ISSUES WITH THE TRANSMISSION, BURNING EXCESSIVE ENGINE OIL, AND SUBSTANDARD SUSPENSION. THE TRANSMISSION SLIPS IN 3RD GEAR, AND STRUGGLES TO SEARCH FOR A GEAR. VW ENGINEERED MY PASSAT FOR CASTROL OIL 5W40 SYNTHETIC OIL, 6-7 QUARTS EVERY OIL CHANGE (EVERY 10,000 MILES). I HAVE TO ADD 3 QUARTS OF OIL EVERY 4,000 MILES. THIS IS A CLEAR INDICATION THE OIL WEIGHT IS INSUFFICIENT FOR THIS VEHICLE, ENGINEERING ISSUES WITH THE OIL PUMP, AND/OR VALVE SEALS. THE PASSAT DOES NOT HANDLE WELL, AND FEELS UNSAFE IN RAIN, SNOW, AND SLEET, BECAUSE THERE IS NO TRACTION CONTROL BUTTON ON THE INSTRUMENT PANEL. IT'S QUITE OBVIOUS THAT THE EXECUTIVES AT VOLKSWAGEN AG ARE NOT INTERESTED IN SAFETY AND QUALITY. THEY ARE ONLY INTERESTED IN SACRIFICING A DOLLAR FOR SAFETY AND QUALITY.
MY 2013 VW PASSAT 3.6 SEL LACKS A ELEC STABILITY CONTROL SWITCH ON THE VEHICLE. AS A RESULT, THE TRACTION IS TERRIBLE ON THIS VEHICLE IN RAIN, SNOW, AND SLEET. THE ENGINE HAS A KNOCKING NOISE, EVEN THOUGH I SERVICE THE VEHICLE AT VW EVERY 10,000 MILES AS REQUIRED IN THE OWNER'S MANUAL. THIS VEHICLE HAS MAJOR ELECTRICAL PROBLE…
Read full complaint
MY 2013 VW PASSAT 3.6 SEL LACKS A ELEC STABILITY CONTROL SWITCH ON THE VEHICLE. AS A RESULT, THE TRACTION IS TERRIBLE ON THIS VEHICLE IN RAIN, SNOW, AND SLEET. THE ENGINE HAS A KNOCKING NOISE, EVEN THOUGH I SERVICE THE VEHICLE AT VW EVERY 10,000 MILES AS REQUIRED IN THE OWNER'S MANUAL. THIS VEHICLE HAS MAJOR ELECTRICAL PROBLEMS, SUCH AS THE SEAT BELT LIGHT ILLUMINATING, AND I LOSE TENSION IN MY DRIVER SEAT BELT. THAT IS A HUGE SAFETY FLAW FOR THIS $40,000 VEHICLE.
TL* THE CONTACT OWNS A 2013 VOLKSWAGEN PASSAT. WHILE DRIVING VARIOUS HIGH SPEEDS IN COLD CLIMATES, THE ENGINE FAILED. THE CONTACT STATED THAT THERE WAS AN EXCESSIVE VIBRATION IN THE ENGINE COMPARTMENT WHEN ACCELERATING. VOLKSWAGEN OF OCALA (5135 SW COLLEGE RD, OCALA, FLORIDA 34474, (352) 387-1330) WAS MADE AWARE OF THE FAILURE A…
Read full complaint
TL* THE CONTACT OWNS A 2013 VOLKSWAGEN PASSAT. WHILE DRIVING VARIOUS HIGH SPEEDS IN COLD CLIMATES, THE ENGINE FAILED. THE CONTACT STATED THAT THERE WAS AN EXCESSIVE VIBRATION IN THE ENGINE COMPARTMENT WHEN ACCELERATING. VOLKSWAGEN OF OCALA (5135 SW COLLEGE RD, OCALA, FLORIDA 34474, (352) 387-1330) WAS MADE AWARE OF THE FAILURE AND REPROGRAMMED THE ENGINE IN OCTOBER OF 2017. AFTER THE ENGINE WAS REPROGRAMMED, SEVERAL OTHER FAILURES OCCURRED. THE COOLANT LINES FAILED AND WERE REPLACED AND AN OIL LEAK DEVELOPED IN THE MAIN SEAL IN THE FRONT OF THE VEHICLE. INITIALLY, THE DEALER COULD NOT DUPLICATE THE FAILURES, BUT LATER REPLACED THE FAULTY MAIN SEAL. ALSO, THE WATER PUMP WAS FAULTY AND NEEDED TO BE REPLACED. AS A RESULT, THE TIMING BELT WAS REPLACED ON THE VEHICLE. FURTHERMORE, THE HIGH PRESSURE FUEL LINES FRACTURED AND FUEL ENTERED INTO THE FUEL FILTER OF THE VEHICLE. THE CONTACT STATED THAT FUEL SPILLED ONTO THE HIGHWAY WHILE DRIVING DUE TO A COOLANT LEAK FROM THE OIL COOLER. THE CONTACT STATED THAT THE FITTING ON THE FUEL LINE RELATED TO THE FUEL LINE ASSEMBLY WAS ALSO REPLACED. LASTLY, WHILE DRIVING 80 MPH, THE CHECK ENGINE INDICATOR ILLUMINATED WITHOUT WARNING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND PROVIDED CASE NUMBER: 181530876. THE FAILURE MILEAGE WAS APPROXIMATELY 105,000.
PULLING OUT OF DRIVEWAY EPC LIGHT COMES ON. TOTAL LOSS OF POWER AND ENGINE SPEED SET TO 1800RPM IN "SAFE MODE" NO ONE KNOWS EXACTLY WHAT IS WRONG. MECHANICS CANNOT TTELL ME WHAT IS WRONG. DEALERSHIP VW HAS NO IDEA AND WANT TO START REPLACING ITEMS IN DESCRIMINATELY AND I DON'T HAVE THAT KIND OF MONEY TO THROW AROUND AND BESIDES.…
Read full complaint
PULLING OUT OF DRIVEWAY EPC LIGHT COMES ON. TOTAL LOSS OF POWER AND ENGINE SPEED SET TO 1800RPM IN "SAFE MODE" NO ONE KNOWS EXACTLY WHAT IS WRONG. MECHANICS CANNOT TTELL ME WHAT IS WRONG. DEALERSHIP VW HAS NO IDEA AND WANT TO START REPLACING ITEMS IN DESCRIMINATELY AND I DON'T HAVE THAT KIND OF MONEY TO THROW AROUND AND BESIDES. THE PEOPLE THAT BUILT THE CAR CAN'T FIGURE IT OUT. THIS IS A HUGE SAFETY ISSUE. COMPUTER FAULTS AND SHUTS DOWN THE POWER AT HIWAY SPEEDS AND SOMETIMES CAR STALLS OUT. THIS IS VERY DANGEROUS AND HAPPENING TO HUNDREDS MAYBE THOUSANDS OF PEOPLE I'M READING ONLINE AND TALKING WITH OTHER OWNERS.
CAR WOULD MAKE WHIRLING SOUNDS INTERMITTENTLY, DIFFICULTY GOING UP HILL, ROUGH IDLE SOMETIMES, CAR SHUT OFF WHILE DRIVING, CAR SHUT OFF WHILE IDLING AT A LIGHT, CAR HAD DIFFICULTY STARTING OR WOULD START THEN SHAKE AND LET OUT LOUD AND HARD BURSTS OF GAS FROM EXHAUST AND CUT OFF, CAR WILL START UP THEN LOSE POWER, SOMETIMES WILL…
Read full complaint
CAR WOULD MAKE WHIRLING SOUNDS INTERMITTENTLY, DIFFICULTY GOING UP HILL, ROUGH IDLE SOMETIMES, CAR SHUT OFF WHILE DRIVING, CAR SHUT OFF WHILE IDLING AT A LIGHT, CAR HAD DIFFICULTY STARTING OR WOULD START THEN SHAKE AND LET OUT LOUD AND HARD BURSTS OF GAS FROM EXHAUST AND CUT OFF, CAR WILL START UP THEN LOSE POWER, SOMETIMES WILL START BACK UP. ONE TIME IT TOOK 3 TRIES AND WOULD NOT START. HAD AT VW DEALER MULTIPLE TIMES SINCE JAM 2017 TILL NOW. HAPPENED AGAIN TODAY AFTER I GOT GAS, SHUT OFF THEN TOOK A WHILE TO GAIN POWER AND EPC AND CHECK ENGINE LIGHT WERE ON THEN DISAPPEARED. EVERY OTHER TIME THE WNGINE LIGHT WOULD DISAPPEAR. THE LAST TIME IN MARCH THEY HAD THE CAR 10 OR SO DAY. TWO DAYS LATER IT IDLED ROUGH. THEY WERE BUSY TO CHECK THE CAR NOW THIS. JAN 2017 CHECK ENGINE LIGHT THEY SAID FAULT P0106/P2188- DID SOFTWARE UPDATE AND ADVISES FAULTS MAY COME BACK. FEB 2017 ENGINE LIGHT THEY SAID SAME FAULTS AND MANIFOLD PRESSURE SENSOR FAILED. GOT REPLACED. MARCH 2017 CAR STALLED IN TRAFFIC MULTIPLE TIMES. THEY CLEANED THROTTLE BODY. MARCH 2017 IN IDLE CAR SHAKING AND SHUT OFF RPMS UP AND DOWN REPLACED CAMSHAFT POSITION SENSOR. MAY 2017 SHUT OFF IN TRAFFIC- REPLACED N80 VALVE. 05/05/18 GOT SPARK PLUGS CHANGED. MARCH 7 CAR SHUT OFF THREE TIMES AFTER GETTING GAS. THEY HAD IT TILL MARCH 19 SAID CHARCOAL CANISTER NEED REPLACING THEN UPON PICK UP SAID N205 VALVE CAM ADJUSTER SOLENOID CLICKING LOUDLY. MARCH 29 NOTICED HEARING WHIRLING SOUNDS AND ROUGH IDLE. CALLED EALER NO ONE AVAILABLE OVER WEEKEND. BUSY. TODAY 04/08 CAR SHUT OFF AFTER 2ND GAS FILL UP. STARTED BACK SLOWLY EPC AND ENGINE LIGHT STEADY THEN IT GAINED POWER AND LIGHTS OFF. VW CORPORARE ADVISED IN 2017 I AM OUT OF WARRANTY AND HAVE HIGH MILEAGE. OPENED CLAIM AGAIN TODAY THEY SAID SAME THING BUT WILL SEE IF THE CORPORATE WOULD BE WILLING TO OFFER ASSISTANCE. ALL WORK HAS BEEN DONE VIA VW DEALERS
Official recalls
924V834000 · Air Bags:frontal:driver Side:inflator Module
Oct 30, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Beetle, Beetle Convertible, 2012-2014 Passat, 2017 Passat Wagon, and 2006-2007 Passat Sedan vehicles. The driver's side frontal air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Dealers will replace the driver's side front air bag module, free of charge. Owner notification letters were mailed December 4, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 69EG, 69GQ, and 69E6.
19V862000 · Air Bags:frontal:driver Side:inflator Module
Dec 4, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2015 Passat, 2011-2014 Golf A6, and 2011-2013 Audi A3 diesel vehicles, thought to have been previously repaired under one of the Takata air bag recalls. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's side air bag inflators, free of charge. The recall began December 20, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 69R6, 69Q8, 69Q9, and 69Y5.
19V389000 · Exterior Lighting:headlights
May 22, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2020 Volkswagen Passat and 2018-2019 Atlas vehicles. The blocking cap disabling the adjustment of the headlight's horizontal aim may not have been installed. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Without the blocking cap, the headlight aim can be adjusted out of specification, reducing visibility and increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will inspect and, as necessary, block the headlight horizontal adjustment, free of charge. The recall began July 16, 2019. Owners may contact Volkswagen customer service at 1-800-253-2834. Volkswagen's number for this recall is 94L9.
18V148000 · Air Bags:frontal:driver Side:inflator Module
Mar 6, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2009-2014 Volkswagen CC, 2010-2014 Golf, 2010-2014 Eos, 2007-2010 Passat Sedan and Wagon, and 2012-2014 Passat vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternative inflator, free of charge. The recall began March 16, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69Q9. Note: This recall partially supersedes recall 16V-078.
17V309000 · Engine And Engine Cooling:engine:diesel; Power Train:driveline:driveshaft
May 11, 2017
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2014 Passat vehicles, equipped with diesel engines and Direct-Shift Transmissions (DSG). The vehicle's underbody heat shield may not be long enough to protect the right half-shaft grease boot from heat, potentially resulting in a grease leak.
Consequence & remedy
Consequence: If the leaking grease contacts a heated surface, such as the exhaust system and/or the diesel particulate filter (DPF), it could increase the risk of fire.
Remedy: Volkswagen will notify owners, and dealers will replace the driveshaft heat shield, free of charge. The recall began on July 7, 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 23W5.
Additional source detail variants (2)
Power Train:driveline:driveshaft
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2014 Passat vehicles, equipped with diesel engines and Direct-Shift Transmissions (DSG). The vehicle's underbody heat shield may not be long enough to protect the right half-shaft grease boot from heat, potentially resulting in a grease leak.
Consequence: If the leaking grease contacts a heated surface, such as the exhaust system and/or the diesel particulate filter (DPF), it could increase the risk of fire.
Remedy: Volkswagen will notify owners, and dealers will replace the driveshaft heat shield, free of charge. The recall began on July 7, 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 23W5.
Engine And Engine Cooling:engine:diesel
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2014 Passat vehicles, equipped with diesel engines and Direct-Shift Transmissions (DSG). The vehicle's underbody heat shield may not be long enough to protect the right half-shaft grease boot from heat, potentially resulting in a grease leak.
Consequence: If the leaking grease contacts a heated surface, such as the exhaust system and/or the diesel particulate filter (DPF), it could increase the risk of fire.
Remedy: Volkswagen will notify owners, and dealers will replace the driveshaft heat shield, free of charge. The recall began on July 7, 2017. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 23W5.
16V171000 · Electrical System:wiring
Mar 24, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2012-2014 Passat vehicles equipped with TDI engines. Due to improperly assembled wire seals in a connector for an underbody sensor, water may enter and corrode the electrical connectors of the sensor, causing an electrical short.
Consequence & remedy
Consequence: An electrical short can cause the electrical connectors of the sensor to overheat, increasing the risk of a fire.
Remedy: Volkswagen will notify owners, and dealers will inspect the connector, replacing it as necessary, free of charge. The recall began in September. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 23T3.
16V078000 · Air Bags:frontal:driver Side:inflator Module
Feb 10, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2010-2014 Golf, 2007-2010 Passat sedans and wagon, 2012-2014 Passat sedan and Eos, 2009-2014 CC, 2009-2012 Audi Q5, 2010-2012 S5 Cabriolet and 2010-2012 Audi A5 Cabriolet vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflators, free of charge. Volkswagen issued an interim notification to owners on April 12, 2016, and will send a second notification when parts are available. Volkswagen will notify owners again once parts are available. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298. Audi owners may contact Audi customer service at 1-800-253-2834.
15V483000 · Air Bags:frontal
Aug 4, 2015
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2010-2014 Volkswagen CC, and Passat, 2010-2013 Eos, 2011-2014 Golf, GTI, Jetta, and Tiguan, and 2012-2014 Jetta Sportwagen vehicles. In the affected vehicles, debris may contaminate the air bag clock spring, a spiral wound, flat cable that keeps the air bag powered while the steering wheel is being turned. This contamination may tear the cable and result in a loss of electrical connection to the driver's frontal air bag.
Consequence & remedy
Consequence: A loss of electrical connection to the driver's frontal air bag will prevent the air bag from deploying in the event of a vehicle crash, increasing the risk of injury.
Remedy: Volkswagen will notify owners, and dealers will install a protective cover over the steering wheel clock spring if the air bag light is off. If the airbag light is on and the steering wheel clock spring requires replacement, dealers will install a new steering wheel clock spring. These repairs will be performed free of charge. The recall began on January 15, 2016. Owners may contact Volkswagen customer service at 1-800-822-8987.
14V125000 · Exterior Lighting:headlights
Mar 17, 2014
Volkswagen Group of America (Volkswagen) is recalling certain model year 2012-2013 Passat vehicles manufactured January 2011 through November 2012. In the affected vehicles, the low beam headlight bulb may become loose and lose electrical contact.
Consequence & remedy
Consequence: A loss of low beam headlights may reduce the driver's visibility and increase the risk of a crash.
Remedy: Volkswagen notified owners, and dealers will replace the bulb holder, free of charge. The recall began in May 2014. Owners may contact Volkswagen at 1-800-822-8987. Volkswagens recall number associated with this campaign is 94G8/7V.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA18003 · Air Bag Clockspring Failure
Opened Apr 18, 2018 · No close date supplied
Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Additional source detail variants (3)
Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Air Bags:frontal
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Air Bags
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
RQ17009 · Air Bag Clockspring Failure
Opened Nov 13, 2017 · Closed May 4, 2018
Status: closed (inferred from source dates) · Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626
Additional source detail variants (2)
Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626
Air Bags:frontal
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.This Recall Query has been upgraded to an Engineering Analysis (EA18-003) to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 107626
PE15010 · Air Bag Clockspring Failure
Opened Mar 24, 2015 · Closed Sep 28, 2015
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Electrical System
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.
Additional source detail variants (3)
Air Bags:frontal
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.
Air Bags
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.
Electrical System
The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of steering wheel clock spring/steering column control module (SCCM) failures in model year (MY) 2012 Volkswagen Passat and CC models.The SCCM is a module within the steering column that incorporates a spiral conductor (a ribbon cable) to electrically connect the steering wheel to the vehicle's electrical system while allowing for the turning of the steering wheel.Complainants alleged that that the clock spring failed while driving and without warning.When the SCCM fails electrically, an air bag warning light is illuminated on the dash of the vehicle.If a vehicle with a failed SCCM were to be involved in a crash of sufficient severity to require deployment, the driver air bag may not deploy properly, or deploy at all.As the result of an Information Request response from Volkswagen, ODI determined that the same SCCM was used in several vehicle models and MYs including: 2010-2013 CC, 2010-2013 Eos, 2011-2013 Golf, 2012-2013 Jetta and Jetta SportWagen, 2010 and 2012-2014 Passat and 2011-2014 Tiguan.ODI identified a total of 29 NHTSA complaints across all affected vehicles potentially indicating a failed SCCM.Drivers often indicated that an audible noise was heard from the steering column when the unit failed. Some drivers also mentioned that there was a noticeable but minor resistance to turning of the steering wheel after the failure with noises coming from the steering column.The average failure mileage is approximately 30,500 miles and failures often occur outside of the factory warranty.There were no reported crashes or injuries identified in either the NHTSA or Volkswagen data as a result of SCCM failures.On July 30th, 2015 Volkswagen notified ODI that it would conduct a safety recall (15V-483) to remedy the SCCMs in 415,825 MY2010-2014 vehicles.According to Volkswagen, the SCCM can become contaminated with human hair or similar fibers entering the unit between the steering wheel and steering column.Over time this can cause the electrical cable to tear and lose connection between the steering wheel and vehicle.Volkswagen will install a cover that attaches over the SCCM to help prevent contaminants from entering the unit.A new SCCM designed to reduce outside contamination intrusion was previously introduced into new vehicle production during the 2014 model year; accordingly vehicles equipped with the new design SCCM are not included in the recall.The recall action initiated by the manufacturer addresses the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10760644, 10758777, 10748922, 110734168, 10731545, 10721424, 10717651, 10715305, 10713742, 10713139, 10712295, 10711945, 10704830, 10704221, 10702926, 10702212, 10701406, 10691906, 10683944, 10682136, 10672715, 10670517, 10669312, 10628549, 10607240, 10575783, 10561143, 10552113, 10397670.