NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
576 reports63,000 miles · May 20, 2009
Engine And Engine CoolingExterior LightingLatches/locks/linkages
TL*THE CONTACT OWNS A 2006 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE STEERING COLUMN LOCKS UP ON HER VEHICLE AND PREVENTS IT FROM BEING DRIVEN. SHE ATTEMPTED TO START THE ENGINE AND AN INDICATOR ILLUMINATED, WHICH STATED THAT THE STEERING COLUMN WAS LOCKED. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE STE…
Read full complaint
TL*THE CONTACT OWNS A 2006 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE STEERING COLUMN LOCKS UP ON HER VEHICLE AND PREVENTS IT FROM BEING DRIVEN. SHE ATTEMPTED TO START THE ENGINE AND AN INDICATOR ILLUMINATED, WHICH STATED THAT THE STEERING COLUMN WAS LOCKED. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE STEERING COLUMN WAS DEFECTIVE AND NEEDED A MODULE. THE REPAIR WOULD COST $1,300. THE FAILURE MILEAGE WAS 63,000. UPDATED 05/27/09 *BF UPDATED 06/08/09 *BF UPDATED 6/16/09 *NJ THE LEFT REAR CALIPER NEEDED TO BE REPLACED,THE CHECK ENGINE LIGHT ILLUMINATED, THE TRANSMISSION WAS MAKING A LOUD NOISE, THE TIRE PRESSURE LIGHT ILLUMINATED, THE LEFT TURN SIGNAL DID NOT WORK, THE LEFT WHEEL BEARING NEEDED TO BE REPLACED, THE HOOD RELEASE LEVER INSIDE THE VEHICLE WAS INOPERATIVE. UPDATED 06/17/09.*JB
NHTSA ODI #10269475
69,000 miles · May 19, 2009
Electrical SystemSteering
TL*THE CONTACT OWNS A 2006 VOLKSWAGEN PASSAT. THE CONTACT ATTEMPTED TO START THE IGNITION AND THE STEERING WHEEL BEGAN TO LOCK UP. THERE WERE TWO WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE MESSAGES DISPLAYED WERE "EMBOLIZATER ACTIVATED MOVE STEERING WHEEL" AND "STEERING LOCK DEFECTIVE". IN ADDITION, THE IGNI…
Read full complaint
TL*THE CONTACT OWNS A 2006 VOLKSWAGEN PASSAT. THE CONTACT ATTEMPTED TO START THE IGNITION AND THE STEERING WHEEL BEGAN TO LOCK UP. THERE WERE TWO WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. THE MESSAGES DISPLAYED WERE "EMBOLIZATER ACTIVATED MOVE STEERING WHEEL" AND "STEERING LOCK DEFECTIVE". IN ADDITION, THE IGNITION KEY WAS STUCK AND FAILED TO RELEASE. THE FAILURES OCCURED WITHOUT WARNING. THE DRIVER DISCONNECTED AND RECONNECTED THE BATTERY CABLE TO START THE VEHICLE. THE VEHICLE STALLED BETWEEN SIX TO TEN TIMES WHILE IN OPERATION. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS TOWED FROM HER RESIDENCE TO AN INDEPENDENT MECHANIC. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 69,000.
NHTSA ODI #10269428
76,500 miles · May 14, 2009
Engine And Engine Cooling
I HAVE A 2006 VOLKSWAGEN 2.0T & ON THE 18TH OF APRIL AS I CROSSED OVER A RAILROAD TRACK THE CAR EXHAUST GOT VERY LOUD. I HAD TO PULL OVER & SHUT CAR OFF. THIS HAPPENED ON A SATURDAY LATE AFTERNOON SO I HAD MY MECHANIC (NOT VOLKSWAGEN DEALER) LOOKED & FOUND THE FLANGE THAT BOLTS THE WHOLE EXHAUST TO THE MANIFOLD HAD BROKE (CLEAN…
Read full complaint
I HAVE A 2006 VOLKSWAGEN 2.0T & ON THE 18TH OF APRIL AS I CROSSED OVER A RAILROAD TRACK THE CAR EXHAUST GOT VERY LOUD. I HAD TO PULL OVER & SHUT CAR OFF. THIS HAPPENED ON A SATURDAY LATE AFTERNOON SO I HAD MY MECHANIC (NOT VOLKSWAGEN DEALER) LOOKED & FOUND THE FLANGE THAT BOLTS THE WHOLE EXHAUST TO THE MANIFOLD HAD BROKE (CLEAN BREAK ALL THE WAY AROUND ) @ THE FACTORY WELD, ALMOST LIKE IT HAD NEVER BEEN "TIG" WELDED COMPLETELY @ THE FACTORY. THIS IS SOMETHING THAT SHOULD NOT HAVE HAPPENED IN ANY CIRCUMSTANCE. *TR
NHTSA ODI #10268711
64,701 miles · May 5, 2009
Steering
2006 VW PASSAT 2.0T STEERING COLUMN PROBLEM INDICATED BY WARNING MESSAGE IN DASHBOARD. WE'VE SEEN THIS MESSAGE ON AND OFF OVER SEVERAL DAYS. ACCORDING TO SERVICE ADVISOR AT THE VW DEALER THE STEERING COLUMN WILL LOCK. THEREFORE, IT NEEDS TO BE REPLACED. THE ESTIMATE IS 1,500.00 DLLS. I DID A WEB SEARCH TO SEE IF OTHER OWNERS HAV…
Read full complaint
2006 VW PASSAT 2.0T STEERING COLUMN PROBLEM INDICATED BY WARNING MESSAGE IN DASHBOARD. WE'VE SEEN THIS MESSAGE ON AND OFF OVER SEVERAL DAYS. ACCORDING TO SERVICE ADVISOR AT THE VW DEALER THE STEERING COLUMN WILL LOCK. THEREFORE, IT NEEDS TO BE REPLACED. THE ESTIMATE IS 1,500.00 DLLS. I DID A WEB SEARCH TO SEE IF OTHER OWNERS HAVE THE SAME PROBLEM. I WAS AMAZED BY THE NUMBER OF PEOPLE COMPLAINING ABOUT THIS AND SO FAR THERE IS NO RECALL FROM VW FOR WHAT IS APPEARS A DESIGN ERROR. *TR
NHTSA ODI #10267729
64,000 miles · Apr 23, 2009
Engine And Engine Cooling
2006 VW PASSAT 3.6 L IN SHOP FOR TWO WEEKS NOW WITH SEIZED MOTOR AT JUST OVER 64K MILES - OIL LIGHT ALARM CAME ON SUDDENLY AT 70MPH ....IMMEDIATELY STOPPED VEHICLE AND HAD ROADSIDE ASSISTANCE TOW TO VW DEALER...BEEN THERE EVER SINCE...STILL WAITING FOR VW TO DECIDE WHAT THEY ARE GOING TO DO FOR ME... *TR
NHTSA ODI #10266555
30,000 miles · Apr 18, 2009
Steering
CAR INTERMITTENTLY WILL NOT START FOR SEVERAL MINUTES, AND DISPLAY READS "STEERING COLUMN LOCK DEFECTIVE". HAS HAPPENED DOZENS OF TIMES. DEALER DENIES ANYTHING WRONG WITH CAR AFTER INSPECTION. *TR
NHTSA ODI #10265924
60,000 miles · Apr 3, 2009
Steering
2006 VW PASSAT STEERING LOCK FAILURE..WILL COST ME 1500 TO FIX EVEN THOUGH THERE ARE COUNTLESS PAGES OF PEOPLE HAVE THE SAME PROBLEM WITH CAR. VOLKSWAGEN DOES NOT RECOGNIZE IT AS BIG ENOUGH FOR A RECALL. *TR
NHTSA ODI #10264098
30,000 miles · Mar 22, 2009
Service Brakes, Hydraulic
POWER BRAKE ASSIST FAILURE IN LOW AMBIENT TEMPERATURES (WI WINTERS). OCCURS WHENEVER TEMPERATURES ARE IN THE 30'S OR LOWER. VACUUM HOSE HAS BEEN REPLACED TWICE, WITH NO IMPROVEMENT. APPARENTLY CONDENSATION IS BUILDING INSIDE THE HOSE (REPORTED BY DEALERSHIP SERVICE DEPT.) *TR
NHTSA ODI #10262699
6,000 miles · Mar 22, 2009
Latches/locks/linkages
I HAD PERSISTENT PROBLEMS WITH THE LATCH ON THE TRUNK OF MY 2006 PASSAT. FINALLY, THE DEALERSHIP FOUND THAT PIECES OF THE PLASTIC COATING OF THE LATCH MECHANISM WERE CHIPPING OFF AND FOULING THE LATCH. THE LATCH WAS REPLACED WITH A BARE METAL PIECE AND THE PROBLEM RESOLVED. THIS WAS NOT RESOLVED, HOWEVER, UNTIL AFTER SOME ANO…
Read full complaint
I HAD PERSISTENT PROBLEMS WITH THE LATCH ON THE TRUNK OF MY 2006 PASSAT. FINALLY, THE DEALERSHIP FOUND THAT PIECES OF THE PLASTIC COATING OF THE LATCH MECHANISM WERE CHIPPING OFF AND FOULING THE LATCH. THE LATCH WAS REPLACED WITH A BARE METAL PIECE AND THE PROBLEM RESOLVED. THIS WAS NOT RESOLVED, HOWEVER, UNTIL AFTER SOME ANONYMOUS DO-GOODER DENTED MY TRUNK TRYING TO SHUT IT. *TR
NHTSA ODI #10262691
48,500 miles · Mar 10, 2009
Service Brakes, Electric
EMERGENCY BRAKE AT TIMES DOES NOT DISENGAGE OR ENGAGE. I HAVE TO TURN THE CAR OFF WAIT A WHILE AND SOMETIMES IT DOES AND SOMETIMES IT DOES NOT ENGAGE/RENGAGE. GIVES ME A PARKING BRAKE FAULT MESSAGE. *TR
NHTSA ODI #10261394
Official recalls
7Oct 30, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Beetle, Beetle Convertible, 2012-2014 Passat, 2017 Passat Wagon, and 2006-2007 Passat Sedan vehicles. The driver's side frontal air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Dealers will replace the driver's side front air bag module, free of charge. Owner notification letters were mailed December 4, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 69EG, 69GQ, and 69E6.
Apr 18, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2006-2007 Volkswagen Passat sedan and wagon vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the front driver air bag inflator with an alternate inflator, free of charge. The recall began on April 30, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69Q8. Note: This recall partially supersedes recall 16V-079.
Aug 16, 2017
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2009-2016 Volkswagen CC, 2006-2010 Passat and Passat Wagon vehicles. Interruption of electrical power to the fuel pump control module may cause the fuel pump to fail.
Consequence & remedy
Consequence: If the fuel pump fails, the engine will stall, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the fuel pump control module, free of charge. The recall began June 26, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20AE.
Feb 10, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2006 Volkswagen Passat sedans and wagons, 2005-2013 Audi A3, and 2006-2009 Audi A4 Cabriolet vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflators, free of charge. The recall began March 2017. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298. Audi owners may contact Audi customer service at 1-800-253-2834.
Dec 12, 2006
ON CERTAIN '6' GENERATION PASSENGER VEHICLES, THE WIPER MOTOR MAY FAIL DURING HEAVY RAIN DUE TO EXCESSIVE MOISTURE ENTERING THE WIPER MOTOR. IF THIS HAPPENS, THE WIPERS CAN BECOME INOPERATIVE.
Consequence & remedy
Consequence: THIS COULD LEAD TO REDUCED VISIBILITY INCREASING THE RISK OF A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A SPECIAL COVER AND SEALING KIT. THE RECALL BEGAN ON JANUARY 12, 2007. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-893-5298.
Dec 12, 2006
CERTAIN PASSENGER VEHICLES EQUIPPED WITH A 2.0L ENGINE WITH 147 KW MAY HAVE A VACUUM LINE THAT MAY FRACTURE AND BECOME DISCONNECTED AT LOW AMBIENT TEMPERATURES.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE POWER ASSIST CAN BECOME INOPERATIVE, AND THE DRIVER WILL EXPERIENCE INCREASED EFFORT TO APPLY THE BRAKES POSSIBLY INCREASING VEHICLE STOPPING DISTANCE. THIS COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED VACUUM LINE. THE RECALL BEGAN ON JANUARY 12, 2007. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-893-5298.
Nov 30, 2005
ON CERTAIN PASSENGER VEHICLES, THE LEFT AND RIGHT TIE ROD SECURING NUT MAY BE INSUFFICIENTLY TORQUED.
Consequence & remedy
Consequence: AN INSUFFICIENTLY TIGHTENED TIE ROD NUT MAY LOOSEN, RESULTING IN SEPARATION OF A TIE ROD. THIS CAN CAUSE A LOSS OF STEERING CONTROL, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL INSPECT AND INSTALL NEW LEFT AND RIGHT TIE ROD SECURING NUTS AT THE PROPER TORQUED SPECIFICATION. THE RECALL BEGAN ON DECEMBER 7, 2005. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-893-5298.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA11002 · Engine Compartment Fire
Opened Jan 26, 2011 · Closed Feb 17, 2012
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Additional source detail variants (2)
Electrical System
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Illustration