2006 Volkswagen Passat

IN STOP AND GO TRAFFIC AND TRAVELING AT AN EXTREMELY SLOW SPEED, THE VEHICLE BUMPED INTO THE REAR OF ANOTHER VEHICLE. THE CONTACT IGNITED THE VW PASSAT INTO FLAMES DESTROYING THE ENTIRE VEHICLE. IMPORTANTLY, THE OTHER VEHICLE INVOLVED HAS ZERO DAMAGE AS THE BUMP WAS EXTREMELY LIGHT. WE ARE AWARE THE MODEL YEAR 2006 VW PASSAT HAS A HISTORY OF THIS OCCURRING IN FRONT END COLLISIONS. WE STRONGLY REQUEST AND RECOMMEND A RECALL BE DEMANDED OF VW. *TR

I GOT A SEVERAL TIME OF SERVICE FROM VW DEALER, BUT THE PROBLEM IS STILL RECURRING. I GOT MORE 100 TIMES OF SUDDENLY ENGINE OFF OR NOT ACCELERATION WHILE DRIVING. I FOUND YOUTUBE LINK THAT IT IS EXTREMELY SAME WITH MY PROBLEM : WWW.YOUTUBE.COM/WATCH?V=LYJB4ERLJES THE PROBLEM RECURS FOR A YEAR FROM THE FIRST RECOGNITION, I REPLACED FUEL PUMP, FUEL SENSOR, FUEL PRESSURE REGULATOR AND SUCTION VALVE FOR THIS PERIOD. BUT THE PROBLEM IS NOT FIXED. I FOUND ANOTHER FORUM LINK FOR MY PROBLEM : 1) HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?3462993-ATTN-3.6L-OWNERS-HAS-YOUR-ENGINE-FAILED I GOT VERY DANGEROUS SITUATION FOR MANY TIMES DUE TO THE PROBLEM. FOR EXAMPLE, I HAD TWICE THAT MY CAR WAS STOPPED WHEN I LEFT TURN AROUND ON CROSS WAY. ANOTHER CAR WAS COMING TO MY SIDE AND STOPPED BARELY. IF THE CAR COULDN'T STOP, I MIGHT GET SEVERE ACCIDENT. *TR

I WAS GETTING ONTO THE HIGHWAY IN MY 2006 3.6 PASSAT. THE CAR LOST POWER, CHECK ENGINE LIGHT & EPC LIGHT CAME ON IN THE CAR. THE CAR WOULD NOT ALLOW ME TO GO OVER 40MPH, SO I EXITED THE HIGHWAY & DROVE CAR TO THE MECHANIC. THEY REMOVED THE TRANSMISSION TO FIND THE ISSUE OF THE BOLT HOLDING THE OIL PUMP WAS PARTIALLY REMOVED. THE CAR DETECTED A TIMING ISSUE & WAS THE REASON THAT IT WOULD NOT ALLOW ME TO GO OVER 40 MPH. WHEN THE MECHANIC REMOVED THE BOLT TO REPLACE IT, IT CAME OFF IN TWO PIECES. HE STATED THAT THE BOLT WAS NOT THE APPROPRIATE BOLT & THE NEW GUIDELINES REQUIRED A DIFFERENT BOLT WITH ADDITIONAL TORQUE. THIS WAS AN ENGINEERED MANUFACTURER DEFECT WITH VOLKSWAGEN & SHOULD BE REQUIRED TO BE RECALLED. *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE VEHICLE STALLED. THE CONTACT TOOK THE VEHICLE TO A DEALER FOR A DIAGNOSTIC. THE DEALER STATED THAT THE FUEL PUMP WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE CONTACT TOOK THE VEHICLE BACK TO THE DEALER. THE DEALER COULD NOT FIND A DEFECT WITH THE VEHICLE. THE FAILURE MILEAGE WAS 94,000. THE VIN WAS NOT AVAILABLE.

OIL PUMP BOLT BROKEN AS IN THE OTHER VW PASSATS FROM 2006 & 7 AND REPORTED ON THIS SITE. DAMAGED TIMING CHAIN COVER, TIMING CHAIN AND A NUMBER OF OTHER PARTS. CAR WAS SERVICED AND INSPECTED 5,000 MILES PREVIOUSLY. ALL SERVICE UP TO THIS POINT COMPLETED PER OWNERS MANUAL AT VW DEALER. THIS PROBLEM IS COVERED EXTENSIVELY AT HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?4321376-**OFFICIAL-24V-3.6L-ENGINE-%28OIL-PUMP-BOLT%29-FAILURE-THREAD** AS WELL AS HTTP://WWW.PASSATWORLD.COM/FORUMS/74-VOLKSWAGEN-PASSAT-B6-DISCUSSION/327507-3-6-OIL-BOLT-FAILURE-REFERENCE-MATERIAL.HTML. NOT ONLY IS THIS A POTENTIALLY DANGEROUS AND KNOWN PROBLEM INVOLVING FAILURE OF MECHANICAL SYSTEMS, BUT EXTREMELY EXPENSIVE TO REPAIR. I RECEIVED A QUOTE FOR $6300 FOR A CAR WITH 78,000 MILES. THIS IS A KNOWN PROBLEM ON 3.6L V6S THAT IS BEING IGNORED BY VW OF AMERICA WHO REFUSED TO HELP EVEN COVER REPLACEMENT PARTS. *TR

MY CAR IS EXHIBITING THE SAME PROBLEMS THAT MANY OTHER CONSUMERS ARE EXPERIENCING. THE ENGINE OIL PUMP BOLT FAILS AND BACKS-OUT, WHICH CAN SHEER OFF THE BOLT AND CAUSE THE ENGINE TO EXPERIENCE CATASTROPHIC FAILURE. MY EPC LIGHT, ENGINE LIGHT, AS WELL AS EXCLAMATION LIGHT ARE ON. THE CAR HAS VERY LITTLE POWER, AND ALTHOUGH IT DOES RUN, THE ACCELERATION NEEDED TO DRIVE THE CAR MAKES IT DANGEROUS. THE ISSUES HAS BEEN HIGHLIGHTED BY MANY CONSUMERS AND HAVE CONTACTED THE PERSON NOTED AT THE BOTTOM OF THIS POST: HTTP://WWW.PASSATWORLD.COM/FORUMS/74-VOLKSWAGEN-PASSAT-B6-DISCUSSION/327507-3-6-OIL-BOLT-FAILURE-REFERENCE-MATERIAL.HTML THE COST TO REPLACE THIS PART IS ON AVERAGE $2000.00. THIS IS A MANUFACTURING ISSUE AND HAS BEEN REPORTED BY MANY PEOPLE. VW HAS YET TO ISSUE A RECALL FOR THE PROBLEM AND I AM AWAITING A RESPONSE FROM [XXX] OR [XXX] ABOUT THE ISSUE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

LIKE MANY OTHERS, THE OIL BOLT IN MY TRANSMISSION SHEARED-OFF. APPARENTLY VW IS AWARE OF THE DESIGN FLAW AND HAS MANUFACTURED A REPLACEMENT BOLT, BUT VW STILL EXPECTS UNSUSPECTING OWNERS TO PAY $1,000'S TO REPLACE IT. I BOUGHT THE CAR AS A CERTIFIED USED CAR FROM VW ON 9/11/10 AND WAS NOT TOLD OF THIS ISSUE. THIS ISSUE NEEDS TO BE ADDRESSED IN A RECALL IF VW WILL NOT WARN CUSTOMERS OR FIX THE ISSUE ON THEIR OWN. HTTP://WWW.PASSATWORLD.COM/FORUMS/74-VOLKSWAGEN-PASSAT-B6-DISCUSSION/327507-3-6-OIL-BOLT-FAILURE-REFERENCE-MATERIAL.HTML. *TR

WHILE DRIVING ON A BUSY HIGHWAY IN PHILADELPHIA PA (SCHUYLKILL EXPRESSWAY), MY 2006 VW PASSAT 3.6L 4 MOTION LOST POWER AND LIMPED TO THE SIDE OF THE ROAD ALMOST CAUSING SEVERAL ACCIDENTS IN THE PROCESS. AFTER TAKING THE AUTO TO TWO DIFFERENT NON-DEALER SPECIALIST AND THEN A VW DEALER - ALL THREE STATED THAT THE DEFAULT CODE (P0016 -008-INCORRECT CORRELATION - MIL ON) MEANT THAT THE OIL PUMP BOLT FAILED AND CAUSED THE ENGINE TO GO INTO LIMP MODE. ONE SPECIALIST SAID I WAS LUCKY TO GET TO 110,000 MILES AS MOST OF THESE BOLTS FAIL AT A RANGE FROM 60,000 TO 70,000 AND THAT THIS BOLT THAT WAS USED BEING OF POOR QUALITY WILL, AND HAS CAUSED CATASTROPHIC ENGINE FAILURE AND COULD CAUSE A LOSS OF POWER AND A REAR END COLLISION - ALL THREE (THE TWO NON-DEALER AND THE VW DEALER SERVICE MANGER WERE WELL AWARE OF THE PROBLEM, STATED IT WAS COMMON ON 2006/2007 PASSAT AND AS MORE AND MORE OF THESE 2006/2007 GET OLDER - MORE WILL FAIL AND COULD CAUSE ACCIDENTS OR WORSE. I WOULD LIKE TO KNOW IF AN INVESTIGATION COULD BE DONE AND A RECALL ESTABLISHED. THERE IS A WIDE RANGE OF REPAIR COST, POTENTIAL FOR PROPERTY DAMAGE AND ULTIMATELY LOSS OF LIFE FOR A $5.00 BOLT THAT THE MANUFACTURER KNOWS IS FLAWED AND WILL NOT FIX IT. *TR