NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
148 reports81,500 miles · Apr 25, 2011
SeatsFire
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE CONTACT STATED THE DRIVER SIDE SEAT WARMER IGNITED A FIRE AND BURNED THROUGH THE SEAT. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO THE DEALER FOR THE REPAIR. THE MANUFACTURER WAS CONTACT WHO STATED THAT THEY WOULD DISCUSS THE REPAIRS WITH THE DEALER AND GIVE HIM A RETURN CA…
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE CONTACT STATED THE DRIVER SIDE SEAT WARMER IGNITED A FIRE AND BURNED THROUGH THE SEAT. THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO THE DEALER FOR THE REPAIR. THE MANUFACTURER WAS CONTACT WHO STATED THAT THEY WOULD DISCUSS THE REPAIRS WITH THE DEALER AND GIVE HIM A RETURN CALL ON THE REPAIR COSTS. THE FAILURE MILEAGE WAS 81,500.
NHTSA ODI #10397390
30,000 miles · Mar 17, 2011
Fuel System, Diesel
TL*THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT GLS TDI. THE ENGINE BEGAN TO RATTLE VIOLENTLY IMMEDIATELY AFTER THE VEHICLE WAS STARTED. THE NOISE SOUNDED LIKE MARBLES ROLLING AROUND IN THE ENGINE COMPARTMENT. THE NOISE WAS LOUDER DURING START UP AND WHILE DRIVING LOWER SPEEDS. THE VEHICLE WAS TAKEN TO THE DEALER FOR THE FAILURE WH…
Read full complaint
TL*THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT GLS TDI. THE ENGINE BEGAN TO RATTLE VIOLENTLY IMMEDIATELY AFTER THE VEHICLE WAS STARTED. THE NOISE SOUNDED LIKE MARBLES ROLLING AROUND IN THE ENGINE COMPARTMENT. THE NOISE WAS LOUDER DURING START UP AND WHILE DRIVING LOWER SPEEDS. THE VEHICLE WAS TAKEN TO THE DEALER FOR THE FAILURE WHO REPLACED THE GLOW PLUGS AND FUEL FILTERS; HOWEVER, THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC AND WHO ADVISED HIM THAT THE BALANCE SHAFT ASSEMBLY NEEDED TO BE REPLACED WITH A REDESIGNED BALANCE SHAFT ASSEMBLY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 70,000.
NHTSA ODI #10390527
70,000 miles · Mar 3, 2011
Electrical SystemFire
WHILE DRIVING MY 2005 VW PASSAT STATION WAGON FOR ABOUT 10 MINUTES, THE CHECK ENGINE LIGHT FLASHED. AS I WAS PULLING TO THE SIDE OF THE ROAD, THE BATTERY LIGHT CAME ON. I TURNED THE CAR OFF AND IMMEDIATELY NOTICED WHITE SMOKE COMING FROM THE HOOD OF THE ENGINE, AS WELL AS A BROWN BURN CIRCLE. I GOT MYSELF AND MY DAUGHTER …
Read full complaint
WHILE DRIVING MY 2005 VW PASSAT STATION WAGON FOR ABOUT 10 MINUTES, THE CHECK ENGINE LIGHT FLASHED. AS I WAS PULLING TO THE SIDE OF THE ROAD, THE BATTERY LIGHT CAME ON. I TURNED THE CAR OFF AND IMMEDIATELY NOTICED WHITE SMOKE COMING FROM THE HOOD OF THE ENGINE, AS WELL AS A BROWN BURN CIRCLE. I GOT MYSELF AND MY DAUGHTER OUT OF THE VEHICLE, AND CALLED 911. WITHIN 2-3 MINUTES, THE ENTIRE ENGINE WAS ENGULFED IN FLAMES. THE FIREMEN INFORMED ME THAT THEY BELIEVE IT STARTED WITH/NEAR THE BATTERY. IT WAS CONSIDERED AN ELECTRICAL FIRE. THE CAR HAD NOT BEEN ACTING UP, NOR HAD THE CHECK ENGINE LIGHT BEEN COMING ON IN RECENT WEEKS OR MONTHS. THE CAR IS A COMPLETE LOSS. THE VW PASSAT WAS ONLY 6 YRS OLD, WITH LESS THAN 70,000 MILES ON IT. REGULAR TUNE-UPS AND MAINTENANCE WAS PERFORMED ON THIS VEHICLE. IT WAS SHOCKING HOW QUICKLY IT WENT UP IN FLAMES. *TR
NHTSA ODI #10386280
168,000 miles · Feb 16, 2011
Engine And Engine Cooling
OIL PUMP FAILURE LEADING TO ENGINE FALUE. REQUIRING ENGINE REPLACEMENT.*TR
NHTSA ODI #10383006
71,430 miles · Jan 31, 2011
Electrical System
I PURCHASED A NEW 2005 VW PASSAT AND NEEDED TO HAVE TWO OF THE IGNITION COILS REPLACED. IN BOTH SITUATIONS, THE CAR SUDDENLY LOST POWER CREATING A DANGEROUS SITUATION. IN ADDITION TO LOSING POWER, THE CHECK ENGINE LIGHT STARTING FLASHING AND I NEEDED TO EXIT THE ROADWAY. I DISPOSED OF THAT VEHICLE AND PURCHASED A CERTIFIED PR…
Read full complaint
I PURCHASED A NEW 2005 VW PASSAT AND NEEDED TO HAVE TWO OF THE IGNITION COILS REPLACED. IN BOTH SITUATIONS, THE CAR SUDDENLY LOST POWER CREATING A DANGEROUS SITUATION. IN ADDITION TO LOSING POWER, THE CHECK ENGINE LIGHT STARTING FLASHING AND I NEEDED TO EXIT THE ROADWAY. I DISPOSED OF THAT VEHICLE AND PURCHASED A CERTIFIED PRE-OWNED 2005 VW PASSAT 4 MOTION. I HAVE NOW HAD TO HAVE ONE OF THE IGNITION COILS REPLACED. AGAIN I WAS DRIVING ALONG AND THE VEHICLE SUDDENLY LOST POWER AND STARTED RUNNING VERY ROUGH. THIS TIME I WAS IN AN AREA WITH VERY LITTLE POPULATION AND A SEVERE SNOW STORM WITHOUT CELL SERVICE. *TR
NHTSA ODI #10379727
14,015 miles · Jan 12, 2011
Power Train
TL*THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE VEHICLE SUDDENLY STALLED WHILE SHE WAS DRIVING AT A VERY LOW SPEED; SHE ALSO COULD NOT SHIFT INTO REVERSE OR DRIVE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO STATED THAT THE FAILURE WAS LOCATED AT THE FRONT AND REAR AXLE. THE VEHICLE WAS REPAIRED A…
Read full complaint
TL*THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE VEHICLE SUDDENLY STALLED WHILE SHE WAS DRIVING AT A VERY LOW SPEED; SHE ALSO COULD NOT SHIFT INTO REVERSE OR DRIVE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO STATED THAT THE FAILURE WAS LOCATED AT THE FRONT AND REAR AXLE. THE VEHICLE WAS REPAIRED AT A LOCAL REPAIR SHOP. THE FAILURE MILEAGE WAS 14,015 AND THE CURRENT MILEAGE WAS 18,000. UPDATED 06/17/11*LJ UPDATED 06/21/11
NHTSA ODI #10376435
141,000 miles · Dec 21, 2010
Engine And Engine Cooling
EXCESSIVE AND INCREASED RATTLING NOISE NOTICED ON MY 2005 PASSAT TDI. EVALUATION REVEALED THAT THE CHAIN AND TENSIONER DRIVING THE BALANCE SHAFTS AND OIL PUMP WAS FAILING AND NEEDED REPLACEMENT. SERVICE TECHNICIAN STATES THAT THIS IS A COMMON PROBLEM AND VW HAS ISSUED A GEAR DRIVE TO REPLACE THE CHAIN, HOWEVER THERE IS NO RECA…
Read full complaint
EXCESSIVE AND INCREASED RATTLING NOISE NOTICED ON MY 2005 PASSAT TDI. EVALUATION REVEALED THAT THE CHAIN AND TENSIONER DRIVING THE BALANCE SHAFTS AND OIL PUMP WAS FAILING AND NEEDED REPLACEMENT. SERVICE TECHNICIAN STATES THAT THIS IS A COMMON PROBLEM AND VW HAS ISSUED A GEAR DRIVE TO REPLACE THE CHAIN, HOWEVER THERE IS NO RECALL OR TSB THEREFORE THE COST OF THE REPAIR IS THE OWNER'S RESPONSIBILITY. OVER $2000 TO REPAIR. *TR
NHTSA ODI #10372009
100,000 miles · Nov 30, 2010
Engine And Engine Cooling
TL*THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT SHE COULD HEAR A CHAIN NOISE WHILE DRIVING AT ANY SPEED. AFTER A YEAR, THE NOISE BECAME LOUDER. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE BALANCE CHAIN WOULD BREAK SOON. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE…
Read full complaint
TL*THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT SHE COULD HEAR A CHAIN NOISE WHILE DRIVING AT ANY SPEED. AFTER A YEAR, THE NOISE BECAME LOUDER. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE BALANCE CHAIN WOULD BREAK SOON. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 117,000. UPDATED 01/24/11 *BF UPDATED 04/14/11
NHTSA ODI #10368304
Mileage unknown · Nov 11, 2010
Power Train
VOLKSWAGEN PASSAT PASSENGER VEHICLE MODEL YEAR 2004 AND 2005 WITH 2.0L DIESEL TDI ENGINE. BALANCE SHAFT AND OIL PUMP ARE DRIVEN WITH A CHAIN MECHANISM WHICH HAS A HISTORY OF FAILURE WITH LESS THAN 100,000 MILES USAGE. THIS PROMPTED A DESIGN CHANGE AND A RECALL OF AFFECTED VEHICLES IN EUROPE. NO RECALL IN NORTH AMERICA. RECALLED…
Read full complaint
VOLKSWAGEN PASSAT PASSENGER VEHICLE MODEL YEAR 2004 AND 2005 WITH 2.0L DIESEL TDI ENGINE. BALANCE SHAFT AND OIL PUMP ARE DRIVEN WITH A CHAIN MECHANISM WHICH HAS A HISTORY OF FAILURE WITH LESS THAN 100,000 MILES USAGE. THIS PROMPTED A DESIGN CHANGE AND A RECALL OF AFFECTED VEHICLES IN EUROPE. NO RECALL IN NORTH AMERICA. RECALLED VEHICLES IN OTHER AREAS OF THE WORLD WERE RETROFIT WITH A GEAR DRIVE MECHANISM THAT IS RELIABLE. FAILURE OCCURS WITHOUT WARNING AND WILL RESULT IN IMMEDIATE LOSS OF OIL PRESSURE AND RAPID ENGINE DAMAGE INCLUDING POSSIBLY ENGINE SEIZURE. IF THIS WERE TO OCCUR AT HIGHWAY SPEEDS IT WOULD BE A CLEAR SAFETY HAZARD. *TR
NHTSA ODI #10365378
60,000 miles · Nov 8, 2010
Structure
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT UPON ARRIVING TO HIS RESIDENCE, HE DISCOVERED THAT THE GRILL OF THE VEHICLE WAS MISSING. THE DEALER WAS CONTACTED AND SENT HIM A REPLACEMENT. THE CONTACT INSTALLED A REPLACEMENT GRILL AND WITHIN A FEW DAYS, THE FAILURE RECURRED AND THE GRILL FRACTURED FROM TH…
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT UPON ARRIVING TO HIS RESIDENCE, HE DISCOVERED THAT THE GRILL OF THE VEHICLE WAS MISSING. THE DEALER WAS CONTACTED AND SENT HIM A REPLACEMENT. THE CONTACT INSTALLED A REPLACEMENT GRILL AND WITHIN A FEW DAYS, THE FAILURE RECURRED AND THE GRILL FRACTURED FROM THE VEHICLE. THE DEALER ACKNOWLEDGED THAT THEY WERE HAVING PROBLEMS WITH THE GRILL STAYING ON THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 60,000.
NHTSA ODI #10364986
Official recalls
3Apr 7, 2008
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
Consequence & remedy
Consequence: A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Dec 15, 2004
ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
Remedy: DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA11002 · Engine Compartment Fire
Opened Jan 26, 2011 · Closed Feb 17, 2012
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Additional source detail variants (2)
Electrical System
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Illustration