NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
148 reports108,269 miles · Sep 12, 2013
Tires
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE VEHICLE WAS EQUIPPED WITH YOKOHAMA TIRES 8VID IN VIGOR 205/55/16. THE DOT NUMBER WAS NOT AVAILABLE. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE DRIVER'S SIDE REAR TIRE POPPED AND HE PULLED OVER TO THE SIDE OF THE ROAD AND CALLED AAA FOR ASSISTANCE. THE VEHICLE WAS TAKEN T…
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE VEHICLE WAS EQUIPPED WITH YOKOHAMA TIRES 8VID IN VIGOR 205/55/16. THE DOT NUMBER WAS NOT AVAILABLE. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE DRIVER'S SIDE REAR TIRE POPPED AND HE PULLED OVER TO THE SIDE OF THE ROAD AND CALLED AAA FOR ASSISTANCE. THE VEHICLE WAS TAKEN TO THE TIRE SHOP WHERE THE TIRE WAS PURCHASED AND THE MECHANIC STATED THAT THEY HAVEN'T SEEN ANY PROBLEMS WITH THE TIRE. THE MANUFACTURER WAS AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 108,269.
NHTSA ODI #10543264
143,000 miles · Apr 5, 2013
EnginePower Train
ON 3/23/13, WHEN TURNING LEFT IN TRAFFIC, THE "SEALED FOR LIFE" 5-SPD AUTO TRANSMISSION MADE AN INCREDIBLY HARD SHIFT, BEGAN SLIPPING BADLY, AND QUICKLY LOST 3 FWD SPEEDS, "LIMPING" IN FOR SERVICE. NORMALLY, A TRANS FAILURE AT 143K WOULD NOT PROMPT AN NHTSA COMPLAINT. IT IS NOT THE CAR, BUT RATHER VWOA AND ITS DEALER NETWORK, …
Read full complaint
ON 3/23/13, WHEN TURNING LEFT IN TRAFFIC, THE "SEALED FOR LIFE" 5-SPD AUTO TRANSMISSION MADE AN INCREDIBLY HARD SHIFT, BEGAN SLIPPING BADLY, AND QUICKLY LOST 3 FWD SPEEDS, "LIMPING" IN FOR SERVICE. NORMALLY, A TRANS FAILURE AT 143K WOULD NOT PROMPT AN NHTSA COMPLAINT. IT IS NOT THE CAR, BUT RATHER VWOA AND ITS DEALER NETWORK, THAT ARE THE PROBLEM. MY LOCAL DEALER REFUSED TO CHECK AUTO TRANS FLUID LEVEL, AND WOULD ONLY GRUDGINGLY DO A FLUID CHANGE IF I WANTED, FOR AN EXTORTIONATE $700, STEADFASTLY MAINTAINING THAT NEITHER WAS NECESSARY. VWOA TODAY 4/5/13, IRONICALLY, CRITICIZED ME FOR NOT FOLLOWING THE OWNER'S MANUAL RECOMMENDATION OF CHECKING FLUID EVERY 40K MILES. LOCAL DEALER WANTED OVER $4400 + MISC FEES & TAX TO REPLACE THE TRANS. AT THE SAME TIME, THEY INDICATED MY NEW TIRES WITH 500 MILES ON THEM WERE IN A MARGINAL TREAD WEAR CONDITION. DITTO THE RECENTLY RENEWED (AT THE SAME DEALER!) REAR BRAKES. BTW, THE TRANSMISSION MANUFACTURER, ZF, RECOMMENDS COMMUNICATING TO CUSTOMERS THE BENEFITS OF FLUID CHANGES AT 50K MILE INTERVALS. VW WON'T LISTEN TO EITHER CUSTOMER OR TRANS MFR. TRANS WAS REBUILT AT QUALIFIED INDEPENDENT SHOP. THERE WAS ALSO AN EARLIER RECALL (THANKS, NHTSA!) OF CERAMIC GLOW PLUGS THAT WOULD FALL INTO CYLINDERS AND CAUSE CATASTROPHIC DAMAGE. FORTUNATELY, I HAD THE REPAIR DONE INDEPENDENTLY, AS THIS CONDITION WAS KNOWN FOR AT LEAST 2 YRS BEFORE VW'S OFFICIAL RESPONSE. VW DID COMPENSATE ME FOR THIS, BUT I WONDER HOW MANY $9K ENGINES WERE DESTROYED WHILE VW CONTEMPLATED ITS COLLECTIVE NAVEL. BTW, AFTER THE OFFICIAL VW FIX (DONE AT DEALER), THE CAR STARTS IN WINTER LIKE A 1980 RABBIT DIESEL. I FITTED A ZEROSTART AS CORRECTIVE MEASURE. VW ALSO REFUSES TO DISCUSS THE BALANCE SHAFT CHAIN DRIVE ISSUE WITH ME. A TICKING TIME BOMB AT 143K. THEY KNOW IT. I KNOW IT. NHTSA, PLEASE TAKE VWOA TO TASK! AS FOR ME, I'M NOW SHOPPING COMPETITORS. *TR
NHTSA ODI #10507306
63,507 miles · Jan 29, 2013
Electrical SystemExterior Lighting
BRAKE LIGHTS REMAINED ON WITHOUT BRAKE PEDAL PRESSURE, AND REMAINED ON AFTER TURNING OFF IGNITION. I INVESTIGATED PRIOR RECALLS AND SAW: REPORT RECEIPT DATE: FEB 20, 2007 NHTSA CAMPAIGN NUMBER: 07V063000 COMPONENT(S): EXTERIOR LIGHTING I WENT TO LOCAL VW FOR RECALL REPAIR AND WAS TOLD THAT BRAKE LIGHT REPAIR WAS ALREA…
Read full complaint
BRAKE LIGHTS REMAINED ON WITHOUT BRAKE PEDAL PRESSURE, AND REMAINED ON AFTER TURNING OFF IGNITION. I INVESTIGATED PRIOR RECALLS AND SAW: REPORT RECEIPT DATE: FEB 20, 2007 NHTSA CAMPAIGN NUMBER: 07V063000 COMPONENT(S): EXTERIOR LIGHTING I WENT TO LOCAL VW FOR RECALL REPAIR AND WAS TOLD THAT BRAKE LIGHT REPAIR WAS ALREADY PERFORMED IN 2004, SO THIS REPAIR WAS NO LONGER COVERED. ( I AM SECOND OWNER, SO COULD NOT CONFIRM.) A 2004 REPAIR ON A 2005 MODEL YEAR CAR FOR A RECALL ISSUED IN 2007? THE BRAKE SWITCH REPLACEMENT COST $176. IS THIS NOT THE SAME RECALL FAILURE AGAIN? I HAVE HAD MANY CARS AND HAVE NEVER HAD A SINGLE BRAKE LIGHT SWITCH FAIL, EXCEPT FOR THIS VW, WHICH AS OF TODAY HAS HAD THREE! (ORIGINAL, 2004 REPLACEMENT AND NOW 2013 REPLACEMENT.) IS THE RECALL STILL IN EFFECT? SHOULD I HAVE TO PAY FOR AN OBVIOUSLY DEFECTIVE PART REPLACEMENT? *TR
NHTSA ODI #10495088
130,000 miles · Jan 14, 2013
EngineVisibility
THE INTERIOR HEATER DOES NOT WORK CORRECTLY. WE TOOK THE VEHICLE TO A VW MECHANIC OASIS AUTO CENTER IN REDDING, CA. HE SAID HE CLEARED THE COIL BUT THAT A VALVE MAY ALSO BE PART OF THE PROBLEM. THIS OCCURRED IN NOVEMBER 2011. SINCE WE LIVE IN N. CALIFORNIA IT HAS NOT BEEN A BIG ISSUE SINCE IT IS WARM MOST OF THE YEAR. I DID HOWE…
Read full complaint
THE INTERIOR HEATER DOES NOT WORK CORRECTLY. WE TOOK THE VEHICLE TO A VW MECHANIC OASIS AUTO CENTER IN REDDING, CA. HE SAID HE CLEARED THE COIL BUT THAT A VALVE MAY ALSO BE PART OF THE PROBLEM. THIS OCCURRED IN NOVEMBER 2011. SINCE WE LIVE IN N. CALIFORNIA IT HAS NOT BEEN A BIG ISSUE SINCE IT IS WARM MOST OF THE YEAR. I DID HOWEVER SEE THIS IS A RECALL ITEM. PLEASE ADVISE ME IF WE CAN STILL GET THIS REPAIRED UNDER THE RECALL. *TR
NHTSA ODI #10492881
Mileage unknown · Oct 15, 2012
Fuel/propulsion System
MY 2005 PASSAT IS LEAKING GAS, LOCATION IS CLOSE TO THE REAR PASSENGER SIDE. I CALLED LOCAL VW DEALER (WHERE I PURCHASED CAR FROM ) ALONG WITH VW 800 NUMBER- BOTH TOLD ME THERE WAS NO RECALL. I TOOK THE VEHICLE TO MY LOCAL REPAIR PLACE WOODYS IN ANKENY, IOWA. THE MECHANIC CALLED ME BACK TO TELL ME THAT HE DID BELIEVE THERE WAS…
Read full complaint
MY 2005 PASSAT IS LEAKING GAS, LOCATION IS CLOSE TO THE REAR PASSENGER SIDE. I CALLED LOCAL VW DEALER (WHERE I PURCHASED CAR FROM ) ALONG WITH VW 800 NUMBER- BOTH TOLD ME THERE WAS NO RECALL. I TOOK THE VEHICLE TO MY LOCAL REPAIR PLACE WOODYS IN ANKENY, IOWA. THE MECHANIC CALLED ME BACK TO TELL ME THAT HE DID BELIEVE THERE WAS A RECALL 26E5-R5. I CALLED BACK VW AND HE TOLD ME THAT INDEED THERE WAS A PRIOR RECALL HOWEVER THE MECHANICS FIXED THE CAR PRIOR AND WOULD NOT FIX IT AGAIN. HE TOLD ME THAT I NEED TO HAVE THE CAR TOWED TO THE LOCAL VW MECHANIC, PAY FOR THE TOW, PAY FOR THE DIAGNOSTIC SCREENING TO DETERMINE IF THERE IS A TRUE GAS LEAK SIMILAR TO THE ONE THAT WAS RECALLED/FIXED, THEN VW WOULD POSSIBLY CONSIDER COVERING THE CHARGES. I'M LEFT PAYING FOR 2 TOWS NOW (ONE TO THE PLACE ITS AT SINCE THEY TOLD ME IN THE FIRST PLACE IT WASN'T COVERED) AND THEN A TOW TO VW, PLUS THE DIAGNOSTIC APPOINTMENT, AND POSSIBLY THE ENTIRE COST TO FIX IT, IF VW DECIDES THEY DON'T WANT TO COVER THE COST AGAIN. THERE WAS A RECALL, THE RECALL OBVIOUSLY WAS SUPPOSED TO BE FIXED AND THEY DID A POOR JOB, MY CAR IS LEAKING FUEL OUT OF IT (RAW FUEL) AND SMELLS HORRIBLE, AND THEY WANT ME TO 'CHECK' TO SEE IF THERE IS AN ISSUE AND POSSIBLY PAY TO FIX IT. THIS DOESN'T SEEM RIGHT. *TR
NHTSA ODI #10480185
125,000 miles · May 8, 2012
Engine And Engine Cooling
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING 30 MPH. THE VEHICLE WAS TOWED TO THE DEALER FOR A DIAGNOSIS. THE DEALER STATED THAT THEY HAD TO REPLACE THE ENGINE. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS CONTACTED STATED THAT THEY WERE NOT RESPONSIBLE FOR T…
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING 30 MPH. THE VEHICLE WAS TOWED TO THE DEALER FOR A DIAGNOSIS. THE DEALER STATED THAT THEY HAD TO REPLACE THE ENGINE. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS CONTACTED STATED THAT THEY WERE NOT RESPONSIBLE FOR THE REPAIRS BECAUSE THE VEHICLE WAS NOT UNDER RECALL. THE FAILURE AND CURRENT MILEAGES WERE 125,000. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10457776
100,000 miles · Mar 20, 2012
Engine And Engine Cooling
I WAS DRIVING ON HIGHWAY WHEN THE ALARM MESSAGE "OIL PRESSURE LOW: STOP ENGINE" CAME ON. I GOT OFF THE SIDE OF THE ROAD AND THE ENGINE LOCKED UP. BENT VALVES, BROKEN PISTON SHAFT, ENGINE NEEDS REPLACED. I'VE SEEN THIS SO MANY TIMES ON THE INTERNET AS I'VE BEEN LOOKING INTO MY OPTIONS SINCE THEN. VOLKSWAGEN WILL DO NOTHING TO HEL…
Read full complaint
I WAS DRIVING ON HIGHWAY WHEN THE ALARM MESSAGE "OIL PRESSURE LOW: STOP ENGINE" CAME ON. I GOT OFF THE SIDE OF THE ROAD AND THE ENGINE LOCKED UP. BENT VALVES, BROKEN PISTON SHAFT, ENGINE NEEDS REPLACED. I'VE SEEN THIS SO MANY TIMES ON THE INTERNET AS I'VE BEEN LOOKING INTO MY OPTIONS SINCE THEN. VOLKSWAGEN WILL DO NOTHING TO HELP NOR TAKE RESPONSIBILITY. THEY OFFERED ME $1000 TOWARD A NEW VOLKSWAGEN. SERIOUSLY? I HAVE MAINTAINED THE VEHICLE. THEY KNOW THERE IS A PROBLEM WITH THESE CARS AND AS FAR AS I'M CONCERNED, IT IS CRIMINAL TO SELL THESE WITHOUT RECALLING TO FIX THE PROBLEM. IF I WASN'T ABLE TO GET OFF THE HIGHWAY, OUTSIDE OF CHICAGO, MY PASSENGER AND I WOULD HAVE BEEN SMASHED WITH COUNTLESS OTHER INJURIES. I DIDN'T STOP THE CAR ONCE I GOT OFF THE ROAD, IT STOPPED ITSELF. VOLKSWAGEN NEEDS TO BE ACCOUNTABLE FOR THEIR PRODUCTS. *KB
NHTSA ODI #10452405
120,000 miles · Mar 10, 2012
Engine And Engine Cooling
2.0L VW PASSAT TDI HAD A RATTLING, VIBRATING CHAIN NOISE FROM THE OIL PUMP BALANCE SHAFT MODULE IN THE OIL PAN. THE OIL PUMP CHAINS/SPROCKETS/TENSIONERS WERE WORN AND CAUSED NOTICEABLE VIBRATION AND RATTLING NOISE FOR THOUSANDS OF MILES; HOWEVER, IT WAS DIFFICULT TO DIAGNOSE. WE HAD THE ENTIRE OIL PUMP ASSEMBLY REPLACED BY A VW …
Read full complaint
2.0L VW PASSAT TDI HAD A RATTLING, VIBRATING CHAIN NOISE FROM THE OIL PUMP BALANCE SHAFT MODULE IN THE OIL PAN. THE OIL PUMP CHAINS/SPROCKETS/TENSIONERS WERE WORN AND CAUSED NOTICEABLE VIBRATION AND RATTLING NOISE FOR THOUSANDS OF MILES; HOWEVER, IT WAS DIFFICULT TO DIAGNOSE. WE HAD THE ENTIRE OIL PUMP ASSEMBLY REPLACED BY A VW DEALERSHIP AT APPROXIMATELY 120,000 MILES WITH OEM GEAR DRIVEN PUMP WHICH INCLUDES THE BALANCE SHAFTS AND OIL PUMP. IT WAS A $3700 REPAIR TO EXCHANGE THE ORIGINAL OIL PUMP WITH THE GEAR DRIVEN PUMP. NOT A CHEAP SERVICE. THE SOUND BEFORE AND AFTER THE MODULE CHANGE WAS MUCH IMPROVED BECAUSE THE GEARS ARE QUIETER. THE REPLACEMENT GEAR DRIVEN OIL PUMP/BALANCE SHAFT ASSEMBLY USES A SIMILAR BALANCE SHAFT BUT WITH A DIFFERENT OIL PUMP AND GEAR DRIVE. THE GEAR DRIVE SMOOTHES OUT STRESS ON THE OIL PUMP HEX SHAFT SO RUNS MUCH BETTER. IN SUMMARY, I AM NOT HAPPY WITH HAVING TO DO SUCH AN EXPENSIVE REPAIR DUE TO A POOR DESIGN AT THE LOW MILEAGE OF 120,000 FOR A DIESEL THAT SHOULD LAST TO AT LEAST 400,000 MILES. THIS IS A RECURRING EXPENSIVE PROBLEM THAT SHOULD BE REIMBURSED BY VW. *TR
NHTSA ODI #10451066
Mileage unknown · Mar 7, 2012
Power Train
I RECENTLY HAD ISSUE WITH THE TORQUE CONVERTER LEAKING AND FAILED, I RESEARCH THIS ONLINE TO SEE IF IWAS THE ONLY ONE HAVING THIS ISSUE, BUT THERE ARE HUNDREDS OF PEOPLE OUT THERE WITH THE SAME ISSUE. I WOULD LIKE VW TO RECALL THEIR VW PASSAT TDI FOR THEIR TORQUE CONVERTER FAILURE. THIS SHOULD NOT GO OUT FOR SOMETHING RIGHT AFT…
Read full complaint
I RECENTLY HAD ISSUE WITH THE TORQUE CONVERTER LEAKING AND FAILED, I RESEARCH THIS ONLINE TO SEE IF IWAS THE ONLY ONE HAVING THIS ISSUE, BUT THERE ARE HUNDREDS OF PEOPLE OUT THERE WITH THE SAME ISSUE. I WOULD LIKE VW TO RECALL THEIR VW PASSAT TDI FOR THEIR TORQUE CONVERTER FAILURE. THIS SHOULD NOT GO OUT FOR SOMETHING RIGHT AFTER THE MANUFACTURE WARRANTY. SOME ALREADY HAS ISSUE WHEN IT WAS ONLY 51,000 MILES. HERE ARE SOME OF THE WEBSITE, WHICH REPORTED THE TC PROBLEM FROM INDIVIDUAL OWNERS LIKE MYSELF: HTTP://FORUMS.TDICLUB.COM/SHOWTHREAD.PHP?T=307836 HTTP://WWW.PASSATWORLD.COM/FORUMS/68-B5-GARAGE/327420-GOT-P0741-TORQUE-CONVERTER-CLUTCH-CIRCUIT-CODE-MY-NEW-B5-5-TDI-PASSAT.HTML. *TR
NHTSA ODI #10450601
82,000 miles · Feb 29, 2012
Engine And Engine Cooling
THE TDI (DIESEL) ENGINE IN THE '04 & '05 NORTH AMERICAN VOLKSWAGEN PASSATS WAS EQUIPPED WITH A CHAIN DRIVEN OIL PUMP/BALANCE SHAFT MODULE. THE CHAIN TENSIONER FAILS CAUSING THE CHAIN TO SEPARATE WHICH STOPS THE OIL PUMP AND DESTROYS THE ENGINE. IF A PERSON IS LUCKY, LIKE I WAS, AND HEARS THE CHAIN NOISE BEFORE IT FAILS, THE ENG…
Read full complaint
THE TDI (DIESEL) ENGINE IN THE '04 & '05 NORTH AMERICAN VOLKSWAGEN PASSATS WAS EQUIPPED WITH A CHAIN DRIVEN OIL PUMP/BALANCE SHAFT MODULE. THE CHAIN TENSIONER FAILS CAUSING THE CHAIN TO SEPARATE WHICH STOPS THE OIL PUMP AND DESTROYS THE ENGINE. IF A PERSON IS LUCKY, LIKE I WAS, AND HEARS THE CHAIN NOISE BEFORE IT FAILS, THE ENGINE CAN BE SAVED. THE FIX INVOLVES INSTALLING A NEW GEAR DRIVEN BALANCE SHAFT MODULE WHICH CONTAINS A NEW OIL PUMP. THE REPAIRS COSTS ~ $2,500 PARTS AND LABOR. VOLKSWAGEN HAS IGNORED THIS FAULT IN THE US (AND CANADA), DENYING THE PROBLEM EXISTS, EVEN THOUGH HUNDREDS OF CASES OF FAILURE HAVE BEEN DOCUMENTED. IN FACT, THE NEW DESIGN MODULES ARE CURRENTLY ON BACK ORDER AT THE VW PARTS FACTORY. THE OIL PUMP CHAIN DRIVE PROBLEM IS WITHOUT A DOUBT A DEFECT. THE FACT THAT VW RE-ENGINEERED AND REPLACED THE ORIGINAL OIL PUMP DRIVE ASSEMBLY IS AN ADMISSION THAT THE DESIGN WAS DEFECTIVE. REFERENCE VW'S TECHNICAL PRODUCT INFORMATION NO. 2016429/2 DATED 29-JAN-2008. I SEE THIS AS A HUGE SAFETY CONCERN. I CAN ONLY IMAGINE WHAT WOULD HAPPEN IF ONE OF THESE CHAINS FAILED, ON THE HIGHWAY DURING FREEWAY RUSH HOUR TRAFFIC, CAUSING THE ENGINE TO DESTROY ITSELF AND SPILL OIL AND OTHER FLUIDS ONTO THE ROAD SURFACE. PLEASE FEEL FREE TO CONTACT ME IF YOU REQUIRE ANY FURTHER INFORMATION. *TR
NHTSA ODI #10449751
NHTSA investigations
3EA11002 · Engine Compartment Fire
Opened Jan 26, 2011 · Closed Feb 17, 2012
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Additional source detail variants (2)
Electrical System
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Illustration