NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
148 reports155,000 miles · May 27, 2016
Power TrainVehicle Speed Control
I DECIDED TO CHANGE THE OIL MYSELF IN MY CAR, SINCE I WANTED TO SAVE MONEY AND I KNEW WHAT I WAS DOING. INSTEAD OF DRAINING THE OIL, I ACCIDENTALLY DRAINED THE TRANSMISSION FLUID. I DIDN'T FIGURE OUT THAT IT WAS TRANSMISSION FLUID BECAUSE IT LOOKED LIKE OIL! SO, THIS IS WHAT HAPPENED AFTER; I DROVE HOME (NOT KNOWING THERE WAS…
Read full complaint
I DECIDED TO CHANGE THE OIL MYSELF IN MY CAR, SINCE I WANTED TO SAVE MONEY AND I KNEW WHAT I WAS DOING. INSTEAD OF DRAINING THE OIL, I ACCIDENTALLY DRAINED THE TRANSMISSION FLUID. I DIDN'T FIGURE OUT THAT IT WAS TRANSMISSION FLUID BECAUSE IT LOOKED LIKE OIL! SO, THIS IS WHAT HAPPENED AFTER; I DROVE HOME (NOT KNOWING THERE WAS NO TRANNY FLUID IN IT) AND I NOTICED THAT THE CAR WANTED TO TAKE OFF BY ITSELF. IT KEPT DOING TIS TWO OR THREE MORE TIMES WHEN IT BECAME STUCK IN 4TH GEAR. I MANAGED TO SAFELY GET HOME, AND FIGURED OUT WHAT HAPPENED. I AM REPORTING THIS BECAUSE THIS IS A DESIGN FLAW!!! THE TRANSMISSION FLUID DRAIN HOLE IS WHERE THE ENGINE OIL DRAIN HOLE SHOULD BE! LUCKILY, AFTER I PUT FRESH TRANNY FLUID IN IT, THE CAR WAS FINE. I WONDER HOW MANY OTHER PEOPLE THIS HAPPENED TO.
NHTSA ODI #10871277
185,000 miles · Apr 29, 2016
Unknown Or Other
CAR HAD INTERMITTENT STARTING ISSUES FOR ABOUT 6 MONTHS. ENGINE CRANKS BUT DOES NOT TURN OVER. WILL EVENTUALLY RESTART ANYWHERE FROM 15MIN - 5 HRS LATER. LENGTH SEEMS TO BE DEPENDENT ON HOW LONG WAS DRIVEN BEFORE TURNING OFF. CODE SAID THE CPS WAS FAULTY. REPLACED IT. BUT STILL HAVING RANDOM PROBLEMS AND CODE STILL SAYS CPS IS F…
Read full complaint
CAR HAD INTERMITTENT STARTING ISSUES FOR ABOUT 6 MONTHS. ENGINE CRANKS BUT DOES NOT TURN OVER. WILL EVENTUALLY RESTART ANYWHERE FROM 15MIN - 5 HRS LATER. LENGTH SEEMS TO BE DEPENDENT ON HOW LONG WAS DRIVEN BEFORE TURNING OFF. CODE SAID THE CPS WAS FAULTY. REPLACED IT. BUT STILL HAVING RANDOM PROBLEMS AND CODE STILL SAYS CPS IS FAULTY. CANNOT GET IT FIXED BECAUSE CAN'T RECREATE PROBLEM AT MECHANICS. CAR DOES NOT DIE WHEN DRIVING. THERE DOES SEEM TO BE FLUCTUATIONS IN SPEED WHILE DRIVING. AND DOES SEEM TO BE WORSE IN RAINY WEATHER. CAR DOESN'T RUN HOT. ANYBODY ELSE HAVE THE SAME PROBS? HOW DID YOU FIX?
NHTSA ODI #10862284
95,900 miles · Mar 2, 2016
EngineUnknown Or OtherFire
CAR WAS STARTED AT 9:30AM AT HOME- LAST DRIVEN NIGHT BEFORE LOCALLY. CAR WAS DRIVEN @ 1 MILE, PARKED, ENGINE TURNED OFF, DOORS LOCKED AND LEFT IN PARKING LOT. AT 9:49 THE LOCAL POLICE CALLED ME TO ALERT ME THAT MY CAR WAS ON FIRE. THERE IS FOOTAGE OF THE FIRE ON YOUTUBE. HTTPS://WWW.YOUTUBE.COM/WATCH?V=IQBNDFDJPAG THE ENGINE…
Read full complaint
CAR WAS STARTED AT 9:30AM AT HOME- LAST DRIVEN NIGHT BEFORE LOCALLY. CAR WAS DRIVEN @ 1 MILE, PARKED, ENGINE TURNED OFF, DOORS LOCKED AND LEFT IN PARKING LOT. AT 9:49 THE LOCAL POLICE CALLED ME TO ALERT ME THAT MY CAR WAS ON FIRE. THERE IS FOOTAGE OF THE FIRE ON YOUTUBE. HTTPS://WWW.YOUTUBE.COM/WATCH?V=IQBNDFDJPAG THE ENGINE IGNITED FOR UNKNOWN REASON. THIS CAR IN UN-REPAIRABLE, THERE IS NO INSURANCE CLAIM. RECEIPTS FOR WORK PERFORMED ON THIS VEHICLE AT THE TIME OF PURCHASE AND RECENT REPAIR DOCUMENTATION IS AVAILABLE. CAR PURCHASE BILL OF SALE, RECEIPT FOR TITLE AND REGISTRATION AND COST FOR INSURING THIS VEHICLE SINCE TIME OF PURCHASE ARE ALL AVAILABLE.
NHTSA ODI #10839433
143,000 miles · Dec 31, 2015
Fuel/propulsion SystemUnknown Or Other
THIS IS THE 4 TH TIME I HAVE HAD THE CHECK ENGINE LIGHT COME ON ALONG WITH MISFIRE ISSUES. EACH TIME COSTING ME AT LEAST 2000.00 TO CORRECT ONLY FOR A SHORT TIME. HAVE CHANGED OIL PUMP, PLUGS, INJECTORS JUST TO NAME A FEW. I LOVE MY CAR BUT THIS HAS BEEN A MONEY PIT FROM DAY ONE. VW NEEDS TO BE HELD RESPONSIBLE FOR THESE ISSUES.…
Read full complaint
THIS IS THE 4 TH TIME I HAVE HAD THE CHECK ENGINE LIGHT COME ON ALONG WITH MISFIRE ISSUES. EACH TIME COSTING ME AT LEAST 2000.00 TO CORRECT ONLY FOR A SHORT TIME. HAVE CHANGED OIL PUMP, PLUGS, INJECTORS JUST TO NAME A FEW. I LOVE MY CAR BUT THIS HAS BEEN A MONEY PIT FROM DAY ONE. VW NEEDS TO BE HELD RESPONSIBLE FOR THESE ISSUES. OIL SLUDGE, IS A BIG PROBLEM TOO. I JUST HAD THE TIMING BELT REPLACED WITH INJECTORS AND A NEW GASKET SET UP AND RAN GOOD FOR TWO MONTHS AND NOW I'M BACK IN THE SAME POSITION OF NEEDING THE SAME REPAIRS ONCE AGAIN. CAR WAS DRIVING BEGAN TO SHUTTER TRYING TO STALL. HELP!
NHTSA ODI #10817201
200,000 miles · Dec 22, 2015
Seats
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 70 MPH, THE SEAT HEATER BURNED A HOLE IN THE PASSENGER SEAT AND THE PASSENGER'S COAT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000. UPDATED 02/23/16*LJ THE CONS…
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 70 MPH, THE SEAT HEATER BURNED A HOLE IN THE PASSENGER SEAT AND THE PASSENGER'S COAT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000. UPDATED 02/23/16*LJ THE CONSUMER STATED THE VEHICLE WAS REPAIRED. UPDATED 03/30/16.*JB
NHTSA ODI #10811662
114,909 miles · Apr 15, 2015
Fuel/propulsion System
DRIVING HOME FROM WORK AND SMELL GAS COMEING FROM VENT INSIDE CAB NEXT DAY DROVE IT AGAIN AND STILL SMELL GAS EVEN ON OUTSIDE OF DRIVERSIDE. *TR
NHTSA ODI #10705983
142,000 miles · Oct 3, 2014
EngineSteering
VEHICLE ENGINE MADE UNUSUAL NOISE AND STOPPED RUNNING. STEERING AND BRAKES BECAME VERY DIFFICULT. COULD NOT RESTART ENGINE AND HEARD LOUD BANGING FROM ENGINE WHEN STARTER WAS TURNING ENGINE. HAD TO HAVE VEHICLE PUSHED OUT OF ROADWAY. INSPECTION OF ENGINE REVEALED THAT THE CRANKSHAFT HAD BROKEN. *TR
NHTSA ODI #10641279
187,000 miles · Sep 22, 2014
Engine
OUR PASSAT IS THE TDI (DIESEL) MODEL. WE PURCHASED IT USED AND AT AROUND 185,000-190,000 (LOW MILES BY DIESEL ENGINE STANDARDS), THE VEHICLE COMPLETELY SHUT DOWN WHILE BEING DRIVEN. I LOST POWER STEERING AND BRAKES. DIAGNOSTICS REVEALED THAT THE CHAIN DRIVEN OIL PUMP ASSEMBLY HAD MALFUNCTIONED. THE CHAIN BROKE AND GOT ALL UP IN …
Read full complaint
OUR PASSAT IS THE TDI (DIESEL) MODEL. WE PURCHASED IT USED AND AT AROUND 185,000-190,000 (LOW MILES BY DIESEL ENGINE STANDARDS), THE VEHICLE COMPLETELY SHUT DOWN WHILE BEING DRIVEN. I LOST POWER STEERING AND BRAKES. DIAGNOSTICS REVEALED THAT THE CHAIN DRIVEN OIL PUMP ASSEMBLY HAD MALFUNCTIONED. THE CHAIN BROKE AND GOT ALL UP IN THE ENGINE AND OIL WAS NO LONGER BEING PUMPED INTO THE ENGINE SO THE ENGINE WAS DESTROYED REQUIRING A COMPLETE ENGINE REPAIR. ABOUT 16,000 MILES LATER, I WAS DRIVING AND THE SAME EXACT THING HAPPENED. DID SOME RESEARCH AND FOUND OUT THAT THIS IS A VERY COMMON PROBLEM WITH THIS MODEL VEHICLE. VOLKSWAGEN HAS ISSUED AN INTERNAL TECHNICAL BULLETIN TELLING THE SERVICE DEPARTMENTS HOW TO FIX THE PROBLEM. THE FIX IS CHANGING OUT THE CHAIN DRIVEN ASSEMBLY WITH A GEAR DRIVEN ONE. THEY ALSO NEVER MADE ANOTHER MODEL WITH A CHAIN DRIVEN ASSEMBLY AFTER THAT MODEL YEAR. SO THEY BASICALLY ADMITTED THAT THIS IS A FAULTY SYSTEM YET WON'T ISSUE A RECALL. CHANGING OUT THE ASSEMBLY IS $1500 FOR THE PART ALONE AND IF YOU'RE CHANGING OUT THAT PART, THE CHANCES ARE GOOD IT'S BECAUSE IT FAILED AND YOU NOW HAVE A DESTROYED ENGINE AS WELL WHICH IS A SEVERAL THOUSAND DOLLAR JOB EVEN FOR A USED ENGINE. THERE IS NO WAY TO TELL WHEN IT'S GOING TO FAIL AND IT'S NOT PART OF ANY MAINTENANCE SCHEDULE. VOLKSWAGEN HAS TOLD ME THAT IT'S NOT A COMMON ENOUGH PROBLEM TO ISSUE A RECALL AND YET IT'S A COMMON ENOUGH PROBLEM TO HAVE TO ISSUE A TECHNICAL BULLETIN ABOUT IT. I FIND IT ABOMINABLE THAT THEY KNOW THIS HAS AND IS HAPPENING WITH THIS VEHICLE AND THEY ARE NOT LETTING PEOPLE KNOW ABOUT IT. EVEN IF THEY REFUSE TO PAY FOR IT TO BE FIXED, THE PUBLIC SHOULD BE AWARE THAT THEY ARE DRIVING A TICKING TIME BOMB. SOMEONE COULD GET KILLED IF THE ENGINE SHUT DOWN ON THEM WHILE TRAVELING AT HIGH SPEEDS ON A HIGHWAY. NO POWER STEERING. NO BRAKES. IT'S COMPLETELY UNETHICAL. *TR
NHTSA ODI #10638209
101,900 miles · Sep 19, 2014
Engine
LOW OIL PRESSURE DO TO SLUDGE BUILD UP. BOUGHT THE CAR AS A CERTIFIED PRE-OWNED VEHICLE. I BOUGHT IT AROUND 60K AND AT 100K I AM BEING TOLD THAT I NEED A NEW ENGINE. *TR
NHTSA ODI #10637575
189,000 miles · Sep 19, 2014
Air BagsService BrakesCrash
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE BRAKE PEDAL WOULD TRAVEL TO THE FLOOR WHEN DEPRESSED. THE DEALER STATED THAT THE BRAKE BOOSTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR STATE INSPECTION AND NO FAILURE CODES…
Read full complaint
TL* THE CONTACT OWNS A 2005 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE BRAKE PEDAL WOULD TRAVEL TO THE FLOOR WHEN DEPRESSED. THE DEALER STATED THAT THE BRAKE BOOSTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR STATE INSPECTION AND NO FAILURE CODES WERE PRESENT AT THAT TIME. THE DEALER WAS UNABLE TO REPAIR THE VEHICLE. A COUPLE OF WEEKS LATER, WHILE DRIVING 32 MPH, THE BRAKES FAILED AND THE CONTACT CRASHED INTO THE REAR PASSENGER SIDE BUMPER OF THE PRECEDING VEHICLE. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 189,000.
NHTSA ODI #10637530
Official recalls
3Apr 7, 2008
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
Consequence & remedy
Consequence: A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Dec 15, 2004
ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
Remedy: DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA11002 · Engine Compartment Fire
Opened Jan 26, 2011 · Closed Feb 17, 2012
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Additional source detail variants (2)
Electrical System
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Illustration