NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
279 reports85,000 miles · Sep 22, 2015
EngineFuel System, GasolineStructureFire
THE PASSAT IGNITED IN OUR DRIVEWAY AT 4:00 A.M. IT HAD NOT BEEN STARTED/DRIVEN IN A WEEK. WE WOKE TO THE SOUND OF THE TIRE BURSTING. THERE IS A HOUSTON POLICE DEPARTMENT /ARSON CASE # [XXX] - PHONE # [XXX]. INSPECTOR [XXX]. HE SAID THE IGNITION AREA OF THE CAR WAS THE START OF THE FIRE. I THINK HE WAS ARSON DEPARTMENT. THE …
Read full complaint
THE PASSAT IGNITED IN OUR DRIVEWAY AT 4:00 A.M. IT HAD NOT BEEN STARTED/DRIVEN IN A WEEK. WE WOKE TO THE SOUND OF THE TIRE BURSTING. THERE IS A HOUSTON POLICE DEPARTMENT /ARSON CASE # [XXX] - PHONE # [XXX]. INSPECTOR [XXX]. HE SAID THE IGNITION AREA OF THE CAR WAS THE START OF THE FIRE. I THINK HE WAS ARSON DEPARTMENT. THE CAR WAS TOTALED. WE ARE LUCKY WE DID NOT LOOSE OUR HOUSE AND NEIGHBOR'S IF WE HAD NOT HEARD THE TIRE BLOW. I AM NOT EXACTLY SURE OF THE MILEAGE BUT KNOW IT WAS LOW FOR THE YEAR AND THINK IT WAS BELOW 90,000...UPDATED 05/02/16 *BF INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10767576
90,000 miles · Sep 4, 2015
Fuel/propulsion System
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN PASSAT. WHILE PUMPING FUEL INTO THE VEHICLE, THE STRONG ODOR OF FUEL WAS PRESENT. IN ADDITION, WHILE DRIVING 35 MPH, THE ODOR WAS STILL PRESENT. THE FAILURE RECURRED CONSTANTLY. THE DEALER DIAGNOSED THAT THE FUEL TANK VENTILATION VALVE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. TH…
Read full complaint
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN PASSAT. WHILE PUMPING FUEL INTO THE VEHICLE, THE STRONG ODOR OF FUEL WAS PRESENT. IN ADDITION, WHILE DRIVING 35 MPH, THE ODOR WAS STILL PRESENT. THE FAILURE RECURRED CONSTANTLY. THE DEALER DIAGNOSED THAT THE FUEL TANK VENTILATION VALVE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
NHTSA ODI #10761704
65,000 miles · Jul 13, 2015
Engine
IGNITION COIL HAS FAILED 3 TIMES IN LAST 12 MONTHS.
NHTSA ODI #10733715
81,000 miles · Mar 10, 2015
EngineFire
MARCH 8 AT APPROXIMATELY 10PM: ON A TRIP BACK FROM OUT OF TOWN WITH MY 2 YOUNG CHILDREN AND PUPPY, THE RPMS IN THE VW PASSAT BEGAN ESCALATING YET NO ADDITIONAL POWER WAS COMING INTO THE ENGINE. I TRIED SHIFTING TO A LOWER GEAR AND ALSO ATTEMPTED CRUISE CONTROL TO MINIMIZE THE RPM RACING. CRUISE CONTROL DID NOT RESPOND AND THE…
Read full complaint
MARCH 8 AT APPROXIMATELY 10PM: ON A TRIP BACK FROM OUT OF TOWN WITH MY 2 YOUNG CHILDREN AND PUPPY, THE RPMS IN THE VW PASSAT BEGAN ESCALATING YET NO ADDITIONAL POWER WAS COMING INTO THE ENGINE. I TRIED SHIFTING TO A LOWER GEAR AND ALSO ATTEMPTED CRUISE CONTROL TO MINIMIZE THE RPM RACING. CRUISE CONTROL DID NOT RESPOND AND THE CHANGE IN GEAR DID NOTHING FOR THE RACING RPMS. A FEW MORE MILES DOWN THE HIGHWAY THE CAR BEGAN LOSING MOMENTUM -? IT WAS SIMILAR TO THE FEELING OF RUNNING OUT OF GAS THOUGH I HAD A FULL TANK. I MOVED THE CAR INTO THE SERVICE LANE BEFORE THE ENGINE SHUT OFF. WITHIN SECONDS OF PULLING OVER, THE ENGINE BEGAN SMOKING. I FELT THE NEED TO GET OUT OF THE VEHICLE, EVEN THOUGH I WAS ON THE HIGHWAY LATE AT NIGHT, PREGNANT, WITH 2 SMALL CHILDREN AND A PUPPY. WE LEFT EVERYTHING IN THE CAR, GOT OUT (I CALLED 911) AND WERE ABOUT 8 FEET AWAY WHEN FLAMES BECAME VISIBLE ESCAPING FROM THE HOOD OF THE VEHICLE. A STATE TROOPER WAS PASSING THROUGH AT THE TIME AND NOTICED THE STRONG SMELL; HE QUICKLY CIRCLED BACK AND THEN SAW THE FIRE.TWO FIRE TRUCKS AND 2 MORE STATE TROOPERS ARRIVED AT THE SCENE -?? BUT BY THAT POINT -?? THE ENTIRE FRONT END OF MY CAR WAS IN FLAMES. THE TIRES WERE SO HOT FROM THE FIRE THAT THEY HAD MELTED TO THE ROAD. THE FRONT END OF THE CAR WAS COMPLETELY DESTROYED, THE DRIVER'??S SIDE WINDOW WAS BLOWN OUT, AND THE DASHBOARD MELTED. EVERYTHING IN THE CAR EXPERIENCED CHEMICAL SMOKE DAMAGE AND/OR WATER DAMAGE FROM THE FIRE TRUCKS. THE INSURANCE COMPANY ??TOTALED?? THE CAR THIS MORNING. SUNDAY NIGHT I NOTICED THAT NHTSA WAS AT ONE POINT INVESTIGATING VW PASSAT ENGINE FIRES. I WOULD ENCOURAGE YOU TO CONTINUE THAT INVESTIGATION. THOUGH MY CHILDREN AND PUPPY WERE NOT PHYSICALLY INJURED (I DON'T KNOW IF THEY HAVE SUFFERED MENTAL TRAUMA) -?? I AM PREGNANT AND DO NOT KNOW IF THE FUMES WILL BE TOXIC TO MY UNBORN CHILD. *TR..UPDATED 06/01/16 *BF UPDATED 9/27/2017*CN
NHTSA ODI #10693241
92,000 miles · Mar 6, 2015
Structure
I NOTICED THERE WAS A CONSIDERABLE AMOUNT OF WATER ON THE PASSENGER SIDE CARPETING. I CHECKED ALL DRAINAGE LOCATIONS FOR BLOCKAGE (I.E. PLENUM, SUNROOF). ALL WERE CLEAR. THE WATER FOUND IT'S WAY INTO THE VEHICLE BY WAY OF A FAULTY (DISINTEGRATED) SEAL BENEATH THE POLLEN FILTER HOUSING. THE CAR HAD 92,000 AND WAS OUT OF WARRANTY.…
Read full complaint
I NOTICED THERE WAS A CONSIDERABLE AMOUNT OF WATER ON THE PASSENGER SIDE CARPETING. I CHECKED ALL DRAINAGE LOCATIONS FOR BLOCKAGE (I.E. PLENUM, SUNROOF). ALL WERE CLEAR. THE WATER FOUND IT'S WAY INTO THE VEHICLE BY WAY OF A FAULTY (DISINTEGRATED) SEAL BENEATH THE POLLEN FILTER HOUSING. THE CAR HAD 92,000 AND WAS OUT OF WARRANTY. HOWEVER, I FOUND THAT THERE WAS A SERVICE ACTION P9/66C8 APPLICABLE TO MY VEHICLE FOR WHICH I WAS TO BE NOTIFIED BY VW IN 2008. I AM THE ORIGINAL OWNER OF THE CAR AND RESIDE IT THE SAME ADDRESS SINCE 1978. THE VEHICLE WAS SOLD DIRECTLY TO ME BY A VW DEALER BRAND NEW IN OCTOBER 2004 AND REGISTERED TO ME AT MY HOME ADDRESS. I NEVER RECEIVED ANY NOTIFICATION. THE CORRECTIVE ACTION NOTED ON THE P9/66C8 INCLUDED DIRECTING THE DEALER TO "INSTALL AN IMPROVED SEAL FOR THE POLLEN FILTER". I CONTACTED VW CUSTOMER CARE AND THEY DID NOT ACKNOWLEDGE THAT THE SERVICE ACTION EXISTED AND CONSEQUENTLY THERE WAS NO REASON FOR THEM TO CONTACT ME IN 2008. THEY LIED AND I HAVE A DAMAGE VEHICLE THAT GETS FLOODED WHENEVER IT RAINS. I WAS COMPELLED TO MAKE THE IMMEDIATE REPAIRS AT MY OWN EXPENSE SINCE THE TRANSMISSION CONTROL MODULE (TCM) IS LOCATED BENEATH THE PASSENGER SIDE FRONT SEAT OF THIS CAR. SHOULD THE WATER GET INSIDE, IT COULD CAUSE DAMAGE TO THE TRANSMISSION FUNCTION. IF THIS WERE TO OCCUR WHILE DRIVING THE VEHICLE, A POTENTIAL FOR PERSONAL INJURY TO THE VEHICLE OCCUPANTS EXISTS ALONG WITH ANY DAMAGE TO THE VEHICLE ITSELF. VW HAS FAILED TO TAKE RESPONSIBILITY FOR A DEFECT KNOWN TO THEM. VW HAS INSTEAD CHOSEN NOT ONLY TO HOLD ME FINANCIALLY RESPONSIBLE FOR THE DEFECT OF THEIR PRODUCT BUT TO ALSO EXPOSE ME (AND OTHER VEHICLE OCCUPANTS OF THIS VEHICLE) TO POTENTIAL HAZARDS AS A RESULT OF THE FAILURE RISK ASSOCIATED WITH A FLOODED TCM. *TR
NHTSA ODI #10692404
104,000 miles · Feb 23, 2015
Fuel System, Gasoline
2004 VOLKSWAGEN PASSAT 4MOTION, THE FUEL TANK ROLLOVER/VENT VALVE ON THE TOP OF THE TANK HAS CRACKED AND IS LEAKING GASOLINE ONTO THE EXHAUST SYSTEM. THE TANK WAS FILLED UP ON 2/22/2015 AND STARTED LEAKING LARGE AMOUNTS OF FUEL FROM THE TOP OF THE TANK OVER THE EXHAUST. THIS CONTINUED UNTIL THE TANK REACHED 3/4 FULL. IF THE FUEL…
Read full complaint
2004 VOLKSWAGEN PASSAT 4MOTION, THE FUEL TANK ROLLOVER/VENT VALVE ON THE TOP OF THE TANK HAS CRACKED AND IS LEAKING GASOLINE ONTO THE EXHAUST SYSTEM. THE TANK WAS FILLED UP ON 2/22/2015 AND STARTED LEAKING LARGE AMOUNTS OF FUEL FROM THE TOP OF THE TANK OVER THE EXHAUST. THIS CONTINUED UNTIL THE TANK REACHED 3/4 FULL. IF THE FUEL TANK IS FILLED ABOVE 3/4 IT WILL LEAK FUEL UNTIL IT GETS TO 3/4. IF THE VEHICLE IS PARKED WITH THE FRONT DOWNHILL, IT CONTINUES TO LEAK BEYOND THE 3/4 POINT. THIS FAILURE WAS PART OF A PREVIOUS VW 2008 NHTSA MANDATED RECALL 08V156000, BUT ONLY REQUIRED DEALER INSPECTION OF THE ROLLOVER/VENT VALVE AND NOT REPLACEMENT OF THE FUEL TANK WITH A FUNCTIONAL PART, IF IT WAS NOT LEAKING WHEN INSPECTED THEN DO NOTHING. THE ROLLOVER/VENT IS INTEGRAL TO THE VW PASSAT AWD TANK, AND THE COMPLETE FUEL TANK HAS TO BE REPLACED. VW CLAIM AS THE CAR WAS INSPECTED IN 2008, THEY ARE NOT RESPONSIBLE FOR THE SUBSEQUENT FAILURE OF THE ROLLOVER/VENT VALVE. *TR
NHTSA ODI #10690159
128,000 miles · Dec 11, 2014
EngineFire
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, AN UNUSUAL SOUND WAS HEARD AND SMOKE STARTED TO EMIT FROM THE ENGINE COMPARTMENT AS THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO A DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE TIMING BELT HAD BECOME FRACTURED AND THE CAM SHAFT PULLEY …
Read full complaint
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, AN UNUSUAL SOUND WAS HEARD AND SMOKE STARTED TO EMIT FROM THE ENGINE COMPARTMENT AS THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO A DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE TIMING BELT HAD BECOME FRACTURED AND THE CAM SHAFT PULLEY FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 128,000.
NHTSA ODI #10663521
143,000 miles · Oct 1, 2014
Fuel System, Gasoline
FUEL BEGAN LEAKING FROM THE TOP OF THE FUEL TANK AFTER FILL UP. MY DAUGHTER WAS HEADING BACK TO COLLEGE, AND AS SHE PULLED AWAY I NOTICED A LARGE PUDDLE OF GASOLINE IN THE STREET. NHTSA HAD PREVIOUSLY RECALLED THE VEHICLE IN 2008 (26E5/R5) ACTION NUMBER (PE08008). VW DEALER INSPECTED AND INSTALLED HEAT SHIELD. NO FUEL LEAK A…
Read full complaint
FUEL BEGAN LEAKING FROM THE TOP OF THE FUEL TANK AFTER FILL UP. MY DAUGHTER WAS HEADING BACK TO COLLEGE, AND AS SHE PULLED AWAY I NOTICED A LARGE PUDDLE OF GASOLINE IN THE STREET. NHTSA HAD PREVIOUSLY RECALLED THE VEHICLE IN 2008 (26E5/R5) ACTION NUMBER (PE08008). VW DEALER INSPECTED AND INSTALLED HEAT SHIELD. NO FUEL LEAK AT THIS TIME. IN SEPTEMBER 2012 FUEL TANK BEGAN LEAKING, VW DEALER REPLACED THE FUEL TANK, WASHER, GASKET AND CLAMP UNDER THE RECALL. IN SEPTEMBER 2014 I BROUGHT CAR BACK TO VW DEALER, AND THEY SAID THEY ARE ONLY RESPONSIBLE TO FIX THE CAR ONCE. FED UP WITH VW, I BROUGHT CAR TO MY LOCAL MECHANIC, AND UPON INSPECTION HE FOUND THE NIPPLES ON THE FUEL TANK ROLLOVER VALVE WERE AGAIN CRACKED. I HAD HIM REPLACE THE TANK. OBVIOUSLY VW DIDN'T PROPERLY FIX THE PROBLEM, AND OR REPLACED THE TANK WITH THE SAME DEFECTIVE DESIGN AND THE TANK CRACKED AGAIN. THIS IS A VERY SERIOUS SAFETY ISSUE, AND I FEEL THAT VW SHOULD PAY FOR THIS REPAIR. IF IT WAS DONE RIGHT AND CORRECTED, THE TANK WOULD NOT BE LEAKING AGAIN AFTER LESS THAN 2 YEARS, AND 20,000 MILES. THIS COULD HAVE CAUSED A FIRE WITH MY DAUGHTER IN THE CAR, AND THAT IS VERY UPSETTING TO ME. *TR
NHTSA ODI #10640452
187,249 miles · Sep 1, 2014
Fuel/propulsion System
VEHICLE: 2004 VW PASSAT 4MOTION SEDAN W/1.8L TURBO, AUTOMATIC TRANSMISSION FILLED VEHICLES FUEL TANK, NOTICED STRONG GASOLINE SMELL INSIDE VEHICLE, NOTICED FUEL DRIPPING FROM FUEL TANK OF VEHICLE TO GROUND. CANNOT FILL TANK WITHOUT GAS DRIPPING TO GROUND; FUEL LEAK IS NEXT TO EXHAUST SYSTEM UNDERNEATH VEHICLE (VERY DANGEROUS). …
Read full complaint
VEHICLE: 2004 VW PASSAT 4MOTION SEDAN W/1.8L TURBO, AUTOMATIC TRANSMISSION FILLED VEHICLES FUEL TANK, NOTICED STRONG GASOLINE SMELL INSIDE VEHICLE, NOTICED FUEL DRIPPING FROM FUEL TANK OF VEHICLE TO GROUND. CANNOT FILL TANK WITHOUT GAS DRIPPING TO GROUND; FUEL LEAK IS NEXT TO EXHAUST SYSTEM UNDERNEATH VEHICLE (VERY DANGEROUS). FOUND FOLLOWING INFORMATION: MANUFACTURER: VOLKSWAGEN OF AMERICA, INC SUMMARY: VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE. *TR
NHTSA ODI #10629809
112,000 miles · Aug 27, 2014
Engine
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN PASSAT. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH, THE ENGINE STALLED. THE VEHICLE COASTED TO THE SHOULDER OF THE ROAD. THE VEHICLE FAILED TO RESTART AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO REPLACED THE RADIATOR, THE WATER PUMP, AND THE TIMIN…
Read full complaint
TL* THE CONTACT OWNS A 2004 VOLKSWAGEN PASSAT. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH, THE ENGINE STALLED. THE VEHICLE COASTED TO THE SHOULDER OF THE ROAD. THE VEHICLE FAILED TO RESTART AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO REPLACED THE RADIATOR, THE WATER PUMP, AND THE TIMING BELT. THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 112,000.
NHTSA ODI #10628678
Official recalls
3Apr 7, 2008
VOLKSWAGEN IS RECALLING 412,000 MY 1999-2005 PASSAT (5TH GENERATION) VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS AND PRODUCED AFTER JUNE 14, 1999. THESE VEHICLES MAY HAVE AN UNDERBODY HEAT SHIELD THAT CAN BECOME DAMAGED. IN ADDITION, AFFECTED VEHICLES WITH AUTOMATIC OR MANUAL TRANSMISSIONS MAY HAVE A FUEL LINE (1.8T ENGINES ONLY) OR FUEL TANK VENTILATION VALVE (4MOTION/ALL WHEEL DRIVE ONLY) THAT CAN LEAK DUE TO FRACTURE.
Consequence & remedy
Consequence: A HEAT SHIELD THAT MAY CONTACT THE EXHAUST SYSTEM CAN RESULT IN A VEHICLE FIRE. IN ADDITION, A FUEL LEAK FROM A FUEL LINE OR FUEL TANK VENTILATION VALVE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN LEAD TO A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL ADDITIONAL UNDERBODY HEAT SHIELDS ON VEHICLES WITH AUTOMATIC TRANSMISSIONS TO COVER THE POSSIBLY DAMAGED AREAS AND FLASH ALL 1.8T ENGINES WITH A PRECAUTIONARY SOFTWARE UPDATE. DEALERS WILL ALSO INSPECT AND ADJUST THE FUEL LINE ROUTING ON 1.8T VEHICLES AND THE FUEL TANK VENTILATION VALVE ON 4MOTION/ALL WHEEL DRIVE VEHICLES, AND REPLACE COMPONENTS IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 13, 2008. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
Dec 15, 2004
ON CERTAIN PASSENGER VEHICLES, THE HIGH PRESSURE DIESEL PUMPS WERE PRODUCED WITH AN IMPROPER FASTENER, WHICH COULD ALLOW DIESEL FUEL TO ESCAPE FROM THE PUMP.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE MAY LEAD TO A FIRE.
Remedy: DEALERS WILL REPLACE THE DIESEL PUMP. THE RECALL BEGAN ON FEBRUARY 8, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA11002 · Engine Compartment Fire
Opened Jan 26, 2011 · Closed Feb 17, 2012
Status: closed (inferred from source dates) · Electrical System; Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Additional source detail variants (2)
Electrical System
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
Engine And Engine Cooling
In July 2010, the Agency opened PE10-027 to investigate allegations of coil on plug (COP) ignition coil fires in MY2002-2003 VW Passat vehicles.The investigation was upgraded in January 2011 to include all MY2001-2007 4-cylinder VW Passat, gasoline, turbo-charged vehicles.Based on the analysis of VW's response, and including ODI's consumer complaints, ODI has since identified 135 unique engine fire reports attributable to the COP coils.After further review of the details as contained in each report, ODI determined that 43 of the 135 fire reports were actual fire/flame incidents, 83 fire reports were thermal events (smoke, spark, heat or wire melt), and another 9 fire reports were undetermined in severity due to the lack of information.These COP coil fires were characterized as initiated from within the COP coil circuit located at the top of the engine block and below the plastic engine cover.The fires observed were contained in the engine compartment and did not reach into the passenger compartment in contrast to those caused by an overheated catalytic converter examined in ODI?s investigation in 2007 and 2008.There were no reports of crashes or personal injury in this examination.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will monitor this issue and reserves the right to take further action if warranted by the circumstancesSee the Closing Report for additional details.
PE08008 · Fuel Tank Leak
Opened Jan 31, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Gasoline:storage:tank Assembly
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
VOLKSWAGEN (VW) IS RECALLING CERTAIN VW PASSAT 4MOTION AND AUDI A6 QUATTRO AND ALLROAD QUATTRO ALL-WHEEL DRIVE PASSENGER CARS.VW VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM NOVEMBER 22, 2000 THROUGH MAY 31, 2005 AND AUDI VEHICLES SUBJECT TO RECALL WERE MANUFACTURED FROM JUNE 2, 2001 TO JUNE 1, 2005.THE NHTSA RECALL NUMBER FOR THE VW VEHICLES IS 08V-156 (VW ALSO IS CORRECTING DEFECTS RELATED TO HEAT SHIELD AND FUEL LINE HAZARDS FOR THESE VEHICLES AND FOR 1999-2000 PASSATS IN THIS RECALL ACTION.)THE NHTSA RECALL NUMBER FOR THE AUDI VEHICLES IS 08V-157.SINCE 2006, ODI HAS RECEIVED 17 COMPLAINTS OF FUEL LEAKING FROM THE SUBJECT VEHICLES' FUEL TANKS.THE 400 COMPLAINTS SHOWN ABOVE MAY INCLUDE DUPLICATE REPORTS TO ODI AND THE MANUFACTURER. WHILE THE CONSEQUENCE (FUEL LEAKS FROM THE TOP OF THE TANK) IS SIMILAR FOR BOTH THE PASSAT AND AUDI SUBJECT VEHICLES, DIFFERENCES IN DESIGN AND CONSTRUCTION REQUIRE A DIFFERENT REMEDY FOR EACH VEHICLE.ON THE PASSATS, THE VENTILATION LINE COULD HAVE BEEN INSTALLED IMPROPERLY WITH TENSION AND WITH AN INCORRECTLY POSITIONED CABLE TIE.THE TENSION COULD CAUSE CRACKED OR BROKEN NIPPLES ON THE FUEL TANK ROLLOVER VALVE.ON THE AUDI VEHICLES, A MATERIAL CHANGE (EFFECTIVE JUNE 2, 2001) WITH DIFFERENT AGING CHARACTERISTICS USED FOR THE ROLLOVER VALVE AND THE USE OF AN INFLEXIBLE ALUMINUM VENTILATION LINE COULD CAUSE CRACKING OF THE NIPPLE ON THE ROLLOVER VALVE.VW IS RECALLING ALL VEHICLES SUBJECT TO THESE DEFECTS.IT WILL INSPECT PASSATS TO ENSURE THAT THE VENT LINE IS TENSION FREE AND CORRECT THE INSTALLATION IF TENSION IS FOUND.IF A CRACK OR FUEL LEAK IS FOUND, VW WILL REPLACE THE FUEL TANK.AUDI WILL REPAIR ALL SUBJECT VEHICLES BY REINFORCING THE FUEL TANK ROLLOVER VALVE WITH AN EPOXY ADHESIVE.THIS INVESTIGATION IS CLOSED.
EA07014 · Passenger Engine Compartment Fires
Opened Sep 28, 2007 · Closed Jul 7, 2008
Status: closed (inferred from source dates) · Electrical System:ignition; Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Additional source detail variants (2)
Electrical System:ignition
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Engine And Engine Cooling:exhaust System
THE MANUFACTURER NOTIFIED NHTSA ON 04-APR-08 THAT A SAFETY RECALL ACTION WOULD BE INITIATED TO REMEDY THE ISSUE.IN JUNE 2008, THE MANUFACTURER ISSUED A TECHNICAL SERVICE BULLETIN (CODE 26E5/R5) REGARDING THE SPECIFIC PROCEDURES TO BE EMPLOYED IN THIS CAMPAIGN.VEHICLE OWNER NOTIFICATION LETTERS WERE SENT BEGINNING APPROXIMATELY JUNE 13, 2008.THE CAMPAIGN WAS ASSIGNED NHTSA NO. 08V-156.THIS RECALL AFFECTS ALL MY 1999-2005, 5TH GENERATION GASOLINE-POWERED PASSAT SEDANS AND STATION WAGONS.APPROXIMATELY 412,000 VEHICLES ARE AFFECTED.CORRECTIVE ACTION WILL CONSIST OF INSTALLING ADDITIONAL EXHAUST SYSTEM HEAT SHIELDING TO MITIGATE THE POTENTIAL THERMAL EFFECTS OF ENGINE IGNITION PROBLEMS.BASED ON THIS ACTION, THE SUBJECT EA HAS BEEN CLOSED.
Illustration