2004 Volkswagen New Beetle

WHENEVER THE PASSENGER/DRIVER SEATS ARE MOVED WITHIN 10 SECONDS OF STARTING THE CAR AIRBAG LIGHT COMES ON IN THE CONSOLE AND DOES NOT TURN OFF UNTIL DONE SO MANUALLY BY A MECHANIC. THE "POD" DEVICE IS THEN DISABLED. IF LIGHT IS ON, THEN AIRBAG MIGHT NOT DEPLOY IN AN ACCIDENT, INJURIES OR DEATH MAY OCCUR. ON 2 SEPARATE OCCASIONS, ONE IN AUGUST AND ONE IN OCTOBER THE LIGHT WAS RESET BY A MECHANIC AND TOOK 3 DAYS EACH TIME. I HAVE BEEN ADVISED TO HAVE THE COMPUTER IN THE CAR REPROGRAMMED, BUT THE DEALERSHIP'S MECHANICS HAVE NOT DONE SO, ASSUMING THAT IS WHY THE LIGHT KEEPS APPEARING.*AK

WHILE DRIVING SRS LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. THE CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND DROVE IT TO THE DEALER FOR INSPECTION. THE MECHANIC DETERMINED THAT THE AIR BAG SENSOR NEEDED TO BE RESET, AND RESET IT SIX TIMES. HOWEVER, THE PROBLEM RECURRED. *AK THE SEAT LATCH WAS BROKEN AND THE REAR CONSOLE WAS FALLING APART. *SC

2004 VW BEETLE BUY 8-19-04. RANSMISSION FAILURE 4 SINCE 9-8, LETTER 9-18 SENT CERTIFIED *VW TECH HOTLINE GAVE NO CASE # SERVICE MGR GAVE CUSTOMER TWO 800#S & CUSTOMER SPOKE W/3 MEN BUT NO CASE #S & SAID THEY WOULD CALL BACK IN 10-15 DAYS. A/O 9-29, NO RETURN CALL & CAR BACK IN SHOP FOR 4TH TIME SAME THING. DEALER WANTS CUSTOMER TO DRIVE AROUND, LEAVE SERVICE TICKET OPEN IN CASE HAPPENS AGAIN. CUSTOMER REQUESTED FULL REFUND UNDER LEMON LAW, BUT NO RESPONSES TO REQUEST. INCIDENTS: 1. 9-8 TRIED DIFFERENT GEARS AND MOVED INTO FIRST GEAR ONLY, CHECK ENGINE LIGHT ON AND GEAR SHIFT INDICATOR LIGHT WOULD NOT LIGHT UP. SALESMAN ADVISED TO DRIVE TO SERVICE DEPARTMENT, WHICH TOOK OVER 45 MINUTES AT A TOP SPEED OF 10 MPH. WORK ORDER #87669 INDICATES POSSIBLE ELECTRICAL CONTACT AND READS: HOOK-UP VAS 5051 CODES PO1626 DATA-BUS POWER-TRAIN MISSING MESSAGE FROM TCM, CODES 01315 AND 01315 INST CLUSTER AND DATA BUS GEARBOX CONTROL UNIT NO COMMUNICATION. PERFORMED ALL TEST WITH VAS 5051 AND PER TECH HOTLINE, NO FAULTS FOUND ADVISE TO CLEAR CODES AND TEST DRIVE. IF NO FURTHER PROBLEM OR CODES, RETURN VEHICLE TO CUSTOMER. VW TECH HELP CONTACT NO CASE #. FURTHER OVERNITE ROAD TEST-ALL OK ON TEST. DISCREPANCY-MILEAGE WO #87669 READS 143 MILES IN, BUT MILEAGE CHANGED TO 561 IN AND 602 OUT WHEN CAR PICKED UP. 2. 9-16 SEPTEMBER 16 SAME HAPPENED AROUND LUNCH, DROVE TO DEALER SALESMAN SAID IT WAS FINE 3. 9-16 EVE OUT OF GEAR-TOWED, SERVICE ORDERED CLUSTER TO INSTALL 4. 9-27 VEHICLE WOULDN'T ENGAGE. STILL AT SHOP. THEY SAY THEY REPLACED MORE STUFF, CUSTOMER DOESN'T TRUST AFRAID OF SAFETY-SELF, FAMILY, OTHERS ON THE ROAD. *AK

DRIVER DOOR POWER WINDOW:NEW BEETLE CONV. WHEN CLOSING,WILL ROLL BACK DOWN BY ITSELF AND CLUNKS WHEN HITS BOTTOM. HAPPENS ALMOST EVERY TIME WINDOW IS OPENED THEN CLOSED. REPORTED AND TAKEN TO DEALER APRIL 20 2004, THEY FOUND WINDOW GLASS ALMOST FALLING OFF CLIP. REINSTALLED. RELEASED BACK TO ME. BEFORE I LEFT THE SERVICE AREA, WINDOW FAILURE HAPPENED AGAIN. DEALER THEN REPLACED MOTOR 2 TIMES. STILL SAME PROBLEM. DEALER CONTACTED VW. AND WAS TOLD SOFTWARE UPDATE NEEDED AND SHORTER CABLES. AS OF TODAY AUGUST 21,2004 WINDOW STILL HAS PROBLEM AND STILL WAITING ON SOFTWARE UP. I HAVE REPORTED THE CASE TO VW. NO RESOLUTION AS OF YET. *JB

PURCHASED MY THIRD VOLKSWAGEN NEW BEETLE - RECOGNIZE THAT MY SECOND ONE, A 2003 WAS A LEMON  5 RIGHT REAR TAIL LIGHTS REPLACED AND 2 HEADLIGHTS. ALSO HAD TO HAVE THE INTERMITTENT WIPER RELAY REPLACED - SEE ODI #10074539.*AK DEALER TRADED ME FOR A 2004, ON 4/6/04 AND NOT EVEN 2 WEEKS INTO MY PURCHASE, THE DRIVERS SIDE WINDOW WOULD NOT OPERATE PROPERLY. THOUGHT I WAS IMAGINING THINGS, ESPECIALLY AFTER MY LAST EXPERIENCE. I PUT THE WINDOW DOWN (ELECTRONICALLY) AND THEN PUT IT UP AND IT COMES DOWN BY ITSELF  CERTAINLY ANOTHER SAFETY FAULT OF THIS CAR. IT HAPPENED 2 MORE TIMES BEFORE I CALLED THE DEALER  THEY TOLD ME OH, WE KNEW ABOUT THAT  BRING IT IN AND GET IT FIXED. OH, HERE WE GO AGAIN! I BUY A NEW CAR ABOUT EVERY 3-4 YEARS, AS I DRIVE A LOT AND WANT A VERY DEPENDABLE CAR, WITH NO REPAIRS NEEDED. I WILL NEVER FEEL SAFE IN A VW NEW BEETLE AGAIN. NO MATTER IF I NEVER HAVE ANOTHER PROBLEM&& INCIDIENT DATE NOTED IS WHEN THE DEALER TOOK MY CAR TO FIX IT...............