2021 Volkswagen Jetta

Upon backing out of a parking spot a vehicle approached at a fast rate of speed. The rear cross-path sensor and emergency braking activated. This action caused the brake line to rupture and the brakes failed on the vehicle. I resumed reversing out of the parking spot and put the vehicle into Drive. Once I applied the brake, the pedal went to the floor with total brake system loss. The vehicle was towed to Armstrong Volkswagen in Gladstone, Oregon. The dealer found the rear passenger side brake like had ruptured due to it rubbing on the fuel filler neck shield. The sudden increase in brake line pressure caused the final failure of the brake line. The brake line was repaired under warranty. This could have been a significant life threatening situation had I been traveling at high speeds and the brake system failed (i.e. exiting an Interstate, etc.).

I replaced the rear brakes on this vehicle at 16,000 miles due to them prematurely wearing out and the were covered under an extended warranty due to known issue. I took the vehicle in for an oil change at 28,871 miles and was told the rear brakes were down to 2mm and needed to be changed as well as the rotors. This is only 12,000 miles since the last rear brake change and when I had the brake pads inspected at 23,000 miles they were fine. It appears there is a major defect in the rear brakes of the VW jetta since the front brake pads are fine. I was charged $522 after a discount to have the brakes and rotors replaced. I don't think it is reasonable for a car with only 28,871 miles to have already had to change the rear brake pads twice and the rotors at all.

My 2021 VW Jetta at 8 months old with 21305 miles had a grinding noise in the rear. Took it to the dealer Aug 9 2022 and was told the rear brakes and rotors needed to be replaced at my cost. I informed them I thought this was way too early to have to pay for brakes and that something must be wrong. They made me pay over $600. I later found out a TSB was issued by VW in Dec 2022 to extend brake coverage to 2 years 24,000 miles. I want my money back as they have now admitted there is an issue with the brakes. 14 months later in Oct 2023 same issue at 40,250. The dealer now informs me of this TSB and although it was intended to ONLY cover your first set of failing brakes, the Service advisor got the ok from the VW district manager to warranty them this time. Once again VW admitting to a problem with my vehicles parts and or manufacturing. The fact that they and the NHTSA know there is a problem with the electronic braking and they refuse to fix it is dumbfounding. My front pads at 41,250 have only used 3mm of the original 12 while the rear pads went through 2 complete sets or 24mm. This could not be more obvious it is a manufacturing defect as the rear pads are applied nearly 100% of time and the front nearly 0%. This is outrageously unacceptable and I demand my car be fixed properly and not be hassled with having to argue warranty issues every 15,000-20,000 miles for new pads and rotors. I will be contacting VW about the issue.

I purchased my vehicle brand new from VW. My vehicle only has just over 33,000 miles on it. After hearing a grinding noise in the rear brakes I took it to Les Shwab to have the brakes inspected along with a tire rotation. After a short time waiting they told me that the rear brakes were metal on metal and the front were just fine. I asked how the rear brakes could go out so soon when the front brakes are the ones that normally wear out so quickly. They had planned to replace the pads and rotors on the rear of the vehicle. When they tried to remove the calipers the piston would not release and I had to pay foe new calipers as well. A couple hour brake inspection turned into three days without my vehicle waiting for parts and a $1,314.49 bill. I went online looking for recalls and there weren't any. I did however find that this is a common issue for the 2021 Jetta, and it is presumed that the roll back brake assist is faulty causing the calipers to not release thus causing excessive wear to the rear brakes. Had my rear brakes gone out completely before I had them inspected this could have been very bad causing myself or others serious injury or even death. I am seeking for NHTSA to investigate this further and force VW to issue a recall. I am also seeking full reimbursement for my bill from VW. Thank you.

On 01/12/2023 at approximately 4:20 PM, I paid the cost to replace the rear brakes on my 2021 VW Jetta SEL. This included parts and labor. I found this very odd due to the vehicle being less than 2 years old. About 1 week after this, I received via USPS mail, a letter from VW of America stating that an extended warranty of the rear brakes applies to my vehicle (see attached). I filled out the required information and submitted the included form as instructed. On 04/08/2023 I received an email from VW Customer Care stating they will not reimburse me for the price of the brakes I had to replace. The only reason I had to replace the said brakes is due to Volkswagen's faulty parts and I fear this is happening to many consumers as well. After a bit of "back and forth" with VWoA, I contacted NYS AG's office and with their help, VWoA finally paid me for the replacement of the stated brakes. Seeing that many others on your site have had this same issue, I think a recall should be enacted by you. This should not be an expense that VWoA's customers should have to bear.

I do not feel safe with my Vehicle. I purchased new and at 16,550 Miles it needed new rear rotors and pads. Again at 38417 it needed new rotors and pads. I drive the car softly and am not heavy on the brakes. This seems to be a known issue and the dealership says I should be prepared to replace rotors and pads this frequently. It was only 1.5 years until the 2nd pad/rotor change. Not only do I not feel safe, that is a financial hardship.

Without warning, the rear brakes started making unusual scraping sound with slight loss of braking power. Within a week of the issue took car to dealer who informed me that rear brake pads were completely worn out with calipers scraping and damaging the rotors. VW refused to fix the issue via warranty. By the end of the week, the scraping escalated and significant loss of braking power occurred. The premature failure or the braking pads and subsequent rotor damage seems to be a pervasive problem and well documented problem at VW. Their approach to safety and resolution however very troubling. The car was purchased new from the dealer 30 months ago and has 15,300 miles at the time of the incident.

Hill Assist system creates dangerous situations because it prevents me from moving right away while pulling out in traffic or in front of traffic lights, out of parking garages and stop signs. Hill Assist system often stalls the engine due to holding brakes engaged for an extended period of time even on a slight hill. With a manual transmission this makes it even worse because engine dies in these situations frequently. Dealer dismisses the issue because "there are no fault codes", but if it was manufactured incorrectly and/or calibrated improperly, no error/fault codes will come on. I have been driving manual transmissions all my life (from motorcycles to semi trucks) for over 40 years and it's clear to me that this vehicle is a safety concern with underpowered engine that cannot overcome Hill Assist. Other Hill Assist systems immediately disengage the brakes when an accelerator pedal is pressed. In this vehicle, the brake stays on and vehicle dies on even on a slightest hill. Please help investigate.