NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
95 reportsClear category filterMileage unknown · Aug 3, 2026
Unknown Or Other
The electronic dashboard does not display critical information like speed, engine RPM, engine warning lights, etc. The electronic dashboard stopped working and remains a black screen with no information about vehicle speed and other important infomation available to the driver. VW has a technical bulletin on this issue. This …
Read full complaint
The electronic dashboard does not display critical information like speed, engine RPM, engine warning lights, etc. The electronic dashboard stopped working and remains a black screen with no information about vehicle speed and other important infomation available to the driver. VW has a technical bulletin on this issue. This is a major safety hazard and should be upgraded to a recall. I am afraid to drive the car without knowing the vehicle speed or other missing information normally displayed on the dashboard.
NHTSA ODI #11754584
Mileage unknown · Jul 3, 2026
Unknown Or Other
Unknown
NHTSA ODI #11748126
Mileage unknown · Jan 1, 2026
Unknown Or Other
While I was driving on the highway, the EPC light came on and the car began to lose power. It went into "limp" mode and lost all oil. I had it diagnosed at VW Carlock North Nashville. They told me the "exhaust camshaft cover bolts backed themselves out causing oil to get into timing belt and make belt swell causing it to lose te…
Read full complaint
While I was driving on the highway, the EPC light came on and the car began to lose power. It went into "limp" mode and lost all oil. I had it diagnosed at VW Carlock North Nashville. They told me the "exhaust camshaft cover bolts backed themselves out causing oil to get into timing belt and make belt swell causing it to lose tension and sheer timing belt, must replace timing belt, timing belt tensioner, timing belt idle pulley, exhaust camshaft cover bolts." This is barely out of warranty and the car has 46,000 miles. Why would the camshaft cover bolts simply come out? This is extremely dangerous, and the cost to repair it will exceed $3000. I am beyond frustrated.
NHTSA ODI #11708243
Mileage unknown · Oct 25, 2025
Unknown Or Other
The panoramic sunroof randomly shattered while driving. Nothing hit it, and it wasnt opened or cracked.
NHTSA ODI #11695609
Mileage unknown · Jul 23, 2025
Unknown Or Other
When switching the gear in reverse. The car's reverse transmission locks then all of the sudden makes big thump sound and sudden rush of torque/power burst while reversing. It nearly hit a pedestrian if I wasn't careful
NHTSA ODI #11675558
Mileage unknown · Jul 10, 2025
EngineFuel/propulsion SystemUnknown Or Other
My 2019 Volkswagen Jetta cannot be refueled — gas nozzle clicks off instantly or overflows. The check engine light came on, and VW Corporate confirmed code P00FE, indicating a failure of the EVAP system vent valve. This is a sealed emissions component integrated with the fuel tank. Dealership initially claimed there were “no co…
Read full complaint
My 2019 Volkswagen Jetta cannot be refueled — gas nozzle clicks off instantly or overflows. The check engine light came on, and VW Corporate confirmed code P00FE, indicating a failure of the EVAP system vent valve. This is a sealed emissions component integrated with the fuel tank. Dealership initially claimed there were “no codes,” but a video shows their technician confirming the EVAP code, disconnecting the EVAP system, and concluding the tank must be replaced. However, since the valve is a powered solenoid, unplugging the system wouldn't allow it to open — this invalidates their test and diagnosis. VW has denied warranty coverage even though the issue clearly falls under the 8-year/80,000-mile federal emissions warranty as defined by the EPA and VW’s own documentation. I also discovered they misrepresented an active recall (#28H7) and falsely told me I had none. VW Customer Care told me about the recall and informed the dealership. VW Customer Care informed me 7/9/25 that the recall had been repaired. Carfax yesterday and your system today show that it still has not been repaired. This is a safety hazard. I cannot refuel reliably, and the dealership is denying coverage while refusing to provide written documentation or a breakdown of findings. My car is disabled and stranded at the dealership since July 24, 2025 and they will barely communicate.
NHTSA ODI #11672502
Mileage unknown · Feb 22, 2025
Electrical SystemExterior LightingUnknown Or Other
Without any warning whatsoever the entire electrical system goes completely off while driving the vehicle after 5 mins of it being on. This means that the lights including blinker and brake lights go off, air conditioning stops, and the entire dashboard goes off. The engine is still able to run. I am able to use the gas and brea…
Read full complaint
Without any warning whatsoever the entire electrical system goes completely off while driving the vehicle after 5 mins of it being on. This means that the lights including blinker and brake lights go off, air conditioning stops, and the entire dashboard goes off. The engine is still able to run. I am able to use the gas and breaks but I do not know what my speed is or any other information that is typically available via the dashboard. I have tried to do a reset when the problem occurs but that does not help the situation. The safety of myself and others is definitely at risk when this happens since the break lights and turning signal will no longer function at all. I can only use the hazard lights to indicate the hazard this presents. I’ve brought this issue up to multiple Volkswagen dealerships having paid the $200 diagnostics fee every time and they inform me that they are not recognizing the issue. I ask if this has anything to do with a recall that had happened to this car and been “fixed” in 2021 and they do not answer the question. I ask if it is possible that the recall was not fixed correctly and that is why I am having issues and they do not answer the question. I have also emailed customer support at Volkswagen worldwide and they state that my car never had any recalls done which is so incredibly false. I have the paperwork to confirm that it had a total of 6 different recalls done in 2021. I believe one of the recalls was never fixed properly and has only deteriorated worse since 2021. Volkswagen dealership of San Bernardino does not give any codes or anything that is more specific than possible alert to car battery/terminals/cables/clamps issues. Their recommendation was to change the car battery but that was already replaced in Aug 2024. They also recommended to change my oil filter but I had an oil change less than 5 days before at a different location. The pep boys diagnostic Revealed code P253200 which indicates a problem with the ignition switch
NHTSA ODI #11644314
Mileage unknown · Feb 21, 2025
Electrical SystemExterior LightingUnknown Or Other
Without any warning whatsoever the entire electrical system goes completely off while driving the vehicle after 5 mins of it being on. This means that the lights including blinker and brake lights go off, air conditioning stops, and the entire dashboard goes off. The engine is still able to run. I am able to use the gas and brea…
Read full complaint
Without any warning whatsoever the entire electrical system goes completely off while driving the vehicle after 5 mins of it being on. This means that the lights including blinker and brake lights go off, air conditioning stops, and the entire dashboard goes off. The engine is still able to run. I am able to use the gas and breaks but I do not know what my speed is or any other information that is typically available via the dashboard. I have tried to do a reset when the problem occurs but that does not help the situation. The safety of myself and others is definitely at risk when this happens since the break lights and turning signal will no longer function at all. I can only use the hazard lights to indicate the hazard this presents. I’ve brought this issue up to multiple Volkswagen dealerships having paid the $200 diagnostics fee every time and they inform me that they are not recognizing the issue. I ask if this has anything to do with a recall that had happened to this car and been “fixed” in 2021 and they do not answer the question. I ask if it is possible that the recall was not fixed correctly and that is why I am having issues and they do not answer the question. I have also emailed customer support at Volkswagen worldwide and they state that my car never had any recalls done which is so incredibly false. I have the paperwork to confirm that it had a total of 6 different recalls done in 2021. I believe one of the recalls was never fixed properly and has only deteriorated worse since 2021.
NHTSA ODI #11644221
Mileage unknown · Dec 12, 2024
Unknown Or Other
Recall emmissions on the evap purge valve with hose assembly. I am having issues under this recall for the 2019 Volswagen Jetta only my VIN number is not included in the recall but I am experiencing the same code and issues. Volkswagen will not honor the recall because my VIN is not included on this overwhelming problem they hav…
Read full complaint
Recall emmissions on the evap purge valve with hose assembly. I am having issues under this recall for the 2019 Volswagen Jetta only my VIN number is not included in the recall but I am experiencing the same code and issues. Volkswagen will not honor the recall because my VIN is not included on this overwhelming problem they have with this issue. Light has been going on and off for over a year.
NHTSA ODI #11630358
Mileage unknown · Dec 3, 2024
Unknown Or Other
The 2019 VW Jetta has a MASSIVE safety issue that is caused by the Andriod Auto feature/software within the vehicle. When driving (for about 45 minutes - 60 minutes) the Android Auto feature will shut off when a cell phone is fully plugged into the vehicle (via USB cable). Therefore, the Android Auto issue is fully unavailable…
Read full complaint
The 2019 VW Jetta has a MASSIVE safety issue that is caused by the Andriod Auto feature/software within the vehicle. When driving (for about 45 minutes - 60 minutes) the Android Auto feature will shut off when a cell phone is fully plugged into the vehicle (via USB cable). Therefore, the Android Auto issue is fully unavailable for drivers. This is an absolute beyond massive safety concern because a cell phone is not 'hands-free' for a driver. This issue has been addressed online and it seems that there is no solution. Buying a new USB charging cord, software update, etc. This issue is caused by the internal system in the 2019 VW Jetta. Hope this makes sense. But please read articles found online. This issue needs to be resolved ASAP. Especially due to the fact that a cell phone is no longer hands-free, and the use of navigation (Google Maps) is no longer available. I am clearly not the only one with this issue with the vehicle. This HAS TO be investigated as this issue could cause an accident in the future, no doubt. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11628713
Official recalls
11Feb 14, 2024
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain front-wheel drive 2015-2020 Audi A3 Sedan, 2015-2019 Audi A3 Cabriolet, 2019-2020 Volkswagen Jetta GLI, 2018 Golf Sportwagen GP, 2018-2019 Golf Sportwagen A7, 2015-2017 Golf Sportwagen, 2015-2020 Golf GTI, and 2015-2020 Golf A7 vehicles. Due to a problem with a suction jet pump seal inside the fuel tank, fuel may flow into the evaporative emissions (EVAP) system and possibly leak out of the charcoal canister.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will replace the suction pump, free of charge. Final owner notification letters for Audi owners were mailed on July 25, 2024. Final owner letters for VW owners were mailed on August 13, 2024. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are VW: 20UF/Audi: 20YF. Vehicles that were previously recalled under 16V-647 will need to have the new remedy completed. This recall expands and replaces previous recall number 16V-647.
Sep 6, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Jetta vehicles. The instrument cluster may not provide an audible warning to let the driver know that the key is still in the ignition when the door is open. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 114, "Theft Protection."
Consequence & remedy
Consequence: Without an audible warning, the driver may be unaware that the key is left in the ignition, which can increase the risk of vehicle theft or a crash.
Remedy: Dealers will update the instrument cluster, free of charge. Owner notification letters are expected to be mailed November 3, 2023. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 90W7.
Aug 30, 2023
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Golf, Golf Alltrack, Golf Sportwagen, 2019-2020 Golf GTI, and Jetta vehicles equipped with a conventional ignition switch. The ignition switch may fail, especially in high temperature environments.
Consequence & remedy
Consequence: Ignition switch failure can cause the electrical system to shut down and the engine to stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the ignition switch, free of charge. Owner notification letters were mailed February 1, 2024. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 28H7.
Oct 31, 2022
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Volkswagen Tiguan LWB, Golf Sportswagen A7, Golf Alltrack, Golf R GP, Audi Q3, Audi A3 Cabriolet, 2019-2020 Jetta NF, Jetta GLI, Golf GTI, Atlas, Golf A7, Audi A3, 2020-2021 Atlas Cross Sport, and 2021 Atlas FL vehicles. The tire pressure monitoring system may not detect an air pressure loss in adequate time when deflating occurs among all four tires simultaneously. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."
Consequence & remedy
Consequence: An undetected sudden loss of pressure in all four tires increases the risk of a crash.
Remedy: Dealers will update the TPMS software, free of charge. Owner notification letters were mailed November 18, 2022. Owners may contact Volkswagen's customer service at 1-800-893-5298 or Audis customer service at 1-800-253-2834. Volkswagen's numbers for this recall are (Audi) 45J7, and (VW) 45J6 and 45J8.
Dec 11, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Jetta GLI, Golf Alltrack, and Golf GTI vehicles. The front wheel bearings may have been improperly machined, potentially causing excessive stress on the wheel, wheel bolts, or wheel bearings.
Consequence & remedy
Consequence: The excessive stress can cause steering, traction or other stability issues or breakage relating to the front wheels, and increase the risk of a crash.
Remedy: Volkswagen has notified owners, and dealers will replace the wheel bearing assemblies, wheels, and wheel bolts, free of charge. The recall began December 11, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 40P1. Note: The affected owners are advised not to drive their vehicles until the repairs have been made.
Sep 25, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017 Volkswagen Passat, 2018 Tiguan LWB, 2007-2009 Jetta Sedan, 2011-2013, 2015 and 2019 Jetta, 2013 Jetta Hybrid, 2008-2009 Jetta Sportwagen, 2015 Golf Sportwagen, 2013 Golf, 2008-2010 and 2012-2013 Beetle and Beetle Convertible, 2008-2010 Beetle, and Beetle Convertible vehicles. Modifications made while the vehicles were in an internal evaluation period may cause the affected vehicles to not comply with all of the applicable regulatory requirements.
Consequence & remedy
Consequence: If the vehicles do not meet all regulatory requirements, there could be an increased risk of a crash, fire, or injury.
Remedy: Volkswagen will notify owners and repurchase the affected vehicles. The recall began November 6, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01D7. Note: This recall is an expansion of NHTSA recall number 18V-329.
Mar 6, 2019
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2017-2019 Golf Sportwagen, 2019 Jetta, 2015-2019 Golf, and 2018-2019 Tiguan vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the rear axle coil springs, free of charge. The recall began April 12, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J5.
Feb 20, 2019
Volkswagen Group of America (Volkswagen) is recalling certain 2019 Jetta vehicles. An incorrect driver frontal airbag may have been installed during a service/repair visit.
Consequence & remedy
Consequence: In the event of a crash necessitating air bag deployment, the wrong air bag may not work correctly, increasing the risk of injury.
Remedy: Volkswagen will notify owners, and dealers will replace the driver frontal air bag with the correct part, free of charge. The recall began April 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 69Y7.
Dec 19, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas, 2015 Volkswagen Golf SportWagen, and 2019 Volkswagen Jetta vehicles. The rear coil springs may prematurely fracture.
Consequence & remedy
Consequence: If a coil spring fractures while driving, it may damage a rear tire causing a loss of vehicle control, increasing the risk of a crash.
Remedy: Volkswagen has notified owners, and dealers will replace the rear axle coil springs, free of charge. The recall began January 31, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 42J2/42J3.
Nov 26, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018-2019 Volkswagen Atlas and Tiguan and 2019 Volkswagen Jetta vehicles that do not have keyless entry. The instrument cluster may not provide an audible warning to let the driver know that the key is still in the ignition when the door is open. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection."
Consequence & remedy
Consequence: If the driver is not notified by an audible noise that the key is left in the ignition, it can increase the risk of vehicle theft or crash.
Remedy: Volkswagen will notify owners, and dealers will reprogram the instrument cluster, free of charge. The recall began December 13, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's numbers for this recall are 90L3 and 90L4.
Sep 26, 2018
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2019 Volkswagen Jetta vehicles equipped with LED headlights. The passenger side headlight may be incorrectly positioned, reducing the driver's visibility when it is dark. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: A reduction in the driver's visibility can increase the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will replace the passenger side headlight, free of charge. The recall began November 2, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 94L1.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ23007 · Fuel Leak Due To Suction Jet Pump Failure Within Fuel Tank (remedy Effectiveness Of Recall 16V647)
Opened Dec 12, 2023 · Closed Jul 1, 2024
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage:evaporative Emissions:canister; Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (3)
Fuel System, Gasoline:storage:evaporative Emissions:canister
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline:storage:tank Assembly
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Fuel System, Gasoline
On December 12, 2023, the Office of Defects Investigations (ODI) opened RQ23-007 to investigate the remedy repair effectiveness and scope of Volkswagen (VW) recall 16V-647. Recall 16V-647 was issued on September 2, 2016, for a defective suction jet pump (SJP) inside the fuel tank. Failure of the SJP could lead to a fuel leak from the vehicle. This recall covered certain model year (MY) 2015-2016 Volkswagen Golf and Audi A3 passenger car vehicles. The recall remedy repair replaced SJP Version 1.0 with an improved version, Version 1.1. The SJP is designed to purge fuel from the evaporative emissions (EVAP) system. VW’s recall filing stated the SJP may have been damaged during assembly, which could potentially allow fuel to flow directly into the EVAP system. Over time, the fuel could accumulate in, and cause a leak from, the charcoal canister filter element. ODI received consumer complaints of SJP failure leading to a fuel leak, refueling spit back, refueling shutoff, and/or fuel odor in vehicles previously repaired under recall 16V-647. Additional complaints alleging SJP failure leading to the previously stated outcomes were received in vehicles outside the scope of recall 16V-647, including MY 2016-2020 VW Golf and Audi A3 vehicles. VW issued recall 24V-110 on February 14, 2024, to address issues with SJPs Versions 1.0 and 1.1. The recall remedy replaces the SJP Version 1.0 or 1.1 with an improved version, Version 2.0. Recall 24V-110 covers certain MY 2015-2020 VW Golf (including Golf GTI), 2015-2020 Audi A3, and 2019-2020 VW Jetta GLI vehicles, including vehicle previously repaired under 16V-647. Vehicle owners were notified of this recall in April 2024 and VW’s projected date for owner notification of recall remedy availability is August 2024. In view of the recall being conducted by VW, ODI is closing this Recall Query (RQ). The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP19003 · Vehicle Stalling - Manual Transmission
Opened Sep 3, 2019 · Closed Jun 30, 2020
Status: closed (inferred from source dates) · Engine; Power Train:manual Transmission
The Office of Defects Investigation (ODI) has completed its review of a defect petition received on 14 August 2019 requesting an investigation of an alleged defect of the manual transmissions in Model Year (MY) 2019 Volkswagen (VW) GTI, Golf GTI and Jetta GLI vehicles. The stalling incidents cited occurred without warning as the vehicle slows to a stop or prepares to make a turn across traffic with the clutch pressed in and the vehicle in neutral.The hazard posed by a vehicle stalling event is manifested in the inability of the vehicle to move with the flow of surrounding traffic. Two factors have a major impact on the potential hazard to the vehicle, its occupants and surrounding vehicles: the surrounding traffic speed and the subject vehicle's restart ability. In the case of the vehicles that are the subject of this petition, restart is immediate and the stalls occur when the vehicle is slowing to stop for a traffic signal, making a turn, or is completely stopped. These circumstances substantially reduce the risk of harm to the vehicle, its occupants and surrounding vehicles.As of March 2, 2020, out of the population of 11,333 subject vehicles, NHTSA has identified 214 consumer complaints in its database, with unique Vehicle Identification Numbers (VIN), citing engine stalling as vehicles are being brought to a stop and/or preparing to make a cross traffic turn. When combined with the warranty, field report and customer complaint data received from VW in response to the Information Request letter sent, NHTSA identified 413 unique VINs alleging low speed engine stalling.Volkswagen determined that the low speed / idle engine stall was the result of unwanted gases remaining in the cylinder caused by the intake valve camshaft not being in the correct position at idle. The intake camshaft is in an advanced position. This advanced position results in too much overlap with the position of the exhaust valve camshaft, allowing both the intake and exhaust valves to be open at the same time. The erroneous advanced position of the intake camshaft is a result of low oil pressure at idle and high oil temperatures, greater than or equal to 110?C/230?F combined with engine control algorithms in the Engine Control Module (ECM) that position the intake camshaft. Based on examination of returned engines, only engines manufactured at the Silao Mexico plant were affected due to a tolerance stack-up issue with the oil system of the engines.In December of 2019, VW initiated a Service Action (24FD) to remedy the stalling issue in the affected vehicles. The warranty for the affected vehicles was extended to December 31, 2025. The software in the Engine Control Module (ECM) will be updated with a new calibration value for the adaptation nodes of the regulation valve. This is a directed action with letters being sent to vehicle owners asking them to bring their vehicles to their dealership to have the software update installed in their vehicle. The letters were sent in December 2019.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Volkswagen in response to an information request and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that the stalling condition as alleged by the petitioner indicates the likelihood of a safety related defect that would warrant a formal investigation, therefore the petition is denied. Further specifics can be found in the Federal Register Notice.ODI complaint ID Numbers are listed on the attached sheet.
Additional source detail variants (2)
Engine
The Office of Defects Investigation (ODI) has completed its review of a defect petition received on 14 August 2019 requesting an investigation of an alleged defect of the manual transmissions in Model Year (MY) 2019 Volkswagen (VW) GTI, Golf GTI and Jetta GLI vehicles. The stalling incidents cited occurred without warning as the vehicle slows to a stop or prepares to make a turn across traffic with the clutch pressed in and the vehicle in neutral.The hazard posed by a vehicle stalling event is manifested in the inability of the vehicle to move with the flow of surrounding traffic. Two factors have a major impact on the potential hazard to the vehicle, its occupants and surrounding vehicles: the surrounding traffic speed and the subject vehicle's restart ability. In the case of the vehicles that are the subject of this petition, restart is immediate and the stalls occur when the vehicle is slowing to stop for a traffic signal, making a turn, or is completely stopped. These circumstances substantially reduce the risk of harm to the vehicle, its occupants and surrounding vehicles.As of March 2, 2020, out of the population of 11,333 subject vehicles, NHTSA has identified 214 consumer complaints in its database, with unique Vehicle Identification Numbers (VIN), citing engine stalling as vehicles are being brought to a stop and/or preparing to make a cross traffic turn. When combined with the warranty, field report and customer complaint data received from VW in response to the Information Request letter sent, NHTSA identified 413 unique VINs alleging low speed engine stalling.Volkswagen determined that the low speed / idle engine stall was the result of unwanted gases remaining in the cylinder caused by the intake valve camshaft not being in the correct position at idle. The intake camshaft is in an advanced position. This advanced position results in too much overlap with the position of the exhaust valve camshaft, allowing both the intake and exhaust valves to be open at the same time. The erroneous advanced position of the intake camshaft is a result of low oil pressure at idle and high oil temperatures, greater than or equal to 110?C/230?F combined with engine control algorithms in the Engine Control Module (ECM) that position the intake camshaft. Based on examination of returned engines, only engines manufactured at the Silao Mexico plant were affected due to a tolerance stack-up issue with the oil system of the engines.In December of 2019, VW initiated a Service Action (24FD) to remedy the stalling issue in the affected vehicles. The warranty for the affected vehicles was extended to December 31, 2025. The software in the Engine Control Module (ECM) will be updated with a new calibration value for the adaptation nodes of the regulation valve. This is a directed action with letters being sent to vehicle owners asking them to bring their vehicles to their dealership to have the software update installed in their vehicle. The letters were sent in December 2019.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Volkswagen in response to an information request and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that the stalling condition as alleged by the petitioner indicates the likelihood of a safety related defect that would warrant a formal investigation, therefore the petition is denied. Further specifics can be found in the Federal Register Notice.ODI complaint ID Numbers are listed on the attached sheet.
Power Train:manual Transmission
The Office of Defects Investigation (ODI) has completed its review of a defect petition received on 14 August 2019 requesting an investigation of an alleged defect of the manual transmissions in Model Year (MY) 2019 Volkswagen (VW) GTI, Golf GTI and Jetta GLI vehicles. The stalling incidents cited occurred without warning as the vehicle slows to a stop or prepares to make a turn across traffic with the clutch pressed in and the vehicle in neutral.The hazard posed by a vehicle stalling event is manifested in the inability of the vehicle to move with the flow of surrounding traffic. Two factors have a major impact on the potential hazard to the vehicle, its occupants and surrounding vehicles: the surrounding traffic speed and the subject vehicle's restart ability. In the case of the vehicles that are the subject of this petition, restart is immediate and the stalls occur when the vehicle is slowing to stop for a traffic signal, making a turn, or is completely stopped. These circumstances substantially reduce the risk of harm to the vehicle, its occupants and surrounding vehicles.As of March 2, 2020, out of the population of 11,333 subject vehicles, NHTSA has identified 214 consumer complaints in its database, with unique Vehicle Identification Numbers (VIN), citing engine stalling as vehicles are being brought to a stop and/or preparing to make a cross traffic turn. When combined with the warranty, field report and customer complaint data received from VW in response to the Information Request letter sent, NHTSA identified 413 unique VINs alleging low speed engine stalling.Volkswagen determined that the low speed / idle engine stall was the result of unwanted gases remaining in the cylinder caused by the intake valve camshaft not being in the correct position at idle. The intake camshaft is in an advanced position. This advanced position results in too much overlap with the position of the exhaust valve camshaft, allowing both the intake and exhaust valves to be open at the same time. The erroneous advanced position of the intake camshaft is a result of low oil pressure at idle and high oil temperatures, greater than or equal to 110?C/230?F combined with engine control algorithms in the Engine Control Module (ECM) that position the intake camshaft. Based on examination of returned engines, only engines manufactured at the Silao Mexico plant were affected due to a tolerance stack-up issue with the oil system of the engines.In December of 2019, VW initiated a Service Action (24FD) to remedy the stalling issue in the affected vehicles. The warranty for the affected vehicles was extended to December 31, 2025. The software in the Engine Control Module (ECM) will be updated with a new calibration value for the adaptation nodes of the regulation valve. This is a directed action with letters being sent to vehicle owners asking them to bring their vehicles to their dealership to have the software update installed in their vehicle. The letters were sent in December 2019.After thoroughly assessing the material submitted by the petitioner, information already in NHTSA's possession, information submitted by Volkswagen in response to an information request and the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that the stalling condition as alleged by the petitioner indicates the likelihood of a safety related defect that would warrant a formal investigation, therefore the petition is denied. Further specifics can be found in the Federal Register Notice.ODI complaint ID Numbers are listed on the attached sheet.
Illustration