← New search

2010 Volkswagen Jetta

Owner reports · Recalls · Investigations

More warning signs than most Jetta years

Owner complaints for the 2010 Volkswagen Jetta are substantially higher than the model-year median of 68.

About this comparison →

When problems were reported

Mileage at the reported incident

779 reports with mileage · 73 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Diesel. Review the 166 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

23 crash reports5 fire reports10 injury reports

What owners actually said

852 reports
Mileage unknown · Jan 23, 2011
Engine And Engine Cooling

I'VE BEEN DRIVING MANUAL TRANS CARS AND TRUCKS FOR 30 YEARS AND NEVER EXPERIENCED THE AMOUNT OF STALLING MY 6 SPEED 2010 VW JETTA SPORTWAGEN TDI EXHIBITS WHILE DRIVING LOW SPEEDS. AT FIRST I THOUGHT IT WAS JUST ME GETTING USED TO THE CAR, BUT SEVERAL ONLINE FORUMS DISCUSS THE SAME PROBLEM. I HAVE OWNED THE CAR 4 MONTHS AND EXPER…

Read full complaint

I'VE BEEN DRIVING MANUAL TRANS CARS AND TRUCKS FOR 30 YEARS AND NEVER EXPERIENCED THE AMOUNT OF STALLING MY 6 SPEED 2010 VW JETTA SPORTWAGEN TDI EXHIBITS WHILE DRIVING LOW SPEEDS. AT FIRST I THOUGHT IT WAS JUST ME GETTING USED TO THE CAR, BUT SEVERAL ONLINE FORUMS DISCUSS THE SAME PROBLEM. I HAVE OWNED THE CAR 4 MONTHS AND EXPERIENCE OVER 6 STALLS. VERY EASY STALLING AT LOW SPEEDS. *LN

NHTSA ODI #10378362

18,200 miles · Jan 23, 2011
Structure

THE FRONT PANEL OF MY PANORAMIC SUNROOF SHATTERED WHILE THE CAR WAS PARKED OVERNIGHT. THERE WAS NO OVERNIGHT PRECIPITATION AND THE OVERNIGHT LOW WAS COLD--ABOUT 0--BUT NOT EXTREMELY SO. THERE WERE NO REMAINING PIECES OF GLASS LARGER THAN A DIME, AND SMALL SPLINTERS OF GLASS FELL ACROSS THE FRONT SEATS. THE DEALER INSISTED THA…

Read full complaint

THE FRONT PANEL OF MY PANORAMIC SUNROOF SHATTERED WHILE THE CAR WAS PARKED OVERNIGHT. THERE WAS NO OVERNIGHT PRECIPITATION AND THE OVERNIGHT LOW WAS COLD--ABOUT 0--BUT NOT EXTREMELY SO. THERE WERE NO REMAINING PIECES OF GLASS LARGER THAN A DIME, AND SMALL SPLINTERS OF GLASS FELL ACROSS THE FRONT SEATS. THE DEALER INSISTED THAT IMPACT WAS THE ONLY POSSIBLE EXPLANATION, BUT THERE ARE NO OBVIOUS IMPACT POINTS. THE CAR WAS NOT PARKED UNDER ANYTHING. NO OTHER PART OF THE CAR WAS DAMAGED, AND NO OTHER CARS IN THE PARKING LOT WERE DAMAGED. THE DEALER REFUSED TO SEE THE CAR, AND VW CUSTOMER CARE IS NOT AVAILABLE ON WEEKENDS. BECAUSE I NEEDED A FORM OF TRANSPORTATION, I OPENED AN INSURANCE CLAIM AND GOT A RENTAL CAR. THE CAR WILL BE CLEANED AND REPAIRED NEXT WEEK. *LN

NHTSA ODI #10378311

7,000 miles · Jan 22, 2011
Fuel System, Gasoline

GLOW PLUG LIGHT CAME ON, THEN ENGINE LIGHT, CAR WOULDN'T ACCELERATE WHEN I STEPPED ON THE GAS. HAD TO PULL OFF THE INTERSTATE. BUT MADE IT HOME SLOWLY. CAR TOWED TO DEALER. DEALER SAYS ITS BAD FUEL. DEPT OF CONSUMER PROTECTION CHECKED STATIONS. NO PROBLEMS FOUND WITH FUEL. CAR NEEDS WHOLE NEW FUEL SYSTEM-8K TO REPAIR. VW WON'T F…

Read full complaint

GLOW PLUG LIGHT CAME ON, THEN ENGINE LIGHT, CAR WOULDN'T ACCELERATE WHEN I STEPPED ON THE GAS. HAD TO PULL OFF THE INTERSTATE. BUT MADE IT HOME SLOWLY. CAR TOWED TO DEALER. DEALER SAYS ITS BAD FUEL. DEPT OF CONSUMER PROTECTION CHECKED STATIONS. NO PROBLEMS FOUND WITH FUEL. CAR NEEDS WHOLE NEW FUEL SYSTEM-8K TO REPAIR. VW WON'T FIX. TOLD ME TO CALL INSURANCE COMPANY. CAR STILL AT DEALER NOW OVER 3 WEEKS.

NHTSA ODI #10379146

Mileage unknown · Jan 21, 2011
Engine And Engine Cooling

I PURCHASED MY 2010 JETTA IN MAY OF 2010. LESS THAN ONE YEAR LATER I HAVE EXPERIENCED POWER LOSS ON FOUR SEPARATE OCCASIONS. EACH TIME THIS OCCURRED I WAS COMING TO A STOP AFTER DRIVING BETWEEN 20-30 MILES. IT SHOULD BE NOTED THAT THERE WAS NO "CHECK ENGINE" LIGHT ILLUMINATED. TWO DAYS LATER I TOOK IT TO THE DEALERSHIP WHO A…

Read full complaint

I PURCHASED MY 2010 JETTA IN MAY OF 2010. LESS THAN ONE YEAR LATER I HAVE EXPERIENCED POWER LOSS ON FOUR SEPARATE OCCASIONS. EACH TIME THIS OCCURRED I WAS COMING TO A STOP AFTER DRIVING BETWEEN 20-30 MILES. IT SHOULD BE NOTED THAT THERE WAS NO "CHECK ENGINE" LIGHT ILLUMINATED. TWO DAYS LATER I TOOK IT TO THE DEALERSHIP WHO ATTEMPTED TO DUPLICATE THE PROBLEM WHICH AS I HAD IMAGINED THEY COULD NOT. *TR

NHTSA ODI #10378178

2,800 miles · Jan 20, 2011
Air BagsCrashInjury

TL*THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE DRIVER CRASHED INTO ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO WARNING LIGHTS ON THE INSTRUMENT PANEL PRIOR TO THE CRASH. THE DRIVER SUSTAINED MINOR INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TO…

Read full complaint

TL*THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE DRIVER CRASHED INTO ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO WARNING LIGHTS ON THE INSTRUMENT PANEL PRIOR TO THE CRASH. THE DRIVER SUSTAINED MINOR INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT GARAGE AND THEY ARE WAITING AN INVESTIGATION UPON APPROVAL. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 2,800. THE VIN WAS UNAVAILABLE.

NHTSA ODI #10378014

Mileage unknown · Jan 19, 2011
Seats

2010 VOLKSWAGEN JETTA. CONSUMER STATES THERE IS A DESIGN FLAW WITH THE HEAD RESTRAINT ON THE DRIVER'S OR FRONT PASSENGER SEAT. *TGW THE CONSUMER STATED HIS WIFE'S HEAD WAS IN CONTACT WITH THE HEAD RESTARINT AND WOULD NOT PROVIDED ANY SUPPORT IN THE EVENT OF A CRASH. DUE TO THE SHAPE, SIZE AND POSITION OF THE RESTRAINT, THE CONS…

Read full complaint

2010 VOLKSWAGEN JETTA. CONSUMER STATES THERE IS A DESIGN FLAW WITH THE HEAD RESTRAINT ON THE DRIVER'S OR FRONT PASSENGER SEAT. *TGW THE CONSUMER STATED HIS WIFE'S HEAD WAS IN CONTACT WITH THE HEAD RESTARINT AND WOULD NOT PROVIDED ANY SUPPORT IN THE EVENT OF A CRASH. DUE TO THE SHAPE, SIZE AND POSITION OF THE RESTRAINT, THE CONSUMER BELIEVED THE FORCE OF A REAR-END COLLISION WOULD FORCE HIS WIFE'S HEAD DOWNWARD TO HER CHEST WHILE THE UPPER BONES OF HER CERVICAL VERTEBRAE WOULD BE FORCED REARWARD INTO THE V-SHAPE CAVITY FORMED BY THE HEAD RESTRAINT AND THE SEAT BACK. JB

NHTSA ODI #10377397

3,000 miles · Jan 11, 2011
Power Train

MY CAR IS A 2010 VW JETTA TDI WITH DSG TRANSMISSION. I TOOK DELIVERY OF THE CAR IN JANUARY OF 2010. DURING JULY OF LAST YEAR WITH 3000 MILES ON THE CAR, I DROVE THE CAR OUT OF A PARKING LOT ON A 95 F DEGREE AFTERNOON. BY THE TIME I REACHED THE EXIT RAMP THE TRANSMISSION, WHICH WAS IN DRIVE MODE, HAD SHIFTED INTO SECOND GEAR. MY …

Read full complaint

MY CAR IS A 2010 VW JETTA TDI WITH DSG TRANSMISSION. I TOOK DELIVERY OF THE CAR IN JANUARY OF 2010. DURING JULY OF LAST YEAR WITH 3000 MILES ON THE CAR, I DROVE THE CAR OUT OF A PARKING LOT ON A 95 F DEGREE AFTERNOON. BY THE TIME I REACHED THE EXIT RAMP THE TRANSMISSION, WHICH WAS IN DRIVE MODE, HAD SHIFTED INTO SECOND GEAR. MY INTENTION WAS TO CROSS OVER THE NEAR LANE OF TRAFFIC INTO THE FAR LANE GOING IN THE OPPOSITE DIRECTION. WHEN A SAFE INTERVAL APPEARED I STEPPED ON THE THROTTLE BUT THE CAR MOVED AHEAD VERY SLOWLY (INTO THE LANE OF FAST MOVING CARS) PRESSING THE THROTTLE FURTHER HAD NO EFFECT. I TOOK MY FOOT OFF THE THROTTLE AND PRESSED DOWN AGAIN AND THE CAR RESPONDED NORMALLY. IT SEEMED AT THE TIME THAT THE TRANSMISSION HAD NOT SHIFTED DOWN INTO FIRST GEAR WHEN I HAD STOPPED AT THE DRIVEWAY EXIT. THE SLOW SPEED LASTED FOR ABOUT TEN SECONDS AND THE ENGINE DID NOT LUG. THE DEALER SAID ALL DSG PROBLEMS HAD BEEN ADDRESSED AND JETTAS IN MY VIN NUMBER SERIES DID NOT REGISTER ANY NEW TRANSMISSION PROBLEMS ON THE VW SERVICE WEB SITE. I AM CONCERNED BECAUSE OF THE POTENTIAL FOR A DISASTROUS ACCIDENT WHEN MY WIFE OR I TRY TO ENTER HIGH SPEED TRAFFIC SHOULD THIS PROBLEM RE-OCCUR. I HAD CALLED YOUR PHONE LINE AFTER THE EVENT AND WAS GIVEN "CALL REFERENCE NUMBER 281881, CONFIRMATION NUMBER 10346067". AND TOLD THAT I WOULD RECEIVE A REPORT FORM BY REGULAR MAIL BUT I NEVER HAVE SO I THOUGHT I SHOULD COMPLETE THE ONLINE FORM. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ODI #10375578

18,579 miles · Jan 8, 2011
Fuel System, Diesel

HAD VOLKSWAGEN 2010 JETTA TDI SERVICED AT VOLKSWAGEN DEALER FOR 20,000 MILE SERVICE, WHICH INCLUDES FUEL FILTER REPLACEMENT. 2 DAYS LATER, SMELLED DIESEL FUMES IN GARAGE. OPENED HOOD AND SAW DIESEL FUEL LEAKING FROM FUEL FILTER. (WAS NOT SURE IF IT WAS SPILLED DURING CHANGE BY DEALER) WENT TO INDEPENDENT GARAGE AND WAS TOLD I…

Read full complaint

HAD VOLKSWAGEN 2010 JETTA TDI SERVICED AT VOLKSWAGEN DEALER FOR 20,000 MILE SERVICE, WHICH INCLUDES FUEL FILTER REPLACEMENT. 2 DAYS LATER, SMELLED DIESEL FUMES IN GARAGE. OPENED HOOD AND SAW DIESEL FUEL LEAKING FROM FUEL FILTER. (WAS NOT SURE IF IT WAS SPILLED DURING CHANGE BY DEALER) WENT TO INDEPENDENT GARAGE AND WAS TOLD IT IS LEAKING AND NOT TO DRIVE THE CAR: POTENTIAL FIRE HAZARD IF DIESEL GETS ON MANIFOLD. I'VE READ SIMILAR DRIVERS COMPLAINT (S) WHERE 2009 JETTA TDI HAS FUEL PUMP FAILURE POSSIBLY AFTER THIS SERVICE AND THEY ALSO HAD THE DIESEL FUEL LEAKING AFTER 20K SERVICE. MINE IS A 2010 JETTA TDI. I WON'T KNOW IF THIS IS AN ERROR OR OMISSION ON THE PART OF THE DEALER OR IF THE REPAIRS WERE DONE CORRECT AND IT'S A DEFECT WITH THE CAR. REGARDLESS, SOMEONE COULD HAVE SERIOUSLY INJURED, POSSIBLY KILLED AND/OR PROPERTY DAMAGE. *LN

NHTSA ODI #10375237

7,500 miles · Jan 3, 2011
Electrical System

I WAS DRIVING MY 2010 VW JETTA WITH MY HUSBAND AND 6 YR OLD DAUGHTER, UNDER NORMAL WEATHER CONDITIONS APPROACHING AN INTERSECTION, ABOUT TO TURN LEFT ACROSS THE INTERSECTION WHEN MY VEHICLE JUST DIED. IT WAS TOWED INTO WHERE I PURCHASED IT SEEING AS IT WAS ONLY 90 DAYS OLD AND THEY HAVE HAD IT SINCE. THERE HAS BEEN NO FORMAL D…

Read full complaint

I WAS DRIVING MY 2010 VW JETTA WITH MY HUSBAND AND 6 YR OLD DAUGHTER, UNDER NORMAL WEATHER CONDITIONS APPROACHING AN INTERSECTION, ABOUT TO TURN LEFT ACROSS THE INTERSECTION WHEN MY VEHICLE JUST DIED. IT WAS TOWED INTO WHERE I PURCHASED IT SEEING AS IT WAS ONLY 90 DAYS OLD AND THEY HAVE HAD IT SINCE. THERE HAS BEEN NO FORMAL DIAGNOSIS, I WAS TOLD IT "COULD BE ELECTRICAL" AND SOME ELECTRICAL WIRES WERE CLEANED AND REPLACED. *TR

NHTSA ODI #10373826

32,475 miles · Dec 18, 2010
Engine And Engine Cooling

1) OVER THE PAST THREE WEEKS, THIS VEHICLE HAS EXPERIENCED SYMPTOMS OF DRAWING WATER THROUGH THE INTAKE AND CYLINDERS ON STARTUP ON 5-6 SEPARATE OCCASIONS. SYMPTOMS INCLUDE: ROUGH IDLE (AS THOUGH MISFIRING ON ONE OR MORE CYLINDERS), WHITE SMOKE, DIFFICULTY GAINING ENGINE RPM, AND STUMBLING FOR FIRST 30-60 SECONDS OF OPERATION …

Read full complaint

1) OVER THE PAST THREE WEEKS, THIS VEHICLE HAS EXPERIENCED SYMPTOMS OF DRAWING WATER THROUGH THE INTAKE AND CYLINDERS ON STARTUP ON 5-6 SEPARATE OCCASIONS. SYMPTOMS INCLUDE: ROUGH IDLE (AS THOUGH MISFIRING ON ONE OR MORE CYLINDERS), WHITE SMOKE, DIFFICULTY GAINING ENGINE RPM, AND STUMBLING FOR FIRST 30-60 SECONDS OF OPERATION UNTIL "CLEARED OUT". ON ONE OCCASION, THE STARTER MOTOR WOULD NOT TURN OVER THE ENGINE DUE TO "HYDROLOCKING" PHENOMENON. WHEN THE STARTER WAS RELEASED AND CRANKED AGAIN, THE CAR CRANKED VERY SLOWLY, CAUGHT, AND STARTED EXTREMELY ROUGHLY, AND NEEDED SIGNIFICANT NURSING OF THROTTLE TO "CLEAR OUT". I TOOK THE CAR TO THE DEALER ON DECEMBER 8TH FOR THE ABOVE BEHAVIOR. THEY COULD OFFER NO EXPLANATION, NO FAULT CODES STORED ON COMPUTER. 2) ON DECEMBER 14TH, DRIVING HOME IN A RAIN AND SNOWSTORM, MY CAR WENT INTO ELECTRONIC LIMP MODE ON THE HIGHWAY AT 70MPH. THE DASH FLASHED "SERVICE ENGINE NOW", THE GLOW PLUG LIGHT FLASHED, AND POWER WAS CUT. I TOOK IT TO THE DEALER THE NEXT DAY - THEY FOUND THE INTERCOOLER AND PRESSURIZED INTAKE LINES FULL OF 1-1.5 CUPS OF ICE AND WATER. THIS FAILURE OCCURS OFTEN, EACH TIME THE CAR IS RUN FOR AN HOUR AT HUMID BELOW FREEZING TEMPERATURES. WHEN THE CAR IS SHUTOFF AND ALLOWED TO WARM TO ABOVE FREEZING, LIQUID WATER IS DRAWING DIRECTLY INTO THE CYLINDERS. THE CONSEQUENCES OF THIS CAN INCLUDE: LIMP MODE, ROUGH STARTING, AND COMPLETED ENGINE DESTRUCTION BY HYDROLOCKING AND BENT OR BROKEN CONNECTING RODS. I STRONGLY SUSPECT MY ENGINE IS PERMANENTLY DAMAGED. 3) THE DEALER DRAINED OUT THE WATER AND REASSEMBLED - SAID THEY CONSIDER THE CAR FIXED. THEY HAVE NOT ADDRESSED THE ROOT CAUSE OF WHY THE POOLS OF WATER ARE PRESENT IN THE INTAKE DURING STARTUP AFTER RUNNING IN HUMID FREEZING CONDITIONS. THE CAUSE IS ICING OF THE INTERCOOLER DURING NORMAL OPERATION, WHICH IS A DESIGN FLAW UNCONTROLLED BY THE USER. WHEN ACCUMULATED ICE MELTS DURING A WARM DAY, THE WATER POOLS AND HAS GRAVE POTENTIAL TO DESTROY THE ENGINE. *TR

NHTSA ODI #10371185

Official recalls

4

16V913000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Dec 20, 2016

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence & remedy

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Additional source detail variants (2)

Electronic Stability Control (esc)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

11V490000 · Fuel System, Diesel

Oct 3, 2011

VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Consequence & remedy

Consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Remedy: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

10V621000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Dec 10, 2010

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

Consequence & remedy

Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

09V333000 · Power Train:automatic Transmission

Aug 20, 2009

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.

Consequence & remedy

Consequence: THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: VOLKSWAGEN WILL REPROGRAM THE TRANSMISSION CONTROL MODULE WITH UPDATED SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 20, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

EA18003 · Air Bag Clockspring Failure

Opened Apr 18, 2018 · No close date supplied

Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Additional source detail variants (3)

Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags:frontal

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

PE11023 · Diesel Fuel Injector Line Leakage

Opened Aug 2, 2011 · Closed Dec 2, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

By letter dated October 3, 2011, Volkswagen Group of America, Inc. (VW) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address a defect in approximately 168,275 model year (MY) 2009-2012 Volkswagen Jetta, Jetta Sportwagen, Golf, and Audi A3 vehicles equipped with the 2.0L TDI Common Rail Clean Diesel engine (NHTSA Recall No. 11V-490).The recalled Jetta and Jetta Sportwagen vehicles were built from May 2008 through September 2011, the Golf vehicles were built from May 2009 through September 2011, and the Audi A3 vehicles were built from September 2009 through September 2011.According to Volkswagen, in U.S. applications of the above cited TDI vehicles including engine codes CJAA and CBEA, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and RPM conditions.This resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.As a contributing factor, VW indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.Lines manufactured in these periods were installed in vehicles produced in the following 10 months:December 2008, January-February 2009, October 2009, March-April 2010 and September-December 2010.Injector lines using this material exhibit a significantly higher failure rate.Dealers will replace injector line #2 in all vehicles built in these months.In addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.Analysis of NHTSA complaints, VW complaints, VW field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.The leaking line was not identified in 62 of the vehicles.For the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.Almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by VW, which accounted for approximately one-quarter of the recalled vehicles.The failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (IPTV).The failure rate for injector line #2 in other production months of recalled vehicles is 0.8 IPTV.The leak/repair rates for the other injector lines are all well under 1 IPTV.The action taken by Volkswagen is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. Accordingly, this investigation is closed.

EA11003 · High-Pressure Fuel Pump Failure

Opened Feb 7, 2011 · Closed Mar 27, 2015

Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Additional source detail variants (2)

Fuel System, Diesel

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

PE10034 · High Pressure Fuel Pump Failure (hpfp)

Opened Aug 26, 2010 · Closed Feb 8, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

The Office of Defects Investigation (ODI) and Volkswagen (VW) have received a total of 160 complaints and field reports alleging incidents of engine stall and/or loss of power that appear to be related to high pressure fuel pump (HPFP) failures in certain model year (MY) 2009 through 2010 Volkswagen Jetta and MY 2010 Volkswagen Golf and Audi A3 vehicles equipped with TDI clean diesel engines.Approximately half of the reports indicate that the failure resulted in an engine stall incident, with many of these alleging stall incidents at highway speeds in traffic with no restart.There has been one minor crash alleged to have resulted from HPFP failure in the subject vehicles.In response to ODI's information request for PE10-034, VW indicated that it had found no defect related to motor vehicle safety with relation to the TDI Clean Diesel fuel system at issue in this investigation and attributed problems with HPFP failure to operation with gasoline contaminated diesel fuel.Volkswagen stated that even a small amount of gasoline in the diesel fuel may disrupt the necessary lubrication required and may cause the HPFP to fail.In response to concerns that fuel contamination was the major cause of HPFP and related fuel system failures, VW issued a Technical Service Bulletin in May 2010 (VW TB V011011 2023624 and Audi TB A011008 2023360-1), with instructions to inspect the diesel fuel for vehicles requiring fuel system service that have symptoms associated with HPFP failure.The bulletin states that fuel system damage incurred by use of fuel not complying to ASTM-D-975 Grade 2 S15 (B5 or less biodiesel content) standards will not be covered under warranty. Volkswagen also provided information about 121 mis-fueling incidents reportedly acknowledged by consumers or dealers and test results for about 50 diesel fuel samples taken from complaint vehicles in late-August through early-October 2010.The mis-fueling incidents include about 20 reports involving incorrect fueling by dealer sales or service personnel and generally report symptoms such as rough running, stalling and/or no start within a few miles of refueling the vehicle with gasoline.Volkswagen indicated that the testing of fuel samples from complaint vehicles found that nearly 90 percent contained high amounts of gasoline.Volkswagen implemented design changes for the HPFP in May 2008, September 2009 and November 2010 to improve the robustness of the pump when used with poor quality fuel.ODI analysis of HPFP failures identified from all sources shows failure rates of 0.53% for MY 2009 vehicles and 0.11% for MY 2010 vehicles.This investigation has been upgraded to an Engineering Analysis (EA11-003) to continue to investigate the issues with mis-fueling and HPFP design identified during the Preliminary Evaluation.