← New search

2010 Volkswagen Jetta

Owner reports · Recalls · Investigations

More warning signs than most Jetta years

Owner complaints for the 2010 Volkswagen Jetta are substantially higher than the model-year median of 68.

About this comparison →

When problems were reported

Mileage at the reported incident

779 reports with mileage · 73 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Diesel. Review the 166 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

23 crash reports5 fire reports10 injury reports

Vehicle Speed Control complaints

30 reports
Clear category filter
53,000 miles · Aug 13, 2013
Fuel System, DieselVehicle Speed Control

VW JETTA SPORTSWAGEN TDI 2010 53,000 MILES. ON AUG 7, 2013 AT APPROXIMATELY 16:20, WHILE STOPPED AT A TRAFFIC SIGNAL, ENGINE BEGINS TO RUN SLIGHTLY ROUGHLY, BUT NOT SUFFICIENT TO BE OF CONCERN. ACCELERATE FROM TRAFFIC SIGNAL TOWARDS ONRAMP TO I195. SUDDENLY ENGINE DIES (BEFORE ONRAMP). COAST CAR INTO PARKING LOT AT SIDE OF RO…

Read full complaint

VW JETTA SPORTSWAGEN TDI 2010 53,000 MILES. ON AUG 7, 2013 AT APPROXIMATELY 16:20, WHILE STOPPED AT A TRAFFIC SIGNAL, ENGINE BEGINS TO RUN SLIGHTLY ROUGHLY, BUT NOT SUFFICIENT TO BE OF CONCERN. ACCELERATE FROM TRAFFIC SIGNAL TOWARDS ONRAMP TO I195. SUDDENLY ENGINE DIES (BEFORE ONRAMP). COAST CAR INTO PARKING LOT AT SIDE OF ROAD. TOTAL TIME FROM BEGINNING OF ROUGH IDLE TO ENGINE SHUTDOWN WAS ABOUT 10-15 SECONDS. HAD FAILURE OCCURRED ON INTERSTATE I195 OR I95 DURING RUSH HOUR, THIS WOULD HAVE BEEN A DANGEROUS CONDITION -- POSSIBLE STRANDING OF CAR IN A TRAVEL LANE OR DANGEROUS CROSSING IN FRONT OF FASTER MOVING TRAFFIC TO REACH SHOULDER. CALLED FOR TOW AND CAR TOWED AT ABOUT 19:00 TO VW DEALER - WEST BROAD VOLKSWAGEN IN RICHMOND VA. DEALERSHIP IS CLOSED SO LEAVE CAR AT DEALER. SPOUSE DRIVES FROM HOME ABOUT 100 MILES TO PICK ME UP. REACH HOME BY 23:30. ON AUG 8 DEALER DIAGNOSES AS A FAILED HIGH PRESSURE FUEL PUMP (TDI DIESEL ENGINE) WITH METAL PARTICLES THROUGHOUT THE FUEL SYSTEM. VWOA TECH LINE INDICATES THAT ENTIRE FUEL SYSTEM NEEDS TO BE REPLACED. CAR IS OUT OF WARRANTY, BUT DEALER ASKS VWOA TO COVER PART OR ALL OF COST. ON AUG 9 VWOA APPROVES REPAIR AND AGREES TO PAY IN FULL. WORK COMPLETED ON AUG 12. *TR

NHTSA ODI #10535249

50,000 miles · Jul 23, 2013
Fuel System, DieselVehicle Speed Control

THIS 2010 VW JETTA TDI OCCASIONALLY STALLS AT SPEEDS OF LESS THAN ~30 MPH AND SURGES VIOLENTLY WHEN STARTING FROM A STOP AND SLOWING TO A STOP. IN A SPAN OF 3 MONTHS THE VEHICLE HAS STALLED 5 TIMES, 3 TIMES WHILE BEGINNING TO MOVE FROM A STOP AND 2 TIMES WHILE TRAVELING AT A SPEEDS OF LESS THAN 30 MPH. THE SURGING HAPPENS FREQUE…

Read full complaint

THIS 2010 VW JETTA TDI OCCASIONALLY STALLS AT SPEEDS OF LESS THAN ~30 MPH AND SURGES VIOLENTLY WHEN STARTING FROM A STOP AND SLOWING TO A STOP. IN A SPAN OF 3 MONTHS THE VEHICLE HAS STALLED 5 TIMES, 3 TIMES WHILE BEGINNING TO MOVE FROM A STOP AND 2 TIMES WHILE TRAVELING AT A SPEEDS OF LESS THAN 30 MPH. THE SURGING HAPPENS FREQUENTLY BUT INCONSISTENTLY. THE VEHICLE HAS BEEN BROUGHT TO A VW DEALER/MECHANIC TO ADDRESS THESE ISSUES AND THE PROBLEM PERSISTS. THE LAST TIME IT WENT IN TO THE DEALER, THE MECHANIC REPLACED THE FLYWHEEL STATING THAT IT WAS THE REASON FOR THE SURGING, HOWEVER THE STALLING AND SURGING REMAIN A PROBLEM SINCE THE FLYWHEEL HAS BEEN REPLACED. THE VEHICLE HAS AN AUTOMATIC TRANSMISSION AND HAS NEVER BEEN FILLED WITH GASOLINE. *TR

NHTSA ODI #10531492

Mileage unknown · Jul 22, 2013
Electrical SystemVehicle Speed Control

SINCE THE VEHICLE WAS PURCHASED IT HAS HAD ROUGH ACCELERATION AND INTERMITTENT SURGING BUT JUST RECENTLY IT HAS EXHIBITED ROUGH AND NO STARTS ALONG WITH STALLS WHICH ALL SEEMS TO BE DUE TO AN ISSUE WITH THE ECU LOSING DIAGNOSTIC COMMUNICATION WITH THE VEHICLE. *TR

NHTSA ODI #10526131

91,000 miles · May 17, 2013
Vehicle Speed Control

DRIVING AT 40 MILES PER HOUR, AS I ACCELERATED TO PASS ON THE LEFT, THE CAR WENT INTO LIMP MODE AND ACCELERATED IN SLOW MOTION, IT TOOK ABOUT 1/2 MILE TO GET UP TO 45 MPH. THEN I NOTICED THE DASHBOARD LIGHT CAME ON WHILE I WAS STILL DRIVING, NOW ATTEMPTING TO GET ON TO THE INTERSTATE. ACCELERATING AT ABNORMALLY SLOW SPEEDS, IT …

Read full complaint

DRIVING AT 40 MILES PER HOUR, AS I ACCELERATED TO PASS ON THE LEFT, THE CAR WENT INTO LIMP MODE AND ACCELERATED IN SLOW MOTION, IT TOOK ABOUT 1/2 MILE TO GET UP TO 45 MPH. THEN I NOTICED THE DASHBOARD LIGHT CAME ON WHILE I WAS STILL DRIVING, NOW ATTEMPTING TO GET ON TO THE INTERSTATE. ACCELERATING AT ABNORMALLY SLOW SPEEDS, IT TOOK ABOUT A MILE TO GET UP TO 60. I THEN DETERMINED FROM THE MANUAL THAT THE LIGHT WAS A "GLOW PLUG" LIGHT. I CALLED THE DEALER AND THEY INFORMED ME I COULD CONTINUE DRIVING THE CAR, BUT I SHOULD BRING IT TO THEM RIGHT AWAY. THE CAR DROVE FOR APPROXIMATELY 6 MILES, AT WHICH TIME THE RED BATTERY LIGHT CAME ON, AND THE CAR COMPLETELY DIED. I HAD TO CROSS TWO LANES OF TRAVEL IN ORDER TO GET TO THE SHOULDER OF THE ROAD. BY THE TIME THE TOW TRUCK CAME, MY LOCAL DEALER WAS CLOSED, AND I WAS FORCED TO CALL A LOCAL REPAIR SHOP OWNER THAT WORKS ON NOTHING BUT VWS AND AUDI'S. (THIS SHOP IS TRUSTED, AND HAS WORKED ON MY VEHICLES FOR 8+ YEARS). HE DIAGNOSED IT AS FUEL PUMP PROBLEM, AND CONFIRMED THAT IT WAS ONLY DIESEL IN THE TANK. I CONTACTED VW USA, WHO WANTED TO TAKE NO ACTION AND STATED THAT THERE WAS NO RESTITUTION, NOR WOULD THEY TAKE ANY ACTION UNLESS INSPECTED AND DIAGNOSED BY A DEALER. SADLY, VW OBVIOUSLY IS AWARE THEY HAVE A RECURRING PROBLEM, AND THIS PUMP SEEMS TO BE EITHER ON BACK-ORDER OR HOARDED BY THE DEALERS, THUS MADE UNAVAILABLE. AT THE CURRENT TIME, MY LOCAL REPAIR SHOP IS WORKING DILIGENTLY TO FIND A PUMP SOMEWHERE IN NORTH AMERICA. *TR

NHTSA ODI #10512599

113,000 miles · May 13, 2013
Power TrainVehicle Speed Control

WHILE IN DRIVE ON THE HIGHWAY AT 70 MPH, DSG TRANSMISSION SLIPPED INTO NEUTRAL, WHERE IT BECAME LOCKED. ESP ICON ON DASH ILLUMINATED. I HAD TO COAST TO THE SIDE OF THE ROAD IN HEAVY TRAFFIC. AFTER COMING TO A STOP I PUT THE VEHICLE INTO PARK. I WAS THEN UNABLE TO REMOVE THE VEHICLE FROM PARK BECAUSE THE SHIFTER BECAME LOCKED…

Read full complaint

WHILE IN DRIVE ON THE HIGHWAY AT 70 MPH, DSG TRANSMISSION SLIPPED INTO NEUTRAL, WHERE IT BECAME LOCKED. ESP ICON ON DASH ILLUMINATED. I HAD TO COAST TO THE SIDE OF THE ROAD IN HEAVY TRAFFIC. AFTER COMING TO A STOP I PUT THE VEHICLE INTO PARK. I WAS THEN UNABLE TO REMOVE THE VEHICLE FROM PARK BECAUSE THE SHIFTER BECAME LOCKED. I TURNED THE VEHICLE OFF, AND RESTARTED IT, AND THAT SEEMED TO FIX IT; AS I WAS THEN ABLE TO SHIFT INTO DRIVE. DURING THIS, I HAD MY 10 MONTH OLD AND 4 YR OLD IN THE CAR WITH ME...A SCARY AND UNSAFE SITUATION WITH HEAVY AND FAST MOVING TRAFFIC, WHILE LEFT STUCK REVVING IN NEUTRAL WITH NO POWER AVAILABLE TO MOVE ME OUT OF HARMS WAY. JUST GLAD I WAS ABLE TO MANEUVER MY VEHICLE OVER TO SAFETY. SIMILAR SITUATION HAPPENED AFTER REFUELING THAT SAME DAY. STARTED CAR, SHIFTED TO DRIVE, ESP ICON CAME ON, TRANSMISSION WAS STUCK AND REVVING IN NEUTRAL, EVEN THOUGH I WAS IN DRIVE. SHIFTED INTO PARK, WHERE IT AGAIN BECAME LOCKED AND UNABLE TO SHIFT. TURNED VEHICLE OFF AND BACK ON, AND WAS OK. *TR

NHTSA ODI #10511669

35,000 miles · Apr 29, 2013
Vehicle Speed Control

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE SHIFTING FROM DRIVE TO PARK, THE VEHICLE ACCELERATED INDEPENDENTLY. THE CONTACT STATED THAT THE DOOR LOCKS ON THE REAR PASSENGER DOOR FAILED. THE VEHICLE WAS NOT INSPECTED AT DEALER OR REPAIR SHOP. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, HOWEVER…

Read full complaint

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE SHIFTING FROM DRIVE TO PARK, THE VEHICLE ACCELERATED INDEPENDENTLY. THE CONTACT STATED THAT THE DOOR LOCKS ON THE REAR PASSENGER DOOR FAILED. THE VEHICLE WAS NOT INSPECTED AT DEALER OR REPAIR SHOP. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, HOWEVER NO ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 35,000. THE CURRENT MILEAGE WAS 44,000.

NHTSA ODI #10509877

15,000 miles · Jan 9, 2013
Vehicle Speed Control

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT ATTEMPTED TO ACCELERATE AND THE VEHICLE DID NOT RESPOND. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC TESTING WHERE THE TECHNICIAN STATED THAT THERE WERE NO FAILURES. THE VEHICLE WAS TAKEN TO THE DEALER F…

Read full complaint

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE CONTACT ATTEMPTED TO ACCELERATE AND THE VEHICLE DID NOT RESPOND. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC TESTING WHERE THE TECHNICIAN STATED THAT THERE WERE NO FAILURES. THE VEHICLE WAS TAKEN TO THE DEALER FOR THE SAME FAILURE ON SEVERAL OCCASIONS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 15,000 AND THE CURRENT MILEAGE WAS 21,758. UPDATED 2/25/2013 *JS

NHTSA ODI #10491993

55,000 miles · Dec 18, 2012
EngineVehicle Speed Control

THE CAR ABRUPTLY DECELERATED FROM 65 TO 35 MPH ON A MAJOR INTERSTATE AS THE ENGINE WENT INTO 'LIMP MODE'. THE SUDDEN DECELERATION CAUSED SWERVING AND I HAD TO PULL OVER TO THE CURB IN ORDER TO AVOID AN ACCIDENT. THE COIL/CHECK ENGINE LIGHT TURNED ON AND CAR HESITATED AS IT DROVE. THIS IS THE THIRD INCIDENT THAT THIS CAR HAS HAD …

Read full complaint

THE CAR ABRUPTLY DECELERATED FROM 65 TO 35 MPH ON A MAJOR INTERSTATE AS THE ENGINE WENT INTO 'LIMP MODE'. THE SUDDEN DECELERATION CAUSED SWERVING AND I HAD TO PULL OVER TO THE CURB IN ORDER TO AVOID AN ACCIDENT. THE COIL/CHECK ENGINE LIGHT TURNED ON AND CAR HESITATED AS IT DROVE. THIS IS THE THIRD INCIDENT THAT THIS CAR HAS HAD WITH THE EXHAUST PROBLEM CAUSING ENGINE TO FORCE DECELERATION AND ABRUPT STOPPING EVEN STALLING. THE SYSTEM THIS TIME DIAGNOSED A DEFECTIVE EXHAUST CONTROL MODULE/FLAP. THE PREVIOUS EMISSIONS ISSUE WHILE THE CAR WAS UNDER WARRANTY INVOLVED DEFECTIVE EGR VALVES. PROBLEM SEEMS TO SHOW UP EVERY 10-15K MILES ON THIS DIESEL MODEL. *TR

NHTSA ODI #10489093

60,000 miles · Dec 13, 2012
Electrical SystemVehicle Speed Control

I WAS DRIVING ON THE HIGHWAY DOING ABOUT 55 MILES AN HOUR WITH FULL TRAFFIC AND MY JETTA SPUTTERED AND BEGAN TO LOSE SPEED-QUICKLY, I TRIED TO ACCELERATE BY PRESSING GAS PEDAL BUT NOTHING HAPPENED AND I LUCKILY COASTED INTO STORE PARKING LOT. I TRIED TO RESTART IT BUT IT WOULD NOT RESTART. I HAD IT TOWED TO VW DEALERSHIP AND THE…

Read full complaint

I WAS DRIVING ON THE HIGHWAY DOING ABOUT 55 MILES AN HOUR WITH FULL TRAFFIC AND MY JETTA SPUTTERED AND BEGAN TO LOSE SPEED-QUICKLY, I TRIED TO ACCELERATE BY PRESSING GAS PEDAL BUT NOTHING HAPPENED AND I LUCKILY COASTED INTO STORE PARKING LOT. I TRIED TO RESTART IT BUT IT WOULD NOT RESTART. I HAD IT TOWED TO VW DEALERSHIP AND THEY CALLED ME THE NEXT DAY TO SAY IT WAS THE INTERCOOLANT SYSTEM AND IT WOULD BE 1300.00. VERY VERY LUCKY I WAS NOT HIT. *TR

NHTSA ODI #10488717

33,300 miles · Aug 19, 2012
Vehicle Speed Control

THIS VEHICLE IS A DIESEL. AS I WAS PRESSING THE ACCELERATOR TO INCREASE MY SPEED FROM A CONSTRUCTION ZONE SPEED TO 55 MPH THE ENGINE LIGHT CAME ON, THE CAR BEGAN TO SPUTTER AND ACTED AS IF NO FUEL WAS BEING INJECTED TO THE ENGINE, AS I PULLED OFF THE ROAD THE CAR KEPT RUNNING BUT IF I PRESSED THE ACCELERATOR NOTHING WOULD HAPPE…

Read full complaint

THIS VEHICLE IS A DIESEL. AS I WAS PRESSING THE ACCELERATOR TO INCREASE MY SPEED FROM A CONSTRUCTION ZONE SPEED TO 55 MPH THE ENGINE LIGHT CAME ON, THE CAR BEGAN TO SPUTTER AND ACTED AS IF NO FUEL WAS BEING INJECTED TO THE ENGINE, AS I PULLED OFF THE ROAD THE CAR KEPT RUNNING BUT IF I PRESSED THE ACCELERATOR NOTHING WOULD HAPPEN, NO MOVEMENT ON THE RPM INDICATOR. I WAS ABLE TO GET THE CAR OFF THE HIGHWAY VIA THE EXIT RAMP. IT STARTED UP AND IMMEDIATELY THE WARNING MESSAGE CAME ACROSS THE VEHICLE INFORMATION SCREEN TO SERVICE IMMEDIATELY AND I CAN'T RECALL THE EXACT WORDING BUT BASICALLY SAYING DAMAGE COULD OCCUR. CAR WAS TOWED FOR SERVICE. CAR WAS FIXED ON 4/24/2012 REPLACING THE ACCELERATOR PEDAL SENSOR AND THE ENGINE SPEED SENSOR. PRIOR TO THIS MAJOR MALFUNCTION, THE CAR HAD DIED WHILE IN TRAFFIC TWICE AT A RED TRAFFIC LIGHT, TWICE WHILE ON THE FREEWAY. ALL OCCASIONS THE VEHICLE RESTARTED AND DROVE JUST FINE. VEHICLE WAS SERVICED FOR ROUTINE 40000 NOTHING FOUND AMISS BY MECHANIC. JUST RECENTLY ON 7/12/2012 DIED @ A RED LIGHT. VEHICLE STARTED UP FINE AND NO MESSAGES ON THE SCREEN. 7/19/2012 VEHICLE WOULD NOT GO INTO GEAR AFTER STOPPING FOR 20 MINUTES, TURNED CAR OFF AND RESTARTED IT WENT INTO GEAR NO PROBLEM. ON 7/28/2012 VEHICLE AGAIN DIED @ A RED LIGHT, STARTED UP JUST FINE, NO WARNING MESSAGES. *TR

NHTSA ODI #10471429

Official recalls

4

16V913000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Dec 20, 2016

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence & remedy

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Additional source detail variants (2)

Electronic Stability Control (esc)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

11V490000 · Fuel System, Diesel

Oct 3, 2011

VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Consequence & remedy

Consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Remedy: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

10V621000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Dec 10, 2010

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

Consequence & remedy

Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

09V333000 · Power Train:automatic Transmission

Aug 20, 2009

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.

Consequence & remedy

Consequence: THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: VOLKSWAGEN WILL REPROGRAM THE TRANSMISSION CONTROL MODULE WITH UPDATED SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 20, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

EA18003 · Air Bag Clockspring Failure

Opened Apr 18, 2018 · No close date supplied

Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Additional source detail variants (3)

Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags:frontal

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

PE11023 · Diesel Fuel Injector Line Leakage

Opened Aug 2, 2011 · Closed Dec 2, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

By letter dated October 3, 2011, Volkswagen Group of America, Inc. (VW) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address a defect in approximately 168,275 model year (MY) 2009-2012 Volkswagen Jetta, Jetta Sportwagen, Golf, and Audi A3 vehicles equipped with the 2.0L TDI Common Rail Clean Diesel engine (NHTSA Recall No. 11V-490).The recalled Jetta and Jetta Sportwagen vehicles were built from May 2008 through September 2011, the Golf vehicles were built from May 2009 through September 2011, and the Audi A3 vehicles were built from September 2009 through September 2011.According to Volkswagen, in U.S. applications of the above cited TDI vehicles including engine codes CJAA and CBEA, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and RPM conditions.This resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.As a contributing factor, VW indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.Lines manufactured in these periods were installed in vehicles produced in the following 10 months:December 2008, January-February 2009, October 2009, March-April 2010 and September-December 2010.Injector lines using this material exhibit a significantly higher failure rate.Dealers will replace injector line #2 in all vehicles built in these months.In addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.Analysis of NHTSA complaints, VW complaints, VW field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.The leaking line was not identified in 62 of the vehicles.For the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.Almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by VW, which accounted for approximately one-quarter of the recalled vehicles.The failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (IPTV).The failure rate for injector line #2 in other production months of recalled vehicles is 0.8 IPTV.The leak/repair rates for the other injector lines are all well under 1 IPTV.The action taken by Volkswagen is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. Accordingly, this investigation is closed.

EA11003 · High-Pressure Fuel Pump Failure

Opened Feb 7, 2011 · Closed Mar 27, 2015

Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Additional source detail variants (2)

Fuel System, Diesel

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

PE10034 · High Pressure Fuel Pump Failure (hpfp)

Opened Aug 26, 2010 · Closed Feb 8, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

The Office of Defects Investigation (ODI) and Volkswagen (VW) have received a total of 160 complaints and field reports alleging incidents of engine stall and/or loss of power that appear to be related to high pressure fuel pump (HPFP) failures in certain model year (MY) 2009 through 2010 Volkswagen Jetta and MY 2010 Volkswagen Golf and Audi A3 vehicles equipped with TDI clean diesel engines.Approximately half of the reports indicate that the failure resulted in an engine stall incident, with many of these alleging stall incidents at highway speeds in traffic with no restart.There has been one minor crash alleged to have resulted from HPFP failure in the subject vehicles.In response to ODI's information request for PE10-034, VW indicated that it had found no defect related to motor vehicle safety with relation to the TDI Clean Diesel fuel system at issue in this investigation and attributed problems with HPFP failure to operation with gasoline contaminated diesel fuel.Volkswagen stated that even a small amount of gasoline in the diesel fuel may disrupt the necessary lubrication required and may cause the HPFP to fail.In response to concerns that fuel contamination was the major cause of HPFP and related fuel system failures, VW issued a Technical Service Bulletin in May 2010 (VW TB V011011 2023624 and Audi TB A011008 2023360-1), with instructions to inspect the diesel fuel for vehicles requiring fuel system service that have symptoms associated with HPFP failure.The bulletin states that fuel system damage incurred by use of fuel not complying to ASTM-D-975 Grade 2 S15 (B5 or less biodiesel content) standards will not be covered under warranty. Volkswagen also provided information about 121 mis-fueling incidents reportedly acknowledged by consumers or dealers and test results for about 50 diesel fuel samples taken from complaint vehicles in late-August through early-October 2010.The mis-fueling incidents include about 20 reports involving incorrect fueling by dealer sales or service personnel and generally report symptoms such as rough running, stalling and/or no start within a few miles of refueling the vehicle with gasoline.Volkswagen indicated that the testing of fuel samples from complaint vehicles found that nearly 90 percent contained high amounts of gasoline.Volkswagen implemented design changes for the HPFP in May 2008, September 2009 and November 2010 to improve the robustness of the pump when used with poor quality fuel.ODI analysis of HPFP failures identified from all sources shows failure rates of 0.53% for MY 2009 vehicles and 0.11% for MY 2010 vehicles.This investigation has been upgraded to an Engineering Analysis (EA11-003) to continue to investigate the issues with mis-fueling and HPFP design identified during the Preliminary Evaluation.