← New search

2010 Volkswagen Jetta

Owner reports · Recalls · Investigations

More warning signs than most Jetta years

Owner complaints for the 2010 Volkswagen Jetta are substantially higher than the model-year median of 68.

About this comparison →

When problems were reported

Mileage at the reported incident

779 reports with mileage · 73 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Diesel. Review the 166 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

23 crash reports5 fire reports10 injury reports

Fuel System, Gasoline complaints

31 reports
Clear category filter
23,600 miles · Oct 4, 2011
Engine And Engine CoolingFuel System, Gasoline

MOTOR LOST MOST POWER BUT WAS ABLE TO GO 10-15MPH TO GET TO END OF TRIP. CHECK ENGINE LIGHT CAME ON AND GLOW PLUG LIGHT FLASHED ON & OFF. CALLED VW AND THEY SCHEDULED APPT FOR NEXT DAY, SAID IT WAS OK TO DRIVE IN. BEGAN DRIVE HOME ON MAJOR CITY STREET. WHILE DRIVING, THE ENGINE DIED AND WOULD NOT RESTART. CAR STALLED IN LEF…

Read full complaint

MOTOR LOST MOST POWER BUT WAS ABLE TO GO 10-15MPH TO GET TO END OF TRIP. CHECK ENGINE LIGHT CAME ON AND GLOW PLUG LIGHT FLASHED ON & OFF. CALLED VW AND THEY SCHEDULED APPT FOR NEXT DAY, SAID IT WAS OK TO DRIVE IN. BEGAN DRIVE HOME ON MAJOR CITY STREET. WHILE DRIVING, THE ENGINE DIED AND WOULD NOT RESTART. CAR STALLED IN LEFT LANE BLOCKING RUSH HOUR TRAFFIC. THE DRIVER OF THE FOLLOWING CAR WAS ABLE TO STOP TRAFFIC ENOUGH TO ALLOW US TO PUSH THE DEAD VW OFF THE ROAD TO THE RIGHT. CARS WERE ATTEMPTING TO PASS US AS WE PUSHED IT TO THE SIDE. CALLED VW AND THEY SENT A TOW TRUCK. DIAGNOSTICS THE NEXT DAY FOUND METAL IN THE TDI DIESEL HIGH PRESSURE FUEL PUMP. FUEL SYSTEM IS TO BE REPLACED UNDER WARRANTY. *TR

NHTSA ODI #10428406

Mileage unknown · Sep 9, 2011
Fuel System, Gasoline

TOOK MY CAR TO GET THE OIL CHANGE AND WAS TOLD I HAVE A FUEL LEAK. LOOKED UP CAR ONLINE AT SAFECAR.GOV AND SAW THE 2010 JETTA HAS BEEN RECALLED FOR: POWER TRAIN:AUTOMATIC TRANSMISSION/ FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS. HAVING A FUEL LEAK IS MORE THAN DRAINING ON GAS MILEAGE IT IS A FIRE/EXPLOS…

Read full complaint

TOOK MY CAR TO GET THE OIL CHANGE AND WAS TOLD I HAVE A FUEL LEAK. LOOKED UP CAR ONLINE AT SAFECAR.GOV AND SAW THE 2010 JETTA HAS BEEN RECALLED FOR: POWER TRAIN:AUTOMATIC TRANSMISSION/ FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS. HAVING A FUEL LEAK IS MORE THAN DRAINING ON GAS MILEAGE IT IS A FIRE/EXPLOSIVE HAZARD. ON THE WEBSITE IT STATES: CONSEQUENCE: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE. I AM HAVING ISSUES WITH THE FUEL LEAKAGE AND NEED MY CAR RECALLED OR FIXED BY THE MANUFACTURER. HTTP://WWW-ODI.NHTSA.DOT.GOV/RECALLS/RESULTS.CFM THANK YOU *TR

NHTSA ODI #10424552

18,500 miles · Sep 9, 2011
Fuel System, Gasoline

THE VEHICLE GLOW POINT WARNING LIGHT STARTED FLASHING AND VEHICLE LOST POWER. RESTARTED AND DROVE HOME WITH NO FURTHER INDICATOR LIGHTS. RESTARTED THE FOLLOWING MORNING, CHECK ENGINE AND GLOW POINT WARNING LIGHTS ILLUMINATED (GLOW POINT WAS FLASHING). CAR LOST POWER TO THE POINT THAT WHEN THE TOW TRUCK CAME THE CAR COULD NOT …

Read full complaint

THE VEHICLE GLOW POINT WARNING LIGHT STARTED FLASHING AND VEHICLE LOST POWER. RESTARTED AND DROVE HOME WITH NO FURTHER INDICATOR LIGHTS. RESTARTED THE FOLLOWING MORNING, CHECK ENGINE AND GLOW POINT WARNING LIGHTS ILLUMINATED (GLOW POINT WAS FLASHING). CAR LOST POWER TO THE POINT THAT WHEN THE TOW TRUCK CAME THE CAR COULD NOT CLIMB THE RAMP UNDER ITS OWN POWER THOUGH ENGINE WAS RUNNING. VW DEALER REPORTS THAT FUEL PUMP DISINTEGRATED AND SENT METAL FRAGMENTS INTO FUEL SYSTEM DAMAGING COMPONENTS OF SYSTEM BUT NOT ENTERING ENGINE. *TR

NHTSA ODI #10424547

26,000 miles · Aug 15, 2011
Fuel System, Gasoline

WHILE TRAVELING AT 70 MPH ON CRUISE CONTROL GLOW-PLUG LIGHT FLASHED SOLID, COMPLETE LOSS OF POWER, ENGINE STALLED, AND NO RESTART. DEALER STATED CATASTROPHIC FAILURE OF THE HIGH PRESSURE FUEL PUMP CONTAMINATED ENTIRE FUEL SYSTEM AND WOULD NEED TO BE REPLACED.

NHTSA ODI #10420245

18,000 miles · Aug 9, 2011
Fuel System, Gasoline

VEHICLE WAS GOING AT 25 MPH WHEN IT STARTED LOSING POWER. IT STOPPED BARELY FEW FEET AFTER THE INTERSECTION. ENGINE WOULD NOT START. VEHICLE WAS TOWED AWAY TO THE NEAREST VW DEALERSHIP. AFTER INVESTIGATION DEALERSHIP SAYS THAT THEY FOUND TRACES OF GASOLINE IN THE FUEL PUMP AND GASOLINE HAS DESTROYED THE FUEL SYSTEM. I SHOWED THE…

Read full complaint

VEHICLE WAS GOING AT 25 MPH WHEN IT STARTED LOSING POWER. IT STOPPED BARELY FEW FEET AFTER THE INTERSECTION. ENGINE WOULD NOT START. VEHICLE WAS TOWED AWAY TO THE NEAREST VW DEALERSHIP. AFTER INVESTIGATION DEALERSHIP SAYS THAT THEY FOUND TRACES OF GASOLINE IN THE FUEL PUMP AND GASOLINE HAS DESTROYED THE FUEL SYSTEM. I SHOWED THEM MY LAST THREE RECEIPTS AS PROOF THAT I ALWAYS PUT DIESEL IN THE VEHICLE. CAR IS AT THE DEALERSHIP SINCE 01-AUG-2011. THEY SAID THEY HAVE TO REPLACE THE WHOLE SYSTEM. INITIALLY THEY HAVE QUOTED ABOUT $4800 + LABOR BUT LATER ON THEY AGREED TO FIX IT UNDER WARRANTY , CAR IS ONLY 18 MONTHS OLD AND HAS 1800 MILES. I AM CONCERNED THAT THIS MAY HAPPEN AGAIN AS I STILL WOULD END UP GOING TO THE SAME DIESEL STATIONS FOR FILLING AND IF THEY ARE CONTAMINATED AS DEALER SAYS I MAY END UP WITH A DEAD ENGINE AGAIN.

NHTSA ODI #10418884

9,500 miles · Aug 9, 2011
Fuel System, Gasoline

DEAD PEDAL - HESITATION - STALLING. ABSOLUTELY NO THROTTLE RESPONSE WHEN TRYING TO PULL OUT INTO TRAFFIC. YOU PRESS THE PEDAL AND THERE IS NOTHING THERE. STOP AND GO TRAFFIC ON THE EXPRESSWAY OR STOPPING AT AN INTERSECTION THE CAR STALLS. ALSO HAVE EXPERIENCED SURGING AT HIGHWAY SPEED AS IF THE FUEL SUPPLY IS CUTTING OUT. WE REC…

Read full complaint

DEAD PEDAL - HESITATION - STALLING. ABSOLUTELY NO THROTTLE RESPONSE WHEN TRYING TO PULL OUT INTO TRAFFIC. YOU PRESS THE PEDAL AND THERE IS NOTHING THERE. STOP AND GO TRAFFIC ON THE EXPRESSWAY OR STOPPING AT AN INTERSECTION THE CAR STALLS. ALSO HAVE EXPERIENCED SURGING AT HIGHWAY SPEED AS IF THE FUEL SUPPLY IS CUTTING OUT. WE RECENTLY RETURNED FROM A TRIP TO PORTSMOUTH NH. WE WERE IN SIX LANES OF STOP AND GO TRAFFIC ON I-95 AND THE CAR KEPT STALLING. WHEN YOU WOULD DEPRESS THE GAS PEDAL TO CONTINUE MOVING THERE IS NO THROTTLE RESPONSE. WE PARKED IN THE PORTSMOUTH MUNICIPAL GARAGE. AS WE ASCENDED THROUGH THE GARAGE LOOKING FOR A PARKING SPACE [INCLINE POSITION] ABOUT 5 MPH, THERE WAS NO THROTTLE RESPONSE. THE CAR WOULD NOT MOVE. I HAD TO CONTINUE TO FEATHER THE PEDAL TO PULL INTO A PARKING SPACE. WE NOW HAVE 20K MILES ON THE CAR AND HAVE HAD THE CAR LOOKED AT 6 TIMES AT THE LOCAL VW DEALER WITH NO FIX. THE CAR HAS SERIOUS THROTTLE ISSUES AND HAS BECOME DANGEROUS TO DRIVE. PLEASE NOTE TO NUMEROUS TO MENTION VW TDI HESITATION ISSUES ON MANY WEB FORUMS. SOMEONE IS LIKELY TO GET SERIOUSLY INJURED OR KILLED WITH THIS PROBLEM THAT VW MUST KNOW ABOUT. PLEASE ADVISE !!!!!

NHTSA ODI #10418876

9,000 miles · Aug 8, 2011
Fuel System, Gasoline

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA SPORTSWAGEN. THE CONTACT STATED THAT THE HIGH PRESSURE FUEL INJECTOR PUMPED FAILED, CAUSING THE VEHICLE TO STALL. THE FAILURE RECURRED REPEATEDLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 9,000 A…

Read full complaint

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA SPORTSWAGEN. THE CONTACT STATED THAT THE HIGH PRESSURE FUEL INJECTOR PUMPED FAILED, CAUSING THE VEHICLE TO STALL. THE FAILURE RECURRED REPEATEDLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 9,000 AND THE CURRENT MILEAGE WAS 51,000. UPDATED 9/13/11 *CN UPDATED 2/22/12 *CN

NHTSA ODI #10417930

7,550 miles · Jul 24, 2011
Fuel System, Gasoline

WAS TRAVELING ON A CITY BLOCK IN SAN FRANCISCO WHEN THE ENGINE LIGHT WENT ON. THERE WAS A SLIGHT POWER SURGE BUT NO STALL. DRIVING INTO THE NEXT CITY BLOCK THE CAR COMPLETELY DIED AND I PULLED OVER TO CURB. UNABLE TO START AGAIN. CAR WAS TOWED TO VW DEALER. WAS TOLD THE FUEL PUMP IN THE TANK HAD MALFUNCTIONED, AND CONTAMINATED T…

Read full complaint

WAS TRAVELING ON A CITY BLOCK IN SAN FRANCISCO WHEN THE ENGINE LIGHT WENT ON. THERE WAS A SLIGHT POWER SURGE BUT NO STALL. DRIVING INTO THE NEXT CITY BLOCK THE CAR COMPLETELY DIED AND I PULLED OVER TO CURB. UNABLE TO START AGAIN. CAR WAS TOWED TO VW DEALER. WAS TOLD THE FUEL PUMP IN THE TANK HAD MALFUNCTIONED, AND CONTAMINATED THE FUEL TANK. ENTIRE FUEL PUMP, TANK, SYSTEM IS BEING REPLACED UNDER WARRANTY.

NHTSA ODI #10415850

3,000 miles · Mar 15, 2011
Engine And Engine CoolingFuel System, Gasoline

THIS VEHICLE HAS EXPERIENCED CONTINUAL PROBLEMS WITH ENGINE SHUDDERING AND STALLING. MOSTLY, WHILE IN 2ND , 3RD OR 4TH GEAR, EARLY ON INTO A TRIP THE ENGINE WILL SUDDENLY DECELERATE AND IN SOME CASE STALL OUT COMPLETELY. IT IS AS IF THERE IS A SUDDEN LOSS IN FUEL GETTING TO THE ENGINE. THIS STARTED SOON AFTER PURCHASING THE CAR.…

Read full complaint

THIS VEHICLE HAS EXPERIENCED CONTINUAL PROBLEMS WITH ENGINE SHUDDERING AND STALLING. MOSTLY, WHILE IN 2ND , 3RD OR 4TH GEAR, EARLY ON INTO A TRIP THE ENGINE WILL SUDDENLY DECELERATE AND IN SOME CASE STALL OUT COMPLETELY. IT IS AS IF THERE IS A SUDDEN LOSS IN FUEL GETTING TO THE ENGINE. THIS STARTED SOON AFTER PURCHASING THE CAR. IT HAS BEEN INTO THE DEALERSHIP NUMEROUS (6 OR 7) TIMES FOR THIS WARRANTY ISSUE, INCLUDING EXTENDED STAY PERIODS OF SEVEN AND TEN DAYS. FIRST THEY FAULTED MY FUEL, THEN THEY REPLACED THE FUEL PUMP, THEN THEY HAVE DONE OTHER WORK AND REPLACED COMPONENTS, BUT CLAIM THEY CAN NOT MAKE THE CAR FAIL AS I HAVE REPORTED. THEY CLAIM TO HAVE ALERTED VW AND HAD A VW TECHNICAL ADVISERS LOOK AT THIS CAR. THEY REFUSE TO DO ANY ADDITIONAL WARRANTY WORK ON THE CAR FOR THIS ISSUE SINCE THEY CAN NOT DIAGNOSE IT. I HAVE KEPT A LOG OF THESE FAILURES SINCE MY LAST SERVICING. BETWEEN 10/22/2010 TO 3/12/2011 THIS VEHICLE HAS HAD 19 OF THESE FAILURE EVENTS. THEY USUALLY OCCUR WHEN THE OUTSIDE AIR TEMPERATURE IS ABOVE 32 DEGREES FAHRENHEIT. THE VEHICLE IS STILL UNDER WARRANTY (28,500 MILES ON THE ODOMETER). I AM FINDING OTHER OWNERS EXPERIENCING SIMILAR PROBLEMS. PLEASE HELP.

NHTSA ODI #10391708

18,000 miles · Feb 23, 2011
Fuel System, Gasoline

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT ATTEMPTED TO START THE VEHICLE BUT IT WOULD NOT START. APPROXIMATELY TWENTY MINUTES LATER, THE CONTACT WAS ABLE TO START THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS TOLD THAT THERE WAS WATER IN THE FUEL SYSTEM. THE VEHICLE WAS REPAIRED…

Read full complaint

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT ATTEMPTED TO START THE VEHICLE BUT IT WOULD NOT START. APPROXIMATELY TWENTY MINUTES LATER, THE CONTACT WAS ABLE TO START THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS TOLD THAT THERE WAS WATER IN THE FUEL SYSTEM. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 18,000.

NHTSA ODI #10384099

Official recalls

4

16V913000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Dec 20, 2016

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence & remedy

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Additional source detail variants (2)

Electronic Stability Control (esc)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

11V490000 · Fuel System, Diesel

Oct 3, 2011

VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Consequence & remedy

Consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Remedy: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

10V621000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Dec 10, 2010

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

Consequence & remedy

Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

09V333000 · Power Train:automatic Transmission

Aug 20, 2009

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.

Consequence & remedy

Consequence: THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: VOLKSWAGEN WILL REPROGRAM THE TRANSMISSION CONTROL MODULE WITH UPDATED SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 20, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

EA18003 · Air Bag Clockspring Failure

Opened Apr 18, 2018 · No close date supplied

Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Additional source detail variants (3)

Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags:frontal

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

PE11023 · Diesel Fuel Injector Line Leakage

Opened Aug 2, 2011 · Closed Dec 2, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

By letter dated October 3, 2011, Volkswagen Group of America, Inc. (VW) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address a defect in approximately 168,275 model year (MY) 2009-2012 Volkswagen Jetta, Jetta Sportwagen, Golf, and Audi A3 vehicles equipped with the 2.0L TDI Common Rail Clean Diesel engine (NHTSA Recall No. 11V-490).The recalled Jetta and Jetta Sportwagen vehicles were built from May 2008 through September 2011, the Golf vehicles were built from May 2009 through September 2011, and the Audi A3 vehicles were built from September 2009 through September 2011.According to Volkswagen, in U.S. applications of the above cited TDI vehicles including engine codes CJAA and CBEA, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and RPM conditions.This resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.As a contributing factor, VW indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.Lines manufactured in these periods were installed in vehicles produced in the following 10 months:December 2008, January-February 2009, October 2009, March-April 2010 and September-December 2010.Injector lines using this material exhibit a significantly higher failure rate.Dealers will replace injector line #2 in all vehicles built in these months.In addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.Analysis of NHTSA complaints, VW complaints, VW field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.The leaking line was not identified in 62 of the vehicles.For the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.Almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by VW, which accounted for approximately one-quarter of the recalled vehicles.The failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (IPTV).The failure rate for injector line #2 in other production months of recalled vehicles is 0.8 IPTV.The leak/repair rates for the other injector lines are all well under 1 IPTV.The action taken by Volkswagen is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. Accordingly, this investigation is closed.

EA11003 · High-Pressure Fuel Pump Failure

Opened Feb 7, 2011 · Closed Mar 27, 2015

Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Additional source detail variants (2)

Fuel System, Diesel

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

PE10034 · High Pressure Fuel Pump Failure (hpfp)

Opened Aug 26, 2010 · Closed Feb 8, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

The Office of Defects Investigation (ODI) and Volkswagen (VW) have received a total of 160 complaints and field reports alleging incidents of engine stall and/or loss of power that appear to be related to high pressure fuel pump (HPFP) failures in certain model year (MY) 2009 through 2010 Volkswagen Jetta and MY 2010 Volkswagen Golf and Audi A3 vehicles equipped with TDI clean diesel engines.Approximately half of the reports indicate that the failure resulted in an engine stall incident, with many of these alleging stall incidents at highway speeds in traffic with no restart.There has been one minor crash alleged to have resulted from HPFP failure in the subject vehicles.In response to ODI's information request for PE10-034, VW indicated that it had found no defect related to motor vehicle safety with relation to the TDI Clean Diesel fuel system at issue in this investigation and attributed problems with HPFP failure to operation with gasoline contaminated diesel fuel.Volkswagen stated that even a small amount of gasoline in the diesel fuel may disrupt the necessary lubrication required and may cause the HPFP to fail.In response to concerns that fuel contamination was the major cause of HPFP and related fuel system failures, VW issued a Technical Service Bulletin in May 2010 (VW TB V011011 2023624 and Audi TB A011008 2023360-1), with instructions to inspect the diesel fuel for vehicles requiring fuel system service that have symptoms associated with HPFP failure.The bulletin states that fuel system damage incurred by use of fuel not complying to ASTM-D-975 Grade 2 S15 (B5 or less biodiesel content) standards will not be covered under warranty. Volkswagen also provided information about 121 mis-fueling incidents reportedly acknowledged by consumers or dealers and test results for about 50 diesel fuel samples taken from complaint vehicles in late-August through early-October 2010.The mis-fueling incidents include about 20 reports involving incorrect fueling by dealer sales or service personnel and generally report symptoms such as rough running, stalling and/or no start within a few miles of refueling the vehicle with gasoline.Volkswagen indicated that the testing of fuel samples from complaint vehicles found that nearly 90 percent contained high amounts of gasoline.Volkswagen implemented design changes for the HPFP in May 2008, September 2009 and November 2010 to improve the robustness of the pump when used with poor quality fuel.ODI analysis of HPFP failures identified from all sources shows failure rates of 0.53% for MY 2009 vehicles and 0.11% for MY 2010 vehicles.This investigation has been upgraded to an Engineering Analysis (EA11-003) to continue to investigate the issues with mis-fueling and HPFP design identified during the Preliminary Evaluation.