PULLED ON TO HIGHWAY AND VEHICLE SUDDENLY STALLED IN MIDDLE OF INTERSECTION. ENGINE WENT TO IDLE. NO THROTTLE RESPONSE. AFTER SEVERAL PEDAL PRESSES IT TOOK OFF. *TR
2010 Volkswagen Jetta
Owner reports · Recalls · Investigations
More warning signs than most Jetta years
Owner complaints for the 2010 Volkswagen Jetta are substantially higher than the model-year median of 68.
About this comparison →How this year compares
Owner complaints by model year
Compare all Jetta years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
779 reports with mileage · 73 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Diesel. Review the 166 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Diesel complaints
166 reportsDURING A NORMAL FUEL FILTER REPLACEMENT I NOTICED METAL SHAVINGS IN THE FUEL FILTER. HAVING BEEN AWARE OF THE FAILURE RATE OF THE HP PUMP ON THE TDI'S I TOOK IT TO MY LOCAL VW DEALER THE NEXT DAY. THE SERVICE MANGER ASSISTED ME PERSONALLY. THE TECHNICIAN REMOVED THE FUEL FILTER AND IN THE BOTTOM OF THE FUEL FILTER THERE WERE …
Read full complaint
DURING A NORMAL FUEL FILTER REPLACEMENT I NOTICED METAL SHAVINGS IN THE FUEL FILTER. HAVING BEEN AWARE OF THE FAILURE RATE OF THE HP PUMP ON THE TDI'S I TOOK IT TO MY LOCAL VW DEALER THE NEXT DAY. THE SERVICE MANGER ASSISTED ME PERSONALLY. THE TECHNICIAN REMOVED THE FUEL FILTER AND IN THE BOTTOM OF THE FUEL FILTER THERE WERE SHAVINGS PRESENT. HE THEN REMOVED TANK FUEL PUMP AND THERE WAS NO EVIDENCE OF WATER NOR GAS FOUND IN THE DIESEL TANK. THE DEALERSHIP CALLED VOA'S TECH LINE AND WITHIN A HALF AN HOUR I WAS GIVEN A FREE LOANER CAR. MOST MAJOR PARTS WERE REPLACED IN THE FUEL SYSTEM INCLUDING THE HPP, THE REGULAR FUEL PUMP, ALL FOUR INJECTORS AND ALL OF THE FUEL LINES IN THE FUEL SYSTEM. THE DIESEL IN THE TANK WAS DRAINED THE TANK WAS FLUSHED OUT AND REFILLED WITH FRESH DIESEL AS WELL AS ALL OF THE FUEL FILTERS WERE REPLACED. THE CAR WAS RETURNED TO ME ON THE 30TH OF APRIL 2013 WITH A FULL TANK OF DIESEL AND COMPLETELY DETAILED. THE CAR SEEMS TO BE RUNNING JUST FINE BUT THEN AGAIN IT WAS RUNNING JUST FINE WHEN I DISCOVERED THE PROBLEM. *TR
THE CAR WAS FUELED UP WITH DIESEL FUEL DURING A ROAD TRIP. AFTER DRIVING FOR SEVERAL HOURS AFTER THE REFUEL ON THE HIGHWAY IN THE EVENING, THE GLOW PLUG SENSOR FLASHED, FOLLOWED BY A SUDDEN LOSS OF POWER. THE CAR WAS PULLED OVER TO THE SHOULDER AND UNABLE TO BE RE-STARTED. THE CAR WAS THEN TOWED TO THE CLOSEST VW DEALER. THE DEA…
Read full complaint
THE CAR WAS FUELED UP WITH DIESEL FUEL DURING A ROAD TRIP. AFTER DRIVING FOR SEVERAL HOURS AFTER THE REFUEL ON THE HIGHWAY IN THE EVENING, THE GLOW PLUG SENSOR FLASHED, FOLLOWED BY A SUDDEN LOSS OF POWER. THE CAR WAS PULLED OVER TO THE SHOULDER AND UNABLE TO BE RE-STARTED. THE CAR WAS THEN TOWED TO THE CLOSEST VW DEALER. THE DEALER DETERMINED THAT THE FUEL PUMP FAILED, CAUSING METAL FRAGMENTS TO BE SENT THROUGHOUT THE FUEL SYSTEM. VW DEALER WILL NOT WARRANTY THE HPFP FAILURE. *TR
ENGINE STALLED AND SHUT OFF WHILE I WAS AT A 4-WAY STOP SIGN. CAR WAS TOWED TO VW SPECIALIST CENTER AND WAS DETERMINED THAT TDI FUEL PUMP AND INJECTOR SYSTEM HAD FAILED. VW SPECIALIST DETERMINED THAT THIS IS A COMMON EVENT WITH TDI FUEL SYSTEMS. FRESH DIESEL FUEL WAS FUELED IN MY VW AND DROVE FOR 6 MILES TO WHEN ENGINE STALLED O…
Read full complaint
ENGINE STALLED AND SHUT OFF WHILE I WAS AT A 4-WAY STOP SIGN. CAR WAS TOWED TO VW SPECIALIST CENTER AND WAS DETERMINED THAT TDI FUEL PUMP AND INJECTOR SYSTEM HAD FAILED. VW SPECIALIST DETERMINED THAT THIS IS A COMMON EVENT WITH TDI FUEL SYSTEMS. FRESH DIESEL FUEL WAS FUELED IN MY VW AND DROVE FOR 6 MILES TO WHEN ENGINE STALLED OCCURRED. VW SPECIALIST INVESTIGATED AND DETERMINED THERE WAS NO CROSS CONTAMINATION OF DIESEL FUEL, WITH WATER OR GASOLINE. DIESEL FUEL WAS 100% DIESEL IN FUEL SYSTEM. *TR
2010 VW JETTA TDI'S CHECK ENGINE AND GLOW PLUG LIGHTS WENT ON. VEHICLE ERROR CODE READ P0087. VEHICLE ENTERED "LIMP MODE" AND TURBO STOPPED FUNCTIONING. TOWED VEHICLE TO VW DEALERSHIP FOR DIAGNOSIS SUSPECTING IMMINENT HPFP FAILURE AT MY COST. PAID THE DEALERSHIP $100 TO DIAGNOSE THE VEHICLE. DEALER DETERMINED IT WAS A SECON…
Read full complaint
2010 VW JETTA TDI'S CHECK ENGINE AND GLOW PLUG LIGHTS WENT ON. VEHICLE ERROR CODE READ P0087. VEHICLE ENTERED "LIMP MODE" AND TURBO STOPPED FUNCTIONING. TOWED VEHICLE TO VW DEALERSHIP FOR DIAGNOSIS SUSPECTING IMMINENT HPFP FAILURE AT MY COST. PAID THE DEALERSHIP $100 TO DIAGNOSE THE VEHICLE. DEALER DETERMINED IT WAS A SECONDARY FUEL PUMP ISSUE, REPAIRED THE PUMP, AND CLEARED THE CODE, WHICH COST ME APPROXIMATELY $760. WITHIN 2 HOURS OF PICKING UP MY VEHICLE, THE CHECK ENGINE AND GLOW PLUG LIGHTS WENT BACK ON, VEHICLE ENTERED "LIMP MODE" AND THEN COMPLETED STALLED. THE VEHICLE WOULD NOT RE-START. VEHICLE WAS TOWED BACK TO VW DEALERSHIP, THIS TIME AT THEIR COST. DEALER PROVIDED ME WITH A RENTAL CAR, AT THEIR COST. ONE DAY LATER, DEALER DIAGNOSED ISSUE AS A CATASTROPHIC HIGH PRESSURE FUEL PUMP FAILURE (HPFP). DUE TO THE DISINTEGRATION OF THE HPFP, SHARDS OF METAL ENTERED THE ENGINE AND FUEL SYSTEM. THE DEALER INFORMED ME THAT A LARGE PORTION OF THE VEHICLE'S FUEL SYSTEM WOULD NEED TO BE REPLACED AS A RESULT OF THIS HPFP FAILURE. WHILE THE VEHICLE IS NOT UNDER WARRANTY ANY LONGER, VW CHOSE TO COVER THE REPAIR (PERHAPS IT IS DUE TO FACT THAT I BROUGHT THE VEHICLE IN AND MADE THEM AWARE OF MY SUSPICIONS, YET THEY CHOSE TO SLOUGH OFF MY DIAGNOSIS). FROM THE NUMBER OF COMPLAINTS THAT I HAVE READ ABOUT THIS SAME ISSUE OCCURRING TO COUNTLESS OTHERS, VW IS CLEARLY AWARE OF THE ISSUE, AND SHOULD MOST CERTAINLY RECALL THIS VEHICLE FOR THIS ISSUE. *TR
MY WIFE WAS DRIVING HER 2010 VW JETTA S/W TDI DSG HOME FROM WORK AND SHE NOTICED THAT IT SEEMED TO BE RUNNING A LITTLE ROUGHER THEN USUAL (IN DECEMBER WHEN WE HAD THE 40K SERVICE DONE WE WERE TOLD THAT IT NEEDED A FUEL FILTER AND THAT WOULD SOLVE THE PROBLEM...IT DID FOR ABOUT A WEEK OR SO). WHEN SHE SLOWED DOWN FOR TRAFFIC THE …
Read full complaint
MY WIFE WAS DRIVING HER 2010 VW JETTA S/W TDI DSG HOME FROM WORK AND SHE NOTICED THAT IT SEEMED TO BE RUNNING A LITTLE ROUGHER THEN USUAL (IN DECEMBER WHEN WE HAD THE 40K SERVICE DONE WE WERE TOLD THAT IT NEEDED A FUEL FILTER AND THAT WOULD SOLVE THE PROBLEM...IT DID FOR ABOUT A WEEK OR SO). WHEN SHE SLOWED DOWN FOR TRAFFIC THE RPM'S WOULD FLUCTUATE BETWEEN 500 RPMS AND 1400 RPMS AND NEARLY STALLING AT TIMES. FINALLY WHEN SHE GOT OFF THE EXIT RAMP NEAR HOME, THE JETTA STALLED AND A CHECK ENGINE LIGHT CAME ON. ONCE SHE WAS HOME I FOUND THAT IT WAS READING CODE P0263. THE JETTA WENT TO DEALER ON 3/13 AND WE GOT IT BACK ON 3/22. UNFORTUNATELY IT STALLED OUT ON MY WIFE ON 3/23 AFTER A SHORT TRIP ACROSS TOWN WHILE DROPPING MY SON OFF AT HIS FRIENDS HOUSE. SHE PRECEDED TO COME HOME AFTER DROPPING HIM OFF AS THE STALLING ISSUE OCCURRED WHILE MAKING A TURN AND SHE WAS NEARLY BROADSIDED BY A SUV! HAD THE VEHICLES COLLIDED, IT WOULD HAVE BEEN A DIRECT IMPACT TO MY WIFE AND SON'S SEATS! THE NEXT MORNING I TOOK THE JETTA OUT FOR A DRIVE TO SEE IF I COULD DUPLICATE THE PROBLEM AND BOY DID I EVER. THANKFULLY THE DEALER IS CLOSE BY AND I WAS ABLE TO GET THE CAR THERE BUT NOT WITHOUT ISSUES. IT STALLED OUT ON ME 4 TIMES IN THE 1.5 MILE TRIP. I TOO WAS NEARLY HIT BY AN ON COMING CAR WHILE MAKING A TURN. NOT TO MENTION IT STALLED WHILE TRYING TO MERGE ONTO THE HIGHWAY GETTING TO THE DEALERSHIP. DURING THE FIRST VISIT FOR THE STALLING PROBLEM, VW HAD THE DEALER DRAIN MY FULL TANK OF DIESEL AS THEY THOUGHT I USED BAD FUEL AND THIS WAS NOT THE CASE. NEXT THEY REPROGRAMMED THE FUEL INJECTORS AND THAT DID NOT SOLVE THE PROBLEM. SO VW HAD THE DEALER REPLACE A FUEL REGULATOR VALVE AND THAT DID NOT WORK AS WELL. AFTER TWO MORE TIMES OF REPROGRAMMING THE FUEL INJECTORS THE LIGHT APPARENTLY WENT OUT A SO VW OF AMERICA AND THE DEALER FELT IT WAS FIXED AND SAFE FOR US TO DRIVE. I THINK NOT! *TR
2010 VW JETTA 2.0 TDI CUP EDITION: ENTERING TRAFFIC IN FIRST GEAR, AT ABOUT 4000-4200 RPM, CAR HAD A COMPLETE LOSS OF POWER. ENGINE DID NOT DIE. I PUSHED IN CLUTCH AND POWER RETURNED. THIS HAS OCCURRED MONTHLY WITH NO CONSISTENCY SINCE I PURCHASED THE CAR IN JULY 2010. OCCURS WITH A WARM ENGINE. COLD ENGINE. VARIOUS LEVELS OF…
Read full complaint
2010 VW JETTA 2.0 TDI CUP EDITION: ENTERING TRAFFIC IN FIRST GEAR, AT ABOUT 4000-4200 RPM, CAR HAD A COMPLETE LOSS OF POWER. ENGINE DID NOT DIE. I PUSHED IN CLUTCH AND POWER RETURNED. THIS HAS OCCURRED MONTHLY WITH NO CONSISTENCY SINCE I PURCHASED THE CAR IN JULY 2010. OCCURS WITH A WARM ENGINE. COLD ENGINE. VARIOUS LEVELS OF FUEL, AND VARIOUS CLIMATE CONDITIONS. IT HAS BEEN TAKEN TO O'BRIEN VOLKSWAGEN, A CERTIFIED REPAIR FACILITY, EVERY 3-6 MONTHS TO HAVE THE ISSUE RESOLVED. DEALERSHIP CAN NOT REPLICATE THE ISSUE AND AS A RESULT HAS NOT SOLVED THE PROBLEM. PROBLEM HAS BEEN WITNESSED BY THREE DIFFERENT PASSENGERS. A SECONDARY STALLING ISSUE OCCURS BETWEEN 1200-1800 WITH LIGHT GAS PEDDLE PRESSURE. IN THIS CASE, THE CAR HAS A SMALL PAUSE OR DECREASE IN POWER. DOWN SHIFTING AND ACCELERATING ELIMINATES THE PROBLEM. *TR
IDIOT LIGHTS CAME ON, KNOCKING SOUNDS FROM ENGINE, AND CAR STALLED. HAD CAR TOWED TO DEALER. DEALER BASICALLY REPLACED ENTIRE FUEL SYSTEM. APPEARS THAT FUEL PUMP DISINTEGRATED AND SENT METAL CHIPS INTO INJECTORS. CAR SERVICED AT PACIFIC VOLKSWAGEN, HAWTHORNE CALIFORNIA. INVOICE NO. [XXX]. INFORMATION REDACTED PURSUANT TO THE …
Read full complaint
IDIOT LIGHTS CAME ON, KNOCKING SOUNDS FROM ENGINE, AND CAR STALLED. HAD CAR TOWED TO DEALER. DEALER BASICALLY REPLACED ENTIRE FUEL SYSTEM. APPEARS THAT FUEL PUMP DISINTEGRATED AND SENT METAL CHIPS INTO INJECTORS. CAR SERVICED AT PACIFIC VOLKSWAGEN, HAWTHORNE CALIFORNIA. INVOICE NO. [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
FAILURE OF HIGH PRESSURE FUEL PUMP. THIS IS A KNOWN WEAK POINT WITH THE VW DIESEL JETTA PRODUCED IN 2009 AND 2010. THEY HAVE MODIFIED THE PUMP THREE TIMES. I WAS TRAVELING ALONG US HIGHWAY 41 IN TAMPA FLORIDA AND THE PUMP FAILED CAUSING ME TO DIE OUT RIGHT ON THE HIGHWAY AROUND 4:00PM. *TR
CAR STALLED OUT AT THE TRAFFIC STOP LIGHT. ALL ATTEMPTS TO RESTART FAILED. CAR WAS THEN TOWED TO THE NEAREST GARAGE. SUBSQUENT TESTED AND DIAGNOSED BY MECHANICS SHOWED FUEL SYSTEM FAILED TO PRESSURIZED. THE MECHANICS SUSPECTED IT MIGHT BE DUE TO FUEL CONTAMINATION. CHECKED RECEIPT TO VERIFY THAT THE PREVIOUS FILL UP (AT THE…
Read full complaint
CAR STALLED OUT AT THE TRAFFIC STOP LIGHT. ALL ATTEMPTS TO RESTART FAILED. CAR WAS THEN TOWED TO THE NEAREST GARAGE. SUBSQUENT TESTED AND DIAGNOSED BY MECHANICS SHOWED FUEL SYSTEM FAILED TO PRESSURIZED. THE MECHANICS SUSPECTED IT MIGHT BE DUE TO FUEL CONTAMINATION. CHECKED RECEIPT TO VERIFY THAT THE PREVIOUS FILL UP (AT THE SHELL STATION) WAS INDEED DIESEL. CALLED THE STATION TO INFORM OF INCIDENT, AND TO INQUIRE IF ANYONE ELSE INFORMED OF SIMILAR INCIDENT; NONE, WAS THE REPLY FROM THE GAS STATION MANAGER. CURRENTLY, THE CAR IS INOPERABLE, AND THE VW DEALER SERVICE STATION RECOMMEND REPLACING INJECTORS, AND ALL THE FUEL PUMPS. *TR
Official recalls
416V913000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Dec 20, 2016
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.
Consequence & remedy
Consequence: A loss of vehicle control can increase the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.
Additional source detail variants (2)
Electronic Stability Control (esc)
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.
Consequence: A loss of vehicle control can increase the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.
Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.
Consequence: A loss of vehicle control can increase the risk of a crash.
Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.
11V490000 · Fuel System, Diesel
Oct 3, 2011
VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.
Consequence & remedy
Consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.
Remedy: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
10V621000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Dec 10, 2010
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.
Consequence & remedy
Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
09V333000 · Power Train:automatic Transmission
Aug 20, 2009
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.
Consequence & remedy
Consequence: THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: VOLKSWAGEN WILL REPROGRAM THE TRANSMISSION CONTROL MODULE WITH UPDATED SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 20, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4EA18003 · Air Bag Clockspring Failure
Opened Apr 18, 2018 · No close date supplied
Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Additional source detail variants (3)
Air Bags:frontal:driver Clockspring/spiral Cassette
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Air Bags:frontal
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
Air Bags
In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922
PE11023 · Diesel Fuel Injector Line Leakage
Opened Aug 2, 2011 · Closed Dec 2, 2011
Status: closed (inferred from source dates) · Fuel System, Diesel
By letter dated October 3, 2011, Volkswagen Group of America, Inc. (VW) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address a defect in approximately 168,275 model year (MY) 2009-2012 Volkswagen Jetta, Jetta Sportwagen, Golf, and Audi A3 vehicles equipped with the 2.0L TDI Common Rail Clean Diesel engine (NHTSA Recall No. 11V-490).The recalled Jetta and Jetta Sportwagen vehicles were built from May 2008 through September 2011, the Golf vehicles were built from May 2009 through September 2011, and the Audi A3 vehicles were built from September 2009 through September 2011.According to Volkswagen, in U.S. applications of the above cited TDI vehicles including engine codes CJAA and CBEA, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and RPM conditions.This resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.As a contributing factor, VW indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.Lines manufactured in these periods were installed in vehicles produced in the following 10 months:December 2008, January-February 2009, October 2009, March-April 2010 and September-December 2010.Injector lines using this material exhibit a significantly higher failure rate.Dealers will replace injector line #2 in all vehicles built in these months.In addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.Analysis of NHTSA complaints, VW complaints, VW field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.The leaking line was not identified in 62 of the vehicles.For the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.Almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by VW, which accounted for approximately one-quarter of the recalled vehicles.The failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (IPTV).The failure rate for injector line #2 in other production months of recalled vehicles is 0.8 IPTV.The leak/repair rates for the other injector lines are all well under 1 IPTV.The action taken by Volkswagen is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. Accordingly, this investigation is closed.
EA11003 · High-Pressure Fuel Pump Failure
Opened Feb 7, 2011 · Closed Mar 27, 2015
Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:delivery:fuel Pump
The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.
Additional source detail variants (2)
Fuel System, Diesel
The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.
Fuel System, Other:delivery:fuel Pump
The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.
PE10034 · High Pressure Fuel Pump Failure (hpfp)
Opened Aug 26, 2010 · Closed Feb 8, 2011
Status: closed (inferred from source dates) · Fuel System, Diesel
The Office of Defects Investigation (ODI) and Volkswagen (VW) have received a total of 160 complaints and field reports alleging incidents of engine stall and/or loss of power that appear to be related to high pressure fuel pump (HPFP) failures in certain model year (MY) 2009 through 2010 Volkswagen Jetta and MY 2010 Volkswagen Golf and Audi A3 vehicles equipped with TDI clean diesel engines.Approximately half of the reports indicate that the failure resulted in an engine stall incident, with many of these alleging stall incidents at highway speeds in traffic with no restart.There has been one minor crash alleged to have resulted from HPFP failure in the subject vehicles.In response to ODI's information request for PE10-034, VW indicated that it had found no defect related to motor vehicle safety with relation to the TDI Clean Diesel fuel system at issue in this investigation and attributed problems with HPFP failure to operation with gasoline contaminated diesel fuel.Volkswagen stated that even a small amount of gasoline in the diesel fuel may disrupt the necessary lubrication required and may cause the HPFP to fail.In response to concerns that fuel contamination was the major cause of HPFP and related fuel system failures, VW issued a Technical Service Bulletin in May 2010 (VW TB V011011 2023624 and Audi TB A011008 2023360-1), with instructions to inspect the diesel fuel for vehicles requiring fuel system service that have symptoms associated with HPFP failure.The bulletin states that fuel system damage incurred by use of fuel not complying to ASTM-D-975 Grade 2 S15 (B5 or less biodiesel content) standards will not be covered under warranty. Volkswagen also provided information about 121 mis-fueling incidents reportedly acknowledged by consumers or dealers and test results for about 50 diesel fuel samples taken from complaint vehicles in late-August through early-October 2010.The mis-fueling incidents include about 20 reports involving incorrect fueling by dealer sales or service personnel and generally report symptoms such as rough running, stalling and/or no start within a few miles of refueling the vehicle with gasoline.Volkswagen indicated that the testing of fuel samples from complaint vehicles found that nearly 90 percent contained high amounts of gasoline.Volkswagen implemented design changes for the HPFP in May 2008, September 2009 and November 2010 to improve the robustness of the pump when used with poor quality fuel.ODI analysis of HPFP failures identified from all sources shows failure rates of 0.53% for MY 2009 vehicles and 0.11% for MY 2010 vehicles.This investigation has been upgraded to an Engineering Analysis (EA11-003) to continue to investigate the issues with mis-fueling and HPFP design identified during the Preliminary Evaluation.
Illustration