← New search

2010 Volkswagen Jetta

Owner reports · Recalls · Investigations

More warning signs than most Jetta years

Owner complaints for the 2010 Volkswagen Jetta are substantially higher than the model-year median of 68.

About this comparison →

When problems were reported

Mileage at the reported incident

779 reports with mileage · 73 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Diesel. Review the 166 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

23 crash reports5 fire reports10 injury reports

Fuel System, Diesel complaints

166 reports
Clear category filter
19,637 miles · Dec 14, 2010
Electrical SystemFuel System, Diesel

WHILE DRIVING ON INTERSTATE, WITHOUT WARNING OR CHANGE OF THROTTLE, ENGINE SLOWED NOTICEABLY. UNABLE TO MAINTAIN HIGHWAY SPEED WITHOUT HIGH FUEL CONSUMPTION AND DANGEROUSLY SLOW ACCELERATION. DASHBOARD LIGHT INDICATED PROBLEM WITH GLOWPLUG (DIESEL ENGINE) AND CHECK ENGINE LIGHT STAYED ON. TOOK TO LOCAL DEALER NEXT DAY; TECH REP…

Read full complaint

WHILE DRIVING ON INTERSTATE, WITHOUT WARNING OR CHANGE OF THROTTLE, ENGINE SLOWED NOTICEABLY. UNABLE TO MAINTAIN HIGHWAY SPEED WITHOUT HIGH FUEL CONSUMPTION AND DANGEROUSLY SLOW ACCELERATION. DASHBOARD LIGHT INDICATED PROBLEM WITH GLOWPLUG (DIESEL ENGINE) AND CHECK ENGINE LIGHT STAYED ON. TOOK TO LOCAL DEALER NEXT DAY; TECH REPLACED "PRESSURE PIPE" (FAULTY CHARGE PRESSURE SENSOR ON HIGH PRESSURE FILTER PUMP) AND "FLASHED" ECM. ENGINE'S ACCELERATION STILL BELOW WHAT IT WAS PRIOR TO EVENT. *TR

NHTSA ODI #10370673

10,000 miles · Nov 20, 2010
Fuel System, Diesel

MY VEHICLE IS A 2010 JETTA TDI SEDAN, PURCHASED IN JULY, 2010 IN FREDERICK, MD. THERE ARE NOW 10,000 MILES ON THE CAR. WITHIN WEEKS OF PURCHASE, I BEGAN NOTICING A HESITATION IN THE ENGINE AFTER CRESTING A HILL AND PROCEEDING DOWN THE OTHER SIDE OF THE HILL WITH MY FOOT RELEASING SOMEWHAT FROM THE ACCELERATOR. THE HESITATION …

Read full complaint

MY VEHICLE IS A 2010 JETTA TDI SEDAN, PURCHASED IN JULY, 2010 IN FREDERICK, MD. THERE ARE NOW 10,000 MILES ON THE CAR. WITHIN WEEKS OF PURCHASE, I BEGAN NOTICING A HESITATION IN THE ENGINE AFTER CRESTING A HILL AND PROCEEDING DOWN THE OTHER SIDE OF THE HILL WITH MY FOOT RELEASING SOMEWHAT FROM THE ACCELERATOR. THE HESITATION LASTS FOR SEVERAL SECONDS. NEXT, AT APPROXIMATELY 1900 RPM THE ENGINE WILL OCCASIONALLY HESITATE AND EVEN BUCK. MOST IMPORTANTLY, ON THREE OCCASIONS THE ENGINE HAS CONTINUOUSLY HESITATED DURING MY 35-MILE COMMUTE. THE FEELING IS AKIN TO A GAS ENGINE RUNNING LEAN OR OUT OF TUNE. WHEN I ARRIVE HOME AND TURN OFF THE KEY ON THESE OCCASIONS, THERE IS AN ASTOUNDING AMOUNT OF HEAT SURROUNDING THE ENGINE COMPARTMENT, AND THE AUTOMATIC COOLING FAN KICKS ON AND RUNS FOR FIVE MINUTES OR MORE. THE CAR IS CURRENTLY IN THE DEALER REPAIR SHOP, WHERE I WAS TOLD THAT THE HIGH PRESSURE FUEL PUMP CONTAINS METAL SHAVINGS AND IS IN THE PROCESS OF DESTROYING ITSELF. I AM AWARE VIA THE INTERNET THAT OTHERS HAVE HAD SIMILAR PROBLEMS WITH THE TDI ENGINE AND THAT VW HAS TENDED TO BLAME THE PROBLEM ON CUSTOMERS ADDING GASOLINE TO THE FUEL TANK. I HAVE MOST DEFINITELY NOT USED GASOLINE AT ANY TIME. I WANTED TO ADD MY VOICE TO OTHERS, SO THAT VW CAN BE ENCOURAGED TO REMEDY THE SITUATION PROPERLY. *TR

NHTSA ODI #10366933

19,800 miles · Nov 19, 2010
Engine And Engine CoolingFuel System, Diesel

1. DRIVING NORMALLY ON HIGHWAY WHEN IT CAME ON AND THE CAR LOST POWER SUDDENLY AND COULD NOT ACCELERATE ANY FURTHER. ALSO CAR STALLED SEVERAL TIMES ON ITS OWN WHILE IDLING AT A TRAFFIC LIGHT (ITS AN AUTOMATIC TRANSMISSION THIS SHOULD NOT BE HAPPENING). 2. THIS IS THE SECOND TIME THIS SAME PROBLEM HAS HAPPENED IN FIRST 20K MILE…

Read full complaint

1. DRIVING NORMALLY ON HIGHWAY WHEN IT CAME ON AND THE CAR LOST POWER SUDDENLY AND COULD NOT ACCELERATE ANY FURTHER. ALSO CAR STALLED SEVERAL TIMES ON ITS OWN WHILE IDLING AT A TRAFFIC LIGHT (ITS AN AUTOMATIC TRANSMISSION THIS SHOULD NOT BE HAPPENING). 2. THIS IS THE SECOND TIME THIS SAME PROBLEM HAS HAPPENED IN FIRST 20K MILES OF THIS VEHICLE ITS AN 2010 VW TDI. FIRST TIME IT WAS AT 9800 MILE MARK SAME LIGHT AND PROBLEM CAME ON THEY REPLACED A EGR VALVE AND NOW AGAIN AT 19800MILES. 3. THEY HAVE REPLACED A PART AT 9800 MILES AND NOW REPLACING IT AGAIN AT 19800MILES. IT SEEMS TO BE A REPEAT PROBLEM WITH THIS VEHICLE AND VERY DANGEROUS TO HAVE IT SLOW DOWN LIKE THAT WHILE DRIVING AND ALSO STALL OUT WHILE IN TRAFFIC. *TR

NHTSA ODI #10366815

12,000 miles · Nov 14, 2010
Fuel System, Diesel

I HAVE A 2010 VW JETTA TDI DIESEL SPORTSWAGEN THAT I PURCHASED NEW. THE CAR HAS 12,000 MILES SINCE NEW. THE CAR HAS BEEN MAINTAINED BY AN AUTHORIZED DEALER PER THE RECOMMENDED MAINTENANCE SCHEDULE. WHILE DRIVING THE CAR IT SUDDENLY LOST POWER WITHOUT WARNING, REQUIRING IMMEDIATE ACTION ON MY PART TO AVOID A MAJOR ACCIDENT. TH…

Read full complaint

I HAVE A 2010 VW JETTA TDI DIESEL SPORTSWAGEN THAT I PURCHASED NEW. THE CAR HAS 12,000 MILES SINCE NEW. THE CAR HAS BEEN MAINTAINED BY AN AUTHORIZED DEALER PER THE RECOMMENDED MAINTENANCE SCHEDULE. WHILE DRIVING THE CAR IT SUDDENLY LOST POWER WITHOUT WARNING, REQUIRING IMMEDIATE ACTION ON MY PART TO AVOID A MAJOR ACCIDENT. THE CAR'S WARNING SYSTEM DISPLAYED CHECK ENGINE AND SERVICE REQUIRED ANNUNCIATION. AFTER THE POWER LOSS. THE SUDDEN COMPLETE LOSS OF POWER CONCERNS ME REGARDING THE SAFETY OF DRIVING THE CAR, I'VE SINCE BEEN ONLINE AND READ THE ACCOUNTS OF DOZENS OF OWNERS THAT HAVE HAD THIS SAME PROBLEM WITH THE 2009-10 TDI VW JETTA. ALL SEEM TO BE RELATED TO FUEL PUMP FAILURES. THE CAR WILL BE TOWED TO THE DEALERSHIP TOMORROW FOR SERVICE. BUT LOOKING AT THE OTHER ACCOUNTS OF THIS PROBLEM, IT WOULD APPEAR THAT THE DEALERSHIPS ARE NOT HAVING COMPLETE SUCCESS IN RESOLVING THIS PROBLEM. *TR

NHTSA ODI #10365645

5,400 miles · Nov 10, 2010
Fuel System, Diesel

AFTER CRAWLING IN TRAFFIC FOR ABOUT 30 MINUTES THE CAR STALLED. THIS IS THE ONLY TIME THIS HAS OCCURED BUT I DO NOT DRIVE THE CAR OFTEN. SINCE THIS OCCURED 1 WEEK AFTER THE CAR'S FIRST SERVICE, I HAVE NOT BROUGHT IT INTO SERVICE YET. *TR

NHTSA ODI #10365278

9,800 miles · Nov 2, 2010
Fuel System, Diesel

2010 VW TDI ----- CHECK ENGINE LIGHT AT 9800 MILES. VW SAYS "CONTAMINATED DIESEL IN FILTER AREA" AND "NOT COVERED UNDER WARRANTY" THEY BELIEVE THEY CAN MAKE OUR AUTO INSURANCE PAY...SHOWING A LITTLE GUNK OR RUSTY SHEEN WITHIN FILTER CANISTER AREA. WILL KEEP CALLING VW WARRANTY...TRYING TO HAVE THE +$6,000 REPAIR COVERED…

Read full complaint

2010 VW TDI ----- CHECK ENGINE LIGHT AT 9800 MILES. VW SAYS "CONTAMINATED DIESEL IN FILTER AREA" AND "NOT COVERED UNDER WARRANTY" THEY BELIEVE THEY CAN MAKE OUR AUTO INSURANCE PAY...SHOWING A LITTLE GUNK OR RUSTY SHEEN WITHIN FILTER CANISTER AREA. WILL KEEP CALLING VW WARRANTY...TRYING TO HAVE THE +$6,000 REPAIR COVERED. I BELIEVE THIS CAR SUFFERED FATAL HPFS FAILURE.. 20 FULL TANKS OF FUEL SINCE PURCHASED NEW - ALL FROM RACE-WAY OR MURPHYS(WALMART) ULSD NO FURTHER EVIDENCE OF CONTAMINATION IN TANK.....YET. CAR STILL AT VW. *TR

NHTSA ODI #10363806

30,000 miles · Oct 27, 2010
Fuel System, Diesel

I HAVE 2010 VW JETTA TDI, 6 SPEED MANUAL TRANSMISSION WITH 30K MILES ON IT. AS I WAS TRYING TO MERGE INTO TRAFFIC, I TRIED TO ACCELERATE AND THE CAR WOULD NOT GO'IT ACTED LIKE IT DIED. I HAD A CAR RIGHT BEHIND ME AND ANOTHER ONE MERGING FROM THE RIGHT SO I HAD NO PLACE TO GO BUT FORWARD. I DOWNSHIFTED AND STILL NO POWER. EVE…

Read full complaint

I HAVE 2010 VW JETTA TDI, 6 SPEED MANUAL TRANSMISSION WITH 30K MILES ON IT. AS I WAS TRYING TO MERGE INTO TRAFFIC, I TRIED TO ACCELERATE AND THE CAR WOULD NOT GO'IT ACTED LIKE IT DIED. I HAD A CAR RIGHT BEHIND ME AND ANOTHER ONE MERGING FROM THE RIGHT SO I HAD NO PLACE TO GO BUT FORWARD. I DOWNSHIFTED AND STILL NO POWER. EVENTUALLY, AND THANKFULLY WITHOUT A CRASH, IT GAINED MOMENTUM AND IT DIDN'T KILL. FOR THE NEXT 5 MILES OR SO, IT CONTINUED TO SPIT AND SPUTTER AND AS I WAS COASTING DOWN A HILL WITHOUT THE CAR BEING IN GEAR, I REVVED UP THE CAR TO LISTEN TO THE ENGINE AND IT WOULD NOT GO BEYOND 2100 RPM. I MADE IT TO WORK AND HAD NO MORE PROBLEMS YESTERDAY. I IMMEDIATELY CALLED THE DEALER AND WILL BE DROPPING THE CAR OFF TODAY FOR DIAGNOSIS. THIS 'STALLING' HAS HAPPENED IN THE PAST FOR ME, MAYBE 6 TIMES, BUT IT WAS NOT ABRUPT OR ALARMING SO I THOUGHT IT WAS JUST ME TRYING TO ACCELERATE IN A GEAR THAT WAS TOO HIGH FOR THE POWER I NEEDED. I HAVE USED NOTHING BUT THE RECOMMENDED DIESEL FUEL AND HAVE NEVER PUT REGULAR GASOLINE IN IT. I AM THE ONLY DRIVER OF THIS CAR. HOPEFULLY, I DON'T GET THE RUN AROUND BUT AM AFRAID OF WHAT IS GOING TO HAPPEN BECAUSE I ONLY HAVE 6K MILES ON THE BUMPER TO BUMPER WARRANTY. WE WILL SEE WHAT THEY SAY TODAY. *TR

NHTSA ODI #10362628

5,000 miles · Oct 21, 2010
Engine And Engine CoolingFuel System, Diesel

2010 VW TDI JETTA SPORTSWAGEN CURRENTLY HAS 18675 MILES, HOWEVER, PROBLEM STARTED AT APPROXIMATELY 5000 MILES. ENGINE FEELS LIKE IT LOSES POWER AND STARTING TO STALL WHEN IN 3RD/4TH GEAR AND BETWEEN 30 TO 40 MPH. AT TIMES IT IS LIKE A SMALL HICCUP AT OTHER TIMES IT IS QUITE SEVERE AND CAUSES THE CAR TO LURCH VIOLENTLY - HAS LO…

Read full complaint

2010 VW TDI JETTA SPORTSWAGEN CURRENTLY HAS 18675 MILES, HOWEVER, PROBLEM STARTED AT APPROXIMATELY 5000 MILES. ENGINE FEELS LIKE IT LOSES POWER AND STARTING TO STALL WHEN IN 3RD/4TH GEAR AND BETWEEN 30 TO 40 MPH. AT TIMES IT IS LIKE A SMALL HICCUP AT OTHER TIMES IT IS QUITE SEVERE AND CAUSES THE CAR TO LURCH VIOLENTLY - HAS LOCKED THE SEAT BELT UP WHEN THIS OCCURS AS I AM THROWN FORWARD HARD. OCCASIONALLY SAME THING WILL HAPPEN IN HIGHER GEAR, BUT PRETTY MUCH EVERY DAY IN 3RD OR 4TH GEAR. HAVE TAKEN THE CAR BACK TO THE DEALER MULTIPLE TIMES AND COMPLAINED ABOUT PROBLEM EACH TIME. RESPONSE HAS BEEN THEY CANNOT DUPLICATE AND CAN FIND NO PROBLEM. ON LAST SERVICE THEY REPLACED THE FUEL FILTER SAID IT "MIGHT" BE CLOGGED. NO IMPROVEMENT - PROBLEM STILL HAPPENING. BUY MY DIESEL FUEL FROM THE SAME STATIONS ALL THE TIME AND THE SAME STATIONS I PURCHASED DIESEL FUEL FOR MY 2004 GOLF TDI WITH 150,000 MILES ON IT AND NEVER HAD ANY PROBLEM WITH THAT CAR. *TR

NHTSA ODI #10361493

28,756 miles · Oct 10, 2010
Fuel System, Diesel

2010 VW JETTA SPORTWAGEN TDI "GLOWPLUG" LIGHT BEGINS BLINKING, LOSS OF ACCELERATION WHILE DRIVING AT HIGHWAY SPEED. I AM FROM FL AND WAS IN THE HOUSTON AREA AT THE TIME. DROVE CAR TO NEAREST VW DEALER. DEALER FOUND METAL PARTICLES IN THE FUEL FILTER AND I HAD TO RENT A CAR TO GET BACK TO FL. THE REPAIR TOOK 2.5 WEEKS AND THE CA…

Read full complaint

2010 VW JETTA SPORTWAGEN TDI "GLOWPLUG" LIGHT BEGINS BLINKING, LOSS OF ACCELERATION WHILE DRIVING AT HIGHWAY SPEED. I AM FROM FL AND WAS IN THE HOUSTON AREA AT THE TIME. DROVE CAR TO NEAREST VW DEALER. DEALER FOUND METAL PARTICLES IN THE FUEL FILTER AND I HAD TO RENT A CAR TO GET BACK TO FL. THE REPAIR TOOK 2.5 WEEKS AND THE CAR WAS TRUCKED TO MY LOCAL VW DEALER. I WAS NEVER TOLD THE CAUSE OF THE ISSUE AND HAVE SEEN IN SEVERAL FORUMS THAT THIS PROBLEM CAN OCCUR MULTIPLE TIMES.HIGH PRESSURE FUEL PUMP DISINTEGRATION IS SUSPECTED CAUSE. BESIDES THE SAFETY ISSUE OF SUDDEN LOSS OF THE ABILITY TO ACCELERATE, I AM CONCERNED ABOUT FUTURE FAILURE DUE TO FAULTY FUEL PUMPS (IF THAT IS THE CAUSE) AND THE $9,000 REPAIR COST. *TR

NHTSA ODI #10359939

18,000 miles · Oct 5, 2010
Fuel System, Diesel

MY 2010 VOLKSWAGEN JETTA SPORTWAGEN TDI WITH 18,000 MILES WAS MAKING A VERY ROUGH SOUND SHORTLY AFTER A NON-COLD STARTUP. A FEW MINUTES LATER, THE ENGINE GROUND TO A HALT WITH A LOUD CRUNCH SOUND AND SHUT DOWN. VEHICLE WAS TOWED TO A LOCAL VOLKSWAGEN DEALERSHIP. DEALERSHIP FOUND PROBLEM TO BE A HIGH-PRESSURE FUEL PUMP FAILURE…

Read full complaint

MY 2010 VOLKSWAGEN JETTA SPORTWAGEN TDI WITH 18,000 MILES WAS MAKING A VERY ROUGH SOUND SHORTLY AFTER A NON-COLD STARTUP. A FEW MINUTES LATER, THE ENGINE GROUND TO A HALT WITH A LOUD CRUNCH SOUND AND SHUT DOWN. VEHICLE WAS TOWED TO A LOCAL VOLKSWAGEN DEALERSHIP. DEALERSHIP FOUND PROBLEM TO BE A HIGH-PRESSURE FUEL PUMP FAILURE. DIESEL FUEL IN TANK WAS NOT CONTAMINATED. VOLKSWAGEN REPLACED THE ENTIRE FUEL SYSTEM UNDER WARRANTY. *TR

NHTSA ODI #10359338

Official recalls

4

16V913000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Dec 20, 2016

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence & remedy

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Additional source detail variants (2)

Electronic Stability Control (esc)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

11V490000 · Fuel System, Diesel

Oct 3, 2011

VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Consequence & remedy

Consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Remedy: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

10V621000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Dec 10, 2010

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

Consequence & remedy

Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

09V333000 · Power Train:automatic Transmission

Aug 20, 2009

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.

Consequence & remedy

Consequence: THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: VOLKSWAGEN WILL REPROGRAM THE TRANSMISSION CONTROL MODULE WITH UPDATED SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 20, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

EA18003 · Air Bag Clockspring Failure

Opened Apr 18, 2018 · No close date supplied

Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Additional source detail variants (3)

Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags:frontal

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

PE11023 · Diesel Fuel Injector Line Leakage

Opened Aug 2, 2011 · Closed Dec 2, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

By letter dated October 3, 2011, Volkswagen Group of America, Inc. (VW) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address a defect in approximately 168,275 model year (MY) 2009-2012 Volkswagen Jetta, Jetta Sportwagen, Golf, and Audi A3 vehicles equipped with the 2.0L TDI Common Rail Clean Diesel engine (NHTSA Recall No. 11V-490).The recalled Jetta and Jetta Sportwagen vehicles were built from May 2008 through September 2011, the Golf vehicles were built from May 2009 through September 2011, and the Audi A3 vehicles were built from September 2009 through September 2011.According to Volkswagen, in U.S. applications of the above cited TDI vehicles including engine codes CJAA and CBEA, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and RPM conditions.This resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.As a contributing factor, VW indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.Lines manufactured in these periods were installed in vehicles produced in the following 10 months:December 2008, January-February 2009, October 2009, March-April 2010 and September-December 2010.Injector lines using this material exhibit a significantly higher failure rate.Dealers will replace injector line #2 in all vehicles built in these months.In addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.Analysis of NHTSA complaints, VW complaints, VW field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.The leaking line was not identified in 62 of the vehicles.For the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.Almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by VW, which accounted for approximately one-quarter of the recalled vehicles.The failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (IPTV).The failure rate for injector line #2 in other production months of recalled vehicles is 0.8 IPTV.The leak/repair rates for the other injector lines are all well under 1 IPTV.The action taken by Volkswagen is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. Accordingly, this investigation is closed.

EA11003 · High-Pressure Fuel Pump Failure

Opened Feb 7, 2011 · Closed Mar 27, 2015

Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Additional source detail variants (2)

Fuel System, Diesel

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

PE10034 · High Pressure Fuel Pump Failure (hpfp)

Opened Aug 26, 2010 · Closed Feb 8, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

The Office of Defects Investigation (ODI) and Volkswagen (VW) have received a total of 160 complaints and field reports alleging incidents of engine stall and/or loss of power that appear to be related to high pressure fuel pump (HPFP) failures in certain model year (MY) 2009 through 2010 Volkswagen Jetta and MY 2010 Volkswagen Golf and Audi A3 vehicles equipped with TDI clean diesel engines.Approximately half of the reports indicate that the failure resulted in an engine stall incident, with many of these alleging stall incidents at highway speeds in traffic with no restart.There has been one minor crash alleged to have resulted from HPFP failure in the subject vehicles.In response to ODI's information request for PE10-034, VW indicated that it had found no defect related to motor vehicle safety with relation to the TDI Clean Diesel fuel system at issue in this investigation and attributed problems with HPFP failure to operation with gasoline contaminated diesel fuel.Volkswagen stated that even a small amount of gasoline in the diesel fuel may disrupt the necessary lubrication required and may cause the HPFP to fail.In response to concerns that fuel contamination was the major cause of HPFP and related fuel system failures, VW issued a Technical Service Bulletin in May 2010 (VW TB V011011 2023624 and Audi TB A011008 2023360-1), with instructions to inspect the diesel fuel for vehicles requiring fuel system service that have symptoms associated with HPFP failure.The bulletin states that fuel system damage incurred by use of fuel not complying to ASTM-D-975 Grade 2 S15 (B5 or less biodiesel content) standards will not be covered under warranty. Volkswagen also provided information about 121 mis-fueling incidents reportedly acknowledged by consumers or dealers and test results for about 50 diesel fuel samples taken from complaint vehicles in late-August through early-October 2010.The mis-fueling incidents include about 20 reports involving incorrect fueling by dealer sales or service personnel and generally report symptoms such as rough running, stalling and/or no start within a few miles of refueling the vehicle with gasoline.Volkswagen indicated that the testing of fuel samples from complaint vehicles found that nearly 90 percent contained high amounts of gasoline.Volkswagen implemented design changes for the HPFP in May 2008, September 2009 and November 2010 to improve the robustness of the pump when used with poor quality fuel.ODI analysis of HPFP failures identified from all sources shows failure rates of 0.53% for MY 2009 vehicles and 0.11% for MY 2010 vehicles.This investigation has been upgraded to an Engineering Analysis (EA11-003) to continue to investigate the issues with mis-fueling and HPFP design identified during the Preliminary Evaluation.