← New search

2010 Volkswagen Jetta

Owner reports · Recalls · Investigations

More warning signs than most Jetta years

Owner complaints for the 2010 Volkswagen Jetta are substantially higher than the model-year median of 68.

About this comparison →

When problems were reported

Mileage at the reported incident

779 reports with mileage · 73 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Diesel. Review the 166 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

23 crash reports5 fire reports10 injury reports

Engine And Engine Cooling complaints

71 reports
Clear category filter
13,252 miles · Feb 9, 2011
Engine And Engine Cooling

SUCCESSFULLY STARTING AND DRIVING THE CAR FOR 3 DAYS OF BELOW FREEZING TEMPS AT 40MPH AVERAGE. PUT CAR IN 40DEG GARAGE OVERNIGHT. STARTED CAR IN THE MORNING IN GARAGE, IT RAN FOR ABOUT 3-5 SECONDS THEN STOPPED. RESTART ACTED LIKE DEAD BATTERY; HALF TURN OF CRANK, THEN NOTHING. SUSPECTING A DEAD BATTERY, I PUT A CHARGER ON AN…

Read full complaint

SUCCESSFULLY STARTING AND DRIVING THE CAR FOR 3 DAYS OF BELOW FREEZING TEMPS AT 40MPH AVERAGE. PUT CAR IN 40DEG GARAGE OVERNIGHT. STARTED CAR IN THE MORNING IN GARAGE, IT RAN FOR ABOUT 3-5 SECONDS THEN STOPPED. RESTART ACTED LIKE DEAD BATTERY; HALF TURN OF CRANK, THEN NOTHING. SUSPECTING A DEAD BATTERY, I PUT A CHARGER ON AND TRIED AGAIN HALF AN HOUR LATER; STILL NO START, JUST HALF TURN THEN NOTHING. TRIED AGAIN ABOUT EVERY HALF HOUR FOR 3 HOURS UNTIL IT FINALLY STARTED, THEN IT SEEMED TO BE RUNNING ON 3 CYL FOR ABOUT 15-20 SEC UNTIL IT STARTED TO RUN SMOOTH. TOOK TO DEALER WHERE THEY TESTED BATTERY AND CHARGING SYSTEM; EVERYTHING WITHIN SPECS AND NO CODES. THEY KEPT CAR OUTSIDE OVERNIGHT AT 20 DEGREES AND IT STARTED RIGHT UP THE NEXT MORNING. I INVESTIGATED THIS ISSUE ON SEVERAL TDI FORUMS AND IT SEEMS THIS IS ATTRIBUTED TO ICE FORMING IN THE INTERCOOLER THEN THAWING WHEN WARMED UP. ENGINE WILL START NORMALLY UNTIL IT INGESTS THE WATER/VAPOR THAT SHUTS IT DOWN. SEVERAL OWNERS ARE REPORTING HALF CUP TO TWO CUPS OF WATER DRAINED OUT OF INTERCOOLER HOSES. SEVERAL OWNERS ARE REPORTING ENGINE EITHER SHUTTING DOWN OR GOING INTO LIMP MODE ON HIGHWAY AFTER ICE BLOCKS INTAKE SUFFICIENTLY. MOST ARE SUSPECTING THE LP EGR CIRCUIT THAT IS PUMPING MOIST AIR BACK INTO THE INTAKE/INTERCOOLER CAUSING CONDENSATION TO ACCUMULATE THEN FREEZE. I NOTIFIED DEALER WHEN THEY HAD THE CAR AND THEY DID NOT INVESTIGATE WATER IN INTERCOOLER AS REQUESTED. I SUSPECT THIS IS HYDROLOCKING THE ENGINE AND THAT SERIOUS ENGINE DAMAGE WILL OCCUR IF THIS CONTINUES DURING THE COLD MONTHS. SEVERAL FORUM MEMBERS IN CANADA ARE REPORTING THAT VW OF USA KNOWS ABOUT THIS AND IS WORKING ON A SOLUTION BUT NOBODY HAS SEEN ANYTHING YET. SEVERAL DEALERS ARE RECOMMENDING THE REMOVAL OF THE FRESH AIR INTAKE PIPE TO DRAW WARM, UNDERHOOD AIR INTO THE INTAKE; THIS DOES NOT SEEM TO AFFECT THE ICING AS THE MOISTURE SEEMS TO BE COMING FROM THE EXHAUST STREAM VIA THE LP EGR. *TR

NHTSA ODI #10381254

10 miles · Feb 8, 2011
Engine And Engine Cooling

THE ENGINE SOMETIMES SKIPS OR HESITATES WHILE DRIVING - IT SEEMS AS IF THE FUEL IS GETTING CUT OFF MOMENTARILY. THE ENGINE SKIPS AND STUTTERS LIKE IT'S ABOUT TO STALL. IT HAS NOT ACTUALLY STALLED YET WHILE I'M DRIVING, BUT SOMETHING IS OBVIOUSLY WRONG. THE ENGINE IS THE 4 CYLINDER 2.0 TDI DIESEL. 2010 VW JETTA SPORTWAGEN…

Read full complaint

THE ENGINE SOMETIMES SKIPS OR HESITATES WHILE DRIVING - IT SEEMS AS IF THE FUEL IS GETTING CUT OFF MOMENTARILY. THE ENGINE SKIPS AND STUTTERS LIKE IT'S ABOUT TO STALL. IT HAS NOT ACTUALLY STALLED YET WHILE I'M DRIVING, BUT SOMETHING IS OBVIOUSLY WRONG. THE ENGINE IS THE 4 CYLINDER 2.0 TDI DIESEL. 2010 VW JETTA SPORTWAGEN. *TR

NHTSA ODI #10381110

3,021 miles · Jan 29, 2011
Engine And Engine CoolingFuel System, Diesel

2010 JETTA TDI SPORTWAGON STALLING WHEN IDLING AT STOP LIGHT NO CHECK ENGINE LIGHT APPEARS. HAS HAPPENED TWICE IN 3000 MILES. *LN

NHTSA ODI #10379527

Mileage unknown · Jan 23, 2011
Engine And Engine Cooling

I'VE BEEN DRIVING MANUAL TRANS CARS AND TRUCKS FOR 30 YEARS AND NEVER EXPERIENCED THE AMOUNT OF STALLING MY 6 SPEED 2010 VW JETTA SPORTWAGEN TDI EXHIBITS WHILE DRIVING LOW SPEEDS. AT FIRST I THOUGHT IT WAS JUST ME GETTING USED TO THE CAR, BUT SEVERAL ONLINE FORUMS DISCUSS THE SAME PROBLEM. I HAVE OWNED THE CAR 4 MONTHS AND EXPER…

Read full complaint

I'VE BEEN DRIVING MANUAL TRANS CARS AND TRUCKS FOR 30 YEARS AND NEVER EXPERIENCED THE AMOUNT OF STALLING MY 6 SPEED 2010 VW JETTA SPORTWAGEN TDI EXHIBITS WHILE DRIVING LOW SPEEDS. AT FIRST I THOUGHT IT WAS JUST ME GETTING USED TO THE CAR, BUT SEVERAL ONLINE FORUMS DISCUSS THE SAME PROBLEM. I HAVE OWNED THE CAR 4 MONTHS AND EXPERIENCE OVER 6 STALLS. VERY EASY STALLING AT LOW SPEEDS. *LN

NHTSA ODI #10378362

Mileage unknown · Jan 21, 2011
Engine And Engine Cooling

I PURCHASED MY 2010 JETTA IN MAY OF 2010. LESS THAN ONE YEAR LATER I HAVE EXPERIENCED POWER LOSS ON FOUR SEPARATE OCCASIONS. EACH TIME THIS OCCURRED I WAS COMING TO A STOP AFTER DRIVING BETWEEN 20-30 MILES. IT SHOULD BE NOTED THAT THERE WAS NO "CHECK ENGINE" LIGHT ILLUMINATED. TWO DAYS LATER I TOOK IT TO THE DEALERSHIP WHO A…

Read full complaint

I PURCHASED MY 2010 JETTA IN MAY OF 2010. LESS THAN ONE YEAR LATER I HAVE EXPERIENCED POWER LOSS ON FOUR SEPARATE OCCASIONS. EACH TIME THIS OCCURRED I WAS COMING TO A STOP AFTER DRIVING BETWEEN 20-30 MILES. IT SHOULD BE NOTED THAT THERE WAS NO "CHECK ENGINE" LIGHT ILLUMINATED. TWO DAYS LATER I TOOK IT TO THE DEALERSHIP WHO ATTEMPTED TO DUPLICATE THE PROBLEM WHICH AS I HAD IMAGINED THEY COULD NOT. *TR

NHTSA ODI #10378178

32,475 miles · Dec 18, 2010
Engine And Engine Cooling

1) OVER THE PAST THREE WEEKS, THIS VEHICLE HAS EXPERIENCED SYMPTOMS OF DRAWING WATER THROUGH THE INTAKE AND CYLINDERS ON STARTUP ON 5-6 SEPARATE OCCASIONS. SYMPTOMS INCLUDE: ROUGH IDLE (AS THOUGH MISFIRING ON ONE OR MORE CYLINDERS), WHITE SMOKE, DIFFICULTY GAINING ENGINE RPM, AND STUMBLING FOR FIRST 30-60 SECONDS OF OPERATION …

Read full complaint

1) OVER THE PAST THREE WEEKS, THIS VEHICLE HAS EXPERIENCED SYMPTOMS OF DRAWING WATER THROUGH THE INTAKE AND CYLINDERS ON STARTUP ON 5-6 SEPARATE OCCASIONS. SYMPTOMS INCLUDE: ROUGH IDLE (AS THOUGH MISFIRING ON ONE OR MORE CYLINDERS), WHITE SMOKE, DIFFICULTY GAINING ENGINE RPM, AND STUMBLING FOR FIRST 30-60 SECONDS OF OPERATION UNTIL "CLEARED OUT". ON ONE OCCASION, THE STARTER MOTOR WOULD NOT TURN OVER THE ENGINE DUE TO "HYDROLOCKING" PHENOMENON. WHEN THE STARTER WAS RELEASED AND CRANKED AGAIN, THE CAR CRANKED VERY SLOWLY, CAUGHT, AND STARTED EXTREMELY ROUGHLY, AND NEEDED SIGNIFICANT NURSING OF THROTTLE TO "CLEAR OUT". I TOOK THE CAR TO THE DEALER ON DECEMBER 8TH FOR THE ABOVE BEHAVIOR. THEY COULD OFFER NO EXPLANATION, NO FAULT CODES STORED ON COMPUTER. 2) ON DECEMBER 14TH, DRIVING HOME IN A RAIN AND SNOWSTORM, MY CAR WENT INTO ELECTRONIC LIMP MODE ON THE HIGHWAY AT 70MPH. THE DASH FLASHED "SERVICE ENGINE NOW", THE GLOW PLUG LIGHT FLASHED, AND POWER WAS CUT. I TOOK IT TO THE DEALER THE NEXT DAY - THEY FOUND THE INTERCOOLER AND PRESSURIZED INTAKE LINES FULL OF 1-1.5 CUPS OF ICE AND WATER. THIS FAILURE OCCURS OFTEN, EACH TIME THE CAR IS RUN FOR AN HOUR AT HUMID BELOW FREEZING TEMPERATURES. WHEN THE CAR IS SHUTOFF AND ALLOWED TO WARM TO ABOVE FREEZING, LIQUID WATER IS DRAWING DIRECTLY INTO THE CYLINDERS. THE CONSEQUENCES OF THIS CAN INCLUDE: LIMP MODE, ROUGH STARTING, AND COMPLETED ENGINE DESTRUCTION BY HYDROLOCKING AND BENT OR BROKEN CONNECTING RODS. I STRONGLY SUSPECT MY ENGINE IS PERMANENTLY DAMAGED. 3) THE DEALER DRAINED OUT THE WATER AND REASSEMBLED - SAID THEY CONSIDER THE CAR FIXED. THEY HAVE NOT ADDRESSED THE ROOT CAUSE OF WHY THE POOLS OF WATER ARE PRESENT IN THE INTAKE DURING STARTUP AFTER RUNNING IN HUMID FREEZING CONDITIONS. THE CAUSE IS ICING OF THE INTERCOOLER DURING NORMAL OPERATION, WHICH IS A DESIGN FLAW UNCONTROLLED BY THE USER. WHEN ACCUMULATED ICE MELTS DURING A WARM DAY, THE WATER POOLS AND HAS GRAVE POTENTIAL TO DESTROY THE ENGINE. *TR

NHTSA ODI #10371185

35,009 miles · Nov 30, 2010
Engine And Engine CoolingPower Train

CAR IDLING IN PARK. ENGAGED DSG TRANSMISSION, CAR IMMEDIATELY STALLS.. ATTEMPTED TO RESTART, RUN/STALL, RUN/STALL, RUN/STALL. NOW RUNS ROUGH... MILEAGE DROPPED 20%. CAR AT DEALER - DEALER HAS REPORTED 5 OTHER TDI'S IN SAME CONDITION. *TR

NHTSA ODI #10368275

19,800 miles · Nov 19, 2010
Engine And Engine CoolingFuel System, Diesel

1. DRIVING NORMALLY ON HIGHWAY WHEN IT CAME ON AND THE CAR LOST POWER SUDDENLY AND COULD NOT ACCELERATE ANY FURTHER. ALSO CAR STALLED SEVERAL TIMES ON ITS OWN WHILE IDLING AT A TRAFFIC LIGHT (ITS AN AUTOMATIC TRANSMISSION THIS SHOULD NOT BE HAPPENING). 2. THIS IS THE SECOND TIME THIS SAME PROBLEM HAS HAPPENED IN FIRST 20K MILE…

Read full complaint

1. DRIVING NORMALLY ON HIGHWAY WHEN IT CAME ON AND THE CAR LOST POWER SUDDENLY AND COULD NOT ACCELERATE ANY FURTHER. ALSO CAR STALLED SEVERAL TIMES ON ITS OWN WHILE IDLING AT A TRAFFIC LIGHT (ITS AN AUTOMATIC TRANSMISSION THIS SHOULD NOT BE HAPPENING). 2. THIS IS THE SECOND TIME THIS SAME PROBLEM HAS HAPPENED IN FIRST 20K MILES OF THIS VEHICLE ITS AN 2010 VW TDI. FIRST TIME IT WAS AT 9800 MILE MARK SAME LIGHT AND PROBLEM CAME ON THEY REPLACED A EGR VALVE AND NOW AGAIN AT 19800MILES. 3. THEY HAVE REPLACED A PART AT 9800 MILES AND NOW REPLACING IT AGAIN AT 19800MILES. IT SEEMS TO BE A REPEAT PROBLEM WITH THIS VEHICLE AND VERY DANGEROUS TO HAVE IT SLOW DOWN LIKE THAT WHILE DRIVING AND ALSO STALL OUT WHILE IN TRAFFIC. *TR

NHTSA ODI #10366815

100 miles · Nov 4, 2010
Electrical SystemEngine And Engine CoolingInterior Lighting

TL*THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 65 MPH SHE HEARD A THROBBING NOISE COMING FROM THE SPEAKERS AND ALL OF THE INTERIOR LIGHTS STOPPED FUNCTIONING. SHE WAS ALSO UNABLE TO USE THE RADIO. THE VEHICLE WAS DRIVEN ONTO THE EMERGENCY LANE AND SHUT OFF. UPON RESTARTING THE VEHICLE IT WOULD FUNCTION…

Read full complaint

TL*THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. WHILE DRIVING APPROXIMATELY 65 MPH SHE HEARD A THROBBING NOISE COMING FROM THE SPEAKERS AND ALL OF THE INTERIOR LIGHTS STOPPED FUNCTIONING. SHE WAS ALSO UNABLE TO USE THE RADIO. THE VEHICLE WAS DRIVEN ONTO THE EMERGENCY LANE AND SHUT OFF. UPON RESTARTING THE VEHICLE IT WOULD FUNCTION NORMALLY. THE FAILURE CONTINUED TO OCCUR INTERMITTENTLY. SHE ALSO STATED THAT SHE WOULD ATTEMPT TO CHANGE THE RADIO STATION BUT THE RADIO WOULD INTERMITTENTLY DISPLAY A MESSAGE READING "NO CD" OR "NO MAGAZINE". A FEW MONTHS LATER WHILE DRIVING APPROXIMATELY 10 MPH THE VEHICLE STALLED. UPON RESTARTING THE VEHICLE IT FUNCTIONED NORMALLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON 3 OCCASIONS WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURES. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100 AND THE CURRENT MILEAGE WAS 10,000.

NHTSA ODI #10363998

8,747 miles · Nov 1, 2010
Engine And Engine Cooling

I WAS DRIVING ON A SECONDARY HIGHWAY GOING ONLY 30 MPH WHEN A WARNING LIGHT CAME ON. AT THE SAME TIME THE ENGINE STARTED RUNNING VERY ROUGH. I IMMEDIATELY PULLED THE CAR TO THE SIDE OF THE ROAD. AT THE SIDE OF THE ROAD WITH THE ENGINE OFF, I PULLED OUT THE JETTA HANDBOOK TO RESEARCH THE MEANING OF THE WARNING LIGHT. THE LIGHT BL…

Read full complaint

I WAS DRIVING ON A SECONDARY HIGHWAY GOING ONLY 30 MPH WHEN A WARNING LIGHT CAME ON. AT THE SAME TIME THE ENGINE STARTED RUNNING VERY ROUGH. I IMMEDIATELY PULLED THE CAR TO THE SIDE OF THE ROAD. AT THE SIDE OF THE ROAD WITH THE ENGINE OFF, I PULLED OUT THE JETTA HANDBOOK TO RESEARCH THE MEANING OF THE WARNING LIGHT. THE LIGHT BLINKING WAS THE ENGINE MALFUNCTION LIGHT. AFTER THAT I CALLED THE VW 800 ROAD SIDE PROGRAM, A TOW TRUCK CAME AND TOWED THE JETTA TO THE DEALER. NOW THIS MORNING I GO TO THE DEALERSHIP AND THEY INFORM ME THE COST OF GETTING THIS NEW CAR FIXED WILL BE $6,800.00. WITH THAT INFORMATION I HAVE TO ASK WHY AND THE DEALERSHIP PROCEEDS TO SAY I HAVE "BAD FUEL". THE COMMENT BY THE DEALERSHIP TRIGGERED ALL TYPES OF RESPONSES. THE FIRST RESPONSE WAS PROOF I PUT THE RIGHT TYPE OF FUEL IN THE TANK WHICH I DID. NEXT I HAD TO GO AND GET A SAMPLE OF FUEL FROM THE FILLING STATION. AFTER THAT I DELIVERED A SAMPLE OF THE FUEL IN QUESTION TO THE DEALERSHIP FOR TESTING. AS IT TURNS OUT THE FUEL WAS OKAY. WHILE I AM RUNNING AROUND DOING ALL OF THIS MY WIFE FINDS OUT VIA THE INTERNET OF ISSUES THE JETTA IS HAVING WITH THE FUEL PUMP. KEEP IN MIND, AT NO POINT HAS THE DEALERSHIP GIVEN ME INFORMATION REGARDING A POSSIBLE FUEL PUMP ISSUE, WHICH WOULD BE A WARRANTY ISSUE, AKA NO COST TO ME! IT IS NOW 5:20 PM AND I HAVE NOT HEARD FROM THE DEALERSHIP. NOW I HAVE ANOTHER ISSUE, IS THE DEALERSHIP TRYING TO DEFRAUD ME? AND IF SO THE DEALERSHIP WILL HAVE BIG PROBLEMS.

NHTSA ODI #10364550

Official recalls

4

16V913000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Dec 20, 2016

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence & remedy

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Additional source detail variants (2)

Electronic Stability Control (esc)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

11V490000 · Fuel System, Diesel

Oct 3, 2011

VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Consequence & remedy

Consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Remedy: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

10V621000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Dec 10, 2010

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

Consequence & remedy

Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

09V333000 · Power Train:automatic Transmission

Aug 20, 2009

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.

Consequence & remedy

Consequence: THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: VOLKSWAGEN WILL REPROGRAM THE TRANSMISSION CONTROL MODULE WITH UPDATED SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 20, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

EA18003 · Air Bag Clockspring Failure

Opened Apr 18, 2018 · No close date supplied

Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Additional source detail variants (3)

Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags:frontal

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

PE11023 · Diesel Fuel Injector Line Leakage

Opened Aug 2, 2011 · Closed Dec 2, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

By letter dated October 3, 2011, Volkswagen Group of America, Inc. (VW) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address a defect in approximately 168,275 model year (MY) 2009-2012 Volkswagen Jetta, Jetta Sportwagen, Golf, and Audi A3 vehicles equipped with the 2.0L TDI Common Rail Clean Diesel engine (NHTSA Recall No. 11V-490).The recalled Jetta and Jetta Sportwagen vehicles were built from May 2008 through September 2011, the Golf vehicles were built from May 2009 through September 2011, and the Audi A3 vehicles were built from September 2009 through September 2011.According to Volkswagen, in U.S. applications of the above cited TDI vehicles including engine codes CJAA and CBEA, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and RPM conditions.This resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.As a contributing factor, VW indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.Lines manufactured in these periods were installed in vehicles produced in the following 10 months:December 2008, January-February 2009, October 2009, March-April 2010 and September-December 2010.Injector lines using this material exhibit a significantly higher failure rate.Dealers will replace injector line #2 in all vehicles built in these months.In addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.Analysis of NHTSA complaints, VW complaints, VW field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.The leaking line was not identified in 62 of the vehicles.For the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.Almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by VW, which accounted for approximately one-quarter of the recalled vehicles.The failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (IPTV).The failure rate for injector line #2 in other production months of recalled vehicles is 0.8 IPTV.The leak/repair rates for the other injector lines are all well under 1 IPTV.The action taken by Volkswagen is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. Accordingly, this investigation is closed.

EA11003 · High-Pressure Fuel Pump Failure

Opened Feb 7, 2011 · Closed Mar 27, 2015

Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Additional source detail variants (2)

Fuel System, Diesel

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

PE10034 · High Pressure Fuel Pump Failure (hpfp)

Opened Aug 26, 2010 · Closed Feb 8, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

The Office of Defects Investigation (ODI) and Volkswagen (VW) have received a total of 160 complaints and field reports alleging incidents of engine stall and/or loss of power that appear to be related to high pressure fuel pump (HPFP) failures in certain model year (MY) 2009 through 2010 Volkswagen Jetta and MY 2010 Volkswagen Golf and Audi A3 vehicles equipped with TDI clean diesel engines.Approximately half of the reports indicate that the failure resulted in an engine stall incident, with many of these alleging stall incidents at highway speeds in traffic with no restart.There has been one minor crash alleged to have resulted from HPFP failure in the subject vehicles.In response to ODI's information request for PE10-034, VW indicated that it had found no defect related to motor vehicle safety with relation to the TDI Clean Diesel fuel system at issue in this investigation and attributed problems with HPFP failure to operation with gasoline contaminated diesel fuel.Volkswagen stated that even a small amount of gasoline in the diesel fuel may disrupt the necessary lubrication required and may cause the HPFP to fail.In response to concerns that fuel contamination was the major cause of HPFP and related fuel system failures, VW issued a Technical Service Bulletin in May 2010 (VW TB V011011 2023624 and Audi TB A011008 2023360-1), with instructions to inspect the diesel fuel for vehicles requiring fuel system service that have symptoms associated with HPFP failure.The bulletin states that fuel system damage incurred by use of fuel not complying to ASTM-D-975 Grade 2 S15 (B5 or less biodiesel content) standards will not be covered under warranty. Volkswagen also provided information about 121 mis-fueling incidents reportedly acknowledged by consumers or dealers and test results for about 50 diesel fuel samples taken from complaint vehicles in late-August through early-October 2010.The mis-fueling incidents include about 20 reports involving incorrect fueling by dealer sales or service personnel and generally report symptoms such as rough running, stalling and/or no start within a few miles of refueling the vehicle with gasoline.Volkswagen indicated that the testing of fuel samples from complaint vehicles found that nearly 90 percent contained high amounts of gasoline.Volkswagen implemented design changes for the HPFP in May 2008, September 2009 and November 2010 to improve the robustness of the pump when used with poor quality fuel.ODI analysis of HPFP failures identified from all sources shows failure rates of 0.53% for MY 2009 vehicles and 0.11% for MY 2010 vehicles.This investigation has been upgraded to an Engineering Analysis (EA11-003) to continue to investigate the issues with mis-fueling and HPFP design identified during the Preliminary Evaluation.