← New search

2010 Volkswagen Jetta

Owner reports · Recalls · Investigations

More warning signs than most Jetta years

Owner complaints for the 2010 Volkswagen Jetta are substantially higher than the model-year median of 68.

About this comparison →

When problems were reported

Mileage at the reported incident

779 reports with mileage · 73 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Diesel. Review the 166 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

23 crash reports5 fire reports10 injury reports

Engine And Engine Cooling complaints

71 reports
Clear category filter
34,034 miles · Mar 20, 2012
Engine And Engine Cooling

ICE IN THE AIR INTAKE CAUSED THE ENGINE TO VAPOR LOCK WHICH CAUSED A BENT PISTON ROD. DEALER IS GOING TO REMOVE THE FACTORY AIR INTAKE AFTER INSTALLING A NEW ENGINE UNDER WARRANTY AND CLAIMS THIS IS AN ENGINEERED FIX. DEALER ALSO SAID THAT VOLKSWAGEN IS WORKING ON SOME HEATER ADD ON IN THE POSSIBLE FUTURE. I SUSPECT THAT THE …

Read full complaint

ICE IN THE AIR INTAKE CAUSED THE ENGINE TO VAPOR LOCK WHICH CAUSED A BENT PISTON ROD. DEALER IS GOING TO REMOVE THE FACTORY AIR INTAKE AFTER INSTALLING A NEW ENGINE UNDER WARRANTY AND CLAIMS THIS IS AN ENGINEERED FIX. DEALER ALSO SAID THAT VOLKSWAGEN IS WORKING ON SOME HEATER ADD ON IN THE POSSIBLE FUTURE. I SUSPECT THAT THE CURRENT FIX IS NOT A FIX AS THE TROUBLE WAS NOT WHEN DRIVING IT WAS AFTER THE CAR SET FOR A FEW DAYS AND ICE FORMED IN THE INTAKE. NHTSA SHOULD INVESTIGATE TO CONFIRM THE ENGINEERING ISSUE IS ADDRESSED CORRECTLY TO PROTECT CONSUMERS. *KB

NHTSA ODI #10452467

30,000 miles · Mar 13, 2012
Engine And Engine Cooling

ENGINE COMPLETELY AND SUDDENLY STALLED OUT AFTER STOPPING AT AN INTERSECTION. THE CAR WAS RESTARTED WITHOUT HESITATION OR DELAY. *TR

NHTSA ODI #10451354

36,500 miles · Mar 9, 2012
Engine And Engine Cooling

COMPLETE ENGINE SHUT-OFF, WITHOUT WARNING OR STUMBLING, INCLUDING ALL SUPPORT SYSTEMS (POWER STEERING AND BRAKES, ETC). NO DASH LIGHTS, ETC. AFTER 30 SECONDS, CAR RESTARTS. HAS NOW HAPPENED MULTIPLE TIMES. DEALER HAS EXAMINED AND OFFERS NO EXPLANATION OR FIX, BECAUSE THEY CAN'T "REPLICATE" THE PROBLEM, AND CAR THROWS NO CODES WH…

Read full complaint

COMPLETE ENGINE SHUT-OFF, WITHOUT WARNING OR STUMBLING, INCLUDING ALL SUPPORT SYSTEMS (POWER STEERING AND BRAKES, ETC). NO DASH LIGHTS, ETC. AFTER 30 SECONDS, CAR RESTARTS. HAS NOW HAPPENED MULTIPLE TIMES. DEALER HAS EXAMINED AND OFFERS NO EXPLANATION OR FIX, BECAUSE THEY CAN'T "REPLICATE" THE PROBLEM, AND CAR THROWS NO CODES WHEN FAILURE OCCURS. THIS IS VERY DANGEROUS. THE SUDDENNESS OF THE FAILURE LEAVES LITTLE TIME TO PULL OFF THE ROAD, SOMETIMES FORCING DRIVER TO STOP IN THE MIDDLE OF THE ROAD! *TR

NHTSA ODI #10451008

39,000 miles · Feb 15, 2012
Engine And Engine CoolingFuel System, Diesel

WHEN SLOWING DOWN TO A STOP THE CAR HESITATES WHILE IDLING AND THEN WHEN YOU START TO PRESS THE GAS PEDAL TO GO IT HESITATES MORE AND ALMOST STALLS. THE COOLING FAN SEEMS TO RUN EXCESSIVELY AFTER TURNING OFF MOTOR. *TR

NHTSA ODI #10448041

29,000 miles · Jan 17, 2012
Engine And Engine CoolingPower Train

I HAVE HAD SEVERAL ISSUES IN THE PAST MONTH WITH MY VEHICLE EITHER STALLING IMMEDIATELY AFTER START (WHILE CLUTCH STILL DEPRESSED) OR SHORTLY AFTER DRIVING. VOLKSWAGEN HAS IDENTIFIED THIS AS AN ISSUE WITH THE INTERCOOLER; THERE IS A FLAW IN THE DESIGN THAT IS LETTING WATER INTO THE AIR PIPES WHICH IS COLLECTING AND FREEZING. THR…

Read full complaint

I HAVE HAD SEVERAL ISSUES IN THE PAST MONTH WITH MY VEHICLE EITHER STALLING IMMEDIATELY AFTER START (WHILE CLUTCH STILL DEPRESSED) OR SHORTLY AFTER DRIVING. VOLKSWAGEN HAS IDENTIFIED THIS AS AN ISSUE WITH THE INTERCOOLER; THERE IS A FLAW IN THE DESIGN THAT IS LETTING WATER INTO THE AIR PIPES WHICH IS COLLECTING AND FREEZING. THREE TIMES THIS HAPPENED IN TRAFFIC, ONE TIME WHILE CROSSING A LANE WITH ONCOMING TRAFFIC GOING 50MPH. VW DRAINED THE INTERCOOLER TWO WEEKS AGO AND SENT ME ON MY WAY BECAUSE THE PART IS BEING REDESIGNED AND IS ON BACKORDER. A WEEK LATER MY CAR FAILED SHORTLY AFTER LEAVING MY DRIVEWAY, STRANDING ME ON THE SIDE OF THE ROAD. I HAD TO HAVE IT TOWED BACK TO MY DRIVEWAY. VW DEALERSHIP AND CUSTOMER CARE WERE CLOSED FOR THE WEEKEND. MONDAY I HAD TO TAKE A TOW TRUCK RIDE 1.5 HOURS TO THE DEALERSHIP. THEY'VE DRAINED IT AGAIN AND WANT ME TO PICK IT UP BUT HAVE ACKNOWLEDGED THE ISSUE IS NOT FIXED. THEY ACKNOWLEDGE IT IS A KNOWN ISSUE, IT IS A SAFETY ISSUE, THE CAR IS UNDER WARRANTY AND YET THEY WANT ME TO PICK UP AN UNREPAIRED CAR BECAUSE VW DOES NOT HAVE PARTS TO REPAIR IT. I LIVE IN VERMONT, THE WINTERS ARE COLD, I CAN'T RISK GETTING INTO AN ACCIDENT BECAUSE MY CAR FAILS DUE TO WHAT VW CLAIMS IS A KNOWN ISSUE. *TR

NHTSA ODI #10444129

58,500 miles · Jan 16, 2012
Engine And Engine Cooling

THIS IS THE SECOND OCCURRENCE IN TWO WEEKS WHERE MY VW JETTA TDI AUTOMATIC (DSG) 2010 CAR WITH 58K MILES STALLED. I AM ORIGINAL OWNER, HAVE NO PREVIOUS ISSUES WITH THE CAR AND HAVE COMPLETED ALL REQUIRED MAINTENANCE. SYMPTOM. SHORTLY AFTER STARTING CAR AND COMMENCING TO DRIVE, THE ENGINE SPUTTERED AND STALLED WITH JUST O…

Read full complaint

THIS IS THE SECOND OCCURRENCE IN TWO WEEKS WHERE MY VW JETTA TDI AUTOMATIC (DSG) 2010 CAR WITH 58K MILES STALLED. I AM ORIGINAL OWNER, HAVE NO PREVIOUS ISSUES WITH THE CAR AND HAVE COMPLETED ALL REQUIRED MAINTENANCE. SYMPTOM. SHORTLY AFTER STARTING CAR AND COMMENCING TO DRIVE, THE ENGINE SPUTTERED AND STALLED WITH JUST OVER 100 FT OF MOTION. I PLACED THE CAR IN NEUTRAL AND WITH SLIGHT HESITATION, THE ENGINE STARTED AND I WAS ABLE TO RESUME NORMAL DRIVING. IN THE FIRST OCCURRENCE (APPROXIMATELY 1/5/12), THE CAR WAS PARKED OUTSIDE AT WORK FOR 8 HOURS AND THE OUTSIDE TEMP WAS IN THE LOW 30S. THIS STALL OCCURRED IN THE PARKING LOT THE SECOND EVENT (1/15/12), THE CAR HAD BEEN IN THE GARAGE FOR JUST OVER 2 HOURS AND THE OUTSIDE TEMP WAS 20. THIS STALL OCCURRED AFTER BACKING OUT OF THE DRIVEWAY ONTO RESIDENTIAL STREET AND STALLED AFTER COMMENCING FORWARD MOTION. *TR

NHTSA ODI #10443906

500 miles · Dec 2, 2011
Engine And Engine CoolingFuel System, Gasoline

VEHICLE HESITATES, USUALLY AT LOWER SPEEDS, BUT SOMETIMES AT HIGHWAY SPEEDS, AND STALLED COMPLETELY IN INTERSECTIONS TWICE. INITIALLY THIS WAS MOST OFTEN ON A COLD START, WITHIN THE FIRST 5-10 MILES, BUT NOT CONSISTENTLY. IT MIGHT DO IT ONCE A DAY, ONCE A WEEK, OR ONCE EVERY TWO OR THREE WEEKS. I BELIEVE THE PROBLEM TO BE FUE…

Read full complaint

VEHICLE HESITATES, USUALLY AT LOWER SPEEDS, BUT SOMETIMES AT HIGHWAY SPEEDS, AND STALLED COMPLETELY IN INTERSECTIONS TWICE. INITIALLY THIS WAS MOST OFTEN ON A COLD START, WITHIN THE FIRST 5-10 MILES, BUT NOT CONSISTENTLY. IT MIGHT DO IT ONCE A DAY, ONCE A WEEK, OR ONCE EVERY TWO OR THREE WEEKS. I BELIEVE THE PROBLEM TO BE FUEL SYSTEM RELATED AND NOT TRANSMISSION. I HAVE REPORTED THE PROBLEM TO DEALER WITH EACH SERVICE CALL (3 SO FAR, I HAVE 20K MILES TO DATE). DEALER INITIALLY SUGGESTED BAD FUEL AND TO BUY ONLY CHEVRON, BUT THERE IS NO CORRELATION BETWEEN FUEL SOURCE AND HESITATION, NO EVIDENCE OF WATER IN FUEL FILTER, ETC., AND I USUALLY PURCHASE CHEVRON FUEL. DEALER REPORTED BEING UNABLE TO IDENTIFY THE PROBLEM WITHOUT "CODES". VEHICLE HESITATED AGAIN (11/25/11), WITHIN ONE BLOCK OF DRIVING AFTER 20K SERVICE. I IMMEDIATELY RETURNED TO DEALER, AND THEY WERE STILL UNABLE TO DIAGNOSE. DEALER HAS KEPT THE CAR AND CONTACTED VW USA TECH SERVICE, BUT REMAINS UNABLE TO DIAGNOSE AS OF 12/2/11. MY DAUGHTER PURCHASED THE SAME CAR 3 DAYS AFTER I BOUGHT MINE AND HAS THE SAME PROBLEM (30K MILES SO FAR), BUT HAS NOT STALLED IN AN INTERSECTION - YET. THIS IS NOT OUR INABILITY TO DRIVE A STICK TRANSMISSION - BOTH OF US HAVE OWNED DIESEL JETTAS WITH MANUAL TRANSMISSIONS FOR 10 YEARS PRIOR TO OUR RECENT PURCHASES. I CONTACTED VW USA AND HAVE RECEIVED THE SAME MESSAGE - UNLESS THEY CAN DIAGNOSE A SPECIFIC PROBLEM, THERE IS NOTHING THEY CAN DO, BUT THEY DID SUGGEST GOING TO A DIFFERENT DEALER. VW DID PERFORM A FUEL LINE RECALL WITH MY LAST SERVICE, BUT THE HESITATION REMAINS. THERE ARE A NUMBER OF REPORTS OF THIS PROBLEM ON THE WEB, BUT VW IS UNWILLING TO ATTEMPT ANY REPAIR WITHOUT A SOLID DIAGNOSIS. STALLING IN INTERSECTIONS AND HESITATION WHILE DRIVING ARE UNACCEPTABLE PERFORMANCE FOR A CAR. PERIOD. I HOPE YOU CAN HELP. EVENINGS OR EARLY AMS ARE BEST TIME TO CALL. *TR

NHTSA ODI #10438174

35,650 miles · Nov 11, 2011
Engine And Engine CoolingFuel System, GasolinePower Train

2010 VW JETTA TDI WITH ROUGHLY 35,650 MILES. WHILE DRIVING UP THE ON-RAMP TO ENTER THE INTERSTATE, GLOW PLUG DASH LIGHT CAME ON AND WARNED TO "CHECK ENGINE NOW." WITHIN 20 SECONDS, THE CAR LOST ALL POWER, AND LUCKILY I WAS ABLE TO COAST OVER TO THE SHOULDER OF THE INTERSTATE (WITH DRIVERS FLYING BY AT 65+MPH AT 9:45PM). VEHICLE …

Read full complaint

2010 VW JETTA TDI WITH ROUGHLY 35,650 MILES. WHILE DRIVING UP THE ON-RAMP TO ENTER THE INTERSTATE, GLOW PLUG DASH LIGHT CAME ON AND WARNED TO "CHECK ENGINE NOW." WITHIN 20 SECONDS, THE CAR LOST ALL POWER, AND LUCKILY I WAS ABLE TO COAST OVER TO THE SHOULDER OF THE INTERSTATE (WITH DRIVERS FLYING BY AT 65+MPH AT 9:45PM). VEHICLE WOULD NOT RESTART AND HAD TO BE TOWED TO THE VW DEALERSHIP. SERVICE REP CLAIMED "FUEL CONTAMINATION," WITH METAL SHARDS ALL THROUGHOUT THE FUEL SYSTEM. ENTIRE FUEL SYSTEM HAS TO BE REPLACED ($10,000 REPAIR) WITH EQUIVALENT, NEW PARTS. ACCORDING TO VW SERVICE TECHNICIANS, THE PARTS HAVE NOT BEEN UPDATED DESPITE VW'S KNOWLEDGE OF THIS PROBLEM. AS A RESULT, "FUEL CONTAMINATION" COULD HAPPEN AGAIN, AND THE CAR COULD SHUT OFF WHILE DRIVING AT ANY TIME WITHOUT NOTICE. THIS IS A VERY SERIOUS SAFETY CONCERN. LUCKILY, BECAUSE I WAS DRIVING AT NIGHT, THERE WAS NOT A LOT OF CONGESTION ON THE ROAD. HAD THIS HAPPENED DURING RUSH HOUR, THERE VERY LIKELY WOULD HAVE BEEN A SEVERE ACCIDENT. VW CLAIMS THE PROBLEM IS A RESULT OF THE POOR QUALITY OF AMERICAN DIESEL FUEL SUPPLY, SAYING THE TDIS ARE DESIGNED IN GERMANY TO RUN ON 100% DIESEL THAT'S FOUND IN EUROPE. IF THIS IS THE CASE, WHY ARE THEY SELLING GERMAN DESIGNED CARS IN THE UNITED STATES THAT DOESN'T HAVE FUEL SUPPLIES THAT ARE 100% DIESEL? VOLKSWAGEN NEEDS TO ISSUE A RECALL OF THE 2009/2010 JETTA TDI. *TR

NHTSA ODI #10435310

22,000 miles · Nov 2, 2011
Engine And Engine Cooling

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA SPORTWAGEN TDI. THE CONTACT STATED THAT WHILE GOING UPHILL, THE VEHICLE STALLED WITHOUT WARNING, FOLLOWED BY THE BATTERY LIGHT ILLUMINATING ON THE INSTRUMENT PANEL. THE DEALER WAS NOTIFIED, BUT WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF…

Read full complaint

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA SPORTWAGEN TDI. THE CONTACT STATED THAT WHILE GOING UPHILL, THE VEHICLE STALLED WITHOUT WARNING, FOLLOWED BY THE BATTERY LIGHT ILLUMINATING ON THE INSTRUMENT PANEL. THE DEALER WAS NOTIFIED, BUT WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 22,000.

NHTSA ODI #10433969

23,600 miles · Oct 4, 2011
Engine And Engine CoolingFuel System, Gasoline

MOTOR LOST MOST POWER BUT WAS ABLE TO GO 10-15MPH TO GET TO END OF TRIP. CHECK ENGINE LIGHT CAME ON AND GLOW PLUG LIGHT FLASHED ON & OFF. CALLED VW AND THEY SCHEDULED APPT FOR NEXT DAY, SAID IT WAS OK TO DRIVE IN. BEGAN DRIVE HOME ON MAJOR CITY STREET. WHILE DRIVING, THE ENGINE DIED AND WOULD NOT RESTART. CAR STALLED IN LEF…

Read full complaint

MOTOR LOST MOST POWER BUT WAS ABLE TO GO 10-15MPH TO GET TO END OF TRIP. CHECK ENGINE LIGHT CAME ON AND GLOW PLUG LIGHT FLASHED ON & OFF. CALLED VW AND THEY SCHEDULED APPT FOR NEXT DAY, SAID IT WAS OK TO DRIVE IN. BEGAN DRIVE HOME ON MAJOR CITY STREET. WHILE DRIVING, THE ENGINE DIED AND WOULD NOT RESTART. CAR STALLED IN LEFT LANE BLOCKING RUSH HOUR TRAFFIC. THE DRIVER OF THE FOLLOWING CAR WAS ABLE TO STOP TRAFFIC ENOUGH TO ALLOW US TO PUSH THE DEAD VW OFF THE ROAD TO THE RIGHT. CARS WERE ATTEMPTING TO PASS US AS WE PUSHED IT TO THE SIDE. CALLED VW AND THEY SENT A TOW TRUCK. DIAGNOSTICS THE NEXT DAY FOUND METAL IN THE TDI DIESEL HIGH PRESSURE FUEL PUMP. FUEL SYSTEM IS TO BE REPLACED UNDER WARRANTY. *TR

NHTSA ODI #10428406

Official recalls

4

16V913000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Dec 20, 2016

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence & remedy

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Additional source detail variants (2)

Electronic Stability Control (esc)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

11V490000 · Fuel System, Diesel

Oct 3, 2011

VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Consequence & remedy

Consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Remedy: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

10V621000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Dec 10, 2010

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

Consequence & remedy

Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

09V333000 · Power Train:automatic Transmission

Aug 20, 2009

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.

Consequence & remedy

Consequence: THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: VOLKSWAGEN WILL REPROGRAM THE TRANSMISSION CONTROL MODULE WITH UPDATED SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 20, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

EA18003 · Air Bag Clockspring Failure

Opened Apr 18, 2018 · No close date supplied

Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Additional source detail variants (3)

Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags:frontal

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

PE11023 · Diesel Fuel Injector Line Leakage

Opened Aug 2, 2011 · Closed Dec 2, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

By letter dated October 3, 2011, Volkswagen Group of America, Inc. (VW) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address a defect in approximately 168,275 model year (MY) 2009-2012 Volkswagen Jetta, Jetta Sportwagen, Golf, and Audi A3 vehicles equipped with the 2.0L TDI Common Rail Clean Diesel engine (NHTSA Recall No. 11V-490).The recalled Jetta and Jetta Sportwagen vehicles were built from May 2008 through September 2011, the Golf vehicles were built from May 2009 through September 2011, and the Audi A3 vehicles were built from September 2009 through September 2011.According to Volkswagen, in U.S. applications of the above cited TDI vehicles including engine codes CJAA and CBEA, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and RPM conditions.This resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.As a contributing factor, VW indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.Lines manufactured in these periods were installed in vehicles produced in the following 10 months:December 2008, January-February 2009, October 2009, March-April 2010 and September-December 2010.Injector lines using this material exhibit a significantly higher failure rate.Dealers will replace injector line #2 in all vehicles built in these months.In addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.Analysis of NHTSA complaints, VW complaints, VW field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.The leaking line was not identified in 62 of the vehicles.For the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.Almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by VW, which accounted for approximately one-quarter of the recalled vehicles.The failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (IPTV).The failure rate for injector line #2 in other production months of recalled vehicles is 0.8 IPTV.The leak/repair rates for the other injector lines are all well under 1 IPTV.The action taken by Volkswagen is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. Accordingly, this investigation is closed.

EA11003 · High-Pressure Fuel Pump Failure

Opened Feb 7, 2011 · Closed Mar 27, 2015

Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Additional source detail variants (2)

Fuel System, Diesel

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

PE10034 · High Pressure Fuel Pump Failure (hpfp)

Opened Aug 26, 2010 · Closed Feb 8, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

The Office of Defects Investigation (ODI) and Volkswagen (VW) have received a total of 160 complaints and field reports alleging incidents of engine stall and/or loss of power that appear to be related to high pressure fuel pump (HPFP) failures in certain model year (MY) 2009 through 2010 Volkswagen Jetta and MY 2010 Volkswagen Golf and Audi A3 vehicles equipped with TDI clean diesel engines.Approximately half of the reports indicate that the failure resulted in an engine stall incident, with many of these alleging stall incidents at highway speeds in traffic with no restart.There has been one minor crash alleged to have resulted from HPFP failure in the subject vehicles.In response to ODI's information request for PE10-034, VW indicated that it had found no defect related to motor vehicle safety with relation to the TDI Clean Diesel fuel system at issue in this investigation and attributed problems with HPFP failure to operation with gasoline contaminated diesel fuel.Volkswagen stated that even a small amount of gasoline in the diesel fuel may disrupt the necessary lubrication required and may cause the HPFP to fail.In response to concerns that fuel contamination was the major cause of HPFP and related fuel system failures, VW issued a Technical Service Bulletin in May 2010 (VW TB V011011 2023624 and Audi TB A011008 2023360-1), with instructions to inspect the diesel fuel for vehicles requiring fuel system service that have symptoms associated with HPFP failure.The bulletin states that fuel system damage incurred by use of fuel not complying to ASTM-D-975 Grade 2 S15 (B5 or less biodiesel content) standards will not be covered under warranty. Volkswagen also provided information about 121 mis-fueling incidents reportedly acknowledged by consumers or dealers and test results for about 50 diesel fuel samples taken from complaint vehicles in late-August through early-October 2010.The mis-fueling incidents include about 20 reports involving incorrect fueling by dealer sales or service personnel and generally report symptoms such as rough running, stalling and/or no start within a few miles of refueling the vehicle with gasoline.Volkswagen indicated that the testing of fuel samples from complaint vehicles found that nearly 90 percent contained high amounts of gasoline.Volkswagen implemented design changes for the HPFP in May 2008, September 2009 and November 2010 to improve the robustness of the pump when used with poor quality fuel.ODI analysis of HPFP failures identified from all sources shows failure rates of 0.53% for MY 2009 vehicles and 0.11% for MY 2010 vehicles.This investigation has been upgraded to an Engineering Analysis (EA11-003) to continue to investigate the issues with mis-fueling and HPFP design identified during the Preliminary Evaluation.