← New search

2010 Volkswagen Jetta

Owner reports · Recalls · Investigations

More warning signs than most Jetta years

Owner complaints for the 2010 Volkswagen Jetta are substantially higher than the model-year median of 68.

About this comparison →

When problems were reported

Mileage at the reported incident

779 reports with mileage · 73 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Electrical System. Review the 233 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Diesel. Review the 166 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel/propulsion System. Review the 122 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

23 crash reports5 fire reports10 injury reports

Engine complaints

117 reports
Clear category filter
5,000 miles · Jun 17, 2013
EngineFuel/propulsion System

2010 VOLKSWAGEN SPORTWAGEN TDI. CAR SUFFERED DOZENS OF LOSS OF POWER INCIDENTS, SEVERAL LEFT THE CAR WITHOUT POWER AT FREEWAY SPEEDS. REPEAT VISIT TO DEALER DID NOT RESOLVE PROBLEM, DEALER WAS AGGRESSIVE THAT I WAS MIS-FUELING THE CAR WITH GASOLINE INSTEAD OF DIESEL, WHICH NEVER HAPPENED ONCE (I HAVE FULL RECEIPTS FOR ENTIRE V…

Read full complaint

2010 VOLKSWAGEN SPORTWAGEN TDI. CAR SUFFERED DOZENS OF LOSS OF POWER INCIDENTS, SEVERAL LEFT THE CAR WITHOUT POWER AT FREEWAY SPEEDS. REPEAT VISIT TO DEALER DID NOT RESOLVE PROBLEM, DEALER WAS AGGRESSIVE THAT I WAS MIS-FUELING THE CAR WITH GASOLINE INSTEAD OF DIESEL, WHICH NEVER HAPPENED ONCE (I HAVE FULL RECEIPTS FOR ENTIRE VEHICLE OWNERSHIP). LATEST INCIDENT LEFT ME WITHOUT POWER OR EFFECTIVE STEERING ON I-5 BRIDGE BETWEEN OREGON AND WASHINGTON, NEARLY CAUSING AN ACCIDENT. DEALER AND VW WOULD NOT ANSWER ANY QUESTIONS, AND CLAIMED IF THEY COULD NOT REPRODUCE THE ISSUE, I WAS ON MY OWN. I SUSPECT THE HIGH PRESSURE FUEL PUMP HAD AN INTERNAL DEFECT, THAT DIDN'T LEAD TO COMPLETE FAILURE/DESTRUCTION, BUT WOULD INTERMITTENTLY THROW ERRORS CAUSING THE CAR TO STALL OR LOSE POWER. *TR

NHTSA ODI #10520219

53,878 miles · Jun 1, 2013
EngineFuel System, Diesel

PULLED ON TO HIGHWAY AND VEHICLE SUDDENLY STALLED IN MIDDLE OF INTERSECTION. ENGINE WENT TO IDLE. NO THROTTLE RESPONSE. AFTER SEVERAL PEDAL PRESSES IT TOOK OFF. *TR

NHTSA ODI #10514625

77,000 miles · May 23, 2013
Engine

LAST YEAR, ENGINE LIGHT CAME ON EVEN THOUGH THE CAR WAS DRIVING FINE. I TOOK IT TO DEALER AND SAID PROBLEM WAS DUE TO DEFECT IN EXHAUST FLAP. HE ASKED ME TO PAY $770.00. LUCKILY, THERE WAS RECALL ON THE SAME A MONTH LATER. DEALER FIXED IT, BUT ENGINE LIGHT STILL IS ON. HE TOLD ME THAT ONE OF OXYGEN SENSOR IS FAULTY NOW CAUSED BY…

Read full complaint

LAST YEAR, ENGINE LIGHT CAME ON EVEN THOUGH THE CAR WAS DRIVING FINE. I TOOK IT TO DEALER AND SAID PROBLEM WAS DUE TO DEFECT IN EXHAUST FLAP. HE ASKED ME TO PAY $770.00. LUCKILY, THERE WAS RECALL ON THE SAME A MONTH LATER. DEALER FIXED IT, BUT ENGINE LIGHT STILL IS ON. HE TOLD ME THAT ONE OF OXYGEN SENSOR IS FAULTY NOW CAUSED BY EXHAUST FLAP PROBLEM AND SAID IT IS NOT COVERED BY RECALL AND ASKED TO PAY $550.00. VW REFUSED TO CORRECT THE PROBLEM. NOW, I CAN'T EVEN INSPECT THE CAR. PRESENT PROBLEM IS CAUSED BY ANOTHER RECALLED DEFECTIVE PROBLEM. *TR

NHTSA ODI #10513289

45,750 miles · Mar 26, 2013
EngineFuel System, Diesel

MY WIFE WAS DRIVING HER 2010 VW JETTA S/W TDI DSG HOME FROM WORK AND SHE NOTICED THAT IT SEEMED TO BE RUNNING A LITTLE ROUGHER THEN USUAL (IN DECEMBER WHEN WE HAD THE 40K SERVICE DONE WE WERE TOLD THAT IT NEEDED A FUEL FILTER AND THAT WOULD SOLVE THE PROBLEM...IT DID FOR ABOUT A WEEK OR SO). WHEN SHE SLOWED DOWN FOR TRAFFIC THE …

Read full complaint

MY WIFE WAS DRIVING HER 2010 VW JETTA S/W TDI DSG HOME FROM WORK AND SHE NOTICED THAT IT SEEMED TO BE RUNNING A LITTLE ROUGHER THEN USUAL (IN DECEMBER WHEN WE HAD THE 40K SERVICE DONE WE WERE TOLD THAT IT NEEDED A FUEL FILTER AND THAT WOULD SOLVE THE PROBLEM...IT DID FOR ABOUT A WEEK OR SO). WHEN SHE SLOWED DOWN FOR TRAFFIC THE RPM'S WOULD FLUCTUATE BETWEEN 500 RPMS AND 1400 RPMS AND NEARLY STALLING AT TIMES. FINALLY WHEN SHE GOT OFF THE EXIT RAMP NEAR HOME, THE JETTA STALLED AND A CHECK ENGINE LIGHT CAME ON. ONCE SHE WAS HOME I FOUND THAT IT WAS READING CODE P0263. THE JETTA WENT TO DEALER ON 3/13 AND WE GOT IT BACK ON 3/22. UNFORTUNATELY IT STALLED OUT ON MY WIFE ON 3/23 AFTER A SHORT TRIP ACROSS TOWN WHILE DROPPING MY SON OFF AT HIS FRIENDS HOUSE. SHE PRECEDED TO COME HOME AFTER DROPPING HIM OFF AS THE STALLING ISSUE OCCURRED WHILE MAKING A TURN AND SHE WAS NEARLY BROADSIDED BY A SUV! HAD THE VEHICLES COLLIDED, IT WOULD HAVE BEEN A DIRECT IMPACT TO MY WIFE AND SON'S SEATS! THE NEXT MORNING I TOOK THE JETTA OUT FOR A DRIVE TO SEE IF I COULD DUPLICATE THE PROBLEM AND BOY DID I EVER. THANKFULLY THE DEALER IS CLOSE BY AND I WAS ABLE TO GET THE CAR THERE BUT NOT WITHOUT ISSUES. IT STALLED OUT ON ME 4 TIMES IN THE 1.5 MILE TRIP. I TOO WAS NEARLY HIT BY AN ON COMING CAR WHILE MAKING A TURN. NOT TO MENTION IT STALLED WHILE TRYING TO MERGE ONTO THE HIGHWAY GETTING TO THE DEALERSHIP. DURING THE FIRST VISIT FOR THE STALLING PROBLEM, VW HAD THE DEALER DRAIN MY FULL TANK OF DIESEL AS THEY THOUGHT I USED BAD FUEL AND THIS WAS NOT THE CASE. NEXT THEY REPROGRAMMED THE FUEL INJECTORS AND THAT DID NOT SOLVE THE PROBLEM. SO VW HAD THE DEALER REPLACE A FUEL REGULATOR VALVE AND THAT DID NOT WORK AS WELL. AFTER TWO MORE TIMES OF REPROGRAMMING THE FUEL INJECTORS THE LIGHT APPARENTLY WENT OUT A SO VW OF AMERICA AND THE DEALER FELT IT WAS FIXED AND SAFE FOR US TO DRIVE. I THINK NOT! *TR

NHTSA ODI #10504620

117,936 miles · Mar 20, 2013
Electrical SystemEngineFuel/propulsion System

THE VEHICLE HAD DRIVEN FINE ALL DAY WHEN ALL OF A SUDDEN WHEN I PULLED UP TO A STOP SIGN, THE CAR DIED LIKE IT WAS RUNNING OUT OF GAS. I WAS IN THE MIDDLE OF A THE ROAD AT THE STOP SIGN, THE CAR MANAGED TO START AGAIN AND DRIVE ANOTHER COUPLE HUNDRED FEET TO GET IT OFF TO THE SIDE OF THE ROAD. LUCKILY I MADE IT JUST PAST A SET…

Read full complaint

THE VEHICLE HAD DRIVEN FINE ALL DAY WHEN ALL OF A SUDDEN WHEN I PULLED UP TO A STOP SIGN, THE CAR DIED LIKE IT WAS RUNNING OUT OF GAS. I WAS IN THE MIDDLE OF A THE ROAD AT THE STOP SIGN, THE CAR MANAGED TO START AGAIN AND DRIVE ANOTHER COUPLE HUNDRED FEET TO GET IT OFF TO THE SIDE OF THE ROAD. LUCKILY I MADE IT JUST PAST A SET OF RAIL ROAD TRACKS. THE CAR DID NOT START AGAIN AND HAD TO BE TOWED. THE VEHICLE HAD ITS ENTIRE FUEL INJECTION PUMP SYSTEM REPLACED ALONG WITH THE SENSORS. MECHANICS HAVE TOLD ME THAT THE PUMPS SHOULD LAST THE LIFE OF THE ENGINE. *TR

NHTSA ODI #10503816

43,300 miles · Mar 17, 2013
Engine

BOUGHT TDI FROM ED MARTIN HONDA IN INDIANAPOLIS. DROVE THE CAR HOME. 30 MINUTES LATER, CAR WOULD NOT START. STARTER WOULD CRANK, BUT ENGINE WOULD NOT FIRE. STARTED THE NEXT MORNING WITH NO ISSUES. DROVE TO INDIANAPOLIS, ABOUT 40 MILES. 2 HOURS LATER I WENT TO LEAVE, CAR WOULD NOT START. AFTER 40 MINUTES OF CRANKING OFF AN…

Read full complaint

BOUGHT TDI FROM ED MARTIN HONDA IN INDIANAPOLIS. DROVE THE CAR HOME. 30 MINUTES LATER, CAR WOULD NOT START. STARTER WOULD CRANK, BUT ENGINE WOULD NOT FIRE. STARTED THE NEXT MORNING WITH NO ISSUES. DROVE TO INDIANAPOLIS, ABOUT 40 MILES. 2 HOURS LATER I WENT TO LEAVE, CAR WOULD NOT START. AFTER 40 MINUTES OF CRANKING OFF AND ON, IT FINALLY STARTED. DROVE STRAIGHT HOME. 3RD TIME DROVE TO WALMART, 3 MILE TRIP. CAR TOOK 20 MINUTES TO START. *TR

NHTSA ODI #10503362

500 miles · Mar 11, 2013
EngineFuel System, DieselPower Train

2010 VW JETTA 2.0 TDI CUP EDITION: ENTERING TRAFFIC IN FIRST GEAR, AT ABOUT 4000-4200 RPM, CAR HAD A COMPLETE LOSS OF POWER. ENGINE DID NOT DIE. I PUSHED IN CLUTCH AND POWER RETURNED. THIS HAS OCCURRED MONTHLY WITH NO CONSISTENCY SINCE I PURCHASED THE CAR IN JULY 2010. OCCURS WITH A WARM ENGINE. COLD ENGINE. VARIOUS LEVELS OF…

Read full complaint

2010 VW JETTA 2.0 TDI CUP EDITION: ENTERING TRAFFIC IN FIRST GEAR, AT ABOUT 4000-4200 RPM, CAR HAD A COMPLETE LOSS OF POWER. ENGINE DID NOT DIE. I PUSHED IN CLUTCH AND POWER RETURNED. THIS HAS OCCURRED MONTHLY WITH NO CONSISTENCY SINCE I PURCHASED THE CAR IN JULY 2010. OCCURS WITH A WARM ENGINE. COLD ENGINE. VARIOUS LEVELS OF FUEL, AND VARIOUS CLIMATE CONDITIONS. IT HAS BEEN TAKEN TO O'BRIEN VOLKSWAGEN, A CERTIFIED REPAIR FACILITY, EVERY 3-6 MONTHS TO HAVE THE ISSUE RESOLVED. DEALERSHIP CAN NOT REPLICATE THE ISSUE AND AS A RESULT HAS NOT SOLVED THE PROBLEM. PROBLEM HAS BEEN WITNESSED BY THREE DIFFERENT PASSENGERS. A SECONDARY STALLING ISSUE OCCURS BETWEEN 1200-1800 WITH LIGHT GAS PEDDLE PRESSURE. IN THIS CASE, THE CAR HAS A SMALL PAUSE OR DECREASE IN POWER. DOWN SHIFTING AND ACCELERATING ELIMINATES THE PROBLEM. *TR

NHTSA ODI #10502429

26,195 miles · Mar 4, 2013
Engine

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT HE ATTEMPTED TO START THE IGNITION IN COLD WEATHER BUT THE ENGINE FAILED TO OPERATE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THAT THE ENGINE FROZE AS A RESULT OF ICE ACCUMULATION. THE VEHICLE WAS REPAIRED. THE MANUFA…

Read full complaint

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT HE ATTEMPTED TO START THE IGNITION IN COLD WEATHER BUT THE ENGINE FAILED TO OPERATE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THAT THE ENGINE FROZE AS A RESULT OF ICE ACCUMULATION. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 26,195. UPDATED 5/7/13 *CN THE CONSUMER STATED THE SAFETY CONCERN WAS THE POSSIBILITY OF ICE BREAKING FREE CAUSING THE ENGINE TO SEIZE. *JS

NHTSA ODI #10501239

88,036 miles · Mar 2, 2013
Engine

WHILE DRIVING MY JETTA (DIESEL), THE ENGINE HAS STALLED ON MULTIPLE OCCASIONS. THE FIRST TIME IT HAD STALLED, MY JETTA WAS ONLY 1 MONTH OLD AND I TOOK IT BACK TO THE DEALER. THE DEALER FOUND NOTHING WRONG AND STATED THAT HE HAD NEVER HEARD OF THIS ISSUE OCCURRING. THE JETTA STALLED AGAIN OVER THE SUBSEQUENT 12 MONTHS OF OWNIN…

Read full complaint

WHILE DRIVING MY JETTA (DIESEL), THE ENGINE HAS STALLED ON MULTIPLE OCCASIONS. THE FIRST TIME IT HAD STALLED, MY JETTA WAS ONLY 1 MONTH OLD AND I TOOK IT BACK TO THE DEALER. THE DEALER FOUND NOTHING WRONG AND STATED THAT HE HAD NEVER HEARD OF THIS ISSUE OCCURRING. THE JETTA STALLED AGAIN OVER THE SUBSEQUENT 12 MONTHS OF OWNING IT AND I ONCE AGAIN TOOK IT TO LEE VOLKSWAGEN DEALERSHIP IN FORT WALTON BEACH. THE MAINTENANCE MANAGER STATED NOTHING WRONG. THE JETTA STALLED A 3RD TIME JUST RECENTLY WHILE I WAS MAKING A RIGHT HAND TURN. I HAD CHILDREN IN THE CAR AND I WAS VERY CONCERNED WITH THEIR SAFETY. IN ADDITION TO THE STALLING ISSUE, MY JETTA (OVER THE FIRST 2 YEARS OF OWNING THE CAR) HAS HAD A NEW BATTERY, NEW COMPRESSOR AND NEW INTERIOR LIGHTING MECHANISM INSTALLED. I AM VERY DISGRUNTLED WITH THE REPEATED SAFETY ISSUES ON THIS VEHICLE. THE STALLING MAKES ME UNCERTAIN OF MY SAFETY OR MY CHILDREN'S SAFETY WHILE DRIVING THIS VEHICLE. IT SHOULD BE RECALLED AND MONEY REFUNDED TO THE INDIVIDUALS WHO HAVE PURCHASED THIS MODEL. *TR

NHTSA ODI #10501040

49,746 miles · Feb 15, 2013
Engine

2010 VW JETTA TDI COMMON RAIL ENGINE STALLED WHILE CRUISING AT HIGHWAY SPEED SOUTHBOUND ON I-390 BETWEEN GENESEO AND ROCHESTER, NY. WHEN TWO ATTEMPTS TO RESTART CAR AS NORMAL FAILED, IT WAS TOWED TO DEALER AND REPAIRED BY REPLACING FUEL INJECTORS IN CYLINDERS 2 & 3 ACCORDING TO INJECTOR FAULT CODE THAT WAS GENERATED. VEHICLE…

Read full complaint

2010 VW JETTA TDI COMMON RAIL ENGINE STALLED WHILE CRUISING AT HIGHWAY SPEED SOUTHBOUND ON I-390 BETWEEN GENESEO AND ROCHESTER, NY. WHEN TWO ATTEMPTS TO RESTART CAR AS NORMAL FAILED, IT WAS TOWED TO DEALER AND REPAIRED BY REPLACING FUEL INJECTORS IN CYLINDERS 2 & 3 ACCORDING TO INJECTOR FAULT CODE THAT WAS GENERATED. VEHICLE WAS RETURNED TO ME, THEN EXHIBITED SAME SYSTEMS AGAIN. TOWED BACK TO DEALER WHEREUPON DISCUSSION WITH VW TECH LINE HAD DEALER REPLACE TURBO INTERCOOLER, POSSIBLY DUE TO EXTREME CONDENSATION AND ICE BUILD UP IN THE INTERCOOLER REFERENCED BY VW TSB # 21 12 01/2025464 FROZEN AIR CHARGE COOLER. AFTER INTERCOOLER REPLACEMENT, DEALER NOTIFIED ME THAT THE CAR IS STILL EXHIBITING THE SAME SYMPTOMS. DISCUSSIONS WITH VW TECH LINE RESULTED IN NOTIFICATION TO ME THAT THE ENGINE WIRING HARNESS SEEMS TO BE THE PROBLEM AND ADVISES REPLACEMENT OF THAT FOR $988 INCLUDING PARTS AND LABOR. HYDROLOCK AND CATASTROPHIC ENGINE DAMAGE DUE TO EXCESSIVE CONDENSATION FROM EMISSIONS SYSTEM DESIGN SEEMS TO BE THE MORE LOGICAL EXPLANATION, ESPECIALLY WITH THE 112 AND 234 PAGES RESPECTIVELY OF POSTS OF PEOPLE WITH THE SAME COMPLAINTS ON THESE WELL KNOWN FORUMS: HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?5574701-TDI-INTERCOOLER-ISSUE-DESIGN-FLAW&P=75723976&VIEWFULL=1#POST75723976 HTTP://FORUMS.TDICLUB.COM/SHOWTHREAD.PHP?T=302863. *TR

NHTSA ODI #10498271

Official recalls

4

16V913000 · Electronic Stability Control (esc); Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Dec 20, 2016

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence & remedy

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Additional source detail variants (2)

Electronic Stability Control (esc)

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2010 Volkswagen Jetta A5 Sedan, 2009 Volkswagen Jetta SportWagen, Eos, GTI, Rabbit and Audi A3 vehicles, and 2010 Volkswagen Golf A6 vehicles. The Antilock Brake System (ABS) control unit may fail during ABS or Electronic Stability Control (ESC) activation, possibly causing a loss of vehicle control.

Consequence: A loss of vehicle control can increase the risk of a crash.

Remedy: Volkswagen will notify owners, and dealers will update the ABS control module software to improve the module's self-testing abilities. Any module that fails the new diagnostic test will be replaced. These repairs will be made free of charge. The recall began February 2017. Owners may contact Volkswagen customer service at 1-800-893-5298.

11V490000 · Fuel System, Diesel

Oct 3, 2011

VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Consequence & remedy

Consequence: DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Remedy: VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

10V621000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Dec 10, 2010

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2006-2010 JETTA, NEW BEETLE, NEW BEETLE CONVERTIBLE, MODEL YEAR 2009 JETTA SPORTWAGEN AND MODEL YEAR 2007-2009 RABBIT VEHICLES EQUIPPED WITH 2.5L ENGINES. THE JETTA, JETTA SPORTWAGEN, AND RABBIT VEHICLES MAY HAVE A SMALL PLASTIC TAB LOCATED ON THE WINDSHIELD WASHER FLUID RESERVOIR THAT MAY CHAFE AGAINST AN UNDERHOOD FUEL SUPPLY LINE. THE NEW BEETLE AND THE NEW BEETLE CONVERTIBLE VEHICLES MAY HAVE A FASTENING CLAMP ON A HYDRAULIC HOSE OF THE POWER STEERING SYSTEM THAT MAY BE LOCATED IN AN IMPROPER POSITION WHICH COULD CAUSE CHAFING AGAINST AN UNDERHOOD FUEL SUPPLY LINE.

Consequence & remedy

Consequence: IF CHAFING OCCURS, THERE IS THE POTENTIAL FOR A FUEL LEAK TO DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSPECT AND IF NECESSARY REPLACE THE UNDERHOOD FUEL LINE. ADDITIONALLY, DEPENDING ON THE VEHICLE MODEL, DEALERS WILL EITHER REMOVE THE PLASTIC TAB FROM THE WINDSHIELD WASHER FLUID RESERVOIR, OR INSPECT THE POSITION OF THE FASTENING CLAMP AND ADJUST THE RELATED FASTENING CLAMP INTO THE CORRECT POSITION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE JANUARY 31, 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

09V333000 · Power Train:automatic Transmission

Aug 20, 2009

VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 PASSENGER CARS MANUFACTURED BETWEEN SEPTEMBER 2008 AND AUGUST 2009. THE WIRING HARNESS OF A TEMPERATURE SENSOR IN THE DIRECT SHIFT GEARBOX (DSG) MAY HAVE CONNECTOR WIRES THAT WERE INSUFFICIENTLY CRIMPED. WITH INSUFFICIENTLY CRIMPED CONNECTOR WIRES, A TEMPERATURE SENSOR HAS THE POTENTIAL TO FALSELY DETECT A HIGH GEARBOX OIL TEMPERATURE, CAUSING THE TRANSMISSION TO ABRUPTLY SHIFT TO NEUTRAL. IF THIS HAPPENS, THE SELECTOR LEVER POSITION INDICATOR WITHIN THE INSTRUMENT PANEL WILL FLASH. IN ADDITION, THE "DEPRESS BRAKE PEDAL" INDICATOR LIGHT WILL BE ILLUMINATED, ALERTING THE DRIVER TO APPLY THE BRAKES.

Consequence & remedy

Consequence: THE ABRUPT SHIFT TO NEUTRAL COULD LEAD TO A CRASH WITHOUT WARNING.

Remedy: VOLKSWAGEN WILL REPROGRAM THE TRANSMISSION CONTROL MODULE WITH UPDATED SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 20, 2009. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

EA18003 · Air Bag Clockspring Failure

Opened Apr 18, 2018 · No close date supplied

Status: open (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Additional source detail variants (3)

Air Bags:frontal:driver Clockspring/spiral Cassette

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags:frontal

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

Air Bags

In August 2015, Volkswagen Group of America, Inc. (Volkswagen) launched Safety Recall 15V-483 to address the loss of the protection provided by the front driver air bag in several models due to the failure of the clockspring.Debris entry into the steering wheel hub can result in contamination and ultimately failure of the clockspring in 2010-2014 Model Year (MY) CC, Passat, Eos, Golf, GTI, Tiguan, Jetta and Jetta Sportwagen models.Contamination of the clockspring can cause the ribbon cable to tear resulting in loss of the electrical connection to the front driver air bag and any steering wheel mounted controls.The loss of the electrical connection to the front driver air bag will result in illumination of the air bag warning light and will prevent operation of the front driver air bag in a crash of sufficient severity requiring a commanded deployment.In November 2017, the Office of Defects Investigation (ODI) opened a Recall Query (RQ17-009) after the agency received 90 complaints alleging failure of the clockspring in the subject models.Several of the complaints allege failure of the clockspring after receiving the recall remedy.The majority of the complaints allege the same failure mode without being included in the original recall, 15V-483.In its March 2018 response to ODI's Information Request under the Recall Query, Volkswagen provided approximately 700 consumer complaints and field reports on the recalled vehicles.These reports allege clockspring failure similar to the NHTSA reports described above.To date, NHTSA has received approximately 154 allegations of clockspring failure since the recall has launched.The total of 852 reports shown in the table above eliminates 6 duplicative reports received by ODI and the manufacturer.An Engineering Analysis has been opened to further evaluate the scope and effectiveness of the remedy associated with 15V-483 and perform a thorough review of the design changes implemented by Volkswagen and its suppliers to address this issue.The ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers: 11080741, 11079877, 11079805, 11079124, 11076709, 11076645, 11076297, 11076249, 11076133, 11075756, 11075726, 11075358, 11075259, 11075055, 11074920, 11074565, 11073090, 11072745, 11072457, 11072089, 11071933, 11071880, 11071630, 11071592, 11067396, 11067061, 11066738, 11066601, 11066511, 11065909, 11065871, 11065262, 11064701, 11064564, 11064544, 11064531, 11063961, 11063501, 11063095, 11062772, 11062464, 11062353, 11062344, 11061463, 11061310, 11061311, 11060735, 11058154, 11057519, 11057477, 11057341, 11056793, 11056243, 11056063, 11055639, 11054279, 11052812, 11052678, 11052384, 11052228, 11051336, 11051155, 11051074, 11048803, 11047037, 11044226, 11043653, 11039142, 11033893, 11033330, 11032548, 11025475, 11025356, 11024647, 11023423, 11020570, 11020312, 11019415, 11019067, 11015441, 11015431, 11014595, 11014016, 11013709, 11013415, 11012596, 11011753, 11006668, 11006521, 11006307, 11006181, 11005301, 11003865, 11001780, 11001783, 11001334, 10994184, 10993360, 10993524, 10992490, 10985926, 10983678, 10981220, 10980831, 10980941, 10980549, 10979418, 10971152, 10967344, 10967155, 10959968, 10958624, 10957279, 10956488, 10949129, 10947562, 10945122, 10936498, 10936543, 10933950, 10927311, 10925421, 10924034, 10915612, 10915569, 10911171, 10902066, 10898733, 10896537, 10896510, 10895526, 10893938, 10891686, 10864967, 10863742, 10861984, 10851242, 10822505, 10821562, 10818403, 10795068, 10794402, 10788738, 10787804, 10782544, 10780725, 10780145, 10779145, 10776477, 10775448, 10763492, 10763423, 10763289, 10762670, 10760644, 10758777, 10749901, 10748922

PE11023 · Diesel Fuel Injector Line Leakage

Opened Aug 2, 2011 · Closed Dec 2, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

By letter dated October 3, 2011, Volkswagen Group of America, Inc. (VW) notified the National Highway Traffic Safety Administration (NHTSA) that it will conduct a safety recall to address a defect in approximately 168,275 model year (MY) 2009-2012 Volkswagen Jetta, Jetta Sportwagen, Golf, and Audi A3 vehicles equipped with the 2.0L TDI Common Rail Clean Diesel engine (NHTSA Recall No. 11V-490).The recalled Jetta and Jetta Sportwagen vehicles were built from May 2008 through September 2011, the Golf vehicles were built from May 2009 through September 2011, and the Audi A3 vehicles were built from September 2009 through September 2011.According to Volkswagen, in U.S. applications of the above cited TDI vehicles including engine codes CJAA and CBEA, the fuel injection pulses could coincide with the natural frequency of the injector line #2 in specific load and RPM conditions.This resonance creates additional stress on the fuel line which a small number of parts (based on the statistic spread of line strength) cannot withstand over its lifetime.As a contributing factor, VW indicated that a supplier used tube material with scratch marks from a grinding process during certain production periods.Lines manufactured in these periods were installed in vehicles produced in the following 10 months:December 2008, January-February 2009, October 2009, March-April 2010 and September-December 2010.Injector lines using this material exhibit a significantly higher failure rate.Dealers will replace injector line #2 in all vehicles built in these months.In addition, as a precautionary measure, all recalled vehicles will have vibration dampers installed on all four fuel injector lines.Analysis of NHTSA complaints, VW complaints, VW field reports and warranty claims found allegations of injector line leakage in 443 subject vehicles.The leaking line was not identified in 62 of the vehicles.For the 381 that did provide information about which injector lines were leaking and/or replaced, 358 (94%) involved an injector line #2 leak/repair.Almost three-quarters of the injector line #2 leak/repair incident vehicles were built in the 10 months identified by VW, which accounted for approximately one-quarter of the recalled vehicles.The failure rate for injector line #2 in vehicles built in the 10 months affected by the supplier line scratching issue is 6.0 incidents per thousand vehicles (IPTV).The failure rate for injector line #2 in other production months of recalled vehicles is 0.8 IPTV.The leak/repair rates for the other injector lines are all well under 1 IPTV.The action taken by Volkswagen is sufficient to resolve the issues raised by this investigation. The agency will continue to monitor this issue and reserves the right to take further action if warranted by the circumstances. Accordingly, this investigation is closed.

EA11003 · High-Pressure Fuel Pump Failure

Opened Feb 7, 2011 · Closed Mar 27, 2015

Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Additional source detail variants (2)

Fuel System, Diesel

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

Fuel System, Other:delivery:fuel Pump

The Office of Defects Investgation (ODI) opened EA11-003 on February 7, 2011, based on 160 complaints to ODI and Volkswagen involving high pressure fuel pump (HPFP) failures in model year (MY) 2009 through 2010 Volkswagen Jetta and Golf and Audi A3 TDI vehicles and questions regarding fuel sample results provided by Volkswagen as part of its response to PE10-034.During EA11-003, ODI analyzed design information, field experience and test data for MY 2009 through 2012 Volkswagen Jetta, Golf and Touareg and Audi A3 and Q7 vehicles equipped with TDI engines. Volkswagen has not identified any design or manufacturing defects in the subject TDI Clean Diesel pumps and has stated that the subject pumps were designed, tested and approved for use in the United States market, with substantial design margins for fuels that are out of specification.Volkswagen believes that misfueling with gasoline is the primary cause of HPFP drivetrain failures in the field.Only the Q7 vehicles were built with misfuel protection devices.In May 2013 Volkswagen initiated a service campaign to install misfuel protection devices in all MY 2009 through 2012 Jetta, Golf and A3 vehicles.Volkswagen implemented misfuel protection devices in all of the subject models beginning in MY 2013. ODI?s analysis of HPFP drivetrain failure incidents indicates that most failures do not result in engine stall while driving and, when pump drivetrain failure does result in stall while driving, it is usually preceded by numerous warning symptoms (e.g., glow plug warning lamp, chime, limp mode, and driveability symptoms).The failure data for the subject vehicles show relatively low stalling rates (less than one percent at three years in service) for each of the pump designs used in the subject vehicles.There have been no reports of crashes, injuries or fatalities related to the alleged defect. Based on these facts, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted.For additional information, see the closing report in the document file for EA11-003.

PE10034 · High Pressure Fuel Pump Failure (hpfp)

Opened Aug 26, 2010 · Closed Feb 8, 2011

Status: closed (inferred from source dates) · Fuel System, Diesel

The Office of Defects Investigation (ODI) and Volkswagen (VW) have received a total of 160 complaints and field reports alleging incidents of engine stall and/or loss of power that appear to be related to high pressure fuel pump (HPFP) failures in certain model year (MY) 2009 through 2010 Volkswagen Jetta and MY 2010 Volkswagen Golf and Audi A3 vehicles equipped with TDI clean diesel engines.Approximately half of the reports indicate that the failure resulted in an engine stall incident, with many of these alleging stall incidents at highway speeds in traffic with no restart.There has been one minor crash alleged to have resulted from HPFP failure in the subject vehicles.In response to ODI's information request for PE10-034, VW indicated that it had found no defect related to motor vehicle safety with relation to the TDI Clean Diesel fuel system at issue in this investigation and attributed problems with HPFP failure to operation with gasoline contaminated diesel fuel.Volkswagen stated that even a small amount of gasoline in the diesel fuel may disrupt the necessary lubrication required and may cause the HPFP to fail.In response to concerns that fuel contamination was the major cause of HPFP and related fuel system failures, VW issued a Technical Service Bulletin in May 2010 (VW TB V011011 2023624 and Audi TB A011008 2023360-1), with instructions to inspect the diesel fuel for vehicles requiring fuel system service that have symptoms associated with HPFP failure.The bulletin states that fuel system damage incurred by use of fuel not complying to ASTM-D-975 Grade 2 S15 (B5 or less biodiesel content) standards will not be covered under warranty. Volkswagen also provided information about 121 mis-fueling incidents reportedly acknowledged by consumers or dealers and test results for about 50 diesel fuel samples taken from complaint vehicles in late-August through early-October 2010.The mis-fueling incidents include about 20 reports involving incorrect fueling by dealer sales or service personnel and generally report symptoms such as rough running, stalling and/or no start within a few miles of refueling the vehicle with gasoline.Volkswagen indicated that the testing of fuel samples from complaint vehicles found that nearly 90 percent contained high amounts of gasoline.Volkswagen implemented design changes for the HPFP in May 2008, September 2009 and November 2010 to improve the robustness of the pump when used with poor quality fuel.ODI analysis of HPFP failures identified from all sources shows failure rates of 0.53% for MY 2009 vehicles and 0.11% for MY 2010 vehicles.This investigation has been upgraded to an Engineering Analysis (EA11-003) to continue to investigate the issues with mis-fueling and HPFP design identified during the Preliminary Evaluation.