IllustrationCHECK ENGINE LIGHT ON INCESSANTLY SINCE ORIGINAL ACQUISITION. REPAIRS EFFECTUATED AT LEAST THREE TIMES UNDER WARRANTY AND ISSUE HAS RETURNED. WHEN PARKED AFTER LONG PERIOD OF TIME A LOW BUBBLING/GURGLING AND FIZZLING SOUNDS COMES FROM THE UNDERSIDE OF THE CAR. *JB
2002 Volkswagen Jetta
Owner reports · Recalls · Investigations
More warning signs than most Jetta years
Owner complaints for the 2002 Volkswagen Jetta are substantially higher than the model-year median of 68.
About this comparison →How this year compares
Owner complaints by model year
Compare all Jetta years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1150–25K
11125–50K
9550–75K
8075–100K
63100–150K
23150K+
487 reports with mileage · 215 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 148 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 108 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 104 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
31 crash reports71 fire reports69 injury reports
What owners actually said
702 reportsI PURCHASED A 2002 VOLKSWAGEN JETTA FOR MY DAUGHTER. IN AUGUST OF 2006 THE CAR WAS TAKEN TO A VW DEALERSHIP FOR TRANSMISSION SERVICE. IN MAY OF 2007 THE TRANSMISSION LIGHT CAME ON AND THE CAR KEPT LOSING POWER WHEN DRIVING. WHEN PUT IN GEAR THE CAR WOULD SHAKE AND SHUT DOWN. I HAD IT TOWED TO THE VW DEALERSHIP FOR REPAIR. THEY R…
Read full complaint
I PURCHASED A 2002 VOLKSWAGEN JETTA FOR MY DAUGHTER. IN AUGUST OF 2006 THE CAR WAS TAKEN TO A VW DEALERSHIP FOR TRANSMISSION SERVICE. IN MAY OF 2007 THE TRANSMISSION LIGHT CAME ON AND THE CAR KEPT LOSING POWER WHEN DRIVING. WHEN PUT IN GEAR THE CAR WOULD SHAKE AND SHUT DOWN. I HAD IT TOWED TO THE VW DEALERSHIP FOR REPAIR. THEY REPLACED A SEAL, TEMP SENDER AND SENDER FOR A TOTAL OF 427.62. MY DAUGHTER PICKED UP THE CAR AND WHEN DRIVING HOME FROM THE DEALERSHIP AFTER THEY REPAIRED IT THE CAR SHUTTERED, THEN SLAMMED DOWN INTO A LOWER GEAR ALMOST CAUSING HER TO LOSE CONTROL OF THE VEHICLE. I CALLED THE DEALER AND THEY APPROVED HAVING IT TOWED BACK TO THEIR FACILITY FOR REPAIR. THEY THEN CHECKED THE CAR AGAIN AND STATED THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED FOR A COST OF $3800.00. THIS CAR HAS 57,000 MILES ON IT AND WHEN ORIGINALLY TAKEN TO THE DEALERSHIP FOR THIS ISSUE IT WAS 4 DAYS OUT OF WARRANTY. NOTE: WHEN THE CAR INITIALLY BROKE DOWN IT WAS STILL IN WARRANTY BUT I WAS OUT OF TOWN FOR WORK AND COULD NOT SET UP HAVING IT TOWED IN UNTIL I RETURNED HOME. THE DEALERSHIP WAS CALLED REGARDING THIS ISSUE PRIOR TO THE WARRANTY EXPIRATION. I CALLED THE DEALERSHIP AND VW CORPORATE HEADQUARTERS. THEY STATED THERE WAS NOTHING THEY COULD DO TO ASSIST IN THIS REPAIR. THE VW DEALERSHIP STATED THAT THEY DID NOT SEE A PROBLEM WITH THE TRANSMISSION WHEN THEY FIRST COMPLETED REPAIRS BUT SHE DID NOT EVEN GET 10 MILES FROM THE DEALERSHIP BEFORE THE CAR SLAMMED DOWN INTO A LOW GEAR. *TR
I OWN A 2002 1.8T AUTOMATIC JETTA WITH 75000 MILES. YESTERDAY I WAS TOLD IT NEEDED A NEW TRANSMISSION. I USE THIS CAR FOR BASIC TRANSPORTATION, AND HAVE MAINTAINED REGULAR UPKEEP. I AM APPALLED THAT I HAVE TO SPEND $5,000 TO FIX A FAULTY TRANSMISSION. I HAVE BEEN DOING RESEARCH AND IT SEEMS THAT A LOT OF JETTAS HAVE THIS PROBLE…
Read full complaint
I OWN A 2002 1.8T AUTOMATIC JETTA WITH 75000 MILES. YESTERDAY I WAS TOLD IT NEEDED A NEW TRANSMISSION. I USE THIS CAR FOR BASIC TRANSPORTATION, AND HAVE MAINTAINED REGULAR UPKEEP. I AM APPALLED THAT I HAVE TO SPEND $5,000 TO FIX A FAULTY TRANSMISSION. I HAVE BEEN DOING RESEARCH AND IT SEEMS THAT A LOT OF JETTAS HAVE THIS PROBLEM, ESPECIALLY THE TURBOS. HOW CAN VOLKSWAGEN GET AWAY WITH THIS? I WOULD LIKE TO START A CLASS ACTION SUIT. SOMETHING NEEDS TO BE DONE TO CORRECT THIS MATTER!. *AK
I OWN A 2002 JETTA 1.8T AND STARTED HAVING SOME INTERMITTENT PROBLEMS WITH SHIFTING FROM PARK INTO REVERSE OR 1ST AND 2ND GEARS, PAUSING OR JERKING INTO GEAR. THE PROBLEM STARTED A COUPLE MONTHS AGO WHEN THE CAR HAD ABOUT 52,000 MILES ON IT AND WAS OUT OF WARRANTY BY ABOUT 5 MONTHS. THE PROBLEM BECAME INCREASINGLY FREQUENT AND…
Read full complaint
I OWN A 2002 JETTA 1.8T AND STARTED HAVING SOME INTERMITTENT PROBLEMS WITH SHIFTING FROM PARK INTO REVERSE OR 1ST AND 2ND GEARS, PAUSING OR JERKING INTO GEAR. THE PROBLEM STARTED A COUPLE MONTHS AGO WHEN THE CAR HAD ABOUT 52,000 MILES ON IT AND WAS OUT OF WARRANTY BY ABOUT 5 MONTHS. THE PROBLEM BECAME INCREASINGLY FREQUENT AND I TOOK IT TO THE DEALER YESTERDAY AND WAS TOLD THAT I NEED A WHOLE NEW TRANSMISSION. THEY SAID THE TRANSMISSION FLUID BUNT AND HA DEBRIS IN IT". I HAVE ALWAYS DONE THE SCHEDULED MAINTENANCE ON THE VEHICLE , AT THE DEALERSHIP, NO LESS, AND HAVE NEVER ABUSED THE TRANSMISSION IN ANY WAY. THE CAR ONLY HAS 54,000 MILES ON IT! THE SERVICE REPRESENTATIVE AT THE DEALERSHIP CALLED VOLKSWAGEN AND STATED HE REALLY WENT TO BAT FOR ME ,AND THAT VOLKSWSGEN HAS AGREED TO COVER 65% OF THE REPAIR, WHICH IN THE RANGE OF $5,000+. SO I WILL STILL BE PAYING AT LEAST $1750.00 TO REPLACE A FAIRLY YOUNG TRANSMISSION. I FEEL VW MUST KNOW THERE IS A DEFECT IN THE TRANSMISSION TO EVEN OFFER TO PAY FOR PART OF THE REPAIR, AND JUDGING BY THE OTHER COMPLAINTS THIS IS A SERIOUS PROBLEM. I HAVE BEEN READING OTHER COMPLAINTS AND IT SEEMED THAT THE TRANSMISSION WAS PAINTED WITH A METALLIC PAINT THAT DISINTEGRATED WITH HIGH HEAT/TEMPERATURES AND THAT IT BROKE DOWN, FLAKES OFF AND DAMAGED THE TRANSMISSION. THIS HAS TO BE A MANUFACTURER'S DEFECT. *AK
2002 JETTA ROOF LEAKS WATER WHEN HEAVY RAIN. RESEARCH SHOWS THAT MAY PEOPLE ARE HAVING THE SAME ISSUE. *TR
PURCHASED USED 2002 VW JETTA 1.8 TURBO (5 SPEED) WITH 34,000 MILES STILL UNDER WARRANTY. TAKEN TO DEALERSHIP FOR BLOWN FUSES (CIGARETTE LIGHTER), TRUNK LATCH, CENTER CONSOLE, AND TRANSMISSION REPAIRS. FUSE PROBLEM WAS ONGOING. WITHIN A FEW MONTHS, A LOCAL MECHANIC INSTALLED A SMALL BOOST GAUGE ON THE DASH, WHICH WAS WIRED IN…
Read full complaint
PURCHASED USED 2002 VW JETTA 1.8 TURBO (5 SPEED) WITH 34,000 MILES STILL UNDER WARRANTY. TAKEN TO DEALERSHIP FOR BLOWN FUSES (CIGARETTE LIGHTER), TRUNK LATCH, CENTER CONSOLE, AND TRANSMISSION REPAIRS. FUSE PROBLEM WAS ONGOING. WITHIN A FEW MONTHS, A LOCAL MECHANIC INSTALLED A SMALL BOOST GAUGE ON THE DASH, WHICH WAS WIRED INTO A 10 AMP FUSE. WITHIN FIVE DAYS, THE CAR WAS BEING BACKED OUT OF THE DRIVEWAY WHEN SMOKE BEGAN POURING FROM ALL THE DASH VENTS. THE WIRE HARNESS, FUSE BLOCK, AND CONTROLLER COMPONENTS LOCATED BEHIND THE DASH WERE DESTROYED BY FIRE. VW OF AMERICA PREPARED TO SEND INVESTIGATORS TO NM, BUT WHEN THEY DISCOVERED GAUGE WIRING MAY HAVE CONTRIBUTED, THEY DID NOT INVESTIGATE. HAVE READ OF OTHER ELECTRICAL FIRES BEHIND INSTRUMENT PANEL, DASH, SINCE THIS TIME. OUR SON WAS DRIVING THE CAR AT THE TIME OF THE FIRE, BUT WAS ABLE TO GET OUT. *TR
TRANSMISSION PROBLEMS. CAR SPUTTERS AND JUMPS. DEALER FIRST WORKED ON THE GEAR SHIFT. THEN THEY REPLACED SPARK PLUGS AND THE BATTERY TO TRY TO FIX THE PROBLEM. RECENTLY SAID THERE WAS A LEAK AND REPLACED THE CRANKCASE VENT PIPES. STILL HAVE THE SAME PROBLEM. *TR
2002 JETTA WITH A SAFETY RECALL- REPLACED BRAKE LIGHT SWITCH CUSTOMER STATES THAT THE DEALERSHIP REFUSED TO FIXED THE RECALL**CC THE VW SERVICE CENTER AND CUSTOMER CARE INFORMED THE CONSUMER THE VEHICLE WAS OUT OF WARRANTY AND THEY HAD NO OBLIGATIONS TO PAY FOR TOWING OR ANY OTHER COST ASSOCIATED WITH THE VEHICLE, INCLUDING TH…
Read full complaint
2002 JETTA WITH A SAFETY RECALL- REPLACED BRAKE LIGHT SWITCH CUSTOMER STATES THAT THE DEALERSHIP REFUSED TO FIXED THE RECALL**CC THE VW SERVICE CENTER AND CUSTOMER CARE INFORMED THE CONSUMER THE VEHICLE WAS OUT OF WARRANTY AND THEY HAD NO OBLIGATIONS TO PAY FOR TOWING OR ANY OTHER COST ASSOCIATED WITH THE VEHICLE, INCLUDING THE LAST RECALL REGARDING THE BRAKE LIGHT SWITCH THAT THE CONSUMER HAS REPLACED ON 3 SEPARATE OCCASIONS. THE CONSUMERS DAUGHTER HAD EXPERIENCED THE VEHICLE LOCKING UP AS A RESULT OF THE DEFECTIVE BRAKE SWITCH. THE INSTRUMENT PANEL FAILED AND THE CONSUMERS DAUGHTER WAS UNABLE TO READ THE PANEL. THE CONSUMER STATED IN THE PAST, THE TRUNK LATCH FAILED AS WELL AS A BROKEN BOLT ON THE TRANSMISSION, THE DRIVERS SIDE SEAT BELT AND THE EGR ALL HAD TO BE REPLACED. THE DOOR LATCH FAILED BECAUSE THE LOCK SIGNAL WAS NOT WORKING. *JB THE CONSUMER STATED THAT HE RECEIVED A RECALL FOR HIS DAUGHTER'S VEHICLE, THIS IS THE 3RD BRAKE SWITCH NOT TO MENTION OVER $800 IN UNWARRANTED CHARGES FROM THE DEALERSHIP. THE CONSUMER STATED HE WAS HOPING THAT THIS CLASSIFIES THE VEHICLE AS A LEMON. THE CONSUMER STATED WOULD LIKE DEALERSHIP TO REVIEW THE OVER CHARGES OR BUYING THE VEHICLE BACK. *TR
HEADLIGHT LENS BECOME VERY MILKY. LIGHT WILL NOT SHINE ON ROAD. CAN'T SEE THE ROAD OR OTHER CARS. CAN CAUSE DAMAGE AND DEATH TO OTHERS. VOLKSWAGEN SHOULD MAKE THEM LASTS LONGER AND REPLACE ALL MILKY HEADLIGHS WITH NEW ONES. ALL 1999-2005 JETTAS 1998-2005 PASSATS HAVE THIS PROBLEM. GO TO ANY VOLKSWAGEN DEALER AND YOU WILL SE…
Read full complaint
HEADLIGHT LENS BECOME VERY MILKY. LIGHT WILL NOT SHINE ON ROAD. CAN'T SEE THE ROAD OR OTHER CARS. CAN CAUSE DAMAGE AND DEATH TO OTHERS. VOLKSWAGEN SHOULD MAKE THEM LASTS LONGER AND REPLACE ALL MILKY HEADLIGHS WITH NEW ONES. ALL 1999-2005 JETTAS 1998-2005 PASSATS HAVE THIS PROBLEM. GO TO ANY VOLKSWAGEN DEALER AND YOU WILL SEE THE PROBLEM.
CAR STALLED WITHOUT WARNING. USUALLY HAPPENED WHEN SLOWING DOWN FOR A STOP OR WHILE AT A STOP. SOMETIMES STALLED WHEN STARTING UP FROM A STOP. THIS WAS VERY DANGEROUS AS CAR STALLED AND CARS BEHIND WERE BEGINNING TO SPEED UP OR WHEN TRYING TO CROSS A BUSY ROAD AND MAKING A LEFT TURN. I HAD ABOUT $1000 OF SERVICE AT THE LOC…
Read full complaint
CAR STALLED WITHOUT WARNING. USUALLY HAPPENED WHEN SLOWING DOWN FOR A STOP OR WHILE AT A STOP. SOMETIMES STALLED WHEN STARTING UP FROM A STOP. THIS WAS VERY DANGEROUS AS CAR STALLED AND CARS BEHIND WERE BEGINNING TO SPEED UP OR WHEN TRYING TO CROSS A BUSY ROAD AND MAKING A LEFT TURN. I HAD ABOUT $1000 OF SERVICE AT THE LOCAL VOLKSWAGEN DEALER IN THE PAST 6 MONTHS. *AK
Official recalls
507V063000 · Exterior Lighting:brake Lights:switch
Feb 20, 2007
ON CERTAIN PASSENGER, WAGON, AND CONVERTIBLE VEHICLES EQUIPPED WITH OR WITHOUT CRUISE CONTROL, A BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON APRIL 27, 2007, AND WILL BE CONDUCTED IN SEVERAL STAGGERED MAILINGS THROUGH SEPTEMBER 21, 2007. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
06V183000 · Exterior Lighting:brake Lights:switch
May 24, 2006
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC OR MANUAL TRANSMISSIONS AND CRUISE CONTROLS, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING SAFETY RECALLS 03V-265 OR 04V-096.
Consequence & remedy
Consequence: THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR REMAIN ON. FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL THE NEWLY DESIGNED BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 27, 2006. VEHICLES WITHIN THE MAKE, MODEL, AND MODEL YEAR OF THIS POPULATION MAY BE INVOLVED IN EITHER THIS RECALL OR 06V-183, BUT NOT BOTH. THE REMEDY IS THE SAME FOR EACH RECALL. VOLKSWAGEN DEALERS WILL APPLY THE REMEDY BASED ON THE VIN NUMBER OF THE VEHICLE. OWNERS MAY CONTACT VW AT 1-800-822-8987.
04V584000 · Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 16, 2004
ON CERTAIN PASSENGER VEHICLES, THE HAZARD SWITCH AND FLASHER SYSTEM FUNCTION MAY DEGRADE OVER TIME BECAUSE OF DISTORTION AND MATERIAL TRANSFER OF THE CONTACTS OF CERTAIN HAZARD SWITCH RELAYS WHICH OCCURS DUE TO SUBSTANTIALLY INCREASED ELECTRICAL CURRENT LOAD FROM HIGHER WATTAGE TURN SIGNAL BULBS.
Consequence & remedy
Consequence: THIS MAY RESULT IN INTERMITTENT OR INOPERATIVE TURN SIGNAL AND HAZARD FLASHER FUNCTION.
Remedy: DEALERS WILL REPLACE THE HAZARD FLASHER SWITCH/RELAY KIT. THE RECALL BEGAN ON MARCH 31, 2005. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
04V096000 · Exterior Lighting:brake Lights:switch
Feb 20, 2004
ON CERTAIN PASSENGER VEHICLES, A BRAKE LIGHT SWITCH ON THESE VEHICLES MAY MALFUNCTION.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE BRAKE LIGHTS COULD BECOME INOPERATIVE, OR COME ON AND STAY ON, EVEN THOUGH THE VEHICLE IS PARKED.
Remedy: THIS RECALL HAS BEEN SUPERCEDED BY 06V-183. OWNERS WHO HAVE HAD A REMEDY PERFORMED UNDER THIS RECALL SHOULD RETURN TO THEIR DEALER FOR THE REDESIGNED REMEDY. OWNERS SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
02V031000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Jan 31, 2002
ON SOME PASSENGER VEHICLES, SHORT CIRCUITS CAN OCCUR WITHIN THE ELECTRONIC CONTROL UNIT OF THE ANTI-LOCK BRAKING SYSTEM (ABS).
Consequence & remedy
Consequence: THIS CAN RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE ABS CONTROL UNIT. OWNER NOTIFICATION BEGAN MARCH 8, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLKSWAGEN AT 1-800-822-8987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7RQ06004 · Brake Light Switch Failure
Opened Feb 28, 2006 · Closed Aug 7, 2006
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:brake Lights:switch
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:brake Lights
BY LETTERS DATED MAY 24, 2006 AND AUGUST 4, 2006, VOLKSWAGEN (VW) NOTIFIED THE AGENCY THAT IT IS CONDUCTING A SAFETY RECALL (NHTSA RECALL NO 06V-183) INVOLVING MODEL YEAR (MY) 1998-2002 VOLKSWAGEN NEW BEETLE AND 1999-2002 VOLKSWAGEN JETTA VEHICLES EQUIPPED WITH CRUISE CONTROL.VOLKSWAGEN?S RECALL COVERS 646,246 VEHICLES.PREVIOUSLY, VW RECALLED THESE VEHICLES TO REPLACE A DEFECTIVE BRAKE LIGHT SWITCH (RECALLS 03V-265 AND 04V-096) THAT WAS UNIQUE TO VEHICLES WITH CRUISE CONTROL.VOLKSWAGEN REPORTS THAT THE BRAKE LIGHT SWITCH MAY MALFUNCTION IF IT WAS INSTALLED INCORRECTLY DURING RECALLS 03V-265 AND 04V-096.VOLKSWAGEN WILL INSTALL A NEW DESIGN BRAKE LIGHT SWITCH.BASED ON VOLKSWAGEN'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
DP05004 · Engine Stalling
Opened Aug 11, 2005 · Closed Dec 8, 2005
Status: closed (inferred from source dates) · Electrical System:ignition:module
BY LETTER RECEIVED ON JUNE 24, 2005, MR. RONALD M. STRICKLAND OF RALEIGH, NC, SUBMITTED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE THE PERFORMANCE OF THE IGNITION COIL PLUGS ON MODEL YEAR (MY) 2000-2003 VOLKSWAGEN JETTA, GOLF AND PASSAT SEDANS.THE PETITIONER ALLEGES THAT HE HAD EXPERIENCED MULTIPLE STALLING EVENTS AS A RESULT OF ONE OR MORE IGNITION COIL PLUGS MALFUNCTIONING ON HIS 2002 VW JETTA SEDAN.AS A RESULT OF THE ENGINE STALLING, THE PETITIONER EXPERIENCED A LOSS OF POWER STEERING AND INCREASED BRAKING EFFORTS WHEN HE PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD TO CONTROL THE VEHICLE.AFTER A FEW MINUTES PARKED ON THE SHOULDER HE WAS ABLE TO RESTART THE VEHICLE ALTHOUGH THE ENGINE OPERATED AT REDUCED POWER.VW ISSUED A CUSTOMER SATISFACTION CAMPAIGN (CSC) ON JANUARY 31, 2003 TO INSTRUCT THEIR DEALERSHIPS TO INSPECT THE VEHICLES FOR ANY MALFUNCTIONING IGNITION COIL PACKS AND TO REPLACE THEM AT NO COST TO THE CONSUMER.CONSUMERS WERE NOTIFIED TO BRING THEIR VEHICLES TO THEIR DEALERSHIPS VIA OWNER LETTERS MAILED OUT ON JUNE 6, 2003.WHILE VW INITIALLY INSTRUCTED THE DEALERSHIPS TO ONLY REPLACE THE MALFUNCTIONING IGNITION COIL PACKS, A REVISED CSC WAS ISSUED TO DEALERSHIPS IN DECEMBER 2003 AND JANUARY 2004, INSTRUCTING DEALERSHIPS TO REPLACE ALL IGNITION COIL PACKS REGARDLESS OF THEIR PERFORMANCE.A REMINDER TO THE DEALERSHIPS WAS SENT BY VW ON APRIL OF 2004.ALTHOUGH THE CONCERNS OF THE PETITIONER COULD THEORETICALLY CREATE A SAFETY PROBLEM, THE RISK IS VERY SMALL, DUE TO THE ENGINE STILL RUNNING ON EITHER 3, 5, OR 7 CYLINDERS.THERE ARE NO REPORTED CRASHES OR INJURIES DUE TO THE ALLEGED DEFECT.ONCE DRIVERS ARE AWARE OF THE PROBLEM (LOSS OF POWER DUE TO ONE OF THE IGNITION COIL PACKS MALFUNCTIONING), DRIVERS ARE ABLE TO TAKE PRECAUTIONARY AND COMPENSATORY MEASURES AND STILL MAINTAIN CONTROL OF THEIR VEHICLES.IN ADDITION, FOUR FIRES WERE REPORTED TO ODI.THESE WERE IGNITION COIL BURNOUTS WITH NO ADDITIONAL DAMAGE TO THE VEHICLE AND WERE LOCALIZED ON TOP OF THE ENGINE. DURING THE LAST 24 MONTHS THE NUMBER OF STALL AND DRIVABILITY COMPLAINTS REPORTED TO ODI HAS GREATLY DIMINISHED FROM A PEAK OF 195 IN JANUARY OF 2003 TO ONLY 3 IN AUGUST OF 2005.THIS COINCIDES WITH THE CSC RELEASED BY VW.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04081 · Inadvertent SIDE-AIRBAG Deployment
Opened Dec 16, 2004 · Closed Apr 1, 2005
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH SIDE-THORAX AND SIDE-HEAD CURTAIN AIRBAGS TO PROTECT THE FRONT AND REAR OUTBOARD OCCUPANTS IN A SIDE-IMPACT CRASH.THIS INVESTIGATION IDENTIFIED A TOTAL OF 499 REPORTS (482 OWNERS REPORTS AND 17 WARRANTY CLAIMS).THE CRASH SENSING SYSTEM?S ALGORITHM MAY RECOGNIZE CERTAIN NON-CRASH IMPACTS (WHEEL, TIRE AND UNDERCARRIAGE IMPACTS) AS DEPLOYABLE EVENTS.THE 97 ALLEGED INJURIES WERE MINOR IN NATURE AND CONSIST OF ABRASIONS, BRUISES, EAR RINGING AND HEADACHES.THERE WAS NO ALLEGED LOSS OF CONTROL CRASH AS A RESULT OF SIDE-AIRBAG DEPLOYMENT.ODI ALSO OBTAINED COUNTS OF ALLEGED INADVERTENT SIDE-AIRBAG DEPLOYMENTS FROM PEER MANUFACTURERS.THE DATA SHOWS THAT THE SUBJECT VEHICLES ARE NOT UNIQUE IN BEING SUBJECT TO SUCH ALLEGATIONS.THE COMPLAINT RATE FOR NON-SUBJECT INDIVIDUAL MODEL VEHICLES VARIES WIDELY.THE RATE FOR THE SUBJECT VEHICLES IS COMPARABLE TO THREE PEER MODELS, EACH WITH COMPACT CHASSIS/WHEELBASES.ODI HAS NOT IDENTIFIED ANY COMPONENT FAILURE OR MANUFACTURING TREND THAT MAY RELATE TO A COMPONENT OR MANUFACTURING ISSUE.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE04073 · Turn Signal/hazard Flasher Failure
Opened Oct 19, 2004 · Closed Dec 16, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Additional source detail variants (4)
Exterior Lighting:hazard Flashing Warning Lights:switch
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:hazard Flashing Warning Lights
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal:flasher Unit
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
Exterior Lighting:turn Signal
THIS INVESTIGATION WAS OPENED ON OCTOBER 19, 2004, BASED ON NINE REPORTS ON 2000 THROUGH 2001 JETTA AND GTI VEHICLES ALLEGING THAT THE TURN SIGNALS AND OR HAZARD FLASHERS FAIL TO BLINK, OR FLASH.SOME OF THE COMPLAINANTS REPORTED THAT THE LIGHTS WOULD BLINK ONLY A FEW TIMES AND THEN STOP.SEVERAL OF THE COMPLAINANTS REPORTED THAT HAVING THE HAZARD FLASHER SWITCH REPLACED REPAIRED THEIR VEHICLES.BY LETTER OF DECEMBER 13, 2004, VOLKSWAGEN NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL OF 350,000 MODEL YEAR 2000 THROUGH 2002 JETTA, GOLF AND GTI VEHICLES TO REPAIR THE TURN SIGNAL AND HAZARD FLASHER SYSTEM.VW REPORTS 216 OWNER REPORTS, 4 FIELD REPORTS AND 4960 WARRANTY CLAIMS ON THIS POPULATION OF VEHICLES. VOLKSWAGEN DEALERS WILL INSTALL A NEW HAZARD FLASHER SWITCH/RELAY KIT TO REMEDY THE DEFECTIVE VEHICLES.PLEASE SEE SAFETY RECALL 04V584 FOR DETAILS.
EA04010 · Driver Side Front Seat Overheats
Opened Mar 30, 2004 · Closed Oct 21, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THIS INVESTIGATION CONCERNS THE ELECTRIC SEAT HEATER INSTALLED IN SOME MY 2002-2003 VOLKSWAGEN (VW) JETTA VEHICLES.CONSUMERS ALLEGE THAT THE SEAT HEATER MAY OVERHEAT, RESULTING IN BURN DAMAGE TO THE SEAT COVER AND TO THE DRIVER'S CLOTHING AND/OR SKIN.THIS EA ADDRESSES WHETHER SUCH FAILURES MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ODI CONCLUDES THAT THE DRIVER-SIDE SEAT HEATER MAY FAIL OR MALFUNCTION DUE TO NORMAL VEHICLE USE, (I.E., DRIVER INGRESS AND EGRESS FROM THE VEHICLE).THE INVESTIGATION DISCLOSED THAT SUCH FAILURES DO NOT POSE A SIGNIFICANT RISK OF INJURY OR FIRE.ODI BELIEVES THAT FURTHER INVESTIGATION WOULD NOT LIKELY IDENTIFY A SAFETY-RELATED DEFECT TREND.THEREFORE, THIS EA HAS BEEN CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.THE ATTACHED SUMMARY REPORT PROVIDES FURTHER DETAIL CONCERNING THIS EA.
RQ03010 · Brake Light Switch
Opened Dec 17, 2003 · Closed Mar 1, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights:switch
THE NUMBER OF DUPLICATES BETWEEN ODI AND MANUFACTURER FAILURE REPORTS CANNOT BE DETERMINED DUE TO MISSING AND OR INACCURATE INFORMATION.THE INJURY NOTED ABOVE WAS MINOR.ON FEBRUARY 26, 2004, VOLKSWAGEN OF AMERICA, INC. (VW) SUBMITTED A DEFECT NOTIFICATION (PER 49CFR573) TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) ADVISING THAT CERTAIN MODEL YEAR (MY) 1999 - 2002 VOLKSWAGEN JETTA VEHICLES MANUFACUTURED WITH THE SAME BRAKE LIGHT SWITCH AS RECALLED UNDER 03V-265 (MY 1998-2002 NEW BEETLE) ARE AFFECTED BY A SAFETY DEFECT.SPECIFICALLY, IF THE BRAKE LIGHT SWITCH MALFUNCTIONS, THE BRAKE LIGHTS COULD FAIL TO ILLUMINATE WHEN THE BRAKES ARE APPLIED, OR COULD STAY ILLUMINATED CONTINUALLY EVEN WHEN THE BRAKES ARE NOT APPLIED.EITHER CONDITION RESULTS IN THE INABILITY OF THE BRAKE LIGHTS TO NOTIFY OTHER MOTORISTS OF VEHICLE BRAKING, THUS INCREASING THE RISK OF A REAR END COLLISION AND OCCUPANT INJURY.ACCORDINGLY, VOLKSWAGEN IS RECALLING JETTA VEHICLES MANUFACTURED FROM MAY 1998 TO NOVEMBER 2001 TO INSPECT AND REPLACE FREE OF CHARGE ANY AFFECTED BRAKE LIGHT SWITCHES.THE RECALL PROGRAM, VW CODE WX, WILL COMMENCE IN APRIL 2004.
PE03052 · Driver Seat Overheats/burns
Opened Nov 19, 2003 · Closed Mar 30, 2004
Status: closed (inferred from source dates) · Seats:front Assembly:seat Heater/cooler
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL ELECTRICALLY HEATED DRIVER AND FRONT PASSENGER SEATS.INFORMATION RECEIVED DURING PE03-052 DISCLOSED A SIGNIFICANT NUMBER OF INCIDENTS OF MALFUNCTIONING/OVERHEATING OF THE DRIVER SEAT HEATER IN THE SUBJECT VEHICLES.ADDITIONAL INCIDENTS MAY OCCUR DURING THE FINAL MONTHS OF THE WINTER SEASON.THIS MATTER IS ALSO CURRENTLY BEING INVESTIGATED BY TRANSPORT CANADA.THIS PE HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA04-010)IN ORDER TO FULLY INVESTIGATE THESE OCCURRENCES AND THEIR SAFETY IMPLICATIONS.